2003 HONDA PILOT battery

Make sure the gas tank is nearly,
but not completely, f ull (around
3/4).
Make sure the vehicle has been
parked with the engine of f f or 8
hours or more.
Make sure the ambient
temperature is between 20° and
95°F.
Without touching the accelerator
pedal, start the engine and let it
idle f or 20 seconds.Keep the vehicle in Park.
Increase the engine speed to 2,000
rpm and hold it there until the
temperature gauge rises to at least
1/4of thescale(approximately3
minutes).
If you take your vehicle f or a state
emissions test shortly af ter the
battery has been disconnected or
gone dead, it may not pass the test.
This is because of certain ‘‘readiness
codes’’ that must be set in the on-
board diagnostics f or the emissions
systems. These codes are erased
when the battery is disconnected,
and set again only after several days
of driving under a variety of
conditions.
If the testing f acility determines that
the readiness codes are not set, you
will be requested to return at a later
date to complete the test. If you must
get the vehicle re-tested within the
next two or three days, you can
condition the vehicle for re-testing
by doing the f ollowing. Select a nearby lightly traveled
major highway where you can
maintain a speed of 50 to 60 mph
(80to97km/h)foratleast20
minutes. Drive on the highway in
D. Do not use the cruise control.
When traffic allows, drive for 90
seconds without moving the
accelerator pedal. (Vehicle speed
may vary slightly; this is okay.) If
you cannot do this f or a
continuous 90 seconds because of
traf f ic conditions, drive f or at least
30 seconds, then repeat it two
more times (for a total of 90
seconds).
T echnical Inf ormation
T esting of Readiness Codes
St at e Emissions T est ing
371

µµ
µ
µ
µ
µµ µ
µ a seat
belt that f ails to f unction properly is
coveredfortheusefullifeof the
vehicle.
provides
coverageforaslongasthepur-
chaser of the muf f ler owns the
vehicle.
all exterior body panels are
covered f or rust-through f rom the
inside f or the specif ied time period
with no mileage limit.
covers
your new vehicle, except f or the
battery, emissions control systems,
and accessories, against def ects in
materials and workmanship.
these two
warranties cover your vehicle’s emis-
sions control systems. Time, mileage,
and coverage are conditional. Please
read the warranty manual for exact
inf ormation.
this warranty gives up
to 100 percent credit toward a
replacement battery. Your new Honda is covered by these
warranties:
covers all genuine
Honda replacement parts against
defects in materials and workman-
ship. provides prorated
coverage f or a replacement battery
purchased f rom a Honda dealer.
Restrictions and exclusions apply to
all these warranties. Please read the
2003 Honda Warranty Inf ormation
booklet that came with your vehicle
f or precise inf ormation on warranty
coverages. Your Honda’s original
tires are covered by their
manuf acturer. Tire warranty
inf ormation is in a separate booklet.
Please ref er to the 2003 Warranty
Manual that came with your vehicle.
Honda Accessories are covered
under this warranty. Time and
mileage limits depend on the type of
accessory and other f actors. Please
read your warranty manual f or
details.Seat Belt Limited Warranty
Replacement Muf f ler L if et imeLimited Warranty
Rust Perf orat ion L imit ed Warrant y
New Car Limited Warranty
Emissions Cont rol Syst ems Def ect sWarrant y and EmissionsPerf ormance Warranty
Original Equipment Bat t ery L imit edWarranty Replacement Part s L imit ed
Warranty Replacement Bat t ery L imit ed
Warranty
Accessory Limited WarrantyU.S. Owners
Canadian Owners
Warranty Coverages
Warrant y and Cust omer Relat ions375

CONT INUED
...
Accessories and Modif ications . 223
................................
Accessories .223
...
Additional Safety Precaution . 224
............................
Modif ications .224
ACCESSORY (Ignition Key .......................................
Position) .82
............
Accessory Power Sockets . 110
....................
Additives, Engine Oil . 284
...............................
Airbag (SRS) .9, 50
.....................
Air Cleaner Element .297
......
Air Conditioning System . 118,130
..............................
Maintenance .306
.....................
Rear A/C Control .135
.................................
Usage .118, 130
...............
Air Outlets (Vents) . 120,128
.......................
Air Pressure, Tires .308
.......................
Alcohol in Gasoline .366
.......
Aluminum Wheels, Cleaning . 327
......................................
Antif reeze .287
Anti-lock Brakes (ABS) ....................
Indicator Light .63, 243
...................................
Operation .242
..............
Anti-thef t, Audio System . 153
.
Anti-thef t Steering Column Lock . 81..........................
Appearance Care .325
................
Audio System . 137,153,168
...
Automatic Seat Belt Tensioners . 48
...
Automatic Lighting Off Feature . 73
.............
Automatic Speed Control . 207
..............
Automatic Transmission . 233
..........................
Capacity, Fluid .362
...............
Checking Fluid Level . 293
.......................................
Shif ting .234
.
Shif t Lever Position Indicator . 233
................
Shif t Lever Positions . 234
....................
Shif t Lock Release . 236
Battery Charging System ...........................
Indicator .62, 348
............................
Jump Starting .343
..............................
Maintenance .302
............................
Specif ications .363
..............................
Bef ore Driving .215
....................................
Belts,Seat .8,46
.........................
Beverage Holders .105
.................................
Body Repairs .332 Brakes
...........
Anti-lock System (ABS) . 242
.............
Break-in, New Linings . 216
...........................................
Fluid .295
....................
Bulb Replacement .320
.......................................
Parking .104
.................
System Indicator . 63,351
........................
Wear Indicators .241
.............................
Braking System .241
.................
Break-in, New Vehicle . 216
..
Brightness Control, Instruments . 73
........................
Brights, Headlights .72
Bulb Replacement ..........................
Back-up Lights .321
..............................
Brake Lights .320
......................
Cargo Area Light .323
................
Front Parking Lights . 318
........
Front Side Marker Lights . 319
.................................
Headlights .317
..............
Individual Map Lights . 322
...................
License Plate Light . 321
.................................
Rear Bulbs .320
............................
Specif ications .363
............
Turn Signal Lights . 318,320
..............................
Bulbs, Halogen .317
Index
A
B
I

CONT INUED
..........
DOT Tire Quality Grading . 364
.....................................
Drive Belts .307
...........
Driver and Passenger Safety . 5
...........................................
Driving .229
....................................
Economy .222
.........................
In Bad Weather .245
................
In Foreign Countries . 367
..................
Dust and Pollen Filter . 307
...................................
DVD Player .190
..............................
Economy, Fuel .222
............
Emergencies on the Road . 333
.............
Battery, Jump Starting . 343
...........
Brake System Indicator . 351
................
Changing a Flat Tire . 335
.....
Charging System Indicator . 348
..................
Checking the Fuses . 353
.....
Low Oil Pressure Indicator . 347
...
Malf unction Indicator Lamp . 349
..................
Overheated Engine . 345
.........................
Emergency Brake .104
......................
Emergency Flashers .76
......................
Emergency Towing .358
.......................
Emissions Controls .368 Engine
....
Coolant Temperature Gauge . 68
.................................
Drive Belts .307
Malf unction Indicator ................................
Lamp .62, 349
........
Oil Pressure Indicator . 62,347
..............
Oil, What Kind to Use . 283
...............................
Overheating .345
............................
Specif ications .363
............................
Speed Limiter .236
.......................................
Starting .232
......................
Ethanol in Gasoline .366
.
Evaporative Emissions Controls . 368
...............................
Exhaust Fumes .56
Exhaust Gas Recirculation ........................................
System .369
Expectant Mothers, Use of Seat ........................................
Belts by .19
..................
Exterior, Cleaning the . 326
............................
Fabric, Cleaning .329
..........................
Fan, Interior .118, 131
Features, Comfort and ..............................
Convenience .117 ....................
Filling the Fuel Tank . 217
Filters ...............................................
Air .297
.......................
Air Conditioning .306
...............................................
Oil .285
.............
Flashers, Hazard Warning . 76
...................
Flat Tire, Changing a . 335
Fluids ..........
Automatic Transmission . 293
..........................................
Brake .295
..........................
Power Steering .296
..................
Windshield Washer . 292
FM Stereo Radio ...................................
Reception .176
...................
Folding the Third Seat . 95
.....
Foreign Countries, Driving in . 367
..........................
Four-way Flashers .76
.................................................
Fuel .216
......................
Fill Door and Cap .217
...........................................
Gauge .68
................
Octane Requirement . 216
...............................
Oxygenated .366
........................
Reserve Indicator .65
........................
Tank, Filling the .217
.....................
Fuses, Checking the .353
Index
E
F
III

Î
CONT INUED
.....................................
Tachometer .67
......
Taillights, Changing Bulbs in . 320
.
Taking Care of the Unexpected . 333
...................
Tape Player . 149,160,178
Technical Descriptions ......
DOT Tire Quality Grading . 364
.....
Emissions Control Systems . 368
.....................
Oxygenated Fuels .366
Three Way Catalytic ...............................
Converter .370
.......................
Temperature Gauge .68
...................
Tensioners, Seat Belts . 48
........
Testing of Readiness Codes . 371
............................
Thef t Protection .189
..
Three Way Catalytic Converter . 370
....................................
Timing Belt .308
.................................................
Seats .89
............
Folding the Second Seat . 94
...............
Folding the Third Seat . 95
..........................
Head Restraints .93
.........
Reclining the Second Seat . 92
............
Reclining the Third Seat . 92
........................
Rear Seat Access .94
...............................
Serial Number .360
...........................
Service Intervals .272
...........................
Service Manual .377
.........
Service Station Procedures . 217
Shif ting the Automatic .............................
Transmission .234
.....
Shif t Lever Position Indicator . 233
........................
Shif t Lock Release .236
Side Marker Lights, Bulb .........................
Replacement in .319
...............................
Signaling Turns .74
.....................................
Snow Tires .314
...................
Solvent-type Cleaners . 326
................
Sound System . 137,153,168
Spare Tire ......................................
Inf lating .334
............................
Specif ications .363
....................................
Spark Plugs .301
....................
Specif ications Charts . 362................................
Speed Control .207
...................................
Speedometer .67
..........
SRS, Additional Inf ormation . 50
...
Additional Safety Precautions . 55
..
How the SRS Indicator Works . 53
How Your Front Airbags .........................................
Work .50
...
How Your Side Airbags Work . 52
........................
SRS Components .50
..................................
SRS Service .55
.............................
SRS Indicator .53 ,62
....
START (Ignition Key Position) . 82
.......................
Starting the Engine .232
In Cold Weather at High ..................................
Altitude .232
................
With a Dead Battery . 343
..............
State Emissions Testing . 371
........
Steam Coming f rom Engine . 345
Steering Wheel ..................................
Adjustment .78
.............
Anti-theft Column Lock . 81
...
Stereo Sound System . 137,153,168
....................
Storing Your Vehicle .324
........................
Sunglasses Holder .108
........................................
Sun Visor .109 Supplemental Restraint System
......................................
Servicing .55
.........................
SRS Indicator .53 ,62
...................
System Components . 50
..................................
Synthetic Oil .284
Index
T
VII