2007 VOLVO XC70 engine

2007 Volvo XC70
2 0 0 7
VOLVO XC70

VOLVO OWNER'S MANUAL XC70
pg. 1 Introduction


Welcome to the world-wide family of Volvo owners. We trust that you will\
enjoy many years of safe driving in
your Volvo, an automobile designed with your safety and comfort in mind.\
To help ensure your satisfaction with
this vehicle, we encourage you to familiarize yourself with the equipmen\
t descriptions, operating instructions and
maintenance requirements/recommendations in this manual. We also urge yo\
u and your passengers to wear seat
belts at all times in this (or any other) automobile. And, of course, \
please do not operate a vehicle if you may be
affected by alcohol, medication or any impairment that could hinder your\
ability to drive.
Your Volvo is designed to meet all applicable safety and emission standa\
rds, as evidenced by the certification
labels attached to the driver's door opening and on the left wheel housi\
ng in the engine compartment.
For further information please contact your retailer, or:
In the USA:
Volvo Cars of North America, LLC
Customer Care Center
file:///K|/ownersdocs/2007/2007_XC70/07xc70_00.htm (1 of 6)12/30/2006 \
5:51:24 PM

2007 Volvo XC70
P.O. Box 914
Rockleigh, New Jersey 07647-0914
1-800-458-1552
www.volvocars.us
In Canada:
Volvo Cars of Canada Corp.
National Customer Service
175 Gordon Baker Road
North York, Ontario M2H 2N7
1-800-663-8255
www.volvocanada.com
2006 © Volvo Car Corporation
pg. 2 Introduction
General Information
Shiftlock (automatic transmission)
When your vehicle is parked, the gear selector is locked in the (P)ark position. To release the selector from this
position, turn the ignition key to position II (or start the engine), \
depress the brake pedal, press the button on the
front side of the gear selector and move the selector from (P)ark.
Keylock (automatic transmission)
When you switch off the ignition, the gear selector must be in the (P)ark position before the key can be removed
from the ignition switch.
Anti-lock Brake System (ABS)
The ABS system in your vehicle performs a self-diagnostic test when the \
vehicle first reaches the speed of
approximately 12 mph (20 km/h). The brake pedal will pulsate several t\
imes and a sound may be audible from the
ABS control module. This is normal.
Fuel filler door
The fuel filler door, located on the right rear fender, is connected to \
your vehicle's central locking system.
Press the button on the light switch panel (see illustration on
page 56) when the vehicle is at a standstill to unlock
the fuel filler door. Please note that the fuel filler door will remain \
unlocked until the vehicle begins to move
forward. An audible click will be heard when the fuel filler door relock\
s.
Fuel filler cap
After refueling, close the fuel filler cap by turning it clockwise until\
it clicks into place. If this cap is not closed
tightly or if the engine is running when the vehicle is refueled, the Ma\
lfunction Indicator Lamp ("Check Engine"
light) will illuminate.
Important information
file:///K|/ownersdocs/2007/2007_XC70/07xc70_00.htm (2 of 6)12/30/2006 \
5:51:24 PM

2007 Volvo XC70
Before you operate your vehicle for the first time, please familiarize y\
ourself with the information in chapters one,
two and eight of this manual.
Information contained in the balance of the manual is extremely useful a\
nd should be read after operating the
vehicle for the first time.
The manual is structured so that it can be used for reference. For this \
reason, it should be kept in the vehicle for
ready access.
Do not export your Volvo to another country before investigating that co\
untry's applicable safety and exhaust
emission requirements. In some cases it may be difficult or impossible t\
o comply with these requirements.
Modifications to the emission control system(s) may render your Volvo \
not certifiable for legal operation in the U.
S., Canada and other countries.
All information, illustrations and specifications contained in this manu\
al are based on the latest product
information available at the time of publication. Please note that some \
vehicles may be equipped differently,
depending on special legal requirements. Optional equipment described in\
this manual may not be available in all
markets. Volvo reserves the right to make model changes at any time, or \
to change specifications or design without
notice and without incurring obligation.
pg. 3 Introduction
General Information
WARNING!
CALIFORNIA Proposition 65 Warning
Engine exhaust, some of its constituents, and certain vehicle components\
contain or emit chemicals known to
the state of California to cause cancer, and birth defects or other repr\
oductive harm. In addition, certain fluids
contained in vehicles and certain products of component wear contain or \
emit chemicals known to the State of
California to cause cancer, and birth defects or other reproductive harm\
.
WARNING!
If your vehicle is involved in an accident, unseen damage may affect you\
r vehicle's driveability and
safety.
pg. 4 Introduction
Volvo and the environment
Volvo is committed to the well being of its customers. As a natural part\
of this commitment, we care about the
environment in which we all live. Caring for the environment means an ev\
eryday involvement in reducing our
environmental impact.
Volvo's environmental activities are based on a holistic view, which mea\
ns we consider the overall environmental
file:///K|/ownersdocs/2007/2007_XC70/07xc70_00.htm (3 of 6)12/30/2006 \
5:51:24 PM

2007 Volvo XC70
impact of a product throughout its complete life cycle. In this context,\
design, production, product use, and
recycling are all important considerations. In production, Volvo has par\
tly or completely phased out several
chemicals including freons, lead chromates, naphtanates, asbestos, mercu\
ry and cadmium; and reduced the amount
of chemicals used in our plants 50% since 1991.
Volvo was the first in the world to introduce into production a three-wa\
y catalytic converter with a Lambda sond,
now called oxygen sensor, in 1976. The current version of this highly ef\
ficient system reduces emissions of
harmful substances (CO, HC, NOx) from the exhaust pipe by approximatel\
y 95% and the search to eliminate the
remaining emissions continues. Volvo is the only automobile manufacturer\
to offer CFC-free retrofit kits for the
air conditioning system of all models as far back as the 1975 model 240.\
Advanced electronic engine controls,
refined purification systems and cleaner fuels are bringing us closer to\
our goal.
After Volvo vehicles and parts have fulfilled their use, recycling is th\
e next critical step in completing the life
cycle. The metal content is about 75% of the total weight of a vehicle, \
which makes the vehicle among the most
recycled industrial products. In order to have efficient and well contro\
lled recycling, many Volvo variants have
printed dismantling manuals, indicating the weight and material of indiv\
idual components. For Volvo, all
homogeneous plastic parts weighing more than 1.7 oz. (50 grams) are ma\
rked with international symbols that
indicate how the component is to be sorted for recycling.
In addition to continuous environmental refinement of conventional gasol\
ine-powered internal combustion
engines, Volvo is actively looking at advanced technology alternative-fu\
el vehicles.
When you drive a Volvo, you become our partner in the work to lessen the\
vehicle's impact on the environment.
To reduce your vehicle's environmental impact, you can:
l Maintain proper air pressure in your tires. Tests have shown decreased f\
uel economy with improperly inflated
tires.
l Follow the recommended maintenance schedule in your Warranty and Service\
Records Information booklet.
l Drive at a constant speed.
l See an authorized Volvo retailer as soon as possible for inspection if t\
he check engine (malfunction indicator)
lamp illuminates, or stays on after the vehicle has started.
l Properly dispose of any vehicle-related waste such as used motor oil, us\
ed batteries, brake pads, etc.
l When cleaning your vehicle, use Volvo's own vehicle care products, all o\
f which have systematically been
adapted to the environment.
PremAir® (certain models only)
The surface of the radiator in the engine compartment
1 is treated with a special coating called PremAir2. This
coating works as a catalytic converter, converting most of the ground le\
vel ozone passing through the
1. Only vehicles with engine B5244S (engine code 39 in the VIN)
2. PremAir is a registered trademark of Engelhard Corporation.
pg. 5 Introduction
Volvo and the environment
radiator into oxygen, thereby reducing harmful ground-level ozone.
NOTE: If a PremAir-coated radiator needs to be replaced, it should be replace\
d with another radiator with this
file:///K|/ownersdocs/2007/2007_XC70/07xc70_00.htm (4 of 6)12/30/2006 \
5:51:24 PM

2007 Volvo XC70
occupant weight sensor, and inflatable curtains. All of these systems ar\
e monitored by the SRS control
module. An SRS warning light in the instrument panel (see the illustrat\
ion above) illuminates when the
ignition key is turned to position I, II, or III, and will normally go o\
ut after approximately 7 seconds if
no faults are detected in the system.
Where applicable, a text message will also be displayed when the SRS war\
ning light illuminates. If this
warning symbol is not functioning properly, the general warning symbol
illuminates and a text
message will be displayed.
WARNING!
l If the SRS warning light stays on after the engine has started or if it \
illuminates while you are
driving, have the vehicle inspected by a trained and qualified Volvo ser\
vice technician as soon as
possible.
l Never try to repair any component or part of the SRS yourself. Any inter\
ference in the system
could cause malfunction and serious injury. All work on these systems sh\
ould be performed by an
authorized Volvo service technician.
WARNING!
If your vehicle has been subjected to flood conditions (e.g. soaked car\
peting/ standing water on the
floor of the vehicle) or if your vehicle has become flood-damaged in an\
y way, do not attempt to start
the vehicle or put the key in the ignition before disconnecting the batt\
ery (see below). This may cause
airbag deployment which could result in personal injury. Have the vehicl\
e towed to a trained and
qualified Volvo service technician for repairs.
Automatic transmission:
Before attempting to tow the vehicle, use the following procedure to ove\
rride the shiftlock system to
move the gear selector to the neutral position:
l Switch off the ignition for at least 10 minutes and disconnect the batte\
ry.
l Wait at least one minute.
l Insert the key in the ignition and turn it to position II.
l Press firmly on the brake pedal.
l Move the gear selector from (P)ark to the (N)eutral position.
pg. 16 Safety
Front airbags
file:///K|/ownersdocs/2007/2007_XC70/07xc70_01.htm (7 of 38)12/30/2006\
5:51:26 PM

2007 Volvo XC70
33. Moonroof control 70
34. Seat belt reminder
12
35. Rearview mirror
67
36. Lock button, for all doors
114
37. Rear seat power window cut-out button
66
38. Controls, power windows
65
39. Controls, sideview mirrors
69
40. Four-C active chassis system (R-models only)
135
pg. 46 Instruments and controls
Instrument panel
1. Turn signal indicators - right/left
2. Text window
The text window displays information and warning messages.
3. Temperature gauge
The pointer should be approximately midway on the gauge when driving. Do not drive the vehicle if
the warning light is on. The text window will provide you with additional information.
If the engine temperature remains high, check coolant level - see
page 188.
4. Trip odometer
The trip odometers are used for measuring shorter distances. The right-h\
and digit gives tenth of a mile/
kilometer. Press the button for more than 2 seconds to reset. Change bet\
ween trip odometers 1 and 2
using one short press on the button.
5. Odometer
6. Speedometer
7. Warning symbol
8. High beam indicator
9. Tachometer
file:///K|/ownersdocs/2007/2007_XC70/07xc70_02.htm (4 of 35)12/30/2006\
5:51:30 PM

2007 Volvo XC70
Indicates engine speed in thousands of revolutions per minute (rpm). D\
o not drive for long with the
needle in the red section. The engine has an built-in function preventin\
g excessively high engine speeds.
When this function operates, you may discern some pulsation, which in th\
at case is quite normal.
10. Gear and driving mode indicator
The currently selected driving mode is displayed here. If you use the op\
tional Geartronic function on the
automatic transmission, the currently selected gear will be displayed.
11. Ambient temperature gauge
This display indicates the air temperature outside your vehicle. A "snow\
flake" symbol in the text
window is displayed when the temperature is in the range of 23 - 36 °\
F (-5 - +2 °C).
Please note that this symbol does not indicate a fault with your vehicle\
. At low speeds or when the
vehicle is not moving, the temperature readings may be slightly higher t\
han the actual ambient
temperature.
12. Clock/set button
Turn the button to set the clock.
13. Fuel gauge
The fuel tank holds approximately:
Front wheel drive, non-turbo models - 18.5 US gal. (70 liters)
All turbo models - 18 US gal. (68 liters)
When the warning light in the gauge comes on, there are approximately 1.\
8 US gal. (8 liters) of fuel
remaining in the tank.
14. Indicator and warning symbols
pg. 47 Instruments and controls
Indicator and warning symbols
The indicator and warning symbols light up when you turn the ignition ke\
y to the driving position
(position II) before starting. This shows that the symbols are functio\
ning. When the engine starts, all
symbols go out. If the engine is not started within 5 seconds, all symbo\
ls except CHECK ENGINE and
file:///K|/ownersdocs/2007/2007_XC70/07xc70_02.htm (5 of 35)12/30/2006\
5:51:30 PM

2007 Volvo XC70
go out. Certain symbols may not have their functions illustrated, depen\
ding on the vehicle's
equipment. The symbol for the parking brake goes out when the parking br\
ake is released.
Warning symbol
in center of the instrument panel
This symbol shines as a red or yellow light depending on the severity of\
the discovered fault.
Red symbol - Stop the vehicle as soon as possible in a suitable location and read \
the message shown in
the text window. The symbol and accompanying text will remain on until t\
he fault has been corrected.
Yellow symbol - Follow the instructions shown in the text window. The text can be era\
sed by pressing
the READ button (see
page 50), or will disappear automatically after two minutes.
When the message "TIME FOR REGULAR SERVICE" is displayed, the text can b\
e erased and the
yellow symbol light can be turned off by pressing the READ button. The t\
ext will disappear and the
symbol light will go out automatically after two minutes.
Seat belt reminder
This symbol lights up to indicate that the driver has not fastened his/h\
er seat belt.
Supplemental Restraint System SRS
If this light comes on while the vehicle is being driven, or remains on \
for longer than approximately 10
seconds after the vehicle has been started, the SRS system's diagnostic \
functions have detected a fault in
a seat belt lock or tensioner, a front airbag, side impact airbag, and/o\
r an inflatable curtain. Have the
system(s) inspected by a trained and qualified Volvo service technicia\
n as soon as possible.
pg. 48 Instruments and controls
Indicator and warning symbols
BRAKE Brake failure warning light If the light comes on while driving or brak\
ing, stop immediately,
open the hood and check the brake fluid level in the reservoir. See
page 189 for reservoir position and
page 193 for instructions.
Canadian models are equipped with this warning light
If the BRAKE and ABS warning lights come on at the same time, this could\
indicate a fault in the
brake system.
- Stop the vehicle in a suitable place and switch off the engine.
file:///K|/ownersdocs/2007/2007_XC70/07xc70_02.htm (6 of 35)12/30/2006\
5:51:30 PM