2004 DACIA SUPERNOVA engine

89C
ELECTRIC DIAGRAMS
89C - 13
The fuse box placed in the engine compartment is attached in front of the left shock absorber
column and contains relays and fusible protecting the following electric circuits:
FUSE
NUMB ER
F01
F02
F03
F04
F17
F06 FUSE
TYPE
30A
40A
7,5A 5A
15A
7,5A PROTECTED C IRCUIT
In jectors, oxygen sensor resistance heating, canister
purging valve, injection computer, fuel pump, ignition coil.
Cooling blower ( vehicles with AC)
Injection computer ( + DC)
In jection computer( (+IC)
Fog headlights
AC compressor
RELAY
RELAY TYPE
CONT ROL LED
CIRCUIT
A
15A
Fog
headlamps
B
40A
C ooling
blower- 1/st
speed(vehicles
with AC)
D
30A
Injector s, canister purging
valve, oxygen sensor
heating resistance,
injection computer.
E
30A
AC
compressor
H
30A
Fuel
pump
Ignition
coil
B. For equipping E2(0), E3 ( EURO 2000)
C
30A
C ooling
blower- 2/
nd speed
(vehicle
with AC)
COCKPIT FUSE BOX
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 15
196 INJECTOR 489-99
199 FU EL LEVEL TRANSMITTER AND ELECTRIC PUMP 89-137
200 REAR WINDOW DEFROSTING 89-140
205 OIL PRESSUR E CONTAC T 89-97
209 CLIGHTS, TURNING LIGHTS, HORN SWITCH 89-106
210 ELECTRONIC CLOC K 89-120
212 WINDSCREEN WIPER MOTOR 89-115
216 RIGHT FRONT BRAKE PAD 89-119
217 LEFT FRONT BRAKE PAD 89-119
221 WINDSCREEN WASHING PUMP 89-117
222 VALVE POTENTIOMETER 89-97
225 DIAGNOSTIC SOCKET 89-127
226 RIGHT HEADLAMP 89-117
227 LEFT HEADLAMP 89-117
242 DOWNSTREAM OXYGEN SENSOR 89-104
244 WATER TEMPERATURE SENSOR 89-92
247 INSTRUMENT PANEL 89-127
250 SPEED TRANSDUC ER 89-109
255 RIGHT FRONT TURNING LAMP 89-118
256 LEFT FRONT TURNING LAMP 89-118
260 COCKPIT FUSE AND RELAYS BOX 89-111
261 R ADIO 89-120
262 COOLING MOTOR FAN (for vehicles with AC) 89-100
267 RIGHT SIDE SIGNALING LAMP 89-118
268 LEFT SIDE SIGNALING LAMP 89-119
272 INJECTION AIR TEMPERATURE SENSOR 89-96
298 CLIMATE CONTROL LIGHTING 89-123
319 AC STARTING BUTTON 89-123
321 MOTOR FAN RESISTANCE ( for vehicles with AC) 89-101
329 RIGHT FRONT CEILING LAMP 89-137
371 CANISTER PURGING VALVE 89-94
427 UCE ANTI-INTRUSION 89-134
438 ENGINE HOOD CONTACT 89-110
442 SIREN 89-110
454 RIGHT VOLUMETRIC SENSOR(Rx) 89-133
454 LEFT VOLUMETRIC SENSOR (Tx) 89-133
474 AC R ELAY (on board) 89-121
503 UCE DECODER 89-107
560 HATCHBAC K C ONTACT 89-140
597 ENGINE RELAYS AND FUSE BOX ( for vehicles without AC) 89-87
597 ENGINE RELAYS AND FUSE BOX ( for vehicles with AC) 89-89
600 CLIMATE CONTROL B LOWER 89-122
639 STOP-S3 LAMP (on roof) 89-139
639 STOP[ -S3 LAMP (in aileron) 89-139
649 STEP-BY-STEP ENGINE 89-96
654 ANTI-STARTING BUSHING 89-108
778 IGNITION COIL 89-93
857 FLASH RELAY 89-108
887 SUPSTREAM OXYGEN SENSOR 89-93
927 CHOCK SENSOR 89-95
993 ANTI-INTRUSION INDICATOR LED 89-133
WIRE FUNCTIONS INDEX IN CONNECTORS AND COUPLINGS
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 16
1033CA BATTERY PLUS PLUG 89-104
1091 ICP BRAKING SYSTEM 89-119
1202 AC PRESSUR E SENSOR 89-99
1335 FRONT ASHTRAY LIGHTING 89-129
MH 121 ENGIN E ELECTRIC MASS 89-103
MOTOR FAN MA SS 89-103
R 89 FRONT WIRING/ BRAKE PADS WEAR COUPLING 89-154
R 107 FRONT WIRING/ DASHB OARD C OUPLING 89-143
R 153 REAR WIRING/LEFT FRONT DOOR COUPLING 89-150
R 154 REAR WIRING/ RIGHT FRONT DOOR COUPLING 89-149
R 155 REAR WIRING/ LEFT REAR DOOR COUPLING 89-151
R 156 REAR WIRING/ RIGHT REAR DOOR COUPLING 89-152
R 157 REAR WIRING/ HATCHBAC K COUPLING 89-153
R 212 FRONT WIRING/ ENGINE COUPLING 89-147
R 265 FRONT WIRING/ REAR COUPLING 89-145
R 318 FRONT WIRING/ DASHB OARD C OUPLING 89-141
OBSERVATIONS:
-Connectors and couplings are represented backwards (from wires forward).
-Some electric c omponents are not connected to the vehicle wiring by means of multiple-way
connectors, but by means of protected individual pl ugs. For illustrating the type of the respective
plug, the following symbols are to be used:
Plug mother 6 mm
Plug father 6 mm
Plug mother broach Φ 3mm
Plug father broach Φ 3mm
Plug mother flag 6,3mm Plug mother 8mm
WIRE FUNCTIONS INDEX IN CONNECTORS AND COUPLINGS
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 18
ENGINE WIRINGB4101
Pos . Sectioning Destination
12,0 3CW CONTROL - CYLINDERS 2-3 IGNITIO N COIL
32,0 MMASS
40 ,6 3BB CANISTE R PURGING VA LVE CONTRO L
80 ,6 3JN CONTROL - BLOWER RELAY
90 ,35 31A CONTROL - WATER TEMPERATURE INDICA TOR
12 0, 63BU IDLE RUNNI NG REGULATOR CONTROL 1
13 0, 63CS IGNAL + WATER TEMPERA TURE SENSOR
15 0, 353GN ATMOSPHERIC PRESSURE SENSOR M AS S
16 0, 353F ATMOSPHERIC PRESSURE SENSOR SIGNAL
19 0, 5 T B1 DETONATION SENSOR SCREENING
20 0, 53SS IGNAL + DETONATION SENSOR
24 0, 63BL SIGNAL - ENGINE RPM > RPM SENSOR
26 0, 35HL DIAGNOSIS SIGNAL - LINE L
28 2, 0 M M A S S
29 0, 35AP29 + AFTER PROTECTED CONTACT > FUSE OUTLET F03
30 0, 6 BP37 + PROTECTED BATTERY > FUSE OUTLET F04
32 2, 03CV CONTROL - CYLINDERS 1-4 IGNITIO N COIL
33 2, 0 M M A S S
34 0, 353F H CONTROL – ANTI-POLLUTION INDICATOR
39 0, 63GT ACTUATORS RELAY CONTROL
41 0, 63BV IDLE RUNNI NG REGULATOR CONTROL 2
42 0, 6 3BW IDLE RUNNI NG REGULATOR CONTROL 3
43 0, 6 3AJ SIGNAL +VALVE POSITION POTENTIOMETER
44 0, 63GL DOWNSTREAM OXYGEN SENSOR SIGNAL
45 0, 63GK UPSTREAM OXYGEN SENSOR SIGNAL
49 0, 63BS IGNAL +AIR TEM PERATURE SENSOR
53 0, 3547F VEHICLE SPEED SIGNAL
54 0, 63BG SIGNAL - ENGINE RPM > RPM SENSOR
56 0, 35HK DIAGNOSIS SIGNAL - LINE K
58 0, 35H17I NJECTION CODED SIGNAL > ANTI-STARTER
59 1, 03CR CONTROL – INJECTOR 1
60 1, 03CT CONTROL – INJECTOR 3
63 1, 03GF CONTROL - UPSTREAM OXYGEN SENSOR HEATING
65 1, 03GG CONTROL - DOWNSTREAM OXYG EN SENSOR HEATING
66 1, 03NR + INJECTORS > ACTUATORS RELAY OUTLE T
68 0, 6 3AC CONTROL - FUEL PUMP RELAY
70 0, 35H7 RPM-METER SIGNAL > INJECTION COMPUTER
72 0, 63BX IDLE RUNNI NG REGULATOR CONTROL 4
73 0, 63JK - WATER TEMPERA TURE
74 0, 6 3AQ SIGNAL + VAL VE POTENTIOMETER
75 0, 63JL - VALVE POTENTIOMETE R
76 0, 63GJ DOWNSTREAM OXYGEN SENSOR MASS
77 0, 63JQ - AIR TEMPERA TURE SENSOR
78 0, 353D ATMOSPHERIC PRESSURE SENSOR > SUPPLY +
79 0, 53DQ - DETONATION SENSOR
80 0, 63GH UPSTREAM OXYGEN SENSOR MASS
89 1, 03CU CONTROL - INJECTOR 4
90 1, 03CS CONTROL – INJECTOR 2
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 20
Pos . SectioningDestination
12,0 3CW CONTROL - CYLIN DERS 2 -3 IGNITIO N COIL
32,0M M ASS
40 ,6 3BB CANISTER PURGIN G VALVE CO NTROL
80,63JN CONTROL - BLOWER RELAY
90 ,35 3 1 A CO N TROL - W AT E R T E MPERAT U RE IN D ICATOR
1 0 0 ,5 3 8 K AIR CO NDITIO NIN G SY STEM ST OPPIN G CO NTROL >
IN J ECTIO N CO MPU TER
1 2 0 ,6 3 BU IDLE RU NNING REGULATOR CO NTROL 1
1 3 0 ,6 3C SIGNAL + WATER TEMPERATURE SENSOR
1 5 0 ,35 3 G N ATMOSPH ERIC PRESSURE SENSOR MASS
1 6 0 ,35 3 F ATMOSPH ERIC PRESSURE SENSOR SIGNAL
1 8 0 ,6 3 8 X FREON PRESSURE SENSOR SIGNAL
1 9 0 ,5 T B1 DETONATION SE NSOR SCREENIN G
2 0 0 ,5 3S SIGNAL + DETONATION SE NSOR
2 4 0 ,6 3BL SIGNAL - ENGIN E RPM > RPM SENSOR
2 6 0 ,35 H L DIAGNOSIS SIG NAL - LIN E L
2 8 2 ,0 M MA SS
2 9 0 ,35 A P2 9 + AFTER PRO TECTED CO NTACT > FUSE OUTLET F0 3
3 0 0 ,6 BP3 7 + PROTECTED BATTERY > FUSE O UTLET F0 4
3 2 2 ,0 3CV CONTROL - CYLIN DERS 1 -4 IGNITIO N COIL
3 3 2 ,0 M MA SS
3 4 0 ,35 3 FH CO N TROL – A N TI-PO L LUTIO N IN DICAT O R
3 8 0 ,6 3 J P CONTROL – BLOWER RELAY TR.2
3 9 0 ,6 3 G T A CT UATORS RE LAY CO N TROL
4 1 0 ,6 3BV IDLE RU NNING REGULATOR CO NTROL 2
4 2 0 ,6 3BW IDLE RU NNING REGULATOR CO NTROL 3
4 3 0 ,6 3 A J SIGNAL +VALVE POSIT ION PO TENTIOMETER
4 4 0 ,6 3 G L DOWNSTREAM OXYGEN SENSOR SIGNAL
4 5 0 ,6 3 G K UPSTREAM OXYGEN SENSOR SIGNAL
4 6 0 ,5 38AS AIR CO NDITIO NIN G COMPRESSOR CONNECTIO N SIGNAL
4 9 0 ,6 3B SIGNAL +AIR TEMPERATURE SE NSOR
5 3 0 ,35 4 7 F VEHICLE SPEED SIGNAL
5 4 0 ,6 3 BG SIGNAL - ENGIN E RPM > RPM SENSOR
5 6 0 ,35 H K DIAGNOSIS SIG NAL - LIN E K
5 8 0 ,35 H 1 7 INJECTIO N CODED SIG NAL > ANTI-ST ARTER
5 9 1 ,0 3CR CONTROL – INJECTOR 1
6 0 1 ,0 3 CT CONTROL – INJECTOR 3
6 3 1 ,0 3 G F CONTROL - UPSTREAM OXYGEN SENSOR H EATING
6 5 1 ,0 3 G G CONTROL - DOWNSTREAM O XYGEN SE NSOR HEATING
6 6 1 ,0 3 N R +INJECTORS > ACTUATORS RE LAY OUTLET
6 8 0 ,6 3 A C CONTROL - FUEL PUMP RELAY
7 0 0 ,35 H 7 RPM-ME T ER SIG N AL > IN J ECTIO N CO MPU TER
7 2 0 ,6 3 BX IDLE RU NNING REGULATOR CO NTROL 4
7 3 0 ,6 3 J K - W AT E R T E MPERAT U RE
7 4 0 ,6 3 A Q SIGNAL + VALVE POTENTIOMETER
7 5 0 ,6 3 J L - VALVE POTENTIO METER
7 6 0 ,6 3 G J DOWNSTREAM OXYGEN SENSOR MASS
ENGINE WIRINGB41 01
CO NNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 21
ENGINE WIRINGB4101
Pos . Sectioning Destination
77 0 ,6 3 J Q - AIR TEMPERATURE SE NSOR
78 0 ,35 3 D ATMOSPH ERIC PRESSURE SENSOR > SUPPLY +
79 0 ,5 3 D Q - DET ONATION SE NSOR
80 0 ,6 3 G H UPSTREAM OXYGEN SENSOR MASS
82 0 ,6 3 8 U - FREON PRESSURE SENSOR
83 0 ,6 38Y + FREON PRESSURE SENSOR
89 1 ,0 3 CU CONTROL - INJECTOR 4
90 1 ,0 3CS CONTROL – INJECTOR 2
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 22
ENGINE RELAYS AND FUSE BOX

(FOR VEHICLES WITHOUT AIR CONDITIONING SYSTEM)
ENGINE WIRINGB41
01
NO
E2
R
C1 C 4 C2
3NR 3JN
A
A-V O R
R-V
A1 A4 A2
8A M
V
A N
R
H1 H4 H2
H3
A-V
A
G
M - G
R
D5
D1 D4 D2
BP17 3GT
D3
A-VI
R-N AS-R R
S1
R
S3G
G
E1 R
R
2
R
E3
R
S2
R-V
1
R
S 4
R
E4
R
597
BP37 BP17
3NR
BB BP17
3NA
AP29
AP293AC
BP17
A
BPR1 B
8D P
BPR1
BP7
49B
B BP7
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su

89C
ELECTRIC DIAGRAMS
89C - 23
ENGINE WIRINGB4101
Pos . Sectioning Destination
A1 0,5 8A + FOG LAMPS RELA Y
A2 0,5 M MASS
A3 1,0 BPR1 + BATTERY > FUSE OUTLET F17 > RELA Y
A5 1,0 8DP + PROTECTED FUSE > FOG LAMPS
C1 0,63 NR+ INJECTORS > ACTUATORS RELAY OUTLE T
C2 0,63 JN CONTROL – BLOWER RELAY, TR.1
C3 1, 5 BP7 + PROTECTED BATTERY > FUSE OUTLET F02
C5 1,54 9BCONTROL + BLOWER COOLING
D1 0, 6 BP17 + PROTECTED BATTERY > FUSE OUTLET F01
D2 0,63 GTINJECTION COMPUTER > ACTUATORS RELAY CONTROL
D3 5, 0 BP17 + PROTECTED BATTERY > FUSE OUTLET F01
D5 5,03 NR+ INJECTORS > ACTUATORS RELAY OUTLE T
H1 0, 6 AP29 + AFTER PROTECTED CONTACT > FUSE OUTLET F03
H2 0, 6 3AC CONTROL - FUEL PUMP RELAY
H3 5, 0 BP17 + PROTECTED BATTERY > FUSE OUTLET F01
H5 2, 0 3NA
+ IGNITION COIL, CHOKE SENSOR > FUEL PUMP RELA Y
H5 1, 4 3NA
+ IGNITION COIL, CHOKE SENSOR > FUEL PUMP RELA Y
E1 5,0B + BATTERY
E1 0, 6 B + BATTERY > FUSE INLET F04
S1 5,0 BP17 + PROTECTED BATTERY > FUSE OUTLET F01
E2 5, 0 B + BATTERY > STARTER
S2 1,5 BP7 + PROTECTED BA TTERY > FUSE OUTLET F02, BLOWER
COOLING
E3 1,0A SUPPLY + AFTER CONTACT
S3 0,6 AP29 +PROTECTED D.C. > ENGINE SAFETY RUNNING RELAY
S3 0,35 AP29
+ AFTER PROTECTED CONTACT > FUSE OUTLET F03
E4 0, 6 B + BATTERY > FUSE INLET F01
S4 0,6 BP37 + PROTECTED BATTERY > FUSE OUTLET F04
11 ,0 B + BATTER Y
21 ,0 BPR1 + BATTERY > FUSE O UTLET F17 >RELA Y
CONNECTORS AND CONNECTIONS WIRES FUNCTION
vnx.su