2007 SKODA OCTAVIA TOUR Owner's Manual

136GENERAL MAINTENANCE1.6-ltr./74 kW petrol engine
1 - Coolant expansion reservoir
2 - Reservoir for hydraulic fluid of powersteering
3 - Windscreen washer reservoir
4 - Engine oil dipstick
5 - Engine oil filler opening
6 - Brake fluid reservoir
7 - Battery 1.9-ltr. TDI 66 kW/81 kW diesel engine
1 - Coolant expansion reservoir
2 - Reservoir for hydraulic fluid of power
steering
3 - Windscreen washer reservoir
4 - Engine oil dipstick
5 - Engine oil filler opening
6 - Brake fluid reservoir
7 - Battery
The arrangement in the engine compart-
ment is largely identical on all petrol and
diesel engines.

137
GENERAL MAINTENANCE
Warning
Particular care is required when per-
forming work in the engine compart-
ment!

Never open the bonnet if you see
that steam or coolant is escaping
from the engine compartment - risk
of scalding!
You must wait long enough, until the
steam or coolant has stopped escap-
ing.

Switch off engine and withdraw ig-
nition key.

Apply handbrake properly.

Move gearshift into Neutral (on
models with automatic gearbox mo-
ve selector lever into position „P“).

Allow engine to cool down.

If the engine is still warm:
- do not place your hand into the ra- diator fan, it might start suddenly.
- do not open filler cap of coolant reservoir as cooling system is
pressurized - risk of scalding.

Avoid short circuits in the electri-
cal system - particularly at the bat-
tery!

If you wish to work under the ve-
hicle, you must secure the vehicle
from rolling away and support it with
suitable supporting blocks: the car
jack is not sufficient for this - risk of
injury!

If it is necessary to carry out test
work when engine is running, there
is an additional risk from rotating
parts - e.g. ribbed belt, alternator,
radiator fan etc. - and from the high-
voltage ignition system.

Never touch the electrical cables
of the ignition system.

Absolutely avoid any jewellery,
loose items of clothing or long hair
from getting into the rotating parts of
the engine - Hazard! Therefore re-
move any jewellery beforehand, tie
up your hair and wear tight fitting
clothing.
It is essential to comply with all the
warning information given in this
manual and with the general rules of
safety when carrying out work on the
engine.
When topping up fluids, ensure that no mix-
ups occur otherwise this may cause severe
operating problems!
The floor below the car should be
inspected regularly in order to de-
tect leaks in good time. If patches of oil or other fluids are visible, the car shouldbe taken to a Škoda Dealer for an inspec-
tion.

138GENERAL MAINTENANCE
LongLife Service*The LongLife Service ensures that your
vehicle is always in proper roadworthy con-
dition while requiring only minimal effort on
your part.
The LongLife Service is determined on the
basis of:
- Oil level and pressure sensor - see page 59
- Brake wear indicator - see page 58
- Engine oils complying with the standard VW 503 00 (petrol engines), VW 506 00
(diesel engines, except PDi engines)
and VW 506 01 (diesel engines) - see
page 138
- Variable service interval display - see page 49
- Battery with so-called „magic eye“ - see page 148.
Further information - refer to Service Sche-
dule. More detailed information is also
available from your Škoda Dealer.
SpecificationThe engine is factory-filled with a brand-
name multigrade oil which can be used as
an all-seasons oil - except in extremely cold
climatic zones. Oils may also be intermixed
when topping up (does not apply to mod-
els with LongLife Service*).
We recommend using oils from the selec-
tion of original oils available at Škoda.
Note
Engine oils naturally also undergo continu-
ous further development. That is why the
information contained in this Owner’s
Manual reflects the technical status at the
time of publication.Engine oil
Škoda Dealers are kept up-to-date by the
factory regarding any changes. It is there-
fore good practice to have the oil change
carried out at a Škoda Dealer.

139
GENERAL MAINTENANCE
Models with fixed service intervals (QG0, QG2) for oil
change
DesignationSpecification for Specification for
petrol engines diesel engines
Multigrade high- VW 500 00 VW 505 00
1)
lubricity oils VW 502 00 VW 505 01
VW 501 01
Multigrade oils ACEA A2
2)
ACEA B3
2)
or A3
2)
or B4
2)
Models with variable service intervals (QG1)* for oil
change
Specification
Petrol engines VW 503 00
Diesel engines VW 506 00
1)
VW 506 01
Warning
Models with variable service intervals (QG1) must only use
the above specified oils. It is recommended for the preser-
vation of the specified properties of the oils conforming to
specification, only engine oil with the same specification
may be used for replenishing. In exceptional cases, only
use engine oil conforming to specification VW 502 00 (only
petrol engines) or conforming to specification VW 505 01
(only diesel engines) for topping up to max. 0.5 ltr. Other
engine oils must not be used - risk of engine damage.
Before a long drive, we recommend that you purchase and
carry with you engine oil which complies with the specifica-
tion for your vehicle. Consequently, you will always have the
correct engine oil for refilling.
We recommend using oils from the range of Škoda Genuine
Oils offered by your Škoda Dealer.
For further information - see Service Schedule.
1)Except PDi engines (engines with unit injection)2)This oil may be used only once for topping up within the specified oil c\
hange
cycle if no approved engine oil is available.

140GENERAL MAINTENANCE
The car should be standing horizontally
when checking the oil level. Wait a few min-
utes after switching off the engine to allow
the oil to flow back into the sump.
Then, withdraw the dipstick, wipe it off with
a clean cloth and re-insert it fully.
After this, once again withdraw the dipstick
and read off the oil level:
a- Oil must be topped up.
After topping up, it is sufficient if the oil
level is somewhere in the range b.
b - Oil may be topped up.
After topping up, the oil level may then
be in the range c.
c - Oil must not be topped up.
If the engine is driven particularly hard, as
for example during long trips on motorways
in summer, when towing a trailer or driving
over mountain passes, the oil level should
be kept within the range c if possible - not
above .Topping up engine oilUnscrew the cap 2 of the oil filler opening
in the cylinder head cover and pour in the
quantity of oil needed. Check the oil level
with the dipstick. The oil level must on no account be hig-
her than the range „c“.
Otherwise, oil may
be drawn into the combustion chamber and
passed through the exhaust system to at-
mosphere. This can have a detrimental ef-
fect on combustion and on the operating
life of the catalytic converter.
Warning
When topping up the oil, do not spill
it onto hot engine components - dan-
ger of fire.
Carefully close the cap of the filler opening
and fully insert the dipstick into the inspec-
tion hole. Otherwise, oil might flow out when
the engine is running.
In the event that you do not have enough
fuel, do not drive any further. Switch off
the engine and contact a Škoda Dealer for
professional assistance, otherwise there is
a risk of serious engine damage.
The illustration shows part of an engine
compartment with the 2.0-ltr./85 kW engine.
For further information regarding the ar-
rangement in the engine compartment - see
page 136.
Checking oil levelIt is normal that the engine consumes a cer-
tain
quantity of oil . The oil consumption
may be as much as 0.5 ltr/1000 km if oper-
ating conditions are disadvantageous (e.g.
when driving in town) - see also page 119.
The engine oil level should therefore be
checked at regular intervals. This is best
done each time you refuel and before a long
journey.
The position of the dipstick 1 is shown in
the illustration.

141
GENERAL MAINTENANCE
Changing engine oilThe engine oil should be changed at the
intervals stated in the Service Schedule or
in the service interval display.Warning

Only carry out the engine oil chan-
ge, if you have the required profes-
sional knowledge!

Read and observe the warning
notes before working in the engine
compartment - see page 137.

Let the engine cool down - risk of
burning from hot oil.

Wear an eye protection - risk of
caustic burns due to oil splashes.

Oil is toxic! Store old oil in a safe
place out of the reach of children and
unauthorised persons until you dis-
pose of it properly.

You must not pour any additives
into the engine oil - risk of engine
damage! Damage, which results from
such product, is excluded from the
warranty.
Power steeringInspecting hydraulic fluid level
The reservoir for the hydraulic fluid of the
power steering is located in the right of the
engine compartment.
The hydraulic power steering system is
filled with hydraulic fluid G 002 000.
The hydraulic fluid level is checked when
the engine is at operating temperature and
switched off.
After your skin has come in contact with the
oil, you must thoroughly wash your skin.
On no account dispose of oil in the sewage system or into the ground.
Because of the disposal problem, the special tools and the specialist knowl-edge required, it is best to have the en-gine oil and filter change carried out by
a Škoda Dealer.

142GENERAL MAINTENANCECooling system
In normal operating conditions the cooling
system requires practically no mainte-
nance. The coolant consists of water and
a 40 % concentration of coolant additive.
This mixture not only offers the necessary
antifreeze protection down to -25 °C, but
also protects the cooling and heating sys-
tem from corrosion. In addition, it prevents
the formation of scale and increases the
boiling point of the coolant.
For this reason, the concentration of cool-
ant should also not be reduced during the
summer or in warm countries by topping up
with water. The coolant additive concen-
tration should be at least 40 %.
If greater antifreeze protection is required
for climatic reasons, the concentration of
coolant additive can be increased, but only
up to 60 % (antifreeze protection down to
about -40 °C). A higher concentration re-
duces the antifreeze protection and the
cooling efficiency is also impaired.
Cars for export countries with a cold climate
(e.g. Sweden, Norway, Finland) are factory-
filled for antifreeze protection down to about
-35 °C.
CoolantThe cooling system is factory-filled with the
coolant TL 774-F (G12 PLUS), lilac in col-
our.
We recommend using the same fluid for
topping up the system - G 12 PLUS (lilac
in colour).
In the event that it is necessary to top up
the system with a different coolant or if there
are any unclear aspects, please contact
your Škoda Dealer.
The correct coolant is available from your
Škoda Dealer.
Other coolant additives may consider-
ably impair the corrosion protection pro-
vided.
Any corrosion damage arising from the
use of another additive may result in a
loss of coolant and consequently in
major engine damage.
The fluid level should always be between
the „MAX“ and „MIN“ markings. If the level
has dropped below the „MIN“ marking, the
power steering should be inspected by a
Škoda Dealer. It is not sufficient simply to
top up the hydraulic fluid.
Note
When the engine is not running (e.g. when
the car is being towed or the ribbed belt is
broken) the power steering does not oper-
ate. The car can still be fully steered how-
ever, although greater physical effort is re-
quired for steering.

143
GENERAL MAINTENANCE
Loss of coolantA loss of coolant is first and foremost an
indication of a leak. In this case, the cool-
ing system should be inspected by a Škoda
Dealer. It is not sufficient merely to top up
the coolant.
If there is no leak in the system, losses may
also occur if the coolant boils as a result of
overheating and is forced out of the cool-
ing system.
If it is not possible to find and rectify the
cause of overheating, contact a Škoda
Dealer as soon as possible - otherwise
major engine damage may result.Topping up coolantFirst of all, switch off the engine and allow
it to cool down. Then, place a rag around
the cap of the expansion reservoir and
carefully unscrew the cap.Warning
Do not open the cap of the expansion
reservoir when the engine is hot -
risk of scalding. The cooling system
is pressurized!
Checking coolant levelThe coolant reservoir is located in the right
of the engine compartment.
The coolant level can be correctly checked
only when the engine is not running.
When the engine is cold, the coolant in the
expansion reservoir must be in the area of
the „ MIN“ mark and the crosshatched area.
When the engine is warm, the coolant level
may be slightly above the crosshatched
area. If, in exceptional cases, it is only possible
to top up the system with water, the correct
mixture concentration should be restored
without delay by using the specified cool-
ant additive.
If there is a major loss of coolant, do not
pour in coolant until the engine has cooled
down to avoid any engine damage.
Do not top up beyond the crosshatched
area!
Excess coolant is forced out of the cooling
system by the pressure relief valve in the
cap of the expansion reservoir when the
coolant heats up.
Screw the reservoir cap tight!
If the event that you do not have enough
coolant,
do not drive any further. Switch
off the engine and contact a Škoda Dealer
for professional assistance, otherwise there
is a risk of serious engine damage.