2007 TOYOTA FJ CRUISER Owners Manual

3192007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
Oil type:Hypoid gear oil API GL −5
Recommended oil viscosity: FrontFull −time four −wheel drive models
Above −18 C (0 F)
SAE 90
Below −18 C (0 F)
SAE 80W or 80W −90
Part −time four −wheel drive models
SAE 75W −90
Rear Above −18 C (0 F)
SAE 90
Below −18 C (0 F)
SAE 80W or 80W −90
CHASSIS LUBRICATION
Propeller shafts: SpidersLithium base chassis grease, NLGI
No.2
Slide yokes Molybdenum −disulfide lithium base
chassis grease, NLGI No.2 or lithium
base multipurpose grease, NLGI No.2 BRAKES
Minimum pedal clearance when depressed
with the force of 490 N (50 kgf, 110 lbf)
with the engine running, mm (in.):
54 (2.1)
Pedal free play, mm (in.): 1—6 (0.04—0.24)
Pad wear limit, mm (in.): 1.0 (0.04)
Lining wear limit, mm (in.): 1.0 (0.04)
Parking brake adjustment when depressed
with the force of 196 N (20 kgf, 44.1 lbf): 5—7 clicks
Fluid type: SAE J1703 or FMVSS No.116 DOT 3
STEERING
Wheel free play: Less than 30 mm (1.2 in.)
Power steering fluid type: Automatic transmission fluid DEXRON II
or III

3202007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
Tire size, cold tire inflation pressure and wheel size:Ti r e siz e
Cold tire inflation pressure kPa (kgf/cm2 or bar, psi)Wheel size
FrontRearSpare
P265/70R17 113S220 (2.2, 32)220 (2.2, 32)220 (2.2, 32)17  7 1/ 2J
NOTE: For a complete information on tires (e.g. replacing ti res or replacing wheels), see “Checking tire inflation pres-
sure” through “Aluminum wheel precautions”, pages 297 through 304 in Section 7 −2.
Wheel nut torque, N·m (kgf·m, ft·lbf): 11 3 ( 11 . 5 , 8 5 )
Tires

3212007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
TS80001a
Engine compartment
Fuses (type A)1. SPARE 10 A: Spare fuse
2. SPARE 15 A: Spare fuse
3. TOWING TAIL 15 A: Trailer lights
4. OFFROAD LP 15 A: Offroad lamp
5. STOP 10 A: Stop lights, high mounted
stoplight, anti −lock brake system, trac-
tion control system, active traction con-
trol system, vehicle stability control
system, “AUTO LSD” system, multiport
fuel injection system/sequential multi-
port fuel injection system, shift lock
system
6. AUX LP 15 A: Driving lamp
TS80002
Instrument panel
7. OBD 7.5 A: On−board diagnosis sys-
tem
8. HEAD (LO RH) 10 A: Right −hand
headlight (low beam) (vehicles with
daytime running light), right −hand head-
light (vehicles without daytime running
light)
9. HEAD (LO LH) 10 A: Left−hand head-
light (low beam) (vehicles with daytime
running light), left −hand headlight (ve-
hicles without daytime running light)
10. HEAD (HI RH) 10 A: Right −hand head-
light (high beam)
TS80003a
Engine compartment
11. HEAD (HI LH) 10 A: Left −hand head-
light (high beam)
12. EFI NO.2 10 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system
13. DRL 7.5 A: Daytime running light
system
14. DEFOG 30 A: Back window defogger
15. DEFOG NO.2 7.5 A: Multiport fuel in-
jection system/sequential multiport fuel
injection system
16. DOME 10 A: Interior light, luggage
compartment light, clock, accessory
meter, meter and gauge
Fuses

3222007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
17. RADIO NO.1 20 A: Audio system
18. ECUB 10 A: Air conditioning system,
multiplex communication system, SRS
airbag system, front passenger occu-
pant classification system
19. ALTS 7.5 A: Charging system
20. HORN 10 A: Horn
21. A/F HEATER 15 A: Multiport fuel injec-
tion system/sequential multiport fuel in-
jection system
22. TRNHAZ 15 A: Turn signal lights,
emergency flashers
23. ETCS 10 A: Multiport fuel injection
system/s equential multiport fuel injec-
tion system, electronic throttle control
system
24. EFI 20 A: “EFI NO.2” fuse, Multiport
fuel injection system/sequential multi-
port fuel injection system
25. DR/LCK 20 A: Door lock system, mul-
tiplex communication system
26. TOWING 15 A: Towing converter
27. RADIO NO.2 20 A: Audio system28. IGN 10 A:
Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, anti −lock brake system, vehicle
stability control system, traction control
system, active traction control system,
“AUTO LSD” system, SRS airbag sys-
tem, front passenger occupant classifi-
cation system
29. GAUGE 7.5 A: Meter and gauge
30. FR WIPWSH 30 A: Windshield wipers
and washer
31. 4WD/DIFF 20 A: Four−wheel drive sys-
tem, rear differential lock system
32. PWR OUTLET 15 A: Power outlet
33. RR WSH 15 A: Back window wiper
and washer, multiplex communication
system
34. ECUIG 10 A: Anti−lock brake system,
vehicle stability control system, traction
control system, active traction control
system, “AUTO LSD” system, multiport
fuel injection system/sequential multi-
port fuel injection system, cruise con-
trol system, back door lock system,
shift lock system, multiplex communica-
tion system 35. IG1 15 A:
Turn signal lights, air condi-
tioning system, charging system, clutch
start cancel switch, anti −lock brake
system, traction control system, active
traction control system, vehicle stability
control system, “AUTO LSD” system,
back −up lights, intuitive parking assist,
rear differential lock system, power out-
let, accessory meter, meter and gauge
36. STA 7.5 A: Starting system, clutch
start cancel switch, power outlet
37. TAIL 10 A: Tail lights, license plate
lights, parking lights, instrument panel
light control, illuminations
38. ACC 7.5 A: Shift lock system, outside
rear view mirrors, audio system, power
outlet, clock, accessory meter, multi-
plex communication system
Fuses (type B)
39. AM1 50 A: “ACC”, “ECU−IG”, “IG1”,
“PR WSH”, “FR WIP −WSH”, “4WD/
DIFF” and “STA” fuses
40. J/B 50 A: “TAIL”, “PWR OUTLET”,
“POWER”
4

1. ABS MTR 40 A: Anti−lock brake sys-
tem, vehicle stability control system,
traction control system, active traction
control system, “AUTO LSD” system

3232007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
42. AM2 30 A: “IGN” and “GAUGE” fuses,
multiport fuel injection system/sequen-
tial multiport fuel injection system,
starting system
43. ABS SOL 30 A: Anti−lock brake sys-
tem, vehicle stability control system,
traction control system, active traction
control system, “AUTO LSD” system
44. POWER 30 A: Power windows
45. AC 115V 80 A: Power outlet
Fuses (type C)
46. ALT 120 A: “AM1”, “AC 115V”,
“DEFOG”, “DEFOG NO.2”, “STOP”,
“OBD”, “J/B”, “TOWING TAIL”, “AUX
LP” and “OFFROAD LP” fuses
47. HEATER 60 A: Air conditioning system

3242007 FJ CRUISER from Oct. ’06Prod. (OM35873U)

3252007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
REPORTING SAFETY DEFECTS FOR U.S.
OWNERS
Reporting safety defects for U.S. owners
Reporting safety defects for U.S. owners326
. . . . . . . . . . . . . . . . . . . . . .
SECTION 9

3262007 FJ CRUISER from Oct. ’06Prod. (OM35873U)
If you believe that your vehicle has a de-
fect which could cause a crash or could
cause injury or death, you should immedi-
ately inform the National Highway Traffic
Safety Administration (NHTSA) in addition
to notifying Toyota Motor Sales, U.S.A.,
Inc.
(Toll−free: 1 −800− 331−4331).
If NHTSA receives similar complaints, it
may open an investigation, and if it finds
that a safety defect exists in a group of
vehicles, it may order a recall and remedy
campaign. However, NHTSA cannot be-
come involved in individual problems be-
tween you, your dealer, or Toyota Motor
Sales, U.S.A., Inc. To contact NHTSA, you may call the Ve-
hicle Safety Hotline toll
−free at
1 −888− 327−4236 (TTY: 1 −800− 424−9153);
go to http://www.safercar.gov ; or write to:
Administrator, NHTSA, 400 Seventh Street,
SW., Washington, DC 20590. You can also
obtain other information about motor ve-
hicle safety from http://www.safercar.gov .
Reporting safety defects for
U.S. owners