2004 ISUZU TF SERIES 4jh1

FUEL SYSTEM 6C – 7
INJECTION PUMP


RTW46CLF000201

4JA1T(L):
A Bosch Distributor Type Injection Pump is used. A single reciprocating/revolving plunger delivers the fuel uniformly
to the injection nozzles, regardless of the number of cylinders.
The governor, the injection timer, and the feed pump are all contained in the injection pump housing. The injection
pump is compact, light weight, and provides reliable high-speed operation.
The vacuum-type fast idle actuator increases the engine idling speed to provide the additional power required to
operate the air conditioner.
Fast idler diaphragm movement is caused by changes in the negative pressure created by the engine’s vacuum
pump.
The diaphragm motion is transferred to the injection pump control lever to increase or decrease the idling speed.

4JA1TC/4JH1TC:
The Bosch VP44 injection pump is electronically controlled. The pump controller combine to injection pump.
Signals from the pump controller are sent to the engine control module (ECM). In response to these signals, the
ECM selects the optimum fuel injection timing and volume for the existing driving conditions.

6C – 20 FUEL SYSTEM

7. Power Steering Pump Bracket


6C-4 8. Throttle Position Sensor Harness Connector
(4JA1TC/4JH1TC only)
Disconnect the harness connector from the throttle
position sensor.

9. Oil Level Gauge
10. Fuel Pipe
1) Disconnect the fuel hoses from the fuel filter or priming
pump.
2) Disconnect the fuel hoses from the injection pump.

11. Fuel Filter Assembly (Except EURO III model)
6C-5
12. Fuel Filter Bracket (Except EURO III model)
13. Leak Off Hose
Disconnect the leak off hose at the injection pump.
14. Injection Pipe Clip
15. Injection Pipe
1) Loosen the injection pipe sleeve nuts at the delivery
valve side and the injection nozzle side.
Note:
Do not apply excessive force to the injection pipes.
2) Loosen the injection pipe clip.
3) Remove the injection pipes.
Note:
Plug the delivery holder ports with the caps to prevent
the entry of foreign material.

16. Intake Manifold
1) Remove the EGR valve from the intake manifold and
EGR pipe.
2) Loosen the intake rubber hoses clip.
3) Loosen the intake manifold bolts and nuts.
17. Injection Pump Cover (4JA1TC/4JH1TC only)

FUEL SYSTEM 6C – 23



4JA1T (L)
RTW46CSH000101





4JA1TC/4JH1TC
RTW36AMH000101


















2. Injection Pump Bracket
1) Install the injection pump bracket (6) and the bracket
bolts (7) and (8) to the cylinder body. Temporarily
tighten the bracket bolts.
2) Tighten the bracket bolts (7) to the specified torque.
3) Tighten the bracket bolts (8) to the specified torque.
Note:
Tighten the bracket bolt (8) first.
Injection Pump Bracket Torque N·m(kg·m / lb ft)
(8) 19 (1.9 / 14)

(7) 40 (4.1 / 30)









3. Timing Check Hole Cover
Install the timing check hole cover and tighten bolts to the
specified torque.
Timing Check Hole Cover Bolts
Torque N·m(kg·m / lb ft)
8 (0.8 / 69)















4. Injection Pump Cover (4JA1TC/4JH1TC only)
5. Intake Manifold
1) Install the intake manifold with gasket.
Intake Manifold Bolts
Torque N·m(kg·m / lb ft)
19 (1.9 / 14)

Intake Manifold Nuts Torque N·m(kg·m / lb ft)
24 (2.4 / 17)

2) Install the EGR valve to the intake manifold and EGR
pipe temporarily.
3) Tighten the nuts and bolts to the specified torque

Torque N
m (kg
m/lb ft)
Nuts 24 (2.4/17)
Bolts 27 (2.8/20)

6C – 24 FUEL SYSTEM




6. Injection Pipe
Install the injection pipe.
Injection Pipe Torque N·m(kg·m / lb ft)
29 (3.0 / 22)
Nozzle Side (4JA1TC/4JH1TC) N·m(kg·m / lb ft)
29 (3.0 / 22)
Pump Side (4JA1TC/4JH1TC) N·m(kg·m / lb ft)
40 (4.1 / 30)





7. Injection Pipe Clip
Install the injection pipe clip.
Note:
Make absolutely sure that the clip is correctly
positioned.

Injection Pipe Clip Torque N·m(kg·m / lb in)
8 (0.8 / 69)

8. Leak Off Pipe and Leak Off Hose
Install the leak off pipe to injection nozzle and connect the
leak off hose to the injection pump.






9. Fuel Filter Bracket (Except EURO III model)
Install the fuel filter bracket and tighten bolts to the
specified torque.
Fuel Filter Bracket Bolts Torque N·m(kg·m / lb ft)
21 (2.1 / 15)









10. Fuel Filter Assembly (Except EURO III model)
Install the fuel filter assembly to bracket and tighten bolts
to the specified torque.
Fuel Filter Assembly Bolts
Torque N·m(kg·m / lb ft)
21 (2.1 / 15)
11. Fuel Pipe
1) Connect the fuel hoses to the fuel filter or priming
pump.
2) Connect the fuel hoses to the injection pump.









12. Oil Level Gauge
Install the oil level gauge and tighten bolts to the specified
torque.
Oil Level Gauge Bolts
Torque N·m(kg·m / lb ft)
M8: 19 (1.9 / 14)
M6: 8 (0.8/6 lb in)

FUEL SYSTEM 6C – 25







13. Throttle Position Sensor Harness Connector
(4JA1TC/4JH1TC only)
Reconnect the harness connector to the throttle position
sensor.
14. Power Steering Pump Bracket

15. Fan
16. Vacuum Hose
Connect the vacuum hose to the EGR valve and the
intake throttle.


Euro under Euro I Euro II Euro III
4JA1L without with with Not used
4JA1TC Not used Not used Not used With cooler
(EGR cooler)
4JH1TC without with with With
(EGR cooler)

17. Accelerator Control Cable
1) Connect the accelerator cable to the injection pump
(4JA1T) the intake throttle. (4JA1TC/4JH1TC only)
18. Power Steering Pump Assembly
19. Drive Belt
Install the drive belt and adjust the belt tension.
20. Battery

4JA1/4JH1 ENGINE DRIVEABILITY AND EMISSIONS 6E–1
ENGINE
CONTENTS
4JA1/4JH1 ENGINE DRIVEABILITY AND EMISSIONS
ABBREVIATION CHARTS ........................ 6E-9
4JA1-TC .................................................... 6E-10
4JH1-TC .................................................... 6E-11
ECM CIRCUIT DIAGRAM (4JA1-TC) ........ 6E-14
ECM CIRCUIT DIAGRAM (4JA1-TC) ........ 6E-15
ECM CIRCUIT DIAGRAM (4JH1-TC) ........ 6E-16
ECM CIRCUIT DIAGRAM (4JH1-TC) ........ 6E-17
GROUND POINT CHART GENERAL EXPORT
(LHD) (1/4) ............................................... 6E-18
LOCATION ................................................ 6E-34
PARTS LOCATION ................................... 6E-39
CONNECTOR LIST ................................... 6E-40
RELAY AND FUSE .................................... 6E-43
RELAY AND FUSE BOX LOCATION
(LHD & RHD) ........................................... 6E-43
RELAY AND FUSE BOX LOCATION
(LHD & RHD) ........................................... 6E-44
FUSE AND RELAY LOCATION (LHD & RHD) 6E-45
ECM WIRING DIAGRAM (1/7) .................. 6E-46
ECM WIRING DIAGRAM (2/7) .................. 6E-47
ECM WIRING DIAGRAM (3/7) .................. 6E-48
ECM WIRING DIAGRAM (4/7) .................. 6E-49
ECM WIRING DIAGRAM (5/7) .................. 6E-50
ECM WIRING DIAGRAM (6/7) .................. 6E-51
ECM WIRING DIAGRAM (7/7) .................. 6E-52
ECM CONNECTOR PIN ASSIGNMENT &
OUTPUT SIGNAL .................................... 6E-53
GENERAL DESCRIPTION FOR ECM AND
SENSORS ............................................... 6E-64
Engine Control Module (ECM) ................... 6E-64
Pump Control Unit (PSG) & Data Ex change
Between Control Module ......................... 6E-64
Mass Air Flow (MAF) Sensor & Intake Air
Temperature (IAT) Sensor ....................... 6E-65
Throttle Position Sensor (TPS) .................. 6E-66
Crankshaft Position (CKP) Sensor ............ 6E-66
Engine Coolant Temperature (ECT) Sensor 6E-67
Vehicle Speed Sensor (VSS) .................... 6E-67
GENERAL DESCRIPTION FOR EGR
(EXHAUST GAS RE-CIRCULATION) ..... 6E-68
GENERAL DESCRIPTION FOR
INJECTION PUMP .................................. 6E-70Outline ....................................................... 6E-70
Cross-section View .................................... 6E-70
Low Pressure Fuel Circuit .......................... 6E-71
High Pressure Fuel Circuit ......................... 6E-72
Pump Camshaft Speed Sensor ................. 6E-72
High Pressure Solenoid Valve ................... 6E-73
Timing Control Valve (TCV) ....................... 6E-74
ISUZU Strategy Based Diagnostics .............. 6E-76
Overview .................................................... 6E-76
STRATEGY BASED DIAGNOSTICS CHART 6E-76
Diagnostic Thought Process ...................... 6E-77
1. Verify the Complaint .............................. 6E-77
2. Perform Preliminary Checks .................. 6E-77
3. Check Bulletins and Troubleshooting Hints 6E-78
4. Perform Service Manual Diagnostic Checks 6E-78
5a and 5b. Perform Service Manual Diagnostic
Procedures .............................................. 6E-78
5c. Technician Self Diagnoses .................. 6E-78
5d. Intermittent Diagnosis .......................... 6E-79
5e. Vehicle Operates as Designed ............ 6E-80
6. Re-examine the complaint ..................... 6E-81
7. Repair and Verify Fix ............................. 6E-81
GENERAL SERVICE INFORMATION ....... 6E-82
ON-BOARD DIAGNOSTIC (OBD) ............. 6E-82
TECH 2 OPERATING FLOW CART
(START UP) ............................................. 6E-86
TYPICAL SCAN DATA & DEFINITIONS
(ENGINE DATA) ................................... 6E-88
TYPICAL SCAN DATA & DEFINITIONS
(ENGINE DATA) ................................... 6E-90
MISCELLANEOUS TEST .......................... 6E-92
Plotting Snapshot Graph ............................ 6E-93
Plotting Graph Flow Chart (Plotting graph
after obtaining vehicle information) .......... 6E-94
Flow Chart for Snapshot Replay
(Plotting Graph) ....................................... 6E-95
SNAPSHOT DISPLAY WITH TIS2000 ...... 6E-96
ON-BOARD DIAGNOSTIC (OBD) SYSTEM
CHECK .................................................... 6E-105
Circuit Description ...................................... 6E-105
Diagnostic Aids .......................................... 6E-105
Test Description ......................................... 6E-105

6E–2 4JA1/4JH1 ENGINE DRIVEABILITY AND EMISSIONS
On-Board Diagnostic (OBD) System Check 6E-106
NO CHECK ENGINE LAMP (MIL) ............. 6E-109
Circuit Description ..................................... 6E-109
Diagnostic Aids .......................................... 6E-109
No Check Engine Lamp (MIL) ................... 6E-110
CHECK ENGINE LAMP (MIL) “ON” STEADY 6E-112
Circuit description ...................................... 6E-112
Diagnostic Aids .......................................... 6E-112
Check Engine Lamp (MIL) On Steady ....... 6E-113
ECM Diagnostic Trouble Codes ................ 6E-114
DIAGNOSTIC TROUBLE CODE (DTC) P0100
(SYMPTOM CODE 7) (FLASH CODE 65)
MASS AIR FLOW (MAF) SENSOR
VOLTAGE SUPPLY CIRCUIT HIGH INPUT 6E-128
DIAGNOSTIC TROUBLE CODE (DTC) P0100
(SYMPTOM CODE 9) (FLASH CODE 65)
MASS AIR FLOW (MAF) SENSOR
VOLTAGE SUPPLY CIRCUIT LOW INPUT 6E-128
DIAGNOSTIC TROUBLE CODE (DTC) P0100
(SYMPTOM CODE B) (FLASH CODE 65)
MASS AIR FLOW (MAF) SENSOR OUTPUT
CIRCUIT LOW INPUT ............................. 6E-128
DIAGNOSTIC TROUBLE CODE (DTC) P0100
(SYMPTOM CODE C) (FLASH CODE 65)
MASS AIR FLOW (MAF) SENSOR OUTPUT
CIRCUIT HIGH INPUT ............................ 6E-128
Circuit Description ..................................... 6E-129
Diagnostic Aids .......................................... 6E-129
Diagnostic Trouble Code (DTC) P0100
(Symptom Code 7) (Flash Code 65) Mass
Air Flow (MAF) Sensor Voltage Supply
Circuit High Input ..................................... 6E-129
Diagnostic Trouble Code (DTC) P0100
(Symptom Code 9) (Flash Code 65) Mass
Air Flow (MAF) Sensor Voltage Supply
Circuit Low Input ...................................... 6E-132
Diagnostic Trouble Code (DTC) P0100
(Symptom Code B) (Flash Code 65) Mass
Air Flow (MAF) Sensor Output Circuit Low
Input ......................................................... 6E-134
Diagnostic Trouble Code (DTC) P0100 (Symptom
Code C) (Flash Code 65) Mass Air Flow (MAF)
Sensor Output Circuit High Input ............. 6E-137
DIAGNOSTIC TROUBLE CODE (DTC) P0105
(SYMPTOM CODE 1) (FLASH CODE 34)
VACUUM PRESSURE SENSOR CIRCUIT HIGH
INPUT ...................................................... 6E-140
DIAGNOSTIC TROUBLE CODE (DTC) P0105
(SYMPTOM CODE 2) (FLASH CODE 34)
VACUUM PRESSURE SENSOR CIRCUIT
LOW INPUT ............................................. 6E-140
DIAGNOSTIC TROUBLE CODE (DTC) P0105
(SYMPTOM CODE 7) (FLASH CODE 34) VACUUM PRESSURE SENSOR VOLTAGE
SUPPLY CIRCUIT HIGH INPUT ............. 6E-140
DIAGNOSTIC TROUBLE CODE (DTC) P0105
(SYMPTOM CODE 9) (FLASH CODE 34)
VACUUM PRESSURE SENSOR VOLTAGE
SUPPLY CIRCUIT LOW INPUT .............. 6E-140
Circuit description ...................................... 6E-141
Diagnostic Aids .......................................... 6E-141
Diagnostic Trouble Code (DTC) P0105
(Symptom Code 1) (Flash Code 34) Vacuum
Pressure Sensor Circuit High Input ......... 6E-142
Diagnostic Trouble Code (DTC) P0105
(Symptom Code 2) (Flash Code 34) Vacuum
Pressure Sensor Circuit Low Input ........... 6E-145
Diagnostic Trouble Code (DTC) P0105
(Symptom Code 7) (Flash Code 34) Vacuum
Pressure Sensor Voltage Supply Circuit
High Input ................................................. 6E-148
Diagnostic Trouble Code (DTC) P0105
(Symptom Code 9) (Flash Code 34) Vacuum
Pressure Sensor Voltage Supply Circuit Low
Input .......................................................... 6E-150
DIAGNOSTIC TROUBLE CODE (DTC) P0110
(SYMPTOM CODE 1) (FLASH CODE 23)
INTAKE AIR TEMPERATURE (IAT) SENSOR
CIRCUIT HIGH INPUT ............................ 6E-152
DIAGNOSTIC TROUBLE CODE (DTC) P0110
(SYMPTOM CODE 2) (FLASH CODE 23)
INTAKE AIR TEMPERATURE (IAT) SENSOR
CIRCUIT LOW INPUT ............................. 6E-152
Circuit Description ...................................... 6E-152
Diagnostic Aids .......................................... 6E-153
Diagnostic Trouble Code (DTC) P0110
(Symptom Code 1) (Flash Code 23) Intake Air
Temperature (IAT) Sensor Circuit High Input 6E-153
Diagnostic Trouble Code (DTC) P0110
(Symptom Code 2) (Flash Code 23) Intake Air
Temperature (IAT) Sensor Circuit Low Input 6E-157
DIAGNOSTIC TROUBLE CODE (DTC) P0115
(SYMPTOM CODE 1) (FLASH CODE 14)
ENGINE COOLANT TEMPERATURE SENSOR
CIRCUIT HIGHINPUT ............................. 6E-160
DIAGNOSTIC TROUBLE CODE (DTC) P0115
(SYMPTOM CODE 2) (FLASH CODE 14)
ENGINE COOLANT TEMPERATURE SENSOR
CIRCUIT LOW INPUT ............................. 6E-160
Circuit Description ...................................... 6E-160
Diagnostic Aids .......................................... 6E-161
Diagnostic Trouble Code (DTC) P0115
(Symptom Code 1) (Flash Code 14) Engine
Coolant Temperature Sensor Circuit
HighInput ................................................. 6E-161
Diagnostic Trouble Code (DTC) P0115

4JA1/4JH1 ENGINE DRIVEABILITY AND EMISSIONS 6E–3
(Symptom Code 2) (Flash Code 14) Engine
Coolant Temperature Sensor Circuit
LowInput .................................................. 6E-165
DIAGNOSTIC TROUBLE CODE (DTC) P0180
(SYMPTOM CODE B) (FLASH CODE 15)
FUEL TEMPERATURE SENSOR CIRCUIT
RANGE/PERFORMANCE ....................... 6E-168
Circuit Description ..................................... 6E-168
Diagnostic Aids .......................................... 6E-168
Diagnostic Trouble Code (DTC) P0180
(Symptom Code B) (Flash Code 15) Fuel
Temperature Sensor Circuit
Range/Performance ................................ 6E-169
DIAGNOSTIC TROUBLE CODE (DTC) P0215
(SYMPTOM CODE A) (FLASH CODE 52)
FUEL CUTOFF SOLENOID VALVE
MALFUNCTION ....................................... 6E-170
DIAGNOSTIC TROUBLE CODE (DTC) P0215
(SYMPTOM CODE B) (FLASH CODE 52)
FUEL CUTOFF SOLENOID VALVE
CIRCUIT HIGH INPUT ............................ 6E-170
DIAGNOSTIC TROUBLE CODE (DTC) P0215
(SYMPTOM CODE C) (FLASH CODE 52)
FUEL CUTOFF SOLENOID VALVE ALWAYS
ACTIVE .................................................... 6E-170
DIAGNOSTIC TROUBLE CODE (DTC) P0215
(SYMPTOM CODE D) (FLASH CODE 52)
FUEL CUTOFF SOLENOID VALVE
MALFUNCTION ....................................... 6E-170
Circuit Description ..................................... 6E-171
Diagnostic Aids .......................................... 6E-171
Diagnostic Trouble Code (DTC) P0215
(Symptom Code A) (Flash Code 52) Fuel
Cutoff Solenoid Valve Malfunction ........... 6E-171
Diagnostic Trouble Code (DTC) P0215
(Symptom Code B) (Flash Code 52) Fuel
Cutoff Solenoid Valve Circuit High Input . 6E-173
Diagnostic Trouble Code (DTC) P0215
(Symptom Code C) (Flash Code 52) Fuel
Cutoff Solenoid Valve Always Active ....... 6E-175
Diagnostic Trouble Code (DTC) P0215
(Symptom Code D) (Flash Code 52) Fuel
Cutoff Solenoid Valve Malfunction ........... 6E-177
DIAGNOSTIC TROUBLE CODE (DTC) P0216
(SYMPTOM CODE A) (FLASH CODE 54)
INJECTION TIMING CONTROL CIRCUIT
MALFUNCTION ....................................... 6E-178
DIAGNOSTIC TROUBLE CODE (DTC) P0216
(SYMPTOM CODE B) (FLASH CODE 54)
INJECTION TIMING CONTROL CIRCUIT
MALFUNCTION ....................................... 6E-178
Circuit Description ..................................... 6E-179
Diagnostic Aids .......................................... 6E-179Diagnostic Trouble Code (DTC) P0216
(Symptom Code A) (Flash Code 54) Injection
Timing Control Circuit Malfunction ........... 6E-180
Diagnostic Trouble Code (DTC) P0216
(Symptom Code B) (Flash Code 54) Injection
Timing Control Circuit Malfunction ........... 6E-180
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 3) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID "A" RANGE/PERFORMANCE 6E-183
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 4) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID"A" LOW ................................ 6E-183
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 4) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID "A" LOW ............................... 6E-183
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 5) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID "A" RANGE/PERFORMANCE 6E-183
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 6) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID "A" MALFUNCTION ............. 6E-183
DIAGNOSTIC TROUBLE CODE (DTC) P0243
(SYMPTOM CODE 8) (FLASH CODE 64)
TURBOCHARGER WASTEGATE
SOLENOID"A" HIGH ............................... 6E-183
Circuit description ...................................... 6E-184
Diagnostic Aids .......................................... 6E-184
Diagnostic Trouble Code (DTC) P0243
(Symptom Code 3) (Flash Ccode 64)
Turbocharger Wastegate Solenoid
"A" Range/Performance ........................... 6E-185
Diagnostic Trouble Code (DTC) P0243
(Symptom Code 4) (Flash Code 64)
Turbocharger Wastegate Solenoid "A" Low 6E-187
Diagnostic Trouble Code (DTC) P0243
(Symptom Code 5) (Flash Code 64)
Turbocharger Wastegate Solenoid "A"
Range/Performance ................................ 6E-190
Diagnostic Trouble Code (DTC) P0243
(Symptom Code 6) (Flash Code 64)
Turbocharger Wastegate Solenoid "A"
Malfunction .............................................. 6E-192
Diagnostic Trouble Code (DTC) P0243
(Symptom Code 8) (Flash Code 64)
Turbocharger Wastegate Solenoid "A" High 6E-194
DIAGNOSTIC TROUBLE CODE (DTC) P0251
(SYMPTOM CODE 6)
(FLASH CODE 53) INJECTION PUMP