REAR BUCKLE EASE OF USE IMPROVEMENT ± BO011-05 Revised November 9, 2005
Page 6 of 9
E. Install the floor anchor of the rear seat center belt assembly RH with the bolt
facing the arrow mark on the plate toward the front of the vehicle.
Torque: 42 N m (420 kgf cm, 31 ft lbf)
NOTE:
Ensure that the anchor does NOT run into any protrusions on the floor panel.
FrontProtrusion
Protrusion
F. Check the ELR lock.
Check that the belt locks when pulled out quickly.
13. Remove the rear seat center belt assembly LH.
Remove the bolt and remove the rear seat center belt assembly LH.
Repair
Procedure
(Continued)
REAR BUCKLE EASE OF USE IMPROVEMENT ± BO011-05 Revised November 9, 2005
Page 8 of 9
E. Install the floor anchor of the rear seat center belt assembly LH with the bolt
facing the arrow mark on the plate toward the front of the vehicle.
Torque: 42 N m (420 kgf cm, 31 ft lbf)
NOTE:
Ensure that the anchor does NOT run into any protrusions on the floor panel.
FrontProtrusion
Protrusion
F. Check the ELR lock.
Check that the belt locks when pulled out quickly.
15. Install the package tray trim panel assembly.
A.Without Sun Shade:
Engage the 6 claws and 2 clips to install the package tray trim panel assembly.
: Claw
: Clip
Repair
Procedure
(Continued)
Lexus Supports ASE CertificationPage 1 of 2
Title:
PASSENGER AIRBAG INDICATOR LAMP
Models:
'04 ± '05 ES 330 & RX 330
Technical Service
Information Bulletin
February 22, 2005
EL002-05
The passenger airbag indicator lamp may switch from ON to OFF for front seat
passengers weighing approximately less than 100 pounds, depending on their seating
position. It is important for the front seat passengers to know that proper operation of the
advanced frontal airbag system is highly dependent on the pressure placed on the seat
bottom. Situations that add or subtract sensed weight can result in occupant
misclassification. To minimize this situation:
Check seating posture.
± Passengers should be seated upright with their back against the seatback and
feet on the floor.
Check loading conditions.
± Extra weight from items such as bags or groceries or toys hanging on the
seatback can add to the sensed weight of the front seat passenger.
± A rear seat passenger lifting the front seat with their legs, objects placed under
the front seat, or the front seatback in contact with the rear seat can subtract from
the sensed weight of the front seat passenger.
If the passenger airbag indicator lamp continues to switch ON to OFF after checking the
above conditions, perform the following repair procedure.
NOTE:
The safest place for children is in the rear seat.
Please note that Lexus recommends
that you NEVER
install a rear±facing child restraint in the front passenger seat, even if
the passenger ªAirbag OFFº lamp is illuminated. Please refer to the Owner's Manual
for additional details.
2004 ± 2005 model year ES 330 and RX 330 vehicles produced BEFORE the
Production Change Effective VINs shown on the following page.
OP CODEDESCRIPTIONTIMEOFPT1T2
EL4014R & R Occupant Detection ECU0.789952±33010
89952±480108A74
Applicable Warranty*:
This repair is covered under the Lexus Comprehensive Warranty. This warranty is in
effect for 48 months or 50,000 miles, whichever occurs first, from the vehicle's
in-service date.
* Warranty application is limited to correction of a problem based upon a customer's specific complaint.
ELECTRICAL
Introduction
Applicable
Vehicles
Warranty
Information
