2005 Seat Ibiza 5D change wheel

If and when
192
– Engage the first gear, or put the selector lever to position P for
those vehicles with an automatic gearbox.
– If you are towing a trailer, unhitch it from your vehicle.
– Take the vehicle tools and the spare wheel out of the luggage
compartment.
WARNING
Put the hazard warning lights on and pl ace the warning triangle in position.
This is for your own safety and also warns other road users.
Caution
If you have to change the tyre on a gradient, block the wheel opposite the
wheel being changed by placing a stone or similar object under it to prevent
the vehicle from rolling away.
Note
Please observe legal requirements when doing so.Changing a wheelChange the wheel as described below
– Rem ove the wheel cover. Also refer to ⇒ page 193.
–Slacken the wheel bolts.
– Raise the car with the jack in the corresponding zone –
Ta k e o f f the wheel and then put on the spare wheel
– Lower the vehicle.
– Tighten the wheel bolts firmly in diagonal sequence with the box
spanner
–Replace the cover .
After changing a wheel
After changing the wheel there are still tasks to complete.– Put the tools and jack back in the luggage compartment.
– Place the wheel with the defective tyre in the luggage compart-
ment and secure it.
– Check the tyre pressure of the newly fitted tyre as soon as possible.
– Have the tightening torque of the wheel bolts checked as soon as possible with a torque wrench. The prescribed torque is 120 Nm.
Note•
If you notice that the wheel bolts are corroded and difficult to turn when
changing a wheel, they must be replaced before having the wheel bolt torque
checked.
•
In the interest of safety, drive at moderate speeds until the wheel bolt
torque has been checked.
ibiza_ingles Seite 192 Mittwoch, 5. Oktober 2005 5:17 17

If and when195
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Raising the vehicle
The vehicle must be raised with a jack to remove the wheel.
– Locate the jacking point under the door sill closest to the wheel
being changed ⇒ fig. 134.
– Wind up the jack under the jacking point until the arm of the jack is directly below the vertical rib under the door sill.
– Align the jack so that the arm of the jack fits around the rib under the door sill and the movable base plate of the jack is flat on the
ground ⇒ fig. 135.
– Raise the vehicle until the defect ive wheel is just clear of the
ground.Recesses at the front and rear of the door sills mark the jacking points
⇒ fig. 134 . A position has been made for each wheel. Do not fit the jack
anywhere else.
An unstable surface under the jack may cause the vehicle to slip off the jack.
Therefore, the jack must be fitted on solid ground offering good support. Use
a large and stable base, if necessary. On a hard, slippery surface (such as
tiles) use a rubber mat or similar to prevent the jack from slipping.
WARNING
•
Take all precautions so that the base of the jack does not slip. Failure to
do so could result in an accident.
•
The vehicle can be damaged if the jack is not applied at the correct
jacking points. There is also a risk of injury since the jack can slip off
suddenly if it is not properly engaged.
Fig. 134 The jacking
pointsFig. 135 Fitting the jack
ibiza_ingles Seite 195 Mittwoch, 5. Oktober 2005 5:17 17

If and when
196Removing and fitting the wheel
For removal and fitting the wheel, the following tasks must be
completed.Change the wheel as described below after loosening the wheel
bolts and raising the vehicle with the jack.
Removing a wheel
– Unscrew the bolts using the hexagonal tool in the handle of the
screwdriver (vehicle tool) and place them on a clean surface
⇒ fig. 136.
Fitting a wheel
– Screw in the wheel bolts and tighten them lightly using the hexagonal socket in the screwdriver handle.
The wheel bolts should be clean and turn easily. Before fitting the spare
wheel, inspect the condition of the whe el and hub mounting surfaces. These
surfaces must be clean before fitting the wheel.
The hexagonal socket in the screwdriver handle makes it easier to turn the
wheel bolts when they are loose. The reversible screwdrive r blade should be
removed when the tool is used for this purpose.
If tyres with a specific di rection of rotation are fitt ed, note the direction of
rotation.
Note
Do not use the hexagonal socket in the screwdriver handle to loosen or
tighten the wheel bolts.Theft inhibiting wheel bolts*
A special adapter is required to turn the theft inhibiting wheel
bolts.
Fig. 136 Wheel change:
Hexagon socket in screw-
driver handle to turn the
wheel bolts after they
have been loosened
Fig. 137 Theft inhibiting
wheel bolts
ibiza_ingles Seite 196 Mittwoch, 5. Oktober 2005 5:17 17

General notes on the technical data
222WeightsKerb weight refers to the basic model with a fuel tank filled to 90% capacity
and without optional extras. The figure quoted includes 75 kg to allow for the
weight of the driver.
For special versions and optional equipment fittings or for the addition of
accessories, the weight of the vehicle will increase ⇒.
WARNING
•
Please note that the centre of gravity may shift when transporting
heavy objects; this may affect the vehi cle's handling and lead to an acci-
dent. Always adjust your speed and dr iving style to suit road conditions
and requirements.
•
Never exceed the gross axle weight rating or the gross vehicle weight
rating. If the allowed axle load or the allowed total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
To w i n g a t r a i l e rTrailer weightsTrailer weights
The trailer weights and drawbar loads approved are selected in intensive
trials according to precisely defined criteria. The approved trailer weights are
valid for vehicles in EU for maximum speeds of 80 km/h (in certain circum-
stances up to 100 km/h). The figures may be different in other countries. All
data in the official vehicle documents take precedence over these data ⇒. Drawbar load
The
maximum permitted weight exerted by the trailer drawbar on the ball joint
of the towing bracket must not exceed 75 kg.
In the interest of road safety, we recommend that you always tow
approaching the maximum drawbar load. The response of the trailer on the
road will be poor if th e drawbar load is too small.
If the maximum permissible drawbar load cannot be met (e.g. with small,
empty and light-weight single axle trailers or tandem axle trailers with an axle
base of less than 1 metre), at least 4% of the actual trailer weight is a legal
stipulation for a drawbar load.
WARNING
•
For safety reasons, you should not drive at speeds above 80 km/h when
towing a trailer. This also applies to countries where higher speeds are
permitted.
•
Never exceed the maximum trailer weights or the draw bar loading. If
the permissible axle load or the perm issible total weight is exceeded, the
driving characteristics of the vehicle may change, leading to accidents,
injuries and damage to the vehicle.
WheelsTyre pressure, snow chains, wheel boltsTyre pressures
The sticker with the tyre pressure values can be found on the inside of the
tank flap. The tyre pressure values given there are for cold tyres. The slightly
raised pressures of warm tyres must not be reduced ⇒.
ibiza_ingles Seite 222 Mittwoch, 5. Oktober 2005 5:17 17

General notes on the technical data 223
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Snow chains
Snow chains may be fitted only to the
front wheels. Chains may be used on
the following tyres 155/80 R 13; 165/70 R 14 and 185/80 R 14.
Consult the chapter “wheels” of this manual.
Wheel bolts
After the wheels have been changed, the tightening torque of the wheel bolts
should be checked as soon as possible with a torque wrench ⇒. The tight-
ening torque for steel and alloy wheels is 120 Nm.
WARNING
•
Check the tyre pressure at least once per month. Correct tyre pressure
is very important. If the tyre pressure is too high or too low, there is an
increased danger of accidents, particularly at high speeds.
•
If the torque of the wheel bolts is too low, they could loosen whilst the
vehicle is in motion. Risk of accident! If the tightening torque is too high,
the wheel bolts and threads could be damaged.Note
We recommend that you ask your Authorised Service Centre for information
about appropriate wheel, tyre and snow chain size.
ibiza_ingles Seite 223 Mittwoch, 5. Oktober 2005 5:17 17

Technical Data239
Safety First
Operating instructions
Tips and Maintenance
Te c h n i c a l D a t a
Dimensions and capacities
Dimensions
Length, width 3.953 mm/ 1.698 mm
Height at kerb weight 1.441 mm
Front and rear projection 931 mm/ 662mm
Wheelbase 2.460 mm
Turning circle 10.54 m
Track width
a)
a)This data will change depending on the type of wheel rim.
Front Rear
1.435 mm 1.424 mm
1.419 mm 1.408 mm
Capacities
Fuel tank 45 litres, reserve 7 litres
Windscreen washer fluid container with headlight washer 2 l/ 4.5 l
Tyre pressure
Summer-grade tyres:
The correct tyre pressure can be seen on the sticker on the inside of the tank flap.
Winter tyres:
The pressure of these tyres is the same as the summer tyre pressure plus 0.2 bar.
ibiza_ingles Seite 239 Mittwoch, 5. Oktober 2005 5:17 17

Index
242CCar care
Exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Car care products . . . . . . . . . . . . . . . . . . . . . . . 153
Car phone . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Car washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Catalytic converter . . . . . . . . . . . . . . . . . . . . . . 144
Central locking . . . . . . . . . . . . . . . . . . . . . . . . . . 70 Automatic speed dependent locking and un-locking system* . . . . . . . . . . . . . . . . . . . . . 72
Emergency unlocking system . . . . . . . . . . . . 72
Locking system for invo luntary unlocking . . 72
Selective unlocking system* . . . . . . . . . . . . 71
Unlocking system* . . . . . . . . . . . . . . . . . . . . 72
Central locking button Central locking . . . . . . . . . . . . . . . . . . . . . . . 72
unlocking . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Cetane number . . . . . . . . . . . . . . . . . . . . . . . . . 168
Change lamps dipped headlight lamp . . . . . . . . . . . . . . . . 206
Changing gear See Manual gearbox . . . . . . . . . . . . . . . . . . 129
Changing lamps interior light and reading light . . . . . . . . . . 214
changing lamps rearlights on frame . . . . . . . . . . . . . . . . . . . 213
Changing the lamps glovebox light* . . . . . . . . . . . . . . . . . . . . . . 214
indicator lights . . . . . . . . . . . . . . . . . . . . . . 209
main beam lights . . . . . . . . . . . . . . . . . . . . 207 Main headlight lamps . . . . . . . . . . . . . . . . . 205
number plate light . . . . . . . . . . . . . . . . . . . 213
side beam lights . . . . . . . . . . . . . . . . . . . . . 208
Side indicator lights . . . .
. . . . . . . . . . . . . . 211
Changing windscreen wiper blades . . . . . . . . . 180
Chassis number . . . . . . . . . . . . . . . . . . . . . . . . 220
Checking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 184
Checking battery electrolyte level . . . . . . . . . . 184
Checking engine oil level . . . . . . . . . . . . . . . . . 174
Child safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Child seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45 Categorisation in groups . . . . . . . . . . . . . . . 45
Group 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Group 2 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Group 3 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 46
Groups 0 and 0+ . . . . . . . . . . . . . . . . . . . . . . 45
ISOFIX system . . . . . . . . . . . . . . . . . . . . . . . . 48
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . 44
Securing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 47
Child seats on the front passenger seat . . . . . . . . . . . . . 29
Cigarette lighter . . . . . . . . . . . . . . . . . . . . . . . . 109
Cleaning alloy wheels . . . . . . . . . . . . . . . . . . . . 158
Cleaning and caring for your vehicle . . . . . . . . 153
Cleaning chrome . . . . . . . . . . . . . . . . . . . . . . . . 157
Cleaning cloth seat covers . . . . . . . . . . . . . . . . 160
Cleaning dash panel . . . . . . . . . . . . . . . . . . . . . 159
Cleaning engine compartment . . . . . . . . . . . . . 159
Cleaning fabric trim . . . . . . . . . . . . . . . . . . . . . . 160
Cleaning leather . . . . . . . . . . . . . . . . . . . . . . . . 160 Cleaning plastic parts . . . . . . . . . . . . . . . . . . . . 159
Cleaning seat belts . . . . . . . . . . . . . . . . . . . . . . 161
Cleaning steel wheels . . . . . . . . . . . . . . . . . . . . 157
Cleaning windows . . . . . . . . . . . . . . . . . . . . . . . 156
Cleaning wooden trim . . . . . . . . . . . . . . . . . . . . 160
Climatronic
automatic mode . . . . . . . . . . . . . . . . . . . . . 120
controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
General notes . . . . . . . . . . . . . . . . . . . . . . . 121
manual mode . . . . . . . . . . . . . . . . . . . . . . . 120
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 54
Cockpit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Control Light switches . . . . . . . . . . . . . . . . . . . . . . . . 88
Control lamps . . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Control lighting . . . . . . . . . . . . . . . . . . . . . . . . . . 51
Controls Electric windows . . . . . . . . . . . . . . . . . . . . . . 83
Convenience closing Sliding/tilting roof . . . . . . . . . . . . . . . . . . . . 87
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Convenience opening Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . 85
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . 176, 177
Coolant Level . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
Coolant level warning light . . . . . . . . . . . . . . . . . . . . . . . . . 64
Coolant Loss . . . . . . . . . . . . . . . . . . . . . . . . . . . 177
ibiza_ingles Seite 242 Mittwoch, 5. Oktober 2005 5:17 17

Index245
Luggage compartment cover . . . . . . . . . . . . . . 112MMain beam . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Main beam headlights
Indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 64
Main headlight lamps . . . . . . . . . . . . . . . . . . . . 205
Manual gearbox . . . . . . . . . . . . . . . . . . . . . . . . . 129
Manual heating . . . . . . . . . . . . . . . . . . . . . . . . . 114 controls . . . . . . . . . . . . . . . . . . . . . . . . . . . . 113
Manual heating system Defrosting the windscreen . . . . . . . . . . . . . 114
Demisting the windscreen and side windows . .114
MFD . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Mileage display . . . . . . . . . . . . . . . . . . . . . . . . . . 58
Mirrors Exterior mirrors, electrical . . . . . . . . . . . . . . . 98
Interior mirror . . . . . . . . . . . . . . . . . . . . . . . . . 97
Make-up mirrors . . . . . . . . . . . . . . . . . . . . . . 93
Mobile phone . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Modifications . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Multi-function display . . . . . . . . . . . . . . . . . . . . . 55NNumber of seats . . . . . . . . . . . . . . . . . . . . . . . . . . 17OObservations . . . . . . . . . . . . . . . . . . . . . . . . . . . 145 Octane number . . . . . . . . . . . . . . . . . . . . . . . . . 167
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Oil change . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Oil properties . . . . . . . . . . . . . . . . . . . . . . . . . . . 173
One-touch opening and closing
Electric windows . . . . . . . . . . . . . . . . . . . . . . 84
Opening and locking . . . . . . . . . . . . . . . . . . . . . . 82
Overview Control lamps . . . . . . . . . . . . . . . . . . . . . . . . . 60
Instrument panel . . . . . . . . . . . . . . . . . . . . . . 51
Instruments . . . . . . . . . . . . . . . . . . . . . . . . . . 52
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . 60
PPaintworkPolishing . . . . . . . . . . . . . . . . . . . . . . . . . . . 156
Waxing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 155
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 134
Parking and dipped/si de lights . . . . . . . . . . . . . 62
Parking lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . 91
Parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
Parts replacement . . . . . . . . . . . . . . . . . . . . . . . 162
Pedals . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
Petrol . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 167 Trips to foreign countries . . . . . . . . . . . . . . 145
Petrol additives . . . . . . . . . . . . . . . . . . . . . . . . . 167
Petrol engines, starting . . . . . . . . . . . . . . . . . . . 126
Physical principles of a frontal collision . . . . . . 19
Plastic key tab . . . . . . . . . . . . . . . . . . . . . . . . . . . 75 Plastic parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 156
Pollen filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Pollution filter . . . . . . . . . . . . . . . . . . . . . . . . . . 121
RRadio frequency remote control
Changing the battery . . . . . . . . . . . . . . . . . . . 78
Radio wave remote control . . . . . . . . . . . . . . . . . 77
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 95
Rear cupholder* . . . . . . . . . . . . . . . . . . . . . . . . . 108
Rear fog lamp indicator lamp . . . . . . . . . . . . . . . . . . . . . . . . 88
Rear seat bench . . . . . . . . . . . . . . . . . . . . . . . . . 105
Rear seats, folding down . . . . . . . . . . . . . . . . . . . . . . . . 105
Rear window heating Heating element wires . . . . . . . . . . . . . . . . 157
Rear window wiper . . . . . . . . . . . . . . . . . . . . . . . 96
Rear-view mirror . . . . . . . . . . . . . . . . . . . . . . . . . . 97
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166
Remote control key Buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Synchronising . . . . . . . . . . . . . . . . . . . . . . . . 78
Removing and fitting the wheel . . . . . . . . . . . . 196
Repairs Airbags . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 30
Replacement keys . . . . . . . . . . . . . . . . . . . . . . . . 76
Replacing lamps fog lights . . . . . . . . . . . . . . . . . . . . . . . . . . . 210
ibiza_ingles Seite 245 Mittwoch, 5. Oktober 2005 5:17 17