2002 ISUZU AXIOM ignition

6D2±6
IGNITION SYSTEM (6VE1 3.5L)
Crankshaft Position Sensor
Removal
1. Disconnect battery ground cable
2. Wiring connector from crankshaft position sensor.
3. Remove crankshaft position sensor from cylinder
block.
012RS008
Installation
1. Install crankshaft position sensor into the cylinder
block.
Before installation,apply small amount of engine oil to
the O±ring.
Torque: 10 N´m (87 lb in)
2. Reconnect wiring connector to crankshaft position
sensor.

6D2±7
IGNITION SYSTEM (6VE1 3.5L)
Main Data and Specifications
General Specifications
Ignition System
Ignition FormElectronic Ignition System (El system) with Crankshaft position Sensor
Spark Plug
TypeK16PR±P11
RC10PYP4
PK16PR11
Plug gap1.0 mm ± 1.1 mm (0.0394 in ± 0.0433 in)
Torque18 N´m (13lb ft)
Torque Specifications
E06R100003

6D3±17
STARTING AND CHARGING SYSTEM (6VE1 3.5L)
Charging System
General Description
The IC integral regulator charging system and its main
components are connected as shown in illustration.
The regulator is a solid state type and it is mounted along
with the brush holder assembly inside the generator
installed on the rear end cover.
The generator does not require particular maintenance
such as voltage adjustment.The rectifier connected to the stator coil has diodes to
transform AC voltage into DC voltage.
This DC voltage is connected to the output terminal of
generator.
F06RX002
General On±Vehicle Inspection
A basic wiring diagram is shown in the illustration. When
operating normally, the indicator bulb will come on when
the switch is turned on, and will then go out when the
engine starts. If the indicator operates abnormally, or if an
undercharged or overcharged battery condition occurs,
the following procedure may be used to diagnose the
charging system. Remember that an undercharged
battery is often caused by accessories being left on
overnight, or by a defective switch which allows a bulb,
such as a trunk or glove box light, to stay on.
Observe the following procedure:
1. Visually check belt and wiring.
2. Go to step 5. for vehicles without charge indicator
light.
3. Switch on, engine stopped, light should be on. If not,
detach harness at generator, ground ªLº terminal
lead.a. Lamp lights, replace or repair generator.
b. Lamp dose not light, locate open circuit between
grounding lead and ignition switch. Bulb may be
open.
4. Switch on, engine running at moderate speed. Light
should be off. If not, detach wiring harness at
generator.
a. If light goes off, replace or repair generator.
b. If light stays on, check for grounded ªLº terminal
wire in harness.
5. Battery undercharged or overcharged.
a. Detach wiring harness connector from generator.
b. With switch on, engine not running connect
voltmeter from ground to ªLº terminal in wiring
harness, and to ªIGº terminal. If used. Wiring
harness may connect to either ªLº or ªIGº or both.
c. Zero reading indicates open circuit between
terminal and battery. Connect as required.

6E±2
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Fuel Trim System Monitor Diagnostic
Operation 6E±59. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Trim System Monitor Diagnostic
Operation 6E±59. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Trim Cell Diagnostic Weights 6E±59. . . . . . .
On-Board Diagnostic (OBD II) System Check 6E±60
Circuit Description 6E±60. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±60. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±60. . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Control Circuit Diagnosis 6E±63. . . . . . .
Circuit Description 6E±63. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±63. . . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Diagnosis 6E±64. . . . . . . . . . . . . . . . . .
Electronic Ignition System Diagnosis 6E±68. . . . . . .
EVAP Canister Purge Solenoid and EVAP
Vent Solenoid Valve 6E±68. . . . . . . . . . . . . . . . . . . . .
Visual Check of The Evaporative Emission
Canister 6E±68. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System Check 6E±68. . . . . . . . . . . . .
Fuel System Pressure Test 6E±68. . . . . . . . . . . . . . .
Fuel Injector Coil Test Procedure and Fuel
Injector Balance Test Procedure 6E±68. . . . . . . . . .
Test Description 6E±68. . . . . . . . . . . . . . . . . . . . . . .
Injector Coil Test Procedure (Steps 1-6)
and Injector Balance Test Procedure
(Steps 7-11) 6E±69. . . . . . . . . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) Diagnosis 6E±73
Multiple PCM Information Sensor DTCs Set 6E±73
Circuit Description 6E±73. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±73. . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Gas Recirculation (EGR) Diagnosis 6E±76
Engine Tech 2 Data Definitions and Ranges 6E±76
Typical Scan Data Values 6E±78. . . . . . . . . . . . . . . .
Test Conditions 6E±78. . . . . . . . . . . . . . . . . . . . . . . .
No Malfunction Indicator Lamp (MIL) 6E±84. . . . . . .
Circuit Description 6E±84. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±84. . . . . . . . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp (MIL) ªONº
Steady 6E±87. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit description 6E±87. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±87. . . . . . . . . . . . . . . . . . . . . . . .
No Reduced Power Lamp (RPL) 6E±89. . . . . . . . . .
Circuit Description 6E±89. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±89. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±89. . . . . . . . . . . . . . . . . . . . . . .
Reduced Power Lamp (RPL) ªONº Steady 6E±93. .
Circuit Description 6E±93. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±93. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±93. . . . . . . . . . . . . . . . . . . . . . .
Starter Control System Check 6E±96. . . . . . . . . . . . .
Circuit Description 6E±96. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±96. . . . . . . . . . . . . . . . . . . . . . . .
Engine Cranks But Will Not Run 6E±100. . . . . . . . . . .
Circuit Description 6E±102. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±102. . . . . . . . . . . . . . . . . . . . . . . . Test Description 6E±102. . . . . . . . . . . . . . . . . . . . . . .
Fuel System Electrical Test 6E±107. . . . . . . . . . . . . . .
Circuit Description 6E±108. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±108. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±108. . . . . . . . . . . . . . . . . . . . . . .
Fuel Pressure Relief Procedure 6E±108. . . . . . . . .
Electric Throttle Control (ETC) System
Check 6E±111. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±112. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±112. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±112. . . . . . . . . . . . . . . . . . . . . . .
Fuel System Diagnosis 6E±115. . . . . . . . . . . . . . . . . . .
Circuit Description 6E±116. . . . . . . . . . . . . . . . . . . . .
Test Description 6E±116. . . . . . . . . . . . . . . . . . . . . . .
Fuel Pressure Relief Procedure 6E±117. . . . . . . . .
Exhaust Gas Recirculation (EGR) System
Check 6E±120. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±120. . . . . . . . . . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Output
Check 6E±122. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±122. . . . . . . . . . . . . . . . . . . . .
Evaporative (EVAP) Emissions Canister
Purge Valve Check 6E±124. . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±124. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±124. . . . . . . . . . . . . . . . . . . . . . . .
PCM Diagnostic Trouble Codes 6E±127. . . . . . . . . . .
DTC P0101 MAF System Performance 6E±131. . . .
DTC P0102 MAF Sensor Circuit Low
Frequency 6E±134. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0103 MAF Sensor Circuit High
Frequency 6E±137. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0106 MAP System Performance 6E±140. . . .
DTC P0107 MAP Sensor Circuit Low
Voltage 6E±143. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0108 MAP Sensor Circuit High
Voltage 6E±146. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0112 IAT Sensor Circuit Low
Voltage 6E±149. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0113 IAT Sensor Circuit High
Voltage 6E±152. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0117 ECT Sensor Circuit Low
Voltage 6E±155. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0118 ECT Sensor Circuit High
Voltage 6E±158. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0125 ECT Excessive Time to Closed
Loop Fuel Control 6E±161. . . . . . . . . . . . . . . . . . . . . . .
DTC P0128 Thermostat Insufficient
Temperature for Stable Operation 6E±164. . . . . . . . .
DTC P0131 HO2S Circuit Low Voltage
Bank 1 Sensor 1 6E±166. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0132 HO2S Circuit High Voltage
Bank 1 Sensor 1 6E±169. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0133 HO2S Slow Response
Bank 1 Sensor 1 6E±172. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0134 HO2S Circuit Insufficient
Activity Bank 1 Sensor 1 6E±176. . . . . . . . . . . . . . . . .

6E±3
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P0135 HO2S Heater Circuit
Bank 1 Sensor 1 6E±179. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0137 HO2S Circuit Low Voltage
Bank 1 Sensor 2 6E±182. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0138 HO2S Circuit High Voltage
Bank 1 Sensor 2 6E±185. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0140 HO2S Circuit Insufficient Activity
Bank 1 Sensor 2 6E±188. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0141 HO2S Heater Circuit
Bank 1 Sensor 2 6E±191. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0151 HO2S Circuit Low Voltage
Bank 2 Sensor 1 6E±194. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0152 HO2S Circuit High Voltage
Bank 2 Sensor 1 6E±197. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0153 HO2S Slow Response
Bank 2 Sensor 1 6E±200. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0154 HO2S Circuit Insufficient Activity
Bank 2 Sensor 1 6E±204. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0155 HO2S Heater Circuit Open
Bank 2 Sensor 1 6E±207. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0157 HO2S Circuit Low Voltage
Bank 2 Sensor 2 6E±210. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0158 HO2S Circuit High Voltage
Bank 2 Sensor 2 6E±213. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0160 HO2S Circuit Insufficient Activity
Bank 2 Sensor 2 6E±216. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0161 HO2S Heater Circuit
Bank 2 Sensor 2 6E±219. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0171 Fuel Trim System Lean Bank 1 6E±222.
DTC P0172 Fuel Trim System Rich Bank 1 6E±226.
DTC P0174 Fuel Trim System Lean Bank 2 6E±230.
DTC P0175 Fuel Trim System Rich Bank 2 6E±234.
DTC P0201 Injector 1 Control Circuit 6E±238. . . . . .
DTC P0202 Injector 2 Control Circuit 6E±241. . . . . .
DTC P0203 Injector 3 Control Circuit 6E±244. . . . . .
DTC P0204 Injector 4 Control Circuit 6E±247. . . . . .
DTC P0205 Injector 5 Control Circuit 6E±250. . . . . .
DTC P0206 Injector 6 Control Circuit 6E±253. . . . . .
DTC P0300 Engine Misfire Detected 6E±256. . . . . . .
DTC P0301 Cylinder Misfire Detected 6E±260. . . . . .
DTC P0302 Cylinder Misfire Detected 6E±262. . . . . .
DTC P0303 Cylinder Misfire Detected 6E±264. . . . . .
DTC P0304 Cylinder Misfire Detected 6E±266. . . . . .
DTC P0305 Cylinder Misfire Detected 6E±268. . . . . .
DTC P0306 Cylinder Misfire Detected 6E±270. . . . . .
DTC P0325 ION Sensing Module/ION
Sensing Knock Intensity Circuit Fault 6E±272. . . . . .
DTC P0336 58X Reference Signal Circuit 6E±275. .
DTC P0337 CKP Sensor Circuit Low
Frequency 6E±278. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0351 Ignition 1 Control Circuit 6E±281. . . . . . .
DTC P0352 Ignition 2 Control Circuit 6E±284. . . . . . .
DTC P0353 Ignition 3 Control Circuit 6E±287. . . . . . .
DTC P0354 Ignition 4 Control Circuit 6E±290. . . . . . .
DTC P0355 Ignition 5 Control Circuit 6E±293. . . . . . . DTC P0356 Ignition 6 Control Circuit 6E±296. . . . . . .
DTC P0401 EGR Flow Insufficient 6E±299. . . . . . . . .
DTC P0402 EGR Pintle Crank Error 6E±302. . . . . . .
DTC P0404 EGR Open Stuck 6E±304. . . . . . . . . . . . .
DTC P0405 EGR Low Voltage 6E±306. . . . . . . . . . . .
DTC P0406 EGR High Voltage 6E±309. . . . . . . . . . .
DTC P0420 TWC System Low Efficiency
Bank 1 6E±312. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0430 TWC System Low Efficiency
Bank 2 6E±315. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0440 EVAP System 6E±318. . . . . . . . . . . . . . . .
DTC P0442 EVAP System Small Leak
Detected 6E±321. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0444 EVAP Purge Control Circuit
Open 6E±324. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0445 EVAP Purge Control Circuit
Short 6E±326. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0446 EVAP Canister Vent Control
Malfunction 6E±328. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0447 EVAP Vent Solenoid Circuit
Open 6E±331. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0448 EVAP Vent solenoid Circuit
Short 6E±333. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0452 Fuel Tank Pressure Sensor
(Vapor Pressure Sensor) Low Voltage 6E±335. . . . .
DTC P0453 Fuel Tank Pressure Sensor
(Vapor Pressure Sensor) High Voltage 6E±338. . . . .
DTC P0456 EVAP Very Small Leak 6E±341. . . . . . .
DTC P0461 Fuel Level Sensor Performance 6E±344
DTC P0462 Fuel Level Sensor Circuit±Low
Voltage 6E±346. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0463 Fuel Level Sensor Circuit±High
Voltage 6E±349. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0462 Fuel Level Sensor Noisy Signal 6E±351
DTC P0502 VSS Circuit Low Input 6E±353. . . . . . . . .
DTC P0506 Idle Air Control System Low
RPM 6E±356. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0507 Idle Air Control System High
RPM 6E±359. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0562 System Voltage Low 6E±362. . . . . . . . . .
DTC P0563 System Voltage High 6E±364. . . . . . . . .
DTC P0565 Cruise Main Switch Circuit Error 6E±366
DTC P0566 Cruise Cancel Switch Circuit
Error 6E±368. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0567 Cruise Resume Switch Circuit
Error 6E±370. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0568 Cruise Set Switch Circuit Error 6E±372.
DTC P0571 No Brake Switch Signal 6E±374. . . . . . .
DTC P0601 PCM Memory 6E±376. . . . . . . . . . . . . . . .
DTC P0602 PCM Programming Error 6E±378. . . . . .
DTC P0604 PCM RAM Error 6E±380. . . . . . . . . . . . . .
DTC P0606 PCM Internal Performance 6E±382. . . .
DTC P1106 MAP Sensor Circuit Intermittent
High Voltage 6E±384. . . . . . . . . . . . . . . . . . . . . . . . . . .

6E±4
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P1107 MAP Circuit Intermittent Low
Voltage 6E±386. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D T C P 1111 I AT Sensor Circuit Intermittent
High Voltage 6E±388. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1112 IAT Sensor Circuit Intermittent
Low Voltage 6E±391. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1114 ECT Sensor Circuit Intermittent
Low Voltage 6E±393. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1115 ECT Sensor Circuit Intermittent
High Voltage 6E±395. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Trouble Code(DTC)P1120-TPS 1
Throttle Position Sensor (TPS1) Output
Abnormal 6E±398. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1125 ETC (Electric Throttle Control)
Limit Performance Mode 6E±401. . . . . . . . . . . . . . . . .
DTC P1133 HO2S Insufficient Switching
Bank 1 Sensor 1 6E±404. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1134 HO2S Transition Time Ratio
Bank 1 Sensor 1 6E±408. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1153 HO2S Insufficient Switching
Bank 2 Sensor 1 6E±412. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1154 HO2S Circuit Transition Time
Ratio Bank 2 Sensor 1 6E±416. . . . . . . . . . . . . . . . . .
DTC P1167 Fuel System Rich During Decel
Fuel Cut Off (Bank 1) 6E±420. . . . . . . . . . . . . . . . . . . .
DTC P1169 Fuel System Rich During Decel
Fuel Cut Off (Bank 2) 6E±422. . . . . . . . . . . . . . . . . . . .
DTC P1171 Fuel System Lean During
Acceleration 6E±424. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1220 Throttle Position Senser2
(TPS2) Circuit Fault 6E±427. . . . . . . . . . . . . . . . . . . . .
DTC P1221 TPS1 ± TPS2 Correlation
(Circuit Performance) 6E±430. . . . . . . . . . . . . . . . . . .
DTC P1271 APS 1± 2 Correlation Error 6E±433. . .
DTC P1272 APS 2 ± 3 Correlation Error 6E±436. . .
DTC P1273 APS 1 ± 3 Correlation Error 6E±439. . . .
DTC P1275 APS 1 Output Fault 6E±442. . . . . . . . . . .
DTC P1280 APS 2 Output Fault 6E±444. . . . . . . . . . .
DTC P1285 APS 3 Output Fault 6E±446. . . . . . . . . . .
DTC P1290 ETC Forced Idle Mode 6E±448. . . . . . . .
DTC P1295 ETC Power Management Mode 6E±451
DTC P1299 ETC Forced Engine Shutdown
Mode 6E±455. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1310 ION Sensing Module Diagnosis 6E±459
DTC P1311 ION Sensing Module SEC
Line 1 Circuit Fault 6E±462. . . . . . . . . . . . . . . . . . . . . .
DTC P1312 ION Sensing Module SEC
Line 2 Circuit Fault 6E±465. . . . . . . . . . . . . . . . . . . . . .
DTC P1326 ION Sensing Module Combustion
Quality Input Circuit Fault 6E±468. . . . . . . . . . . . . . . .
DTC P1340 ION Sensing Module Cylinder ID
Fault (Cylinder Synchronization Fail) 6E±471. . . . . .
DTC P1404 EGR Stuck Closed 6E±474. . . . . . . . . . .
DTC P1441 EVAP System Flow During
Non-Purge 6E±477. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1514 TPS - MAF Correlation Error 6E±480. . . DTC P1515 Command - Actual TPS
Correlation Error 6E±484. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1516 Command - Actual TPS
Correlation Error 6E±487. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1523 Actuator Control Return
Performance 6E±490. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1571 Brake Switch No Operation 6E±493. . . .
DTC P1625 PCM Unexpected Reset 6E±495. . . . . . .
DTC P1635 Reference Voltage # 1 Circuit
Fault 6E±496. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1639 Reference Voltage # 2 Circuit
Fault 6E±498. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1640 Driver-1-Output Circuit Fault
(ODM) 6E±500. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1650 Quad Driver Module ªAº Fault 6E±503. .
Symptom Diagnosis 6E±506. . . . . . . . . . . . . . . . . . . . .
Default Matrix Table 6E±535. . . . . . . . . . . . . . . . . . . . .
On Vehicle Service
Crankshaft Position (CKP) Sensor 6E±538. . . . . . . . .
Engine Coolant Temperature (ECT) Sensor 6E±538.
Heated Oxygen Sensor (HO2S) 6E±539. . . . . . . . . . .
Intake Air Temperature (IAT) Sensor 6E±542. . . . . . .
ION Sensing Module 6E±542. . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor 6E±543. . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor 6E±544.
Malfunction Indicator Lamp (MIL) 6E±545. . . . . . . . . .
Reduced Power Lamp 6E±545. . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) 6E±545. . . . . . . . .
Service Precaution 6E±545. . . . . . . . . . . . . . . . . . . .
EEPROM 6E±547. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Position (TP) Sensor 6E±547. . . . . . . . . . . . .
Vehicle Speed Sensor (VSS) 6E±548. . . . . . . . . . . . .
Air Cleaner/Air Filter 6E±549. . . . . . . . . . . . . . . . . . . . .
Common Chamber 6E±549. . . . . . . . . . . . . . . . . . . . . .
Accelerator Pedal Replacement 6E±550. . . . . . . . . . .
Accelerator Position Sensor Replacement 6E±551. .
Accelerator Position Sensor Adjustment 6E±551. . . .
Fuel Filler Cap 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filter 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit 6E±553. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injectors 6E±554. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Assembly 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Relay 6E±556. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Rail Assembly 6E±557. . . . . . . . . . . . . . . . . . . . . .
Fuel Tank 6E±558. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body (TB) 6E±558. . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition System 6E±560. . . . . . . . . . . . . . . .
Catalytic Converter 6E±561. . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Thermo Relay 6E±561. . . . . . . . . . .
EVAP Canister Hoses 6E±561. . . . . . . . . . . . . . . . . . . .
EVAP Canister 6E±562. . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Canister Vent Solenoid 6E±562. . . . . . . . . . . . .

6E±5
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Fuel Tank Pressure
(Vapor Pressure) Sensor 6E±563. . . . . . . . . . . . . . . . .
EVAP Canister Purge Solenoid (Purge Duty
Solenoid Valve) 6E±564. . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Tank Vent Valve
(Vent Solenoid Valve) 6E±565. . . . . . . . . . . . . . . . . . .
Linear Exhaust Gas
Recirculation (EGR) Valve 6E±565. . . . . . . . . . . . . . . .
Positive Crankcase Ventilation (PCV) Valve 6E±566.
Wiring and Connectors 6E±566. . . . . . . . . . . . . . . . . . .
PCM Connectors and Terminals 6E±567. . . . . . . . . . .
Wire Harness Repair: Twisted Shielded
Cable 6E±567. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Twisted Leads 6E±568. . . . . . . . . . . . . . . . . . . . . . . . . .
Weather-Pack Connector 6E±569. . . . . . . . . . . . . . . . .
Com-Pack III 6E±570. . . . . . . . . . . . . . . . . . . . . . . . . . .
Metri-Pack 6E±571. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description (PCM and Sensors) 6E±572. . .
General Description (Air Induction) 6E±577. . . . . . . .
General Description (Fuel Metering) 6E±578. . . . . . .
General Description (Electronic Ignition
System) 6E±580. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Diagnosis 6E±583. . . . . . . . . . . . . . . . . . . .
General Description (Evaporative (EVAP)
Emission System) 6E±583. . . . . . . . . . . . . . . . . . . . . .
General Description (Exhaust Gas
Recirculation (EGR) System) 6E±588. . . . . . . . . . . . .
General Description (Positive Crankcase
Ventilation (PCV) System) 6E±589. . . . . . . . . . . . . . .
Special Tools 6E±591. . . . . . . . . . . . . . . . . . . . . . . . . . .

6E±14
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
PCM Pinouts
PCM Pinout Table, 80-Way Blue Connector ± Row ªF1 ~ 20º
060RY00045
PINPIN FunctionWire ColorIGN ONENG RUNRefer To
F1PCM GroundBLK0.0V0.0VChassis Electrical
F25Volt Referenceª2º (AP
Sensor 2)GRN5.0V5.0VAccelerator Position (AP)
Sensor
F35Volt Referenceª2º (TP
Sensor 2)RED/WHT5.0V5.0VThrottle Position (TP) Sensor
F4A/C ClutchGRY/REDB+(A/C off)B+(A/C off)General Description and
Operation, A/C Clutch Circuit
Operation
F5Relay Shift SolenoidGRN/RED0.0V0.0V4L30E T/Mission
F6Not UsedÐÐÐÐ
F7TachometerBLK/RED8.8V10.0V (at
idle)Chassis Electrical
F8Not UsedÐÐÐÐ
F9Not UsedÐÐÐÐ
F10Not UsedÐÐÐÐ
F11T.O.DRED/WHTÐÐÐ
F12Not UsedÐÐÐÐ
F13Starter FeedPNKÐÐÐ
F14Mass Air Flow(MAF)BLK/BLU4.9V4.2VGeneral Description, Mass
Air Flow Sensor
F15Not UsedÐÐÐÐ
F16Not UsedÐÐÐÐ
F17Bank 1 HO2S LowRED0.3V0.1±0.9VGeneral Description and
Operation, Catalyst Monitor
HO2S 2
F18Not UsedÐÐÐÐ
F19Ignition FeedRED/GRNB+B+6D Section
F20Ignition FeedRED/WHTB+B+6D Section