2001 TOYOTA PRIUS light

2001 PRIUS (EWD414U)
POWER SOURCE
HEAD RELAY
2±1 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
Closed with the engine running and the parking brake pedal released (Parking brake SW off) [w/ Daytime running light]
TAIL RELAY
5±3 : Closed with the light control SW at TAIL or HEAD position
I15 IGNITION SW
2±3 : Closed with the ignition key at ACC or ON position
2±4 : Closed with the ignition key at ON or ST position
7±6 : Closed with the ignition key at ON or ST position
7±8 : Closed with the ignition key at ST position
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
F10A34F13D34I1537
F11B34F17A38
F12C34F18B38
: RELAY BLOCKS
CodeSee PageRelay Blocks (Relay Block Location)
324Engine Room R/B No.3 (Engine Compartment Right)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CodeSee PageJunction Block and Wire Harness (Connector Location)
1B27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)1J27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
2B
2C30Instrument Panel Wire and Instrument Panel J/B (Cowl Side Panel LH)
2D
()
2G31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)2H31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)
SERVICE HINTS

2001 PRIUS (EWD414U)
TOYOTA HYBRID SYSTEM
C 1
1D1B 215A
AM2 1J 9ST2IG2 AM2 6
BATTERY7
IGNITION SW I15
FUSIBLE
LINK
BLOCK
NO. 1D F1 2 , F13C
B±G B W±R W±R
2C 2
2G 1
120A MAIN
1
FUSIBLE
LINK BLOCK
NO. 2 F18A CACE 7
B B
ID1 63 4D 2D16 ST1± IGSW CCS
B±W
B±Y
L LB±W
B±W
E 6ST2
R±W
STOP LIGHT SW S 3
B±W 8
IGA AAAB A B A B AD 31 D24
5
A 4
CRUISE CONTROL SW
[COMB. SW] C14
W±B W±B
W±B
W±BW±B
W±B
D 1STP GND1 GND2
G±W
JUNCTION
CONNECTOR J17
FROM STOP LIGHT
SW
W±B JUNCTION
CONNECTORB J18 , J19A
JUNCTION
CONNECTORB J24 A , J25
H14 , D H13 , E H12 , B CH11, H10 A
HYBRID VEHICLE CONTROL ECU
B±W
CCS
CRUISE
RES/ACC
SET/COAST
CANCEL 11 2G52B
1J 3
32 51
1A 21K3
IK1 14
M
1 2
E 5
B±W B±W B±W
W±B W±B W±B
W± B
WATER PUMP MOTOR
(
INVERTER) W 3
IG2
RELAYB±W
B±W
R±W
W±B ECC

2001 PRIUS (EWD414U)
6. MANUAL CANCEL CONTROL
When each of the following signals is input during driving with cruise control, the cruise control is released with turning the
cruise control requirement to 0. (The memorized speed is maintained when following signals except the signal, main switch
OFF is input.)
*Stop light switch ON (Pressing the brake pedal)
*Control switch's cancel switch ON
*Main switch OFF
7. AUTO CANCEL FUNCTION
A) The memorized speed is erased and the control is canceled if the following conditions occur. The power indicator blinks
at that time until the main switch is turned ON. The speed control is unavailable unless the main switch is turned ON
again.
*When the stop light switch breaks or short±circuits.
*When sudden change of the running speed signal occur.
B) The memorized speed is erased and the control is canceled if the following conditions occur.
*When the malfunction of the stop light switch input circuit occurs.
*When the running speed becomes slower than 40km/h.
*When the running speed becomes slower than the speed that 16 km/h subtracted from the memorized speed.
8. REGENERATIVE SYSTEM OPERATION
This system operates the motor as a generator to change the kinetic energy of the vehicle into the electricity when accel
pedal release or foot braking controls the vehicle, and store the electricity in the battery.
C14 CRUISE CONTROL SW [COMB. SW]
5±4 : Approx. 1540 W with CANCEL SW on
Approx. 240 W with RES/ACC SW on
Approx. 630 W with SET/COAST SW on
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
A736H10C37J18A37
A1336H11A37J19B37
A1836H12B37J2137
B836H13E37J22A37
B1136H14D37J23B37
B1538H16A38J24A37
B1638H17B38J25B37
B17A38I9D35J2637
B18B38I10C35J27A37
B1938I11A35J28B37
C334I12B35J3238
C4A34I13E35A38
C5B34I14F35J33B38
C10A36I1537M2A35
C11B36I1738M3B35
C1436J137M4C35
D236J2A37P137
E9C36J3B37S337
E10D36J737S8A39
F1034J8A37S9B39
F12C34J9B37S10C39
F13D34J1137S11D39
F1738J1637S12E39
F1838J1737T437
G137J1837W335
SERVICE HINTS

2001 PRIUS (EWD414U)
IO1 6
I 7C 20 B 18
I 7IK1 7IK16 IE1 1IE12 D 1D12
IK1 1IE1 22D 7 D 11
I 6
A DD 16
B EBEBE A 41 2
A 23 A24 C10 C18 C19 C28 C27
1
422
IE1 12 2
431
L P Y BRO Y±R
W± GLG
W± G B±W B±W
P±L
W
BRBR BR
B
BR
BR
Y
G± YBR(
*1)
BR BR
B
BB
B(
*1)
(
*1)
P±L
W P±L
W
(
*1)
(
*1)
(
*1)CAMS HAFT TIMING OIL
CONTROL VALVE C 2 VSV (
HC ADSORBER AND
CATALYST SYSTEM) V 3
HEATED OXYGEN SENSOR
(
BANK 1 SENSOR 1) H 3
HEATED OXYGEN SENSOR
(
BANK 1 SENSOR 2) H 9 BJUNCTION
CONNECTORB J22 A , J23
HT1B OX1 B E11 OX1A HT1A HCC E2SPHV
13HTE± HTE+ ETH+ ETH± OCV± OC V+ FAN
FROM FAN NO. 1 AND
FAN NO. 2 RE LAY
(
*1)
(
*1)(
*1)
(
*1) * 1 : SHIELDED
E10 , D C , E 9 AE 8, E 7 B
ENGINE CONTROL MODULE
I 6
(
*1)
BR D 5
V±W
SPD
TO COMBI NATION
METER
SPDO HTE± HTE+ ETH+ ETH1
D 6D29 D19 D28 D27
C 21
G
GO GO
B 10
C 16
R±Y
ESTP ESTP
D 8D 1 HYBRID VEHICLE CONTROL ECUD H12 , H14
B15A
STOP FROM POWER SOURCE SYSTEM (
SEE PAGE 50)
2K 9
1 2 DBEA
STOP LIGHT SW S 3JUNCTION
CONNECTORB J14 A , J15 G± W
G± W R± B
STPG±W
IA2 9
G

2001 PRIUS (EWD414U)
HEADLIGHT (w/ DAYTIME RUNNING LIGHT)
30A
HEAD FROM POWER SOURCE SYSTEM (
SEE PAGE 50)
23 14
32 14 2 1
10A
HEAD HI (
RH) 10A
HEAD HI (
LH) 10A
HEAD LO (
RH) 10A
HEAD LO (
LH)
213
213IA19 1E 5 1E 2 1F 7 1F 6313 25
33 7. 5A
DRL
33
IE 1E 31F8
IA217 IA26
JUNCTION
CONNECTOR J 1 A
G± R R±WR±YR
R±G R±G
R±W
R
W±B W±B
R±G
LR±G
L R±W
R±B R±L
R±G HEAD
RELAY
DIM
RELAYDRL
RELAY
R±B
HEADLIGHT
LH H 1
HEADLIGHT
RH H 2
R±Y G±R
2 1
E 2
R±B

2001 PRIUS (EWD414U)
2B 62A 7 10 2A72I
ID OFF
TAIL
HEAD
LOW
HIGH
IG ID2 510A
GAUGE FROM POWER SOURCE SYSTEM (
SEE PAGE 50)
2K 10
B E
A E
1ID2 7 7. 5A
ECU±B
2C 5
ID1 8
IA2 16
DAYTIME RUNNING LIGHT RELAY D 3
JUNCTION
CONNECTOR J20JUNCTION
CONNECTOR J2 0
JUNCTION
CONNECTOR J17
JUNCTION
CONNECTOR J1 1
PARKING
BRAKE SW P 2
COMBINATION SW C13 DIODE
(
DAYTIME
RUNNING
LIGHT) D 5 1
EE46 3 12AC
87
A17 2
E17 8 11 92 5AC
14
R±W
R±G
R±L R±G R±G
R±L R±W RR±GR±G
L±O
R±Y
Y±B
W±B
R±G L Y±B R±Y
BRW±B
L
R±BL R±G R±W
R R±G R±G
R±W
W±B
EDRL HDIM H±LP +B IG
HI PKB CHG± IND
ID2 3
13 16
JUNCTION CONNECTORB J12 A , J13
B 2
B 17 A9 BODY ECUB B 8 , B 9A
Y±BA F
B HR±G
R±G
JUNCTION
CONNECTORB J27 A , J28
E
FLASH
LIGHT
CONTROL SW DIMMER SW
15A
DOME
1J 7
HIGH BEAM
HEAD
42A 22G
LL±Y
21
COMBINATION METER C10L±Y
H RDY HRLY
IH

2001 PRIUS (EWD414U)
HEADLIGHT (w/ DAYTIME RUNNING LIGHT)
When the ignition SW is turned on ST position and ºREADYº signal from engine control module is sent to the daytime
running light relay via body ECU. If the parking brake pedal is depressed (Parking brake SW is on) at that time, the daytime
running light system does not operate. If the parking brake pedal is released (Parking brake SW is off), the daytime running
light system operates and the low beam headlight comes on.
HEAD RELAY
1±2 : Closed with the light control SW at HEAD position or the dimmer SW at FLASH position
Closed with the engine running and the parking brake lever is released (Parking brake SW off)
D3 DAYTIME RUNNING LIGHT RELAY
12±GROUND : Approx. 12 volts with the ignition SW at ON position
3±GROUND : Always approx. 12 volts
11±GROUND : Continuity with the parking brake lever pulled up
2±GROUND : Always continuity
8±GROUND : Continuity with the dimmer SW at HIGH or FLASH position
: PARTS LOCATION
CodeSee PageCodeSee PageCodeSee Page
B8A36H134J1737
B9B36H234J2037
C1036J137J27A37
C1336J1137J28B37
D336J12A37P237
D536J13B37
: RELAY BLOCKS
CodeSee PageRelay Blocks (Relay Block Location)
324Engine Room R/B No.3 (Engine Compartment Right)
: JUNCTION BLOCK AND WIRE HARNESS CONNECTOR
CodeSee PageJunction Block and Wire Harness (Connector Location)
1E
1F27Engine Room Main Wire and Engine Room J/B (Engine Compartment Left)
1J
gg(g)
2A
2B30Instrument Panel Wire and Instrument Panel J/B (Cowl Side Panel LH)
2C
()
2G31Engine Room Main Wire and Instrument Panel J/B (Cowl Side Panel LH)
2I31Cowl Wire and Instrument Panel J/B (Cowl Side Panel LH)2K31Cowl Wire and Instrument Panel J/B (Cowl Side Panel LH)
: CONNECTOR JOINING WIRE HARNESS AND WIRE HARNESS
CodeSee PageJoining Wire Harness and Wire Harness (Connector Location)
IA142Engine Room Main Wire and Cowl Wire (Cowl Side Panel LH)IA242Engine Room Main Wire and Cowl Wire (Cowl Side Panel LH)
ID142Instrument Panel Wire and Cowl Wire (Left Kick Panel)ID242Instrument Panel Wire and Cowl Wire (Left Kick Panel)
: GROUND POINTS
CodeSee PageGround Points Location
ID42Cowl Side Panel LHIE42Cowl Side Panel LH
IG42Cowl Side Panel RH
IH42Right Kick Panel
SYSTEM OUTLINE
SERVICE HINTS

2001 PRIUS (EWD414U)
HEADLIGHT (w/o DAYTIME RUNNING LIGHT)
120A MAIN
1
F18
FUSIBLE LINK
BLOCK NO. 2
1B 11 2
32 41
4 1
10A
HEAD
(
LH)10A
HEAD
(
RH)
1F 81F61F7
OFF
TAIL
HEAD
LOW
HIGH
FLASH
IG IA2 6
ID2 3
ID2 5213
213
A FAFBE
B DAEAE
IA1 7IA13
B DA F A F
2A 102I 7
16 17E E
2
A17 7 8 13 C 1
D 1R±G
R±Y
R±Y
R±G
R±L R±GR±W R±W B
R±W R±W R RB±G
W±B
R±G L
R±G R±GR±Y R±Y
R±G
ER±W SHORT
PINSHORT
PIN HEAD
RELAY
HEADLIGHT
LH H 1
JUNCTION
CONNECTOR J20
JUNCTION CONNECTORB J 4 A , J 5
BATTERY
FUSIBLE LINK
BLOCK NO. 1D F12 C , F13
JUNCTION CONNECTORB J12 A , J13
COMBINATION
SW C13
JUNCTION
CONNECTOR J1 7
BODY ECU B 9
HRLY
H
R±W
R±Y
R±G LIGHT
CONTROL SW DIMMER SW
HEADLIGHT
RH H 2
JUNCTION CONNECTORB J 4
A, J 5
L