2007.5 Peugeot 307 check engine
[x] Cancel search: check enginePage 124 of 212
CHECKS
112
1. Power steering reservoir.
2. Windscreen/headlamp wash
reservoir.
3. Coolant reservoir.
4. B r a k e l u i d r e s e r v o i r .
5. Battery.
6. Fuse box.
7. A i r i l t e r .
8. Dipstick.
9. Engine oil reservoir.
2 LITRE 16V PETROL ENGINE
Page 125 of 212
CHECKS
113
1. Power steering reservoir.
2. Windscreen /headlamp wash
reservoir.
3. Coolant reservoir .
4. B r a k e l u i d r e s e r v o i r .
5. Battery .
6. Fuse box.
7. Dipstick .
8. Engine oil reservoir.
9. Priming pump.
1.6 LITRE 16V TURBO DIESEL HDI ENGINE (90 BHP/110 BHP)
Page 126 of 212
CHECKS
114
1. Power steering reservoir.
2. Windscreen/headlamp wash
reservoir.
3. Coolant reservoir.
4. B r a k e l u i d r e s e r v o i r .
5. Battery.
6. Fuse box.
7. A i r i l t e r .
8. Engine oil reservoir.
9. Dipstick.
10. Priming pump.
11. Degas screw.
2 LITRE 16V TURBO DIESEL HDI ENGINE (136 BHP)
Page 127 of 212
CHECKS
115
CHECKING THE LEVELS
There are two marks on
the dipstick:
A = maximum
N e v e r i l l p a s t t h i s m a r k .
B = minimum
Oil change
According to the information given in
the servicing booklet.
Viscosity selection
In all cases, the oil selected must
meet the manufacturer’s require-
ments.
Note: the coolant does not need to
be changed.
Dipstick
Cooling system
U s e t h e l u i d r e c o m m e n d e d b y t h e
manufacturer.
When the engine is warm, the tem-
perature of the coolant is controlled
by the engine fan. This fan can oper-
ate with the ignition off.
I n t h e c a s e o f v e h i c l e s i t t e d w i t h
a p a r t i c l e e m i s s i o n i l t e r , t h e f a n
can operate after the vehicle has
s t o p p e d , e v e n w h e n t h e e n g i n e i s
cold.
In addition, as the cooling system is
pressurised, wait for at least one hour
after the engine has stopped before
carrying out any work.
Slacken the cap by two turns to re-
lease the pressure to prevent any
risk of scalding. When the pressure
has dropped, remove the cap and
top up the level.
Windscreen and headlamp
w a s h l e v e l
Diesel additive level (Diesel
w i t h p a r t i c l e e m i s s i o n f i l t e r )
If the service warning light comes on,
accompanied by a message and an
audible signal, this indicates a low
diesel additive level.
This additive must be topped up.
Contact a PEUGEOT dealer as soon
as possible.
Brake fluid level
* According to engine.
Oil level
To maintain the reliability of
engines and emission control
systems, the use of additives
in engine oil is prohibited.
The level should always be
above the MIN mark and
close to the MAX mark.
P o w e r s t e e r i n g r e s e r v o i r
Remove the style trim * (see §
"Changing a bulb - Front lights").
Open the reservoir, with the engine
at ambient temperature. The level
should always be above the MIN.
mark and close to the MAX. mark.
For best quality cleaning and
for your safety, we would ad-
vise that you use products
recommended by PEUGEOT.
Check the level regularly and
top up between changes. The
maximum consumption is 0.5 l
per 600 miles (1 000 km).
Check the level with the ve-
hicle level, engine cold, using the oil
level gauge on the instrument panel
or the dipstick. Replacement must be car-
ried out according to the
manufacturer’s servicing
schedule.
U s e l u i d s r e c o m m e n d e d b y
t h e m a n u f a c t u r e r , w h i c h f u l i l D O T 4
standards.
Page 128 of 212
CHECKS
116
CHECKS
Where the handbrake travel
is too great or there is a re-
duction in the performance
of the system, the hand-
brake should be adjusted,
even between services.
Have the system checked by a
PEUGEOT dealer.
Particle emission filter
(Diesel)
It is imperative that the particle emis-
s i o n i l t e r i s m a i n t a i n e d i n a c c o r d a n c e
with the manufacturer’s servicing
schedule, by a PEUGEOT dealer.
Note: following prolonged operation
of the vehicle at very low speed or at
idle, you may, in exceptional cases,
notice discharges of water vapour
at the exhaust on acceleration. This
has no effect on the behaviour of the
vehicle or on the environment. Brake pad wear depends
on the style of driving, in
particular for vehicles which
are used in town, over short
distances.
D i s c a n d d r u m w e a r s t a t u s
For any information relating to the wear
status of the surfaces of the discs and
drums, contact a PEUGEOT dealer
.
Only use products recom-
mended by PEUGEOT or
products of equivalent qual-
ity and characteristics.
To ensure best performance
from components as important as the
power steering and the braking sys-
tem, PEUGEOT selects and offers
q u i t e s p e c i i c p r o d u c t s .
To prevent damage to the electrical
units, high pressure washing to clean
the engine compartment is strictly
prohibited .
Oil filter
Used products
Avoid all prolonged contact of the
used oil with the skin.
B r a k e l u i d i s h a r m f u l t o h e a l t h a n d
very corrosive.
Air filter and passenger
compartment filter
Do not dispose of used oil,
b r a k e l u i d o r c o o l a n t i n t o
drains or onto the ground.
Empty the used oil into the
containers provided for this
purpose in the PEUGEOT network.
Battery
At the start of winter, have
your battery checked by a
PEUGEOT dealer.
Brake pads
It may be necessary to
check the thickness of the
pads, even between ser-
vices.
Handbrake
C h a n g e t h e i l t e r r e g u l a r l y ,
in accordance with the ser-
vicing schedule.
Manual gearbox
This does not require an oil
change. Have the level checked
in accordance with the manu-
facturer’s servicing schedule.
To check the main levels
a n d c e r t a i n c o m p o n e n t s ,
i n a c c o r d a n c e w i t h t h e
manufacturer’s servicing
s c h e d u l e , r e f e r t o t h e
pages of the servicing booklet
w h i c h c o r r e s p o n d t o y o u r v e h i -
cle’s engine.
H a v e t h e i l t e r e l e m e n t s r e -
placed regularly.
If you drive
i n d u s t y c o n d i t i o n s , c h a n g e
t h e m t w i c e a s o f t e n .
Page 129 of 212
CHECKS
116
CHECKS
Where the handbrake travel
is too great or there is a re-
duction in the performance
of the system, the hand-
brake should be adjusted,
even between services.
Have the system checked by a
PEUGEOT dealer.
Particle emission filter
(Diesel)
It is imperative that the particle emis-
s i o n i l t e r i s m a i n t a i n e d i n a c c o r d a n c e
with the manufacturer’s servicing
schedule, by a PEUGEOT dealer.
Note: following prolonged operation
of the vehicle at very low speed or at
idle, you may, in exceptional cases,
notice discharges of water vapour
at the exhaust on acceleration. This
has no effect on the behaviour of the
vehicle or on the environment. Brake pad wear depends
on the style of driving, in
particular for vehicles which
are used in town, over short
distances.
D i s c a n d d r u m w e a r s t a t u s
For any information relating to the wear
status of the surfaces of the discs and
drums, contact a PEUGEOT dealer
.
Only use products recom-
mended by PEUGEOT or
products of equivalent qual-
ity and characteristics.
To ensure best performance
from components as important as the
power steering and the braking sys-
tem, PEUGEOT selects and offers
q u i t e s p e c i i c p r o d u c t s .
To prevent damage to the electrical
units, high pressure washing to clean
the engine compartment is strictly
prohibited .
Oil filter
Used products
Avoid all prolonged contact of the
used oil with the skin.
B r a k e l u i d i s h a r m f u l t o h e a l t h a n d
very corrosive.
Air filter and passenger
compartment filter
Do not dispose of used oil,
b r a k e l u i d o r c o o l a n t i n t o
drains or onto the ground.
Empty the used oil into the
containers provided for this
purpose in the PEUGEOT network.
Battery
At the start of winter, have
your battery checked by a
PEUGEOT dealer.
Brake pads
It may be necessary to
check the thickness of the
pads, even between ser-
vices.
Handbrake
C h a n g e t h e i l t e r r e g u l a r l y ,
in accordance with the ser-
vicing schedule.
Manual gearbox
This does not require an oil
change. Have the level checked
in accordance with the manu-
facturer’s servicing schedule.
To check the main levels
a n d c e r t a i n c o m p o n e n t s ,
i n a c c o r d a n c e w i t h t h e
manufacturer’s servicing
s c h e d u l e , r e f e r t o t h e
pages of the servicing booklet
w h i c h c o r r e s p o n d t o y o u r v e h i -
cle’s engine.
H a v e t h e i l t e r e l e m e n t s r e -
placed regularly.
If you drive
i n d u s t y c o n d i t i o n s , c h a n g e
t h e m t w i c e a s o f t e n .
Page 148 of 212
10PRACTICAL INFORMATION
S p e c i a l f r o n t w i n d s c r e e n
wiper position
Within one minute of switching off
the ignition, operate the wipers
stalk to position the wiper blades
in the centre of the windscreen
(maintenance position).
C h a n g i n g a w i p e r b l a d e
Lift the wiper arm, then unclip the
blade and remove it.
Fit the new blade and push back
the arm.
Note: t h e s h o r t e s t b l a d e i s i t t e d o n
the vehicle’s right-hand windscreen
wiper arm.
T o r e t u r n t h e w i n d s c r e e n w i p e r s
t o t h e i r n o r m a l p o s i t i o n , s w i t c h o n
t h e i g n i t i o n a n d o p e r a t e t h e w i p e r
stalk.
BATTERY
T o c h a r g e t h e b a t t e r y u s i n g a
b a t t e r y c h a r g e r :
- Disconnect the battery starting
with the negative (-) terminal,
- Follow the instructions for use given by the battery charger
manufacturer,
- Check that the terminals and connectors are clean; if they are
covered with sulphate (white or
greenish deposit), disconnect
them and clean them,
- Reconnect the battery starting with the negative (-) terminal. Before disconnecting the
battery, you must wait for
2 minutes after switching off
the ignition.
Never disconnect a terminal when
the engine is running.
N e v e r c h a r g e a b a t t e r y w i t h o u t i r s t
disconnecting the terminals.
Close the windows and sunroof
before disconnecting the battery.
If they do not operate normally
following reconnection of the
battery, they must be reinitialised
(see sections "Reinitialisation of the
electric windows" and "Sunroof").
After every reconnection of the
battery, switch on the ignition and
wait 1 minute before starting to
allow the electronic systems to be
i n i t i a l i s e d . I f s l i g h t d i f i c u l t i e s a r e
experienced after this, please contact
a PEUGEOT dealer.
Following disconnection of the battery,
the remote control key and the GPS
satellite navigation system must
be reinitialised (see corresponding
section).
I t i s a d v i s a b l e t o d i s c o n n e c t t h e
b a t t e r y i f t h e v e h i c l e i s n o t t o b e
u s e d f o r a p e r i o d o f m o r e t h a n
one month.
T o s t a r t t h e v e h i c l e f r o m a n o t h e r
b a t t e r y :
- Connect the red cable to the positive (+) terminals of the two
batteries,
- Connect one end of the green or black cable to the negative (-)
terminal of the slave battery,
- Connect the other end of the green or black cable to an earth point on
the broken down vehicle as far as
possible from the battery,
-
Operate the starter, let the engine run,
- Wait for the engine to return to idle, then disconnect the cables. The batteries contain harmful
substances such as sulphuric
acid and lead. They must be
disposed of in accordance
with regulations and must never be
discarded with household waste.
Take used remote control and vehicle
batteries to an approved collection
point.
C H A N G I N G A W I N D S C R E E N
W I P E R B L A D E
Page 151 of 212
10PRACTICAL INFORMATION
136
D r i v i n g a d v i c e
D i s t r i b u t i o n o f l o a d s :
Distribute the load in the trailer so
that the heaviest items are as close
as possible to the axle and the nose
weight approaches the maximum
permitted without exceeding it.
Cooling:
towing a trailer on a slope increases
the temperature of the coolant.
As the fan is electrically controlled,
its cooling capacity is not dependent
on the engine speed.
To lower the engine speed, reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and
the outside temperature.
In all cases, pay attention to the
coolant temperature.
If the warning light comes on, stop
the vehicle and switch off the engine
as soon as possible. T y r e s :
check the tyre pressures of the towing
vehicle and of the trailer, observing
the recommended pressures.
Braking:
towing increases the
braking distance.
Lights: check the electrical
signalling on the trailer.
S i d e w i n d : take into account the
increased sensitivity to side wind.
T O W I N G A T R A I L E R , A
C A R A V A N , A B O A T , E T C . . .
Your vehicle is primarily designed
for transporting people and luggage
but it may also be used for towing a
trailer.
We recommend the use of original
PEUGEOT towbars and their
harnesses that have been tested and
approved from the design stage of
y o u r v e h i c l e a n d t h a t t h e i t t i n g o f t h e
towbar is entrusted to a PEUGEOT
dealer.
I f t h e t o w b a r i s n o t i t t e d b y a
PEUGEOT dealer, it is imperative
t h a t i t i s i t t e d u s i n g t h e e l e c t r i c a l
pre-equipment located at the rear of
the vehicle in accordance with the
manufacturer’s instructions.
Driving with a trailer subjects the
t o w i n g v e h i c l e t o m o r e s i g n i i c a n t
stress and its driver must be
particularly careful.
Air density decreases with altitude,
thus reducing engine performance.
Above 1 000 metres, the maximum
towing load must be reduced by 10 %
and so on for every 1 000 metres of
altitude.
The rear parking assistance function
will be disarmed automatically when
a t o w b a r i s i t t e d .