2003 NISSAN X-TRAIL mirror

MA-4
DESCRIPTION

DESCRIPTIONPFP:00000
Pre-delivery Inspection ItemsELS000Y5
Shown below are Pre-delivery Inspection Items required for the new vehicle. It is recommended that
necessary items other than those listed here be added, paying due regard to the conditions in each
country.
Perform applicable items on each model. Consult text of this section for specifications.
Install vehicle protection kit
Fit all accessories ordered (if applicable) (e.g. towbar, audio, navigation, air conditioner, styling kit)
UNDER HOOD — engine off
Check coolant level and cooling system for leaks
Charge battery and check terminals for condition
Check drive belts tension (diesel only)
Check fuel filter for water or dust (diesel only) and fuel system for leaks
Check engine oil level and for oil leaks
Check brake and clutch fluid levels and fluid lines for leaks
Check and top up washer reservoirs
Check power steering fluid level and fluid lines for leaks (if applicable)
Check air conditioning system for gas leaks (if applicable)
ON INSIDE AND OUTSIDE
Install transit fuse if removed for vehicle storage
Check instruments, gauges, lamps, horn and accessories for operation
Check wipers and washers for operation and adjustment
Check interior and door mirrors and sun visors for operation
Set radio code and set clock
Check parking brake adjustment
Check clutch pedal adjustment
Check steering lock operation
Check seat adjusters and seat belts for operation
Check all windows for operation and alignment
Check mouldings, trim and fittings for fit and alignment
Check weatherstrips for fit and adhesion
Check hood, trunk lid, door panels and fuel lid for fit and alignment
Check latches, keys, remote key, door locks and remote trunk lid and fuel lid release for operation
Check wheel nut torques
Check tyre pressure (incl. spare tyre)
Check tool kit and jack for operation
Check automatic transmission/transaxle starter inhibitor (if applicable)
Check sunroof for operation and alignment (if applicable)
UNDER BODY
Check manual transmission/transaxle, differential and transfer box for oil level and oil leaks
Tighten bolts and nuts steering linkage and gear box, axle/suspension parts, propeller and exhaust system
Check brake and clutch lines, and oil/fluid reservoirs for leaks
Remove front suspension spacer blocks (if applicable)
Check body mounting torque (if applicable)

PG-62
HARNESS

F/FOG LT Front Fog Lamp
F/PUMP EC Fuel Pump
FIAR EC Fuel Injector Adjustment Resistor
FRO2 EC Front Heated Oxygen Sensor
FRO2/H EC Front Heated Oxygen Sensor Heater
FRPS EC Fuel Rail Pressure Sensor
FTP EC Fuel Transport Pump
FTS EC Fuel Temperature Sensor
FTS AT A/T Fluid Temperature Sensor Circuit
FUEL EC Fuel Injection System Function
GLORLY EC Glow Relay
GLOW EC Glow Control System
H/AIM LT Headlamp Aiming Control System
H/LAMP LT Headlamp
H/SEAT SE Heated Seat
HEATER MTC Heater System
HLC WW Headlamp Cleaner
HO2S1 EC Heated Oxygen Sensor 1
HO2S1H EC Heated Oxygen Sensor 1 Heater
HO2S2 EC Heated Oxygen Sensor 2
HO2S2H EC Heated Oxygen Sensor 2 Heater
HORN WW Horn
IATS EC Intake Air Temperature Sensor
IATSEN EC Intake Air Temperature Sensor
IGNSYS EC Ignition System
ILL LT Illumination
INJECT EC Injector
INJ/PW EC Fuel Injector Power Supply Circuit
INT/L LT Map Lamp
IVC EC Intake Valve Timing Control Solenoid Valve
KS EC Knock Sensor
LOAD EC Electrical Load Signal
LPSV AT Line Pressure Solenoid Valve
MAFS EC Mass Air Flow Sensor
MAIN AT Main Power Supply and Ground Circuit
MAIN EC Main Power Supply and Ground Circuit
METER DI Speedometer, Tachometer, Temp. and Fuel Gauges
MIL/DL EC MIL & Data Link Connector
MIRROR GW Door Mirror
MULTI BL Multi-Remote Control System
NATS BL Nissan Anti-Theft System
NAVI AV Navigation System
NONDTC AT Non-Detective Items
OVRCSV AT Overrun Clutch Solenoid ValveCode Section Wiring Diagram Name

LT-66
ILLUMINATION

ILLUMINATIONPFP:27545
System Description EKS003C7
Power is supplied at all times

through 10A fuse [No. 31, located in the fuse and fusible link box]

to lighting switch terminal 11.
The lighting switch must be in the 1ST or 2ND position for illumination.
The following chart shows the power and ground connector terminals for the components included in the illu-
mination system.
Component Connector No. Power terminal Ground terminal
Headlamp washier switch M23 3 4
Headlamp aiming switch M24 3 4
Door mirror remote control switch M26 10 1
ESP off switch M25 3 4
Hazard switch M51 7 8
4WD mode switch M39 4 3
Rear window defogger switch M50 5 6
A/C auto amp. M52 12 11
Combination meter (LHD models) M46 56 66
Combination meter (RHD models) M46 45 56
Audio M42 2 1
CD auto changer M82 34 35
Heater control panel M55 2 6
A/T device M58 3 4
Cigarette lighter M56 3 2
Heated seat switch LH (LHD models) B131 5 6
Heated seat switch RH (LHD models) B132 5 6
Heated seat switch LH (RHD models) B35 5 6
Heated seat switch RH (RHD models) B34 5 6

IDX-4
ALPHABETICAL INDEX
EC-926, EC-1251
Daytime light system ........................................... LT-20
Daytime running light - See Daytime light system LT-20
DEF - Wiring diagram ....................................... GW-21
Desiccant Assembly ...................................... ATC-156
Diagnosis sensor unit ..................................... SRS-41
Diagnostic trouble code (DTC) ...................... EC-1223
Diagnostic trouble code (DTC) for OBD system EC-19,
EC-54
, EC-482, EC-513, EC-874, EC-894, EC-1205
Diagnostic trouble code (DTC) inspection priority chart
EC-76
, EC-523, EC-904, EC-1230
Differential gear (FF M/T) ..................... MT-23, MT-28
DLC - Wiring diagram ........................ EC-469, EC-861
Door glass ........................................... GW-80, GW-83
Door glass Fitting Adjustment ............. GW-80, GW-83
Door lock ................................................. BL-91, BL-95
Door mirror ........................................................ GW-86
Door trim ............................................................. EI-32
Door, front .......................................................... BL-18
Door, rear ........................................................... BL-18
Drive belt inspection(QR20DEQR25DE) ......... MA-20
Drive belt inspection(YD22DDTi) ...................... MA-27
Drive belt(QR20DEQR25DE) .......................... EM-13
Drive belt(YD22DDTi) ..................................... EM-131
Drive shaft (front) ............................................. FAX-11
Drive shaft (rear) ............................................. RAX-10
Driver air bag .................................................. SRS-30
Dropping resistor (A/T) ...................... AT-160, AT-393
DTC work support ............................................ EC-111
DTRL - Wiring diagram ....................................... LT-20
Dual pressure switch ........ ATC-18, ATC-95, ATC-158
Duct and grilles ............................... ATC-137, MTC-33
E
ECM input/output signal ....................... EC-95
, EC-543
ECM power supply EC-124, EC-282, EC-571, EC-664,
EC-937
, EC-1261
ECM relay ...................................... EC-1110, EC-1399
ECM/PW - Wiring diagram ................. EC-283, EC-665
ECTS - Wiring diagram ...... EC-164, EC-599, EC-983,
EC-1293
EGR function ................ EC-1073, EC-1080, EC-1465
EGR volume control valve ............ EC-1073, EC-1080,
EC-1465
EGRC/V - Wiring diagram ............. EC-1076, EC-1083,
EC-1467
Electric sunroof .................................................. RF-10
Electric throttle control actuator ........ EC-290, EC-292,
EC-310
, EC-668, EC-671, EC-690
Electrical load signal circuit ................ EC-456, EC-848
Electrical unit ..................................................... PG-72
Electrical units location ...................................... PG-65
Electronic ignition (EI) system ............. EC-37, EC-499
Engine control circuit diagram EC-93, EC-541, EC-917,
EC-1243
Engine control component parts location .......... EC-88,
EC-536
Engine control module (ECM) ........... EC-279, EC-661, EC-1089
, EC-1091, EC-1378, EC-1380
Engine control system diagram and chart ........ EC-30,
EC-492
, EC-883, EC-1214
Engine coolant temperature sensor (ECTS) ... EC-162,
EC-597
, EC-981, EC-1291
Engine coolant(QR20DEQR25DE) .................... CO-9
Engine coolant(YD22DDTi) .............................. CO-31
Engine fail-safe system ....................... EC-77, EC-524
Engine oil filter replacement(QR20DEQR25DE) .........
MA-25
Engine oil filter replacement(YD22DDTi) MA-33, MA-35
Engine oil precautions .......................................... GI-7
Engine oil replacement(QR20DEQR25DE) ..... MA-23
Engine oil replacement(YD22DDTi) .................. MA-33
Engine oil(QR20DEQR25DE) ............................. LU-7
Engine oil(YD22DDTi) ....................................... LU-20
Engine removal(QR20DEQR25DE) ................ EM-78
Engine removal(YD22DDTi) ........................... EM-208
ETC1 - Wiring diagram ..................... EC-293, EC-673
ETC2 - Wiring diagram ..................... EC-304, EC-684
ETC3 - Wiring diagram ..................... EC-311, EC-691
EVAP canister purge volume control solenoid valve ....
EC-265
, EC-473, EC-809, EC-865
EVAP vapor lines inspection(QR20DEQR25DE) ........
MA-26
Evaporative emission (EVAP) system EC-473, EC-865
Evaporator .................................................... ATC-158
Exhaust manifold(QR20DEQR25DE) .............. EM-23
Exhaust manifold(YD22DDTi) ......................... EM-141
Exhaust system ................................................... EX-2
Exhaust system inspection ..................... EX-2, MA-37
Expansion valve ............................................ ATC-159
Exterior EI-21, EI-22, EI-24, EI-25, EI-26, EI-27, EI-28,
EI-30
, EI-31
F
F/FOG - Wiring diagram ......................... LT-52
, LT-53
F/PUMP - Wiring diagram EC-444, EC-836, EC-1134,
EC-1422
Fan control amp. ............................. ATC-84, ATC-129
Fan switch ....................................................... MTC-18
FIAR - Wiring diagram .................. EC-1117, EC-1406
Final drive (FF M/T) .............................. MT-23, MT-28
Finisher, interior - See Trim ................................ EI-32
Finisher, rear panel ............................................. EI-31
Floor trim ............................................................. EI-38
Flow charts ......................................................... GI-23
Fluid temperature sensor (A/T) ........................ AT-111
Fluorescent leak detector ............................. ATC-160
Flywheel (clutch) ................................................ CL-14
Flywheel runout(QR20DEQR25DE) EM-108, EM-235
Fog lamp, front ................................................... LT-52
Fork rod (M/T) ....................................... MT-22, MT-27
Freeze frame data EC-55, EC-514, EC-895, EC-1223
FRO2 - Wiring diagram ..................... EC-772, EC-787
Front bumper ...................................................... EI-14
Front disc brake ................................................. BR-27
Front door .......................................................... BL-18

IDX-5
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
Front Door Trim ................................................... EI-32
Front fog lamp .................................................... LT-52
Front passenger air bag .................................. SRS-35
Front seat .......................................................... SE-24
Front seat belt ...................................................... SB-3
Front seat belt pre-tensioner .... SB-2, SRS-3, SRS-40
Front side air bag ............................................. SRS-37
Front suspension ............................................... FSU-5
Front washer ...................................................... WW-4
Front wiper ......................................................... WW-4
FRPS - Wiring diagram .................... EC-999, EC-1309
FTS - Wiring diagram ...................... EC-994, EC-1304
FUEL - Wiring diagram ...................... EC-218, EC-225
Fuel check valve ................................ EC-473, EC-865
Fuel cut control (at no load high engine speed) EC-38,
EC-500
, EC-887, EC-1218
Fuel filler lid ...................................................... BL-103
Fuel filter .......................................... EC-890, EC-1221
Fuel filter replacement(QR20DEQR25DE) .......... FL-4
Fuel filter replacement(YD22DDTi) ....... FL-17, MA-31
Fuel gauge ............................................................ DI-4
Fuel injection control system ........... EC-885, EC-1216
Fuel injection system ......................... EC-216, EC-223
Fuel injector adjustment resistor .... EC-1115, EC-1404
Fuel injector and fuel tube(QR20DEQR25DE) . EM-32
Fuel injector and fuel tube(YD22DDTi) ............ EM-157
Fuel line inspection(QR20DEQR25DE) . FL-3, MA-23
Fuel line inspection(YD22DDTi) ............ FL-16, MA-31
Fuel pressure check ............................ EC-48, EC-510
Fuel pressure release .......................... EC-48, EC-510
Fuel pump .......... EC-443, EC-835, EC-890, EC-1127,
EC-1416
Fuel pump and gauge(QR20DEQR25DE) .......... FL-4
Fuel rail pressure sensor ................. EC-997, EC-1307
Fuel system(QR20DEQR25DE) .......................... FL-3
Fuel system(YD22DDTi) ..................................... FL-16
Fuel tank(QR20DEQR25DE) ............................ FL-11
Fuel tank(YD22DDTi) ......................................... FL-23
Fuel temperature sensor ................. EC-993, EC-1303
Fuse ................................................................... PG-12
Fuse and fusible link box ................................... PG-76
Fusible link ......................................................... PG-12
G
Gauges ................................................................. DI-4
Gear components (M/T) ....................... MT-20, MT-25
Generator .......................................................... SC-12
Generator - See Alternator ................................ SC-12
Generic scan tool (GST) .................... EC-112, EC-931
Glass .................................................. GW-80, GW-83
GLOW - Wiring diagram EC-1070, EC-1170, EC-1458
Glow plug ....................................... EC-1169, EC-1457
Glow plug(YD22DDTi) ..................................... EM-152
Glow relay ...................... EC-1069, EC-1169, EC-1457
GPS antenna ..................................................... AV-43
Grille - See Exterior ............................................. EI-19
Ground distribution ............................................ PG-13
H
H/AIM - Wiring diagram ...................................... LT-29
H/LAMP - Wiring diagram ........................... LT-4, LT-7
H/MIRROR - Wiring diagram ............................ GW-21
Harness connector ............................................. PG-70
Harness layout ................................................... PG-30
Headlamp ............................................................. LT-4
Headlamp aiming control .................................... LT-29
Headlamp leveler - See Headlamp aiming control .......
LT-29
Headlamp washer ............................................ WW-20
Headlining - See Roof trim .................................. EI-39
Heated oxygen sensor 1 .... EC-176, EC-183, EC-193,
EC-318
, EC-324, EC-611, EC-618, EC-786
Heated oxygen sensor 1 heater ......... EC-138, EC-771
Heated oxygen sensor 2 .... EC-201, EC-208, EC-330,
EC-338
, EC-792
Heated oxygen sensor 2 heater ......... EC-144, EC-776
Heated seat ........................................... SE-18, SE-21
HEATER - Wiring diagram ................................ MTC-6
Heater and cooling unit (Heater core) ............ ATC-131
Heater mirror ..................................................... GW-21
Heater system - Wiring diagram ....................... MTC-6
Heater unit (heater core) .. ATC-136, MTC-27, MTC-30
HFC134a (R134a) system precaution ............... ATC-4
HFC134a (R134a) system service procedure ATC-141
HFC134a (R134a) system service tools .......... ATC-15
HFC134a system service equipment precaution ..........
ATC-10
HO2S1 - Wiring diaram ...... EC-178, EC-186, EC-196,
EC-613
, EC-620
HO2S1H - Wiring diagram ............................... EC-140
HO2S2 - Wiring diagram .... EC-203, EC-211, EC-333,
EC-341
HO2S2H - Wiring diagram ............................... EC-146
Hood .................................................................. BL-12
Horn ................................................................. WW-25
HORN - Wiring diagram ................................... WW-25
How to erase DTC ........................... EC-514, EC-1223
How to erase DTC for OBD system ..... EC-63, EC-895
I
IATS - Wiring diagram ...... EC-158
, EC-977, EC-1287
IATSEN - Wiring diagram ................................ EC-782
Identification ...................................... ATC-12, ATC-13
Idle air volume learning ........................ EC-46, EC-508
Idle speed ............. EC-79, EC-526, EC-905, EC-1231
Ignition coil ......................................... EC-417, EC-798
Ignition coil(QR20DEQR25DE) ....................... EM-29
Ignition control system ....................... EC-417, EC-798
Ignition timing ....................................... EC-79, EC-526
IGNSYS - Wiring diagram .................. EC-418, EC-799
ILL - Wiring diagram ........................................... LT-66
Illumination .......................................................... LT-66
In vehicle sensor ........... ATC-111, ATC-113, ATC-122
INJE/PW - Wiring diagram ............. EC-1158, EC-1446
INJECT - Wiring diagram . EC-429, EC-821, EC-1008,

IDX-6
ALPHABETICAL INDEX
EC-1124, EC-1163, EC-1317, EC-1413, EC-1451
Injection nozzle(YD22DDTi) ........................... EM-157
Injector ............................................... EC-428, EC-820
Input shaft (FF M/T) .............................. MT-20, MT-25
Intake air temperature sensor ........... EC-156, EC-781,
EC-976
, EC-1286
Intake door control linkage adjustment ............ ATC-81
Intake door motor ATC-79, ATC-128, MTC-11, MTC-26
Intake manifold(QR20DEQR25DE) ................. EM-17
Intake manifold(YD22DDTi) ............................ EM-136
Intake sensor ................................................. ATC-117
Intake valve timing control ................. EC-135, EC-582
Intake valve timing control solenoid valve ....... EC-286
Interior ....................... EI-32, EI-34, EI-35, EI-38, EI-39
Interior lamp ........................................................ LT-76
Interior lamp on-off control ...................... LT-76, LT-77
ISO 15031-5 Mode 1 - 9 ...................... EC-51, EC-892
IVC - Wiring diagram ....................................... EC-287
J
Joint connector (J/C) .......................................... PG-75
K
Keyless entry system - See Multi-remote control system
BL-74
Knock sensor (KS) ............................. EC-242, EC-633
KS - Wiring diagram ........................... EC-243, EC-634
L
LAN system circuit ........................................... ATC-69
License lamp ....................................................... LT-47
Line pressure test (A/T) ....................... AT-68, AT-260
Liquid gasket application ......................... LU-3, LU-17
Liquid gasket application(QR20DEQR25DE) ... EM-6,
EM-123
, CO-3, CO-25
LOAD - Wiring diagram ...................... EC-457, EC-849
Location of electrical units ................................. PG-65
Lock, door ............................................... BL-91, BL-95
Lubricant (R134a) A/C ........................ ATC-5, ATC-24
Lubrication circuit (engine)(QR20DEQR25DE) .. LU-5
Lubrication circuit (engine)(YD22DDTi) ............. LU-19
Lubrication oil A/C .......................................... ATC-164
Lubrication-locks, hinges and hood latches ...... MA-45
M
M/T major overhaul ............................... MT-28
, MT-37
M/T oil replacement ........................................... MT-11
M/T removal and installation .............................. MT-17
MAFS - Wiring diagram ..... EC-151, EC-592, EC-965,
EC-972
, EC-1282
Magnet clutch ................................. ATC-88, ATC-146
MAIN - Wiring diagram ...... EC-124, EC-571, EC-938,
EC-1262
Mainshaft (M/T) ..................................... MT-20, MT-25
Maintenance (engine)(YD22DDTi) ................... MA-27
Major overhaul (Transfer) .................................. TF-57
Malfunction indicator (MI) .... EC-64, EC-516, EC-896,
EC-1224
Mass air flow sensor (MAFS) ........... EC-149, EC-590,
EC-963
, EC-970, EC-1280
Master cylinder (brake) ...................................... BR-14
Master cylinder (clutch) ........................................ CL-8
Meter ..................................................................... DI-4
METER - Wiring diagram ......................... DI-14, DI-17
MIL/DL - Wiring diagram ............... EC-1202, EC-1498
MIRROR - Wiring diagram ............................... GW-87
Mirror defogger ................................................ GW-21
Mirror, door ...................................................... GW-86
Mirror, out side ................................................. GW-86
Misfire .............................................................. EC-237
Mode door control linkage adjustment ........... ATC-75,
ATC-134
, MTC-9, MTC-31
Mode door motor ............................ ATC-73, ATC-134
Molding - See Exterior ................... EI-22, EI-24, EI-25
Mud guard - See Exterior .................................... EI-24
MULTI - Wiring diagram ..................................... BL-77
Multiport fuel injection (MFI) system ... EC-34, EC-496
Multiport fuel injection precautions ....................... GI-6
Multi-remote control system ............................... BL-74
N
NATS - Wiring diagram .................................... BL-111
NATS (Nissan anti-theft system) ..................... BL-108
NATS (Nissan anti-theft system) precautions ....... GI-3
NVH troubleshooting (BR) ................................... BR-5
NVH troubleshooting (Transfer) ........................... TF-8
O
Oil cooler (engine)(QR20DEQR25DE) ............. LU-11
Oil cooler (engine)(YD22DDTi) .......................... LU-28
Oil filter(QR20DEQR25DE) .............................. LU-10
Oil filter(YD22DDTi) ........................................... LU-23
Oil pan (engine)(QR20DEQR25DE) ................ EM-25
Oil pan (engine)(YD22DDTi) ........................... EM-147
Oil pressure (engine)(QR20DEQR25DE) ........... LU-7
Oil pressure (engine)(YD22DDTi) ...................... LU-20
Oil pump (engine)(QR20DEQR25DE) .............. LU-13
Oil pump (engine)(YD22DDTi) ........................... LU-30
Oil seal replacement (engine)(QR20DEQR25DE) ......
EM-44
, EM-67, EM-82
On board diagnostic system . EC-51, EC-513, EC-892
Operating cylinder (clutch) ................................. CL-10
Out side mirror ................................................. GW-86
Overdrive control switch .................... AT-240, AT-327
Overheat ........... EC-348, EC-700, EC-1011, EC-1320
Oversize piston(QR20DEQR25DE) ............... EM-104
Oversize piston(YD22DDTi) ........................... EM-230
P
Park/Neutral position switch EC-373
, EC-725, EC-816,
EC-1182
, EC-1479