2001 Peugeot Partner VU engine

1
2
80V- 11.9 D ENGINES *
* According to specification.

1
81V- 12.0 HDi ENGINES *
* According to specification.

A
B
Repriming the circuit
To reprime after running out of diesel : - Fill the tank with at least five litres of diesel, with the vehicle parked on as level a surface as possible. - Operate the manual repriming pump until resistance is felt.
- Operate the starter, pressing the accelerator lightly until the engine starts. If the engine fails to start at the first attempt, wait for 15 seconds and then try again. If it fails to start after several attempts, repeat the operation from the beginning. With the engine at idle, press the accelerator lightly to bleed the system.
86V- 3DIESEL INJECTION SYSTEM
1.9 Diesel engine, removal of the engine undertray- Pull the securing clip Atowards the front
of the vehicle.
- Remove the dipstick.
- Unscrew bolt Band remove it.
- Remove the undertray.
- Reprime the circuit.
- Refit the undertray (engine not running).

1
2Manual repriming pump
See ÒDIESEL INJECTION SYSTEMÓ.
78
Power steering reservoir
Level: see ÒLEVELS AND
CHECKSÓ. Topping up engine oil
See ÒCAPACITYÓ. Finish by checking the oil level using the manual dipstick.
Battery
See ÒBATTERYÓ. Air filter Follow the instructions in the Maintenance Guide.
Engine oil dipstick Check with the vehicle on a level surface and at leastten minutes after having
switched off the engine. Never exceed the maxi- mum level.
Check the level regularly.Maxi Mini
Caution
Take care when carrying out checks under the bonnet when theengine is hot, even if the engine is
switched off, as the cooling fancan start up at any time. The engine oil should be checked regularly between the servicevisits recommended by the manu-
facturer, as well as before longjourneys.
Topping up brake fluid
See ÒLEVELS AND CHECKSÓ.
Front and rear screenwash and headlampwash* reservoir
See ÒCAPACITYÓ.
Topping up enginecoolant
See ÒLEVELS AND CHECKSÓ. Note : If it is necessary to top up
the coolant frequently this indi- cates a fault which should bechecked as soon as possible.V- 1LEVELS

Topping up engine coolant Engine cold : The coolant level should be between the MINI and MAXI marks.
Engine warm : Wait for 15 minutes, the coolant temperature must be below 100¡C. Protect your
hands with a cloth, and slowly unscrew the cap as far as the safety catch to release the pressure.
Level :
Top up.
If more than 1 litre of coolant is required, have the cooling circuit checked by an approved dealer. Ensure that the cap is properly locked in position on the 2nd notch.
If it is necessary to add fluid frequently, this indicates a fault which should be checked as soon as possible.
* According to specification.
82V- 2LEVELS AND CHECKS*
This is a delicate operation which must be performed by an approved dealer.

Radiator - engine coolant
The coolant level should only be checked when the engine is cold. The level must always be between the MINI and MAXI marks on the vertical part ofthe radiator (water tank, cap side) for petrol engines, or in the reservoir ope-ning for diesel engines. The coolant contains an anti-freeze which not only enables it to withstand low temperatures (original protection to minus 37¡C) but also makes it anti-corrosive and resistant to high temperatures.
83V- 2LEVELS AND CHECKS*
Petrol engineDiesel engine
* According to specification.

Front and rear screen wash and headlamp wash reservoir.
For best cleaning results and for your safety, use products recommended by the manufacturer to avoid any damage to the windscreen wash circuit.
When topping up, fill slowly. Reservoir level The reservoir is fitted with a transparent tube (with the headlamp wash option).
To see the fluid level, cover the breather hole with your finger.
Unclip the cover, keeping your finger on the opening. The level can be seen through the tube.
85V- 2LEVELS AND CHECKS*
Power steering reservoir*
Check the level with the engine off. The level in the reservoir must be above the MINI mark and below the MAXI mark. The power steering pump must never operate without fluid (risk of seizing).* According to specification.

Front and rear screen wash
and headlamp wash reservoir 3,5 or 7,5 litres
88V- 5CAPACITIES *
Engine typeOil capacity (litres)
(1)
Without air conditioning With air conditioning
1.1i Engines 3,50 Ñ
1.4i Engines 3,50 3,50
1.9D Engines 4,75 4,50
2.0 HDi Engines 4,50 4,25
(1)Oil change with filter cartridge.
* According to specification.