2007 ISUZU KB P190 Electrical

8A-354 ELECTRICAL-BODY AND CHASSIS

Installation
To Install, follow the removal steps in the reverse order.











FUEL GAUGE UNIT
Removal
Dismount the fuel tank first, then remove the fuel gauge unit.
1. Remove the rear inner liner -LH
• Remove the clip
2. Remove the filler neck. • Remove the screw
3. Remove the ground with cable.
4. Remove the fuel tank band. • Disconnect fuel line quick connectors.
5. Remove the fuel gauge unit from the fuel tank.



BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007

ELECTRICAL-BODY AND CHASSIS 8A-355



Installation
Follow the removal procedure in the reverse order to install the
fuel gauge unit.
Pay close attention to the important points mentioned in the
following paragraphs.


Rubber Seal
Be absolutely sure that the fuel gauge unit rubber seal is
correctly seated.



Connector
Be absolutely sure that the fuel gauge unit connector is
securely connected.
This will prevent a poor contact and an open circuit.



VEHICLE SPEED SENSOR (INSTALLED
ON THE TRANSMISSION)
Removal
1. Disconnect the connector.
2. Remove the vehicle speed sensor body by rotating it.







Installation
To Install, follow the removal steps in the reverse order, noting
the following point.
Tighten the vehicle speed sensor to the specified torque.
Vehicle Speed Sensor Tightening Torque N ⋅m (kg ⋅m/lb.ft)
25 ± 4.9 (2.5 ± 0.5/18 ± 3.6)



BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007

8A-356 ELECTRICAL-BODY AND CHASSIS
INSPECTION AND REPAIR

METER AND INDICATOR LIGHT LAYOUT
Without tachometer (4JJ1-TC/4JK1-TC)





RTW 78AMF000501
With tachometer (4JJ1-TC/4JK1-TC)




RTW 78AMF000101

BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007

ELECTRICAL-BODY AND CHASSIS 8A-357

Without tachometer (4JA1T(L)/4JH1-TC)




RTW 78AMF000401
With tachometer (4JA1T(L)/4JH1-TC)




RTW 78AMF000201

BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007

8A-358 ELECTRICAL-BODY AND CHASSIS

With tachometer (HFV6)




RTW 78AMF000601
Without tachometer (C24SE)


RTW 78AMF000701


BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007

ELECTRICAL-BODY AND CHASSIS 8A-359

SPEEDOMETER AND TACHOMETER
Speedometer On-Vehicle Inspection
Check the speedometer accuracy with a speedometer tester.
Carefully follow the tester manufacturer’s instructions.

SPEEDOMETER (km/h)




RTW 780SH000301

km/h meter
Permissible Range
Indication EUROPE,
G.EXP AUSTRALIA
20 20.2-24.5 20.2-24.3
40 40.6-44.9 41.7-46.0
60 60.9-65.2 62.6-66.9
80 81.5-85.8 83.4-87.7
100 102.0-106.3 104.4-108.7
120 122.5-126.8 125.1-129.4
140 143.1-147.4 146.1-150.4
160 163.7-168.0 166.7-171.0
180 184.2-188.5 187.3-191.6
200 204.6-208.9 208.4-212.7



SPEEDOMETER (mPH)



RTW 78ASH001201

mPH meter
Permissible Range
Indication
G.EXP, EUROPE
20 20.5-23.2
40 40.9-43.6
60 62.2-64.9
80 83.2-85.9
100 104.2-106.9
120 125.2-127.9



BACK TO CHAPTER INDEX
TO MODEL INDEXISUZU KB P190 2007

8A-360 ELECTRICAL-BODY AND CHASSIS






Tachometer On-Vehicle Inspection
1. Attach a tune-up tester to the engine.
2. Start the engine.
3. Compare the tachometer reading and the tester reading.
If the tachometer indication is outside the permissible range, the tachometer must be replaced.
4. Gradually increase and decrease the engine speed.
Note the movement of the tachometer needle.
If the needle movement is sluggish, the tachometer must be replaced.

4JJ1-TC/4JA1T(L)/4JH1-TC



RTW 780SH000401

rpm
Indication Permissible Range
750 700-870
2,000 1915-2085
3,000 2915-3085
4,000 3950-4120
5,000 4950-5120

4JK1-TC



RTW 780SH000501


Tachometer rpm
Indication Permissible Range
750 700-870
2,000 1915-2085
3,000 2915-3085
4,000 3950-4120
5,000 4950-5120

C24SE



RTW 78ASH001301


rpm
Indication Permissible Range
1,000 950-1150
2,000 1900-2100
3,000 2900-3100
4,000 3900-4100
5,000 4900-5100
6,000 5950-6150


BACK TO CHAPTER INDEX
TO MODEL INDEXISUZU KB P190 2007

ELECTRICAL-BODY AND CHASSIS 8A-361
HFV6


RTW 78ASH001401

rpm
Indication Permissible Range
750 690-910
1,000 890-1110
2,000 1890-2110
3,000 2890-3110
4,000 3890-4110
5,000 4890-5110
6,000 5940-6160
7,000 6940-7160



BACK TO CHAPTER INDEX TO MODEL INDEXISUZU KB P190 2007