2003 SSANGYONG MUSSO steering

8B-18 SUPPLEMENTAL RESTRAINT SYSTEM(SRS)
MAINTENANCE AND REPAIR ON-VEHICLE SERVICE AIR BAG MODULE Removal & Installation Procedure
1. Remove the steering wheel rid (LH,RH) with a screwdriver.Installation Notice Each position mark (LH,RH) is stamped on the inner surface of the rids.
Tightening Torque 7 - 11 Nm
3. Disconnect the connectors and remove the air bag module.
4. Installation should follow the removal procedure in thereverse order.
2. Unscrew the bolts from both sides.
Installation Notice

8B-20 SUPPLEMENTAL RESTRAINT SYSTEM(SRS) Removal & Installation Procedure preceding work : removal of steering wheel
1. Turn the ignition switch to “OFF” position and disconnectthe battery negative cable. Start the procedure after waiting over 3oseconds.
2. Unscrew 3 screws from lower cover on steering column shaft and remove the lower cover.
3. Unscrew 4 screws from clock spring and remove the clock
spring
Installation Notice
Don’t try to repair and modify the clock spring.
When aligning the neutral position, turn to clockwise until it stops, and turn to counter clockwise until the marks are aligned

POSITION OF CONNECTORS AND GROUNDS 2-3
C361 C371C381C401C402C403 22
88626 White
ColorlessColorlessColorlessColorlessColorless Main - Co-Driver DoorFloor - Rear Left DoorFloor - Rear Right DoorFloor - Tail GateFloor - Tail GateFloor - Tail Gate
Inside Co-Driver Side Cowl PanelCenter 'B' PillarCenter Left 'B' PillarBehind The Left LampBehind The Left LampBehind The Left Lamp
2. CONNECTOR, GROUND AND SPLICE PACK INFORMATION
1) CONNECTOR
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
C101 C102C103C104C105C106C107 C108 C109C110C111C112C201C203C204C205 C206
C206B C207 C208C208
C208B C209C210C211C212 C213 C251C301C302C303 C304 C305 C351212 2
15 143 2
16 6
40 6 84
10 33
4 [6]
1616121584
1417 6 3
20 1614 12 6
22 Colorless Colorless
WhiteBlackBlackBlackBlack Black BlackBlackBlack Gray
White
Colorless WhiteBlackBlack Black BlackBlackBlackBlackBlackBlackBlack
White
Colorless Black
White WhiteWhite
Colorless White
Blue Main - Engine Main - EngineMain - EngineEngine - MainEngine - EngineGenerator - EngineGenerator - Engine Genertor - Engine Engine - MainMain - Engine MainEngine Main - ECM MainEngine Main - ECM MainMain - RoofMain Air BagMain - Driver SeatMain - T/MMain - Fuel Tank Main - Fuel Tank Main - T/MMain - T/MMain - T/MMain - T/MMain - T/MMain - T/MDLC Connector - MainMain - Air ConMain - ECM Main Driver Seat - Driver Seat, AUX Main - FloorMain - Floor Main - Floor Main - FloorMain - Floor Main - Driver DoorInside The Engine Room Fuse Block Inside The Engine Room Fuse BlockInside The Engine Room Fuse BlockUnder The Engine Room Fuse BlockBeside Pre-Heating Unit (DSL)Under The Air Cleaner Housing (DSL, Turbo)Under The Air Cleaner Housing (DSL, N/Turbo) Under The Air Cleaner Housing (GSL) Under The Coolant Reservoir TankBehind The ABS Module (HFM)Center The Engine Room Dash PanelCenter The Engine Room Dash PanelUpper The I/P Fuse BlockLeft The AudioUnder The Driver SeatUpper The T/C MotorUpper The T/C (DSL) Upper The T/C (GSL) Upper The T/CUpper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Upper The T/C (DSL)Upper The T/C (GSL)Beside The Steering ColumnBehind The Glove BoxBeside The ECM (MSE) Under The Driver Seat Beside The I/P Relay BlockBeside The I/P Relay BlockBeside The I/P Relay Block Inside Co-Driver Side Cowl Panel Beside Center ConsoleUpper The I/P Fuse Block
Connector
Number Connecting Wiring HarnessConnector PositionColorPin
Number
2) GROUND
G101 G102 G103G201 G202 G203G204G205 G206 G207G208 G209 G301G302G303 Ground Position
Wiring Harness
Ground
Number
Behind The Left LampBeside The Start Motor Behind The Right Head Lamp Right The I/P Fuse BlockBeside The STICSUpper The ECM Behind The Ashtray Beside The TCCUBeside The ABS Module Beside THe ECM Under THe CO-Driver SeatBeside The EBCMCenter The Left 'B' Pillar Beside The Left Rear Speaker Beside The Right Rear Speaker
Engine Engine Engine
Main MainMain Main MainMain Main MainMain
Floor Floor Floor
* [ ] : EURO III

5-32 ELECTRICAL WIRING DIAGRAMS
4) VSS, CLUTCH SWITCH, IMMOBILIZER CIRCUIT(1) W/O EURO III
1
13
37
36
60
23456789101112
61
73
97
96
120
62 63 64 65 66 67 68 69 70 71 72
ECM(MSE)
DLC Connector - Main Main Main MainMain Main
C211 (14Pin, Black) S201 (Black)
S205 (Colorless) G201 G202 G205
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
VSSIMMOBILIZER
UNIT DLC
C211
W/H DLC
STOP LAMP SWITCH
CONNECTOR(NUMBER) CONNECTING. WIRING HARNESSCONNECTOR POSITION
Beside The Steering Column Behind The Cluster Upper Left The AudioRight The I/P Fuse Block Beside The STICS Beside The TCCU
1234
141516 13 12 11 10 9
8765432112
3
CLUTCH
SWITCH 1
2112
34
CRUISE
CONTROL SWITCH
12
3456
910 1213
12
11
34
56
71 4
8
15 IGN 1
31 GND
G205
BrB
BRG202
LR
G201
S201
Cruise Control Switch
1
7
BrW Y
VSS
(M/T)
59 55YB
Y 5
F24
2
1 LW
BrWBrB BrW
S205BrB
3
3 2
57
Gr
4
52
13
43 12 2 1
14 43 49 21 29 58 60
ECM
GY
WB
W
Y
RGBr
YW BrBGY
YR
5
54
YGr
6
7
2
53 38 37
BR
BrB
"L"CAN "H"CAN BrW
1
3 6
15
10A
TOD
"A11"
"7"
DLC
Stop Lamp
Switch"4"
Clutch Switch(M/T) Stop Lamp
Switch
"2"
"7"
OVPR
"86"
Fuel Pump Relay "33"
Cluster (MIL) "29"
Cluster (RPM)
TCM
"A24" TCM
"A23"
TOD
"A11"
"16"
Cluster
Immobilizer C211
14
SIG
SIG SIG
5V
Read

5-34 ELECTRICAL WIRING DIAGRAMS(2) W/ EURO III
1
13
37
36
60
23456789101112
61
73
97
96
120
62 63 64 65 66 67 68 69 70 71 72
ECM(MSE)
DLC Connector - Main Main - Fuell Tank Main MainMain Main Main
C211 (14Pin, Black)C206B (6Pin, Black) S201 (Black) S205 (Colorless) G201 G202G205
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
VSSIMMOBILIZER
UNIT DLC
C211
W/H DLC
STOP LAMP SWITCH
CONNECTOR(NUMBER) CONNECTING. WIRING HARNESSCONNECTOR POSITION
Beside The Steering Column Upper The T/C (GSL) Behind The ClusterUpper Left The Audio Right The I/P Fuse Block Beside The STICS Beside The TCCU
1234
141516 13 12 11 10 9
8765432112
3
CLUTCH
SWITCH 1
2112
34
CRUISE
CONTROL SWITCH
12
3456
5
40 56 1
YG Y
Fuel Gauge
GC206B
6
1
15 IGN 1
31 GND
G205
BrB
BRG202
LR
G201
S201
Cruise Control Switch
1
7
BrW Y
VSS
(M/T)
59 55YB
Y 5
F24
2
1 LW
BrWBrB BrW
S205BrB
3
3 2
57
Gr
4
52
13
43 12 2 1
14 43 49 21 29 58 60
ECM
GY
WB
W
Y
RGBr
YW BrBGY
YR
5
54
YGr
6
7
2
53 38 37
BR
BrB
"L"CAN "H"CAN BrW
1
3 6
15
10A
TOD
"A11"
"7"
DLC
8
RY
Cluster "15" Stop Lamp
Switch"4"
Clutch Switch(M/T) Stop Lamp
Switch
"2"
"7"
OV PR
"86"
Fuel Pump Relay "33"
Cluster
(MIL) "29"
Cluster
(RPM)
TCM
"A24" TCM
"A23"
TOD
"A11"
"16"
Cluster
Immobilizer C211
14
SIG
SIG SIG
5V
Read
910 1213
12
11
34
56
71 4
8
FUEL
GANGE
321
654

5-46 ELECTRICAL WIRING DIAGRAMS
4) VSS, CLUTCH SWITCH, IMMOBILIZER CIRCUITDLC Connector - Main Main Main MainMain Main
C211 (14Pin, Black) S201 (Black) S205 (Colorless) G201 G202 G205
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
VSSIMMOBILIZER
UNIT
C211
W/H DLC STOP LAMP
SWITCH
CONNECTOR(NUMBER) CONNECTING. WIRING HARNESSCONNECTOR POSITION
Baside The Steering Column Behind The Cluster Upper Left The AudioRight The I/P Fuse Block Beside The STICS Beside The TCCU
123412
3
CLUTCHSWITCH
12
34
CRUISE CONTROL SWITCH
12
3456
11 2
29 38
28
13 2021
39 434842
CLUSTER
15
IGN 1
31 GND
G205
B
BBG202
LR
G201
S201
Cruise Control Switch
1
7
BrW Y
VSS
(M/T)
59 55YB
Y 5
F24
2
1 LW
BrB BrW
S205
LY Y W
(M/T) CAN
3
3 2
57
Gr
4
52
13
43 12 2 1
14 43 49 21 29 58 60
ECM
GY
WB
W
Y
RGBr
YW BrBGY
YR
5
54
YGr
6
7
42
53 38 37
BR
BrB
"L"CAN "H"CAN BrW
1
386
15
10A
TOD
"A10"
"7"
DLC
Stop Lamp
Switch"4"
Clutch Switch(M/T) Stop Lamp
Switch"2"
"7"
OVPR
"86"
Fuel Pump Relay "33"
Cluster (MIL) "2"
Cluster (RPM)
TCM
"A24" TCM
"A23"
TOD
"A11"
"16"
Cluster
Immobilizer C211
14
SIG
SIG SIG
5V
910 1213
12
11
34
56
71 4
8

5-74 ELECTRICAL WIRING DIAGRAMS
C303
W/H MAIN
9. DLC CIRCUIT
Main - Engine Main - Air Bag DLC Connector - MainMain - Floor Main Main Main
C103 (2Pin, White)
C203 (4Pin, Colorless) C211 (14Pin, Black) C303 (14Pin, White) S201 (Black)
S202 (Gray) G201
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
C203
W/H MAIN
C103
W/H MAIN
CONNECTOR(NUMBER) CONNECTING. WIRING HARNESSCONNECTOR POSITION
Inside The Engine Room Fuse Block Left The AudioBeside The Steering Column Beside The I/P Relay Block Behind The Cluster Behind The Cluster Right The I/P Fuse Block
12
34141516 13 12 11 10 9
87654321
DLC
C211
W/H DLC
1
2910 1213
12
11
34
56
71 4
812 45
78 3
9 101112 13 6
14

5-76 ELECTRICAL WIRING DIAGRAMS
10. TCM (GSL, BTRE)
1) POWER SUPPLY, GROUND, INDICATION LAMP CIRCUIT
TCM
B1
A1 B6
B7B14
A15 A30
A14
DLC Connector - Main Main MainMain
C211 (14Pin, Black)
S205 (Colorless) G201 G208
b. CONNECTOR IDENTIFICATION SYMBOL & PIN NUMBER POSITION
a. CONNECTOR INFORMATION
MODE SWITCH
CONNECTOR(NUMBER) CONNECTING. WIRING HARNESSCONNECTOR POSITION
Beside The Steering Column Upper Left The AudioRight The I/P Fuse Block Under THe CO-Driver Seat
123
141516 13 12 11 10 9
87654321
DLC
C211
W/H DLC
11 2
29 38
28
13 2021
39 434842
CLUSTER
910 1213
12
11
34
56
71 4
8
31
15
GND
G208
G208 G20112V
PW
3
4H 4L
1
2
A2
A30
A23
B 6
7 2
3
S205
1
5 A24 A22 A14 A5
SIG
12V A1
SIG
12V A15 A6 A12
SIG
12V
C211
5
"38" "A3"
TOD
"37"
ECM
(MSE)
"A10" TOD "A11"
TOD "14"
DLC
"8"
TCCU
F20
LW34
18
35 23 24
LW
BrW
BrW BrW
BrB BrB BrB
LG LGBBY
HL
CAN GB
BrW
"15"
TCCU TOD
"A9" Y GBr
TCM
BrW
LB
ClusterPOWER WIN- TER27
LgW
LgW
LgW
Mode
Switch
10A
F22
10A IGN 1