2004 Peugeot Partner VU Dag battery

PEUGEOT SERVICING25
22-12-2003
A AND C SERVICE LEVELS AND THE INTERMEDIATE VISIT
Level
Operations Description of operation 1st service
A C Intermediate
DRAIN/REFILLÐ Engine oilÐ Bleed fuel filter (diesel)Ð Oil filterÐ Petrol filter (according to engine)REPLACEÐ Diesel filter or element (according to engine)Ð Air filter elementÐ Spark plugs (petrol)Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if cap is removableLEVELÐ Screen wash (check + top-up)Ð Coolant (check + top-up)Ð Brake fluid (check + top-up)Ð Power steering fluid (check + top up according to specification)Ð Operation of lights and indicatorsÐ Condition of glass, headlamp and light lenses and mirrorsÐ HornÐ Windscreen washer jetsÐ Condition of wiper bladesÐ Condition and tension of the ancillary drive beltsÐ HandbrakeÐ Condition of hydraulic circuits (hoses and covers)CHECKÐ Condition of rubber boots and gaitersÐ Brake pads Ð Play in hubs, link rods, ball joints, flexible mountingsÐ Shock absorbersÐ Rear drum brake lining wearÐ Condition and pressure of tyres (including spare wheel)Ð Emission control check as per current legislation (petrol)Ð Smoke opacity (diesel)Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions. : Arduous conditions. * According to destination.

INSTRUMENTS AND CONTROLS
28
22-12-2003
1.
Seat belt not fastened warning light*
2. Passenger air bag disarmingwarning light*
3. Front and side air bags warninglight
4. Front fog lamps indicator light
5. Anti-lock braking system (ABS)warning light
6. Rear fog lamp indicator light
7. Diesel pre-heat warning light
8. Left hand direction indicator
9. Total distance recorder, serviceindicator and engine oil levelindicator 10.
Right hand direction indicator
11 . Engine diagnostics warning light
12. Main beam headlamps indicator light
13. Handbrake, low brake fluid leveland electronic brake forcedistribution warning light
14. Dipped beam headlampsindicator light
15. Battery charge warning light
16. Engine oil pressure andtemperature warning light
17. Water in diesel filter warning light
18. Low coolant level warning light 19.
Coolant temperature indicator
20. Total distance recorder button
21. Central (STOP) warning light
22. Speedometer
23. Rev counter
24. Lighting rheostat button
25. Fuel level indicator
26. Low fuel level warning light
* According to destination.
INSTRUMENT PANEL: PETROL-DIESEL MANUAL GEARBOX

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

INSTRUMENTS AND CONTROLS
30
22-12-2003
Seat belt not fastened warning light*
When the ignition is switchedon, this indicator light comes on
if the driver has not fastened his seat belt. Above 12 mph (20 km/h), the warning light flashes for two minutes accompa-nied by an audible signal which
becomes progressively louder. Oncethe two minutes have elapsed, thewarning light remains on until the driverfastens his seat belt.
Front and side airbags warning light
The light will come on for a few sec-onds when the ignition is switched on. With the engine running, illumination of this warning light indicates a faultin the air bags.
Consult a PEUGEOT dealer.
Battery charge warning light
This indicates one of the following:
Ð faulty operation of the charging circuit,
Ð slack battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator failure.
Consult a PEUGEOT dealer.
Engine diagnostics warning light
This comes on each time the ignitionis switched on. If it comes on with the engine running, this indicates incorrectoperation of the injection, ignition or
emission control system. There is arisk of damage to the catalyticconverter (petrol engine only).
Consult a PEUGEOT dealer.
* According to destination.
Water in diesel filter indicator*
There is a risk of damage to theinjection system.
Consult a PEUGEOT dealer as soon as possible.
Passenger air bag disarmedwarning light*
If the passenger air bag is disarmed, the warning light comes on when the ignitionis switched on and it remains on.
Always consult a PEUGEOT dealerif the warning light flashes. Low fuel levelwarning light
When this light first comes on, you haveenough fuel to drive
approximately
30 miles (50 km) . (The tank capacity is
approximately 55 litres for petrol engines
and 60 litres for Diesel engines.)
Diesel engine pre-heatwarning light
Wait until the warning light goes out before starting the engine. If the temperature is high enough, the warning light comes on for less
than one second. You can start theengine without waiting.
Coolant temperature indicator
Ð needle in zone (A), the tempera-
ture is correct,
Ð needle in zone (B), the tempera-
ture is too high. The central STOP
warning light flashes.
You must stop.
Consult a PEUGEOT dealer.

MULTIFUNCTION DISPLAY This displays the following infor- mation:
Ð the time,
Ð the date,
Ð the audio system displays,
Ð a door check (e.g.: ''left front dooropen''),
Ð warning messages (e.g.: ''remote control battery flat'') or information messages (e.g.: ''eco mode
active''), displayed temporarily.
CLOCK Button
1: hour adjustment.
Button 2: minute adjustment.
Press and hold the button for rapid advance.
YOUR PARTNER IN DETAIL 33
22-12-2003
Adjusting the parameters Press and hold button
1for two sec-
onds to access the settings; the data flashes, indicating it is ready to bemodified. Then, each press of button 1scrolls
through the various data in the fol- lowing order:
Ð language of information displayed,
Ð hours (12 then 24 hour mode),
Ð minutes,
Ð year,
Ð month,
Ð day. Pressing button 2alters the value of
the parameter selected. Press and hold for rapid advance (return to startafter the last possible value). After 7 seconds with no action, the main display returns; the modifieddata are now recorded.

YOUR PARTNER IN DETAIL61
THE KEYS The keys allow you to switch on the ignition and operate the passengerair bag disarming switch as well as toindependently operate the locks onthe doors and the fuel filler cap. Central locking From the front doors, the keys allow you to lock and unlock the doors andtailgate. If one of the doors or the tailgate is open, the central locking does notwork. The remote control performs the same functions at a distance.
Locating your vehicle
To locate your vehicle, if you have locked it, in a car park: press button A, the courtesy
lights come on and the direction indicators flash for a few seconds.
The remote control Locking Press button
Ato lock the vehicle.
This is confirmed by fixed lighting of the direction indicators for approxi-mately two seconds. Unlocking Press button B to unlock the vehicle.
This is confirmed by rapid flashing of the direction indicators. Note: if the vehicle is locked and
unlocking is activated inadvertently, unless the doors are opened within30 seconds, the vehicle will lock
automatically.
Changing the battery of the remote control The "battery flat" information is pro-
vided by an audible signal accompa-
nied by the message "Remote con-
trol battery flat" on the screen.
To change the battery, unclip thecasing using a coin at the ring
(CR 2016/3 volt battery). If the remote control does not work after the battery has been changed,re-programme the remote control. Programming the remote control  Switch off the ignition.
 Switch the ignition on again.
 Press button Aimmediately for a
few seconds.
 Switch off the ignition and remove the remote control key from the
ignition lock. The remote control isnow working again.
22-12-2003

22-12-2003
PRACTICAL INFORMATION85
1.
Power steering reservoir
2. Windscreen and headlamp* wash reservoir
3. Coolant reservoir 4.
Brake fluid reservoir
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil reservoir
* According to destination.
1.1 LITRE (60 bhp) and 1.4 LITRE (75 bhp) PETROL ENGINES

1.Power steering reservoir
2. Windscreen and headlamp* wash reservoir
3. Coolant reservoir 4.
Brake fluid reservoir
5. Battery
6. Air filter 7.
Dipstick
8. Engine oil reservoir
* According to destination.
1.9 LITRE (70 bhp) DIESEL ENGINE
PRACTICAL INFORMATION
86
22-12-2003