2004 CHRYSLER VOYAGER ECU

[x] Cancel search: ECU

Page 79 of 2585

CHRYSLER VOYAGER 2004  Service Manual (16) Install wheel and tire. (Refer to 22 - TIRES/
WHEELS - INSTALLATION)
(17) Tighten the wheel mounting stud nuts in
proper sequence until all nuts are torqued to half
specification. Then repeat the

Page 81 of 2585

CHRYSLER VOYAGER 2004  Service Manual ASSEMBLY - SHOCK ABSORBER (UPPER
BUSHING)
NOTE: This procedure applies to load-leveling
shock absorbers only.
(1) Install the Receiver, Special Tool 8526-1, into
the cup of the Ball Joint Press, Speci

Page 85 of 2585

CHRYSLER VOYAGER 2004  Service Manual (4) Using 2 jack stands positioned under the outer
ends of the axle, raise the axle enough to remove the
weight of the axle from the rear springs.
(5) Loosen and remove the spring plate bolts from
the

Page 86 of 2585

CHRYSLER VOYAGER 2004  Service Manual (5) Raise axle into correct position on leaf spring
with axle centered under spring locator post (Fig.
36).
(6) Verify that the leaf spring isolator is correctly
positioned in the spring plate.
(7) In

Page 88 of 2585

CHRYSLER VOYAGER 2004  Service Manual INSTALLATION
CAUTION: The following sequence must be fol-
lowed when tightening the pin nuts on the rear
hanger for the rear leaf spring. First the hanger pin
nuts must be tightened to the specified t

Page 104 of 2585

CHRYSLER VOYAGER 2004  Service Manual CAUTION: The steering knuckle to strut assembly
attaching bolts are serrated and must not be turned
during installation. Install nuts while holding bolts
stationary in the steering knuckle.
CAUTION: I

Page 113 of 2585

CHRYSLER VOYAGER 2004  Service Manual (4) Remove hub nut and washer.
CAUTION: The half shaft outer CV joint, when
installed, acts as a bolt and secures the hub/bear-
ing assembly. If the vehicle is to be supported or
moved on its wheels,

Page 125 of 2585

CHRYSLER VOYAGER 2004  Service Manual DIAGNOSIS AND TESTING - REAR DRIVELINE
MODULE OPERATION
Driveline module operation requires relatively
straight-forward diagnosis. Refer to the following
chart:
DRIVELINE MODULE DIAGNOSIS CHART
CONDIT
Page:   < prev 1-8 9-16 17-24 25-32 33-40 41-48 ... 288 next >