2003 Hyundai H-1 (Grand Starex) coolant reservoir

8-9
CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
G210A01A-AATCHECKING THE BATTERY
CHECKING THE BATTERY CHECKING THE BATTERY
CHECKING THE BATTERY
CHECKING THE BATTERY
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
When working with batteries, carefully ob-
When working with batteries, carefully ob- When working with batteries, carefully ob-
When working with batteries, carefully ob-
When working with batteries, carefully ob-
serve the following precautions to avoid
serve the following precautions to avoid serve the following precautions to avoid
serve the following precautions to avoid
serve the following precautions to avoid
serious injuries.
serious injuries. serious injuries.
serious injuries.
serious injuries. The fluid in the battery contains a strong solu- tion of sulfuric acid, which is poisonous andhighly corrosive. Be careful not to spill it onyourself or the car. If you do spill battery fluid onyourself, immediately do the following:
o If battery fluid is on your skin, flush the affected areas with water for at least 15minutes and then seek medical assistance.
o If battery fluid is in your eyes, rinse out your eyes with water and get medical assistanceas soon as possible. While you are beingdriven to get medical assistance, continueto rinse your eyes by using a sponge or softcloth saturated with water.
o If you swallow battery fluid, drink a large quantity of water or milk followed by milk ofmagnesia, eat a raw egg or drink vegetableoil. Get medical assistance as soon aspossible.
While batteries are being charged (either by abattery charger or by the vehicle’s alternator),they produce explosive gases. Always observethese warnings to prevent injuries from occur-ring:
WARNING:
WARNING: WARNING:
WARNING:
WARNING:
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia-
Do not open the reservoir tank lid or radia- tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
tor cap while the engine is hot. The coolant
system is under pressure and any hot cool-
system is under pressure and any hot cool- system is under pressure and any hot cool-
system is under pressure and any hot cool-
system is under pressure and any hot cool-
ant escaping could cause severe burns.
ant escaping could cause severe burns. ant escaping could cause severe burns.
ant escaping could cause severe burns.
ant escaping could cause severe burns.
I080B01P-GATAnti-freeze
Anti-freeze Anti-freeze
Anti-freeze
Anti-freeze
The engine coolant contains an ethylene glycol
anti-corrosion agent. The cylinder head and coolant pump housing are cast aluminium alloy,and periodic changing of the engine coolant isnecessary to prevent corrosion of these parts. Because of the necessity of this anti-corrosion
agent, the coolant must not be replaced withplain water even in summer.
The required concentration of anti-freeze differs
depending on the expected ambient tempera-ture.
Ambient tempera-ture (minimum) °C (°F) Anti-freeze concentration %
-10
(15)
30 -20
(-5)
40 -30
(-20)
50 -45
(-49)
60
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze
For effective anti-corrosion and anti-freeze performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen- performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
performance, keep the anti-freeze concen-
tration within the range of 30 to 60%.
tration within the range of 30 to 60%. tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
tration within the range of 30 to 60%.
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result in
Concentrations exceeding 60% will result ina reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool- a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
a reduction of both the anti-freeze and cool-
ing performance thus adversely affecting
ing performance thus adversely affecting ing performance thus adversely affecting
ing performance thus adversely affecting
ing performance thus adversely affecting
the engine.
the engine. the engine.
the engine.
the engine.
I080A01P-GAT
ENGINE COOLANT
ENGINE COOLANT ENGINE COOLANT
ENGINE COOLANT
ENGINE COOLANT
I080A01P-GAG
FULL
LOW
A translucent coolant reservoir tank is in the
engine compartment. The coolant level in this tank should be kept
between the "LOW" and "FULL" marks when measured while the engine is warm and idling.
The cooling system is a closed system and
normally the loss of coolant should be veryslight. A noticeable drop in the coolant levelcould indicate leakage.
If this occurs, have the system checked at an
authorized HYUNDAI dealer as soon as pos-sible.
If the level should drop below the "LOW" level
on the reservoir tank, add coolant.
Also, if the reservoir tank is completely empty,
remove the radiator cap and add coolant untilthe level reaches the filler neck.

CONSUMER INFORMATION
CONSUMER INFORMATION CONSUMER INFORMATION
CONSUMER INFORMATION
CONSUMER INFORMATION
8-12 I150A01P-GAT
WHEEL CONDITION
WHEEL CONDITION WHEEL CONDITION
WHEEL CONDITION
WHEEL CONDITION Check the tires for cuts, cracks and other damage. Replace the tires if there are deepcuts or cracks. Also check each tire for piecesof metal or pebbles. The use of worn tires can be very dangerous because of the greater chance of skidding orhydroplaning. The tread depth of the tires mustexceed 1.6 mm (0.06 in.) in order for the tiresto meet the minimum requirement for use.If there are belt-line wear indicators on thetires, they will appear in six places on thesurface of the tire thereby indicating that thetire no longer meets the minimum requirementfor use. When these wear indicators appear,the tires must be replaced with new one. Con-firm that the wheel nuts are tightened sufficient-ly. Refer to the section of this manual entitled"In case of emergency" for information con-cerning care of the tires.
I140A02P-GAT
TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID
TAILGATE WINDOW WASHER FLUID
LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed) LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed)
LEVEL (Minibus, Van) (If installed) After opening the cover of quarter trim panel which is located on the left side of quarter trim,check the fluid level. If the fluid level is low, refill the washer fluid.
I140A01P-1
I130A01P-GAT
WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL
WINDSHIELD WASHER FLUID LEVEL
The washer fluid reservoir supplies fluid to the
windshield washer system.
A good quality washer fluid should be used to fill
the washer reservoir. The fluid level should be checked more frequently during bad weather orwhenever the washer system is in more fre-quent use.
CAUTION:
CAUTION: CAUTION:
CAUTION:
CAUTION:
oo
oo
o Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant) Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant)
Radiator antifreeze (engine coolant)
should not be used in the washer system
should not be used in the washer system should not be used in the washer system
should not be used in the washer system
should not be used in the washer system
because it will damage the car’s finish.
because it will damage the car’s finish. because it will damage the car’s finish.
because it will damage the car’s finish.
because it will damage the car’s finish.
oo
oo
o
The washer lever should not be pulled
The washer lever should not be pulled The washer lever should not be pulled
The washer lever should not be pulled
The washer lever should not be pulled
and the washer should not be operated if
and the washer should not be operated if and the washer should not be operated if
and the washer should not be operated if
and the washer should not be operated if
the washer reservoir is empty. This can
the washer reservoir is empty. This can the washer reservoir is empty. This can
the washer reservoir is empty. This can
the washer reservoir is empty. This can
damage the washer fluid pump.
damage the washer fluid pump. damage the washer fluid pump.
damage the washer fluid pump.
damage the washer fluid pump.
I130A01P-1
the fan will automatically shut off. This is a
the fan will automatically shut off. This is a the fan will automatically shut off. This is a
the fan will automatically shut off. This is a
the fan will automatically shut off. This is a
normal condition.
normal condition. normal condition.
normal condition.
normal condition.
Wear indicator
1.6 mm (0.06 in.)
HGK248