2004 DODGE INTREPID radiator

Points to Remember
NOTE:
When the vehicle is stopped after a few miles of
operation, you may observe vapor coming from the front
of the engine compartment. This is normally a result of
moisture from rain, snow, or high humidity accumulat-
ing on the radiator and being vaporized when the
thermostat opens, allowing hot water to enter the radia-
tor.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
•Do not overfill the coolant bottle.
•Check coolant freeze point in the system.
•If frequent coolant additions are required, or if the
level in the recovery bottle does not drop when the
engine cools, the cooling system should be pressure
tested for leaks.
•Maintain coolant concentration of a minimum of 50%
ethylene glycol and high quality water with recom-
mended antifreeze for proper corrosion protection of
your engine cooling system that contains aluminum
components.
•Make sure that the radiator and coolant bottle hoses
are not kinked or obstructed.
•Keep the front of the radiator and air conditioning
condenser clean.
•Do not change the thermostat for summer or winter
operation. If replacement is ever necessary, install
ONLY the correct type thermostat. Other designs may
result in unsatisfactory engine cooling performance,
poor gas mileage, and increased emissions.
Hoses and Vacuum/Vapor Harnesses
Inspect surfaces of hoses and nylon tubing for evidence
of heat and mechanical damage. Hard or soft spots,
brittle rubber, cracking, checking, tears, cuts, abrasions,
and excessive swelling indicate deterioration of the rub-
ber.
MAINTAINING YOUR VEHICLE 191
7

Once a Month
•
Check tire pressure and look for unusual wear or
damage.
•Inspect the battery and clean and tighten the terminals
as required.
•Check the fluid levels of coolant reservoir, brake
master cylinder, power steering and transaxle and add
as needed.
•Check all lights and all other electrical items for correct
operation.
•Check rubber seals on each side of the radiator for
proper fit.
At Each Oil Change
•
Change the engine oil filter.
•Inspect the exhaust system.
•Inspect the brake hoses.
•Inspect the CV joints and front and rear suspension
components.
•Check the automatic transmission fluid level.
•Check the coolant level, hoses, and clamps.
•Rotate the tires at each oil change interval shown on
Schedule “A” 6,000 miles (10 000 km) or every other
interval shown on Schedule “B” 6,000 miles (10 000
km).
214 MAINTENANCE SCHEDULES
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Washing............................ 198
Waxing............................. 198
Wheels............................. 199
Windshield Wiper Blades............... 186
Climate Control........................ 114
Clock................................. 93
Coat Hook............................. 52
Compact Disc Maintenance............... 113
Compact Disc Player...................93,98
Compact Spare Tire..................... 139
Compass.............................. 79
Computer, Trip/Travel.................... 77
Console, Overhead....................... 70
Contract, Service....................... 230
Cooling System........................ 188
Adding Coolant (Antifreeze)............. 189
Coolant Level........................ 190
Disposal of Used Coolant............... 188
Drain, Flush, and Refill................. 188
Inspection........................... 188
Points to Remember................... 191
Pressure Cap........................ 189
Radiator Cap........................ 189Rubber and Plastic Components.......... 191
Selection of Coolant................... 189
Corrosion Protection.................... 197
Courtesy Lights......................... 61
Crankcase Emission Control System......... 180
Cruise Light........................... 89
Cup Holder............................ 52
Customer Assistance.................... 228
Daytime Running Lights.................. 63
Dealer Service......................... 171
Defroster, Rear Window.................. 117
Defroster, Windshield...............48,116,120
Diagnostic System, Onboard.............90,169
Dimmer Switch, Headlight................. 64
Disabled Vehicle Towing................. 163
Disposal
Antifreeze........................... 188
Engine Oil.......................... 177
Door Ajar Light......................... 89
Door Locks........................14,15,16
Door Locks, Automatic................... 16
Door Locks, Central...................... 15
240 INDEX

Pregnant Women and Seat Belts............. 32
Programmable Electronic Features.........71,75
Programming Transmitters............20,71,75
Radial Ply Tires........................ 138
Radiator Cap.......................... 189
Radio...........................93,100,105
Radio Operation........................ 114
Rear Window Defroster.................. 117
Reclining Front Seats..................... 56
Recommended Fluids, Lubricants and Genuine
Parts............................... 209
Reformulated Gasoline................... 144
Refrigerant............................ 182
Remote Keyless Entry.................... 18
Remote Trunk Release.................... 25
Replacement Tires...................... 141
Reporting Safety Defects................. 231
Restraint, Head......................... 57
Restraints, Occupant..................... 26
Rotation, Tires......................... 142
Safety Checks Inside Vehicle............... 48Safety Checks Outside Vehicle.............. 48
Safety, Exhaust Gas...................... 47
Safety Tips............................. 47
Schedule, Maintenance................... 212
Scheduled Maintenance.................. 172
Seat Belt Maintenance................... 201
Seat Belts............................26,27
Adjustable Upper Shoulder Anchorage...... 31
Child Restraint........................ 45
Extender............................ 32
Inspection........................... 48
Reminder............................ 89
Seats................................. 55
Adjustment.......................... 55
Cleaning............................ 199
Lumbar Support....................... 57
Power.............................. 56
Rear Folding......................... 58
Reclining............................ 56
Security Alarm......................... 23
Sentry Key............................. 9
Service Assistance...................... 228
Service Contract........................ 230
246 INDEX