2004 DODGE INTREPID timing belt

Engine Timing Belt
Replace the engine timing belt at the intervals described
in the appropriate maintenance schedule.
Crankcase Emission Control System
Proper operation of this system depends on freedom
from sticking or plugging due to deposits. As vehicle
mileage builds up, the PCV valve and passages may
accumulate deposits. If a valve is not working properly,
replace it with a new valve. DO NOT ATTEMPT TO
CLEAN THE OLD PCV VALVE!
Check ventilation hose for indication of damage or
plugging deposits. Replace if necessary.
Fuel Filter
A plugged fuel filter can cause hard starting or limit the
speed at which a vehicle can be driven. Should an
excessive amount of dirt accumulate in the fuel tank,
frequent replacement of the fuel filter which is mounted
in the fuel tank may be necessary. See your dealer for
service.
Air Cleaner Filter
Under normal driving conditions, replace the air filter at
the intervals shown on Schedule “A”. If, however, you
drive the vehicle frequently under dusty or severe con-
ditions, the filter element should be inspected periodi-
cally and replaced if necessary at the intervals shown on
Schedule “B”.
WARNING!
The air cleaner can provide a measure of protection
in the case of engine backfire. Do not remove the air
cleaner unless such removal is necessary for repair or
maintenance. Make sure that no one is near the
engine compartment before starting the vehicle with
the air cleaner removed. Failure to do so can result in
serious personal injury.
180 MAINTAINING YOUR VEHICLE

Miles 93,000 96,000 99,000 100,000 102,000 105,000
(Kilometers) (149 000) (154 000) (158 000) (160 000) (163 000) (168 000)
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XXX X
Replace theair cleaner filter.X
Inspect the front and rear brake linings and
rotors.X
Flush and replace the engine coolant. X
Replace theengine timing belt(Federal Emis-
sions).X
Replace theengine timing belt(California
Emissions).X
Replace thespark plugs.X
Adjust the drive belt tension.X
Change the differential fluid. X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
SCHEDULE “B” 221
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Miles 78,000 84,000 90,000 96,000 102,000
(Kilometers) (125 000) (134 000) (144 000) (154 000) (163 000)
[Months] [78] [84] [90] [96] [102]
Change engine oil and engine oil filter. X X X X X
Inspect theair cleaner filterand replace if re-
quired.*XX XX
Replace theair cleaner filter.*X
Adjust the drive belt tension. X
Inspect the front and rear brake linings and rotors. X
Replace thespark plugs.X
Check and replace, if necessary, thePCV valve.*‡ X
Replace theengine timing belt(Federal Emissions
equipped vehicles only).X
Replace theengine timing belt(California Emis-
sions equipped vehicles only).X
Flush and replace the engine coolant at 60 months
or 100,000 miles.X
* This maintenance is recommended by the manufacture
to the owner but is not required to maintain the emis-
sions warranty.
‡ This maintenance is not required if previously replaced.Inspection and service should also be performed anytime
a malfunction is observed or suspected. Retain all re-
ceipts.
224 SCHEDULE “A”
8
M
A
I
N
T
E
N
A
N
C
E
S
C
H
E
D
U
L
E
S

Door Opener, Garage..................... 70
Drive Belts............................ 178
Drive Shaft Universal Joints............... 184
Driving
On Slippery Surfaces.................. 161
With an Automatic Transaxle............ 129
Electric Remote Mirrors................... 54
Electronic Speed Control.................. 67
Emergency Flashers..................... 152
Emission Control System Maintenance. . 170,180,212
Engine
Air Cleaner.......................... 180
Block Heater......................... 129
Break-In Recommendations............... 47
Checking Oil Level.................... 172
Compartment.....................167,168
Cooling..........................89,188
Fails to Start......................... 128
Oil ..............................88,172
Oil Change Interval................... 174
Oil Selection......................... 175
Oil Synthetic......................... 177Overheating.......................89,152
Specifications........................ 208
Timing Belt.......................... 180
Entry System, Illuminated................. 14
Exhaust Gas Caution..................47,187
Exhaust System........................ 187
Exterior Lights.......................62,204
Filters
Air Cleaner.......................... 180
Automatic Transaxle................... 197
Engine Fuel......................... 180
Engine Oil.......................... 178
Flashers
Hazard Warning...................... 152
Flat Tire Changing...................... 153
Floor Shift Interlock...................... 13
Fluid Capacities........................ 208
Fluid Leaks............................ 48
Fog Lights............................. 63
Freeing A Stuck Vehicle.................. 162
Fuel...............................88,143
Adding............................. 146
INDEX 241
10

Service Engine Soon Light................ 169
Service Manuals........................ 233
Setting the Clock........................ 93
Shoulder Belts.......................... 31
Side Airbag............................ 38
Side View Mirror Adjustment............... 54
Side Window Demisters.................. 122
Signals, Turn........................... 64
Slippery Surfaces, Driving On............. 161
Snow Chains.......................... 140
Snow Tires............................ 140
Spare Tire............................ 139
Spark Plugs........................... 178
Specifications.......................... 208
Engine............................. 208
Speed Control........................67,89
Speedometer........................... 89
Starting.............................. 127
Steering
Linkage............................ 184
Power...........................135,183
Tilt Column.......................... 65
Stuck, Freeing......................... 162Sulfur in Gasoline...................... 145
Sun Roof............................76,77
Supplemental Restraint System - Airbag....... 33
Synthetic Engine Oil..................... 177
Tachometer............................ 88
Temperature Gauge, Engine Coolant......... 153
Theft Alarm............................ 23
Theft System........................... 23
Tilt Steering Column..................... 65
Time Delay, Headlight.................... 62
Timing Belt........................... 180
Tires ...........................48,136,235
Air Pressure......................136,137
Alignment.......................... 143
Balancing........................... 143
Chains............................. 140
Changing........................153,154
Flat Changing........................ 153
High Speed......................... 138
Jacking............................. 154
Pressure Label....................... 137
Quality Grading...................... 235
INDEX 247
10