2003 CHEVROLET ASTRO boot

Section 6 Maintenance Schedule
Maintenance Schedule ............................... 6.2
Introduction
................................................... 6.2
Your Vehicle and the Environment
.................... 6-2
Maintenance Requirements
.............................. 6-2
How This Section
is Organized ......................... 6-3
Part
A: Scheduled Maintenance Services ........... 6.4
Using Your Maintenance Schedule
.................... 6.4
Selecting the Right Schedule
........................... 6-5
Short Trip/City Scheduled Maintenance
.............. 6.7
Long Trip/Highway Scheduled Maintenance
...... 6.18
Part B: Owner Checks and Services
................ 6.26
At Each Fuel Fill
.......................................... 6-26
At Least Once a Month
................................. 6.26
At Least Twice a Year
................................... 6.26 At
Least Once a Year
................................... 6-27
Part C: Periodic Maintenance inspections
......... 6.30
Steering. Suspension and Front Drive Axle
Boot and Seal Inspection
............................ 6.30
Exhaust System Inspection
............................ 6.30
Fuel System Inspection
.................................. 6.30
Engine Cooling System Inspection
................... 6.30
Throttle System Inspection
............................ -6-31
Transfer Case and Front Axle
(All-Wheel Drive) Inspection
....................... -6-31
Brake System Inspection
................................ 6.31
Part D: Recommended Fluids
and Lubricants
.......................................... 6.32
Part E: Maintenance Record
........................... 6.34
6-
1

Part C: Periodic Maintenance
Inspections
Listed in this part are inspections and services which
should be performed at least twice a year (for instance,
each spring and fall).
You should let your dealer’s
service department or other qualified service center
do these jobs. Make sure any necessary repairs
are completed at once.
Proper procedures to perform these services may be
found in a service manual. See
Service Publications
Ordering Information on page
7- 1 1.
Steering, Suspension and Front
Drive Axle Boot and Seal Inspection
Inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc. Clean and then inspect the drive
axle boot seals for damage, tears or leakage. Replace
seals
if necessary.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body
near the exhaust system.
Look for broken, damaged,
missing or out-of-position parts as well as open seams,
holes, loose connections or other conditions which
could cause a heat build-up in the floor pan or could let
exhaust fumes into the vehicle. See
Engine Exhaust
on page
2-30.
Fuel System Inspection
Inspect the complete fuel system for damage or leaks.
Engine Cooling System Inspection
Inspect the hoses and have them replaced if they
are cracked, swollen or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed. Clean the
outside of the radiator and air conditioning condenser.
To help ensure proper operation, a pressure test of
the cooling system and pressure cap is recommended
at least once a year.
6-30

Inspection (cont.) Exhaust System
........................ ....... 6-30
Fuel System
............................................... 6-30
Part C
- Periodic Maintenance ....................... 6-30
Steering, Suspension and Front Drive Axle
Boot and Seal
......................................... 6-30
Throttle System
........................................... 6-31
Installing a Garage Door Opener
....................... 2-40
Instrument Panel Cluster
....................................................... 3-24
Overview
.................................................. 3-2
Instrument Panel Brightness Control
.............. 3-1 5
Instrument Panel Fuse Block ............................ 5-93
Interior Lamps
................................................ 3-15
Interior Plastic Components
.............................. 5-85
Introduction Transfer Case (All-Wheel Drive) Inspection
........ 6-31
Jump Starting
....................................... ... 5-47
Key Lock Cylinders Service
.............................. 6-27
Keys
............................................................... 2-2
Keyless Entry System
....................................... 2-4
L
Lamps
Exterior
...................................................... 3-12
Interior
....................................................... 3-15
Lap Belt
........................................................ 1-27
Lap-Shoulder Belt
................................... 1-18, 1-29
LATCH System
Child Restraints
........................................... 1-52
Securing a Child Restraint Designed for
the LATCH System
........................... . 1-54
Latches, Seatback
............................................ 1-6
Leather
......................................................... 5-85
Leaving Your Vehicle
....................................... 2-10
Leaving Your Vehicle With the
Engine Running
.......................................... 2-28
Light
Air Bag Readiness
....................................... 3-26
Brake System Warning
................................. 3-28
Charging System
......................................... 3-27
Check Gages Warning
................................. 3-36
Low Fuel Warning
....................................... 3-37
Malfunction Indicator
.................................... 3-30
Safety Belt Reminder
................................... 3-26
Security
.............................................. 3-35
Service All-Wheel-Drive
......................... 3-35
Tow/Haul Mode
........................................... 3-36
Lamps On Reminder
....................................... 3-14
Anti-Lock Brake System Warning
................... 3-29
7

Loading Your Vehicle ....................................... 4-29
Locks Door
........................................................... 2-7
Front Doors
.................................................. 2-8
Leaving Your Vehicle
.................................... 2-10
Power Door
.................................................. 2-8
Programmable Automatic Door Locks
............... 2-9
Long Trip/Highway Definition
.............................. 6-6
Long Trip/Highway Intervals
............................... 6-6
Long Trip/Highway Scheduled Maintenance
........ 6-1 8
Loss
of Control ............................................... 4-1 3
Low Fuel Warning Light
................................... 3-37
Lumbar
Luggage
Carrier
.............................................. 2-44
Manual Controls
............................................ 1-3
M
Maintenance. Normal Replacement Parts .......... 5-1 01
Maintenance Schedule At Each Fuel Fill
......................................... 6-26
At Least Once a Month
................................ 6-26
At Least Once a Year
.................................. 6-27
At Least Twice a Year
.................................. 6-26
Brake System Inspection
.............................. 6-31
Engine Cooling System Inspection
................. 6-30
Fuel System Inspection
................................ 6-30
How This Section is Organized
....................... 6-3
Exhaust System
Inspection
........................... 6-30 Maintenance Schedule (cont.)
Introduction
.................................................. 6-2
Long Trip/Highway Scheduled Maintenance
..... 6-18
Maintenance Requirements
............................. 6-2
Part A
. Scheduled Maintenance Services ......... 6-4
Part B
. Owner Checks and Services ............. 6-26
Part C
. Periodic Maintenance Inspections ...... 6-30
Part D
- Recommended Fluids and
Lubricants
............................................... 6-32
Part E
. Maintenance Record ........................ 6-34
Selecting the Right Schedule
.......................... 6-5
Short Trip/City Scheduled Maintenance
............. 6-7
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection
.......................... 6-30
Using Your
................................................... 6-4
Your Vehicle and the Environment
................... 6-2
Maintenance When Trailer Towing
..................... 4-40
Throttle
System Inspection
............................ 6-31
Making Turns
................................................. 4-38
Malfunction Indicator Light
................................ 3-30
Manual Lumbar Controls
.................................... 1-3
Manual Seats
................................................... 1-2
Manual Windows
........................................ 2-16
Mirrors Manual Rearview Mirror
................................ 2-32
Outside Convex Mirror
................................. 2-33
Outside Manual Mirrors
................................ 2-32
Outside Power Mirrors
.................................. 2-32
Model Reference
............................................ vi
8

Service (cont.)
Doing Your Own Work
................................... 5-3
Engine Soon Light
....................................... 3-30
Publications Ordering Information
................... 7-1 1
Sewice Bulletins ............................................. 7-1 2
Service Engine Soon Light in the United States
or Check Engine Light
in Canada
.................................................. 3-30
Service Manuals
............................................. 7-1 1
Servicing Your Air Bag-Equipped Vehicle ............ 1-69
Setting Preset Stations
............................ 3-39, 3-42
Setting the Temperature
................................... 3-20
Setting the Time
Radios with HR and MN Buttons
................... 3-38
Radios with the Set Button
........................... 3-38
Setting the Tone (Bassnreble)
.................. 3-40, 3-43
Shifting Into Park (P)
....................................... 2-27
Sheet
Metal Damage
....................................... 5-88
Shifting Out of Park (P)
................................... 2-29
Short Trip/City Definition
.................................... 6-5
Short TripKity Intervals
..................................... 6-5
Short Trip/City Scheduled Maintenance
...... ... 6-7
Shoulder Belt Height Adjuster
............... ..... 1-20
Skidding
........................................ ......... 4-13
Sliding Door Security Lock
............................... 2-1 1
Sliding Side Door
............................................ 2-10
Some Other Rainy Weather Tips
....................... 4-18
Spare Tire Check
............................................ 6-27 Special Fabric Cleaning
Problems
..................... 5-84
Specifications, Capacities
................................. 5-99
Speedometer
.................................................. 3-25
Steering
.......................................................... 4-9
Starter Switch
Check
....................................... 6-28
Starting Your Engine
....................................... 2-21
Steering in Emergencies
.................................. 4-10
Steering, Suspension and Front Drive Axle
Boot and Seal Inspection .............................. 6-30
Steering Tips
................................................... 4-9
Storage Areas
................................................ 2-38
Convenience Net
......................................... 2-45
Luggage Carrier
.......................................... 2-44
Overhead Console
....................................... 2-39
Storing a Flat or Spare Tire and
Tools ............... 5-81
Stuck in Sand, Mud, Ice or Snow
...................... 4-28
Sun Visors
..................................................... 2-17
Sunglasses Storage Compartment
..................... 2-44
Taillamps
....................................................... 5-60
Theft.Deterrent. Radio
..................................... 3-47
Theft-Deterrent Systems
................................... 2-18
Passlock@
............................................... 2-18
Throttle System Inspection
........................... 6-31
Tilt Wheel
........................................................ 3-5
Tire Inflation Check
......................................... 6-26
12