2001 DODGE RAM airbag off

(5) Lift the panel/defrost door out of the top open-
ing of the HVAC housing.
INSTALLATION - HEAT/DEFROST DOOR
(1) Install the heat/defrost door in the HVAC hous-
ing.
(2) Assemble the HVAC housing. (Refer to 24 -
HEATING & AIR CONDITIONING/DISTRIBUTION/
HVAC HOUSING - ASSEMBLY)
(3) Install the heat/defrost door actuator on the
HVAC housing. (Refer to 24 - HEATING & AIR CON-
DITIONING/CONTROLS/MODE DOOR ACTUATOR
- INSTALLATION)
(4) Install the HVAC housing in the vehicle. (Refer
to 24 - HEATING & AIR CONDITIONING/DISTRI-
BUTION/HVAC HOUSING - INSTALLATION)
INSTALLATION - PANEL/DEFROST DOOR
(1) Install the panel/defrost door through the top
opening of the HVAC housing.
(2) Install the defroster and demister duct adapter
on the HVAC housing. (Refer to 24 - HEATING &
AIR CONDITIONING/DISTRIBUTION/DEFROSTER
DUCTS - INSTALLATION)
(3) Install the panel/defrost door actuator on the
HVAC housing. (Refer to 24 - HEATING & AIR CON-
DITIONING/CONTROLS/MODE DOOR ACTUATOR
- REMOVAL)
(4) Install the instrument panel assembly in the
vehicle. Refer to Instrument Panel System for the
procedures.
(5) Connect the battery negative cable.
RECIRCULATION DOOR
REMOVAL
WARNING: ON VEHICLES EQUIPPED WITH AIR-
BAGS, DISABLE THE AIRBAG SYSTEM BEFORE
ATTEMPTING ANY STEERING WHEEL, STEERING
COLUMN, OR INSTRUMENT PANEL COMPONENT
DIAGNOSIS OR SERVICE. DISCONNECT AND ISO-
LATE THE BATTERY NEGATIVE (GROUND) CABLE,
THEN WAIT TWO MINUTES FOR THE AIRBAG SYS-
TEM CAPACITOR TO DISCHARGE BEFORE PER-FORMING FURTHER DIAGNOSIS OR SERVICE. THIS
IS THE ONLY SURE WAY TO DISABLE THE AIRBAG
SYSTEM. FAILURE TO TAKE THE PROPER PRE-
CAUTIONS COULD RESULT IN AN ACCIDENTAL
AIRBAG DEPLOYMENT AND POSSIBLE PERSONAL
INJURY.
WARNING: IF THE VEHICLE IS EQUIPPED WITH AIR
CONDITIONING, REVIEW THE WARNINGS AND
CAUTIONS IN PLUMBING BEFORE PERFORMING
THE FOLLOWING OPERATION. (Refer to 24 - HEAT-
ING & AIR CONDITIONING/PLUMBING - WARNING)
(Refer to 24 - HEATING & AIR CONDITIONING/
PLUMBING - CAUTION)
(1) Remove the HVAC housing from the vehicle.
(Refer to 24 - HEATING & AIR CONDITIONING/
DISTRIBUTION/HVAC HOUSING - REMOVAL)
(2) Unsnap the recirculation door vacuum actuator
link clip and disengage the link from the recircula-
tion door lever. (Refer to 24 - HEATING & AIR CON-
DITIONING/CONTROLS/RECIRCULATION DOOR
ACTUATOR - REMOVAL)
(3) Using a trim stick or another suitable wide
flat-bladed tool, gently pry the retainer off of the
recirculation door pivot shaft.
(4) Remove the recirculation door through the out-
side air intake opening on the top of the HVAC hous-
ing.
INSTALLATION
(1) Install the recirculation door through the out-
side air intake opening on the top of the HVAC hous-
ing.
(2) Install the retainer on the recirculation door
pivot shaft.
(3) Engage the recirculation door vacuum actuator
link clip with the recirculation door lever. (Refer to
24 - HEATING & AIR CONDITIONING/CONTROLS/
RECIRCULATION DOOR ACTUATOR - INSTALLA-
TION)
(4) Install the HVAC housing in the vehicle. (Refer
to 24 - HEATING & AIR CONDITIONING/DISTRI-
BUTION/HVAC HOUSING - INSTALLATION)
BR/BEDISTRIBUTION 24 - 39
MODE DOOR (Continued)

AIR PUMP FILTER - INSTALLATION......25-29
AIR PUMP FILTER - REMOVAL..........25-29
AIR TESTING TRANSMISSION CLUTCH
AND BAND OPERATION - DIAGNOSIS
AND TESTING................21-490,21-661
AIR TO OIL COOLER - INSTALLATION.....7-88
AIR TO OIL COOLER - REMOVAL.........7-87
AIRBAG - ASSEMBLY, DRIVER..........8O-17
AIRBAG - DESCRIPTION, DRIVER........8O-14
AIRBAG - DESCRIPTION, PASSENGER....8O-21
AIRBAG - DISASSEMBLY, DRIVER.......8O-15
AIRBAG - INSTALLATION, DRIVER.......8O-18
AIRBAG - INSTALLATION, PASSENGER . . . 8O-23
AIRBAG - OPERATION, DRIVER.........8O-14
AIRBAG - OPERATION, PASSENGER......8O-21
AIRBAG - REMOVAL, DRIVER...........8O-14
AIRBAG - REMOVAL, PASSENGER.......8O-21
AIRBAG CONTROL MODULE -
DESCRIPTION........................8O-6
AIRBAG CONTROL MODULE -
INSTALLATION.......................8O-8
AIRBAG CONTROL MODULE -
OPERATION..........................8O-6
AIRBAG CONTROL MODULE - REMOVAL . . . 8O-7
AIRBAG DEPLOYMENT - STANDARD
PROCEDURE, SERVICE AFTER AN........8O-4
AIRBAG INDICATOR - DESCRIPTION......8J-15
AIRBAG INDICATOR - OPERATION.......8J-15
AIRBAG ON/OFF SWITCH -
DESCRIPTION, PASSENGER............8O-23
AIRBAG ON/OFF SWITCH -
INSTALLATION, PASSENGER...........8O-25
AIRBAG ON/OFF SWITCH - OPERATION,
PASSENGER........................8O-24
AIRBAG ON/OFF SWITCH - REMOVAL,
PASSENGER........................8O-24
AIRBAG SYSTEM - DIAGNOSIS AND
TESTING............................8O-4
AIRBAG SYSTEM - SPECIAL TOOLS.......8O-6
AIRBAGS - STANDARD PROCEDURE,
HANDLING NON-DEPLOYED.............8O-4
AIRFLOW - DESCRIPTION, HVAC
SYSTEM............................24-31
AJAR SWITCH - DESCRIPTION, DOOR....8L-34
AJAR SWITCH - DIAGNOSIS AND
TESTING, DOOR.....................8L-34
AJAR SWITCH - INSTALLATION, DOOR . . . 8L-35
AJAR SWITCH - REMOVAL, DOOR.......8L-35
ALIGNMENT - DESCRIPTION, WHEEL.......2-1
ALIGNMENT - OPERATION, WHEEL........2-2
ALIGNMENT I.F.S. - STANDARD
PROCEDURES.........................2-2
ALIGNMENT LINK/COIL SUSPENSION -
STANDARD PROCEDURES...............2-5
ALIGNMENT, SPECIAL TOOLS -
HEADLAMP..........................8L-4
ALIGNMENT, SPECIFICATIONS............2-6
ALUMINUM THREAD REPAIR -
STANDARD
PROCEDURE.....21-159,21-330,21-502,21-673
AMBIENT TEMP SENSOR - DESCRIPTION . 8M-11
AMBIENT TEMP SENSOR -
INSTALLATION......................8M-13
AMBIENT TEMP SENSOR - OPERATION . . 8M-11
AMBIENT TEMP SENSOR - REMOVAL
....8M-12
AMBIENT TEMPERATURE SENSOR -
DIAGNOSIS & TESTING
...............8M-12
AMPERAGE TEST - DIAGNOSIS AND
TESTING, FUEL PUMP
.................14-10
AN AIRBAG DEPLOYMENT - STANDARD
PROCEDURE, SERVICE AFTER
...........8O-4
ANTENNA - DIAGNOSIS AND TESTING
.....8A-5
ANTENNA BODY & CABLE -
DESCRIPTION
........................8A-4
ANTENNA BODY & CABLE - OPERATION
. . . 8A-4
ANTENNA CABLE - INSTALLATION,
INSTRUMENT PANEL
.................8A-10
ANTENNA CABLE - REMOVAL,
INSTRUMENT PANEL
..................8A-9
ANTILOCK BRAKE - DESCRIPTION,
CONTROLLER
.......................8E-11
ANTILOCK BRAKE - INSTALLATION,
CONTROLLER
.......................8E-12
ANTILOCK BRAKE - OPERATION,
CONTROLLER
.......................8E-11
ANTILOCK BRAKE - REMOVAL,
CONTROLLER
.......................8E-12A-PILLAR GRAB HANDLE -
INSTALLATION......................23-119
A-PILLAR GRAB HANDLE - REMOVAL . . . 23-119
A-PILLAR TRIM - INSTALLATION.......23-119
A-PILLAR TRIM - REMOVAL...........23-119
A-PILLAR TWEETER SPEAKER -
INSTALLATION.......................8A-19
A-PILLAR TWEETER SPEAKER -
REMOVAL..........................8A-19
APPEARANCE TIPS - CLEANING.........30-21
APPLICATION TABLE, SPECIFICATIONS -
A/C ................................24-8
APPLIQUE - INSTALLATION........23-62,23-67
APPLIQUE - REMOVAL...........23-62,23-67
AREA LEAKS - DIAGNOSIS AND
TESTING, REAR SEAL..................9-10
ARM / ADJUSTER ASSEMBLY -
INSTALLATION, ROCKER................9-85
ARM / ADJUSTER ASSEMBLY -
REMOVAL, ROCKER...................9-85
ARM / ADJUSTER ASSY - CLEANING,
ROCKER............................9-262
ARM / ADJUSTER ASSY - DESCRIPTION,
ROCKER............................9-261
ARM / ADJUSTER ASSY - INSPECTION,
ROCKER............................9-262
ARM / ADJUSTER ASSY -
INSTALLATION, ROCKER.....9-142,9-200,9-263
ARM / ADJUSTER ASSY - REMOVAL,
ROCKER.................9-142,9-200,9-261
ARM - DESCRIPTION, WIPER...........8R-11
ARM - INSTALLATION, LOWER
CONTROL.......................2-10,2-20
ARM - INSTALLATION, UPPER
CONTROL.......................2-13,2-24
ARM - INSTALLATION, WIPER..........8R-12
ARM - OPERATION, WIPER............8R-12
ARM - REMOVAL, LOWER CONTROL . . 2-10,2-20
ARM - REMOVAL, UPPER CONTROL . . 2-13,2-23
ARM - REMOVAL, WIPER..............8R-12
ARMREST/CONSOLE - INSTALLATION,
CENTER SEAT......................23-132
ARMREST/CONSOLE - REMOVAL,
CENTER SEAT......................23-132
ARMREST/LATCH COVER -
INSTALLATION, CENTER SEAT.........23-132
ARMREST/LATCH COVER - REMOVAL,
CENTER SEAT......................23-132
ASD AND FUEL PUMP RELAYS -
DIAGNOSIS AND TESTING...............8I-3
ASD SENSE - PCM INPUT - OPERATION....8I-3
ASH RECEIVER - INSTALLATION........23-109
ASH RECEIVER - REMOVAL...........23-108
ASSEMBLE, OIL PUMP...........9-109,9-165
ASSEMBLY - INSTALLATION, ROCKER
ARM / ADJUSTER.....................9-85
ASSEMBLY - REMOVAL, ROCKER ARM /
ADJUSTER...........................9-85
ASSEMBLY, AUTOMATIC
TRANSMISSION - 42RE...............21-166
ASSEMBLY, AUTOMATIC
TRANSMISSION - 44RE...............21-337
ASSEMBLY, AUTOMATIC
TRANSMISSION - 46RE...............21-510
ASSEMBLY, AUTOMATIC
TRANSMISSION - 47RE...............21-681
ASSEMBLY, AXLE VACUUM MOTOR . . . 3-33,3-65
ASSEMBLY, DIFFERENTIAL . . . 3-128,3-159,3-188,
3-37,3-69,3-98
ASSEMBLY, DIFFERENTIAL - POWR-LOK . . 3-163
ASSEMBLY, DIFFERENTIAL - TRAC-LOK . . . 3-101,
3-132,3-190
ASSEMBLY, DISC BRAKE CALIPERS.......5-12
ASSEMBLY, DRIVER AIRBAG...........8O-17
ASSEMBLY, FLYWHEEL.................6-17
ASSEMBLY, FRONT CLUTCH.....21-206,21-376,
21-550,21-721
ASSEMBLY, FRONT SERVO......21-208,21-379,
21-553,21-723
ASSEMBLY, GLOVE BOX..............23-112
ASSEMBLY, HVAC HOUSING............24-36
ASSEMBLY, INSTRUMENT CLUSTER......8J-13
ASSEMBLY, MANUAL - NV3500
.........21-17
ASSEMBLY, MANUAL - NV4500
.........21-65
ASSEMBLY, MANUAL - NV5600
........21-110
ASSEMBLY, OIL PUMP
.................9-51
ASSEMBLY, OIL PUMP
. . . 21-212,21-382,21-558,
21-729ASSEMBLY, OVERDRIVE UNIT . . . 21-225,21-395,
21-569,21-742
ASSEMBLY, OVERHEAD CONSOLE -
OVERHEAD CONSOLE.................8M-7
ASSEMBLY, OVERRUNNING CLUTCH
CAM/OVERDRIVE PISTON
RETAINER.......21-236,21-406,21-581,21-752
ASSEMBLY, PLANETARY GEARTRAIN/
OUTPUT SHAFT . . . 21-241,21-412,21-588,21-760
ASSEMBLY, REAR CLUTCH......21-248,21-419,
21-593,21-766
ASSEMBLY, REAR SERVO.......21-251,21-422,
21-595,21-768
ASSEMBLY, TRANS COOLER -
3.9L/5.2L/5.9L........................7-82
ASSEMBLY, TRANSFER CASE - NV231HD . 21-834
ASSEMBLY, TRANSFER CASE - NV241HD . 21-904
ASSEMBLY, TRANSFER CASE - NV241LD . 21-869
ASSEMBLY, VALVE BODY . 21-294,21-466,21-638,
21-810
ASSEMBLY, WHEEL CYLINDERS..........5-31
ASSIST HANDLE - INSTALLATION.......23-124
ASSIST HANDLE - REMOVAL..........23-124
ASSY - CLEANING, ROCKER ARM /
ADJUSTER..........................9-262
ASSY - DESCRIPTION, ROCKER ARM /
ADJUSTER..........................9-261
ASSY - INSPECTION, ROCKER ARM /
ADJUSTER..........................9-262
ASSY - INSTALLATION, ROCKER ARM /
ADJUSTER................9-142,9-200,9-263
ASSY - REMOVAL, ROCKER ARM /
ADJUSTER................9-142,9-200,9-261
AUDIO - DESCRIPTION.................8A-1
AUDIO - DIAGNOSIS AND TESTING.......8A-2
AUDIO - OPERATION...................8A-2
AUDIO SYSTEMS, SPECIAL TOOLS.......8A-4
AUGAT - INSTALLATION, CONNECTOR . . 8W-01-8
AUGAT - REMOVAL, CONNECTOR.....8W-01-8
AUTO. TRANS. - INSTALLATION, DIESEL
WITH..........................8P-11,8P-4
AUTO. TRANS. - REMOVAL, DIESEL
WITH...........................8P-4,8P-8
AUTOMATIC DAY / NIGHT MIRROR -
DESCRIPTION.......................8N-10
AUTOMATIC DAY / NIGHT MIRROR -
INSTALLATION......................8N-12
AUTOMATIC DAY / NIGHT MIRROR -
OPERATION.........................8N-11
AUTOMATIC DAY / NIGHT MIRROR -
REMOVAL..........................8N-12
AUTOMATIC DAY/NIGHT MIRROR -
DIAGNOSIS AND TESTING.............8N-11
AUTOMATIC SHUT DOWN RELAY -
INSTALLATION........................8I-5
AUTOMATIC SHUT DOWN RELAY -
REMOVAL............................8I-4
AUTOMATIC TRANSMISSION - 42RE -
ASSEMBLY.........................21-166
AUTOMATIC TRANSMISSION - 42RE -
CLEANING.........................21-165
AUTOMATIC TRANSMISSION - 42RE -
DESCRIPTION
......................21-135
AUTOMATIC TRANSMISSION - 42RE -
DISASSEMBLY
......................21-160
AUTOMATIC TRANSMISSION - 42RE -
INSPECTION
.......................21-165
AUTOMATIC TRANSMISSION - 42RE -
INSTALLATION
......................21-173
AUTOMATIC TRANSMISSION - 42RE -
OPERATION
........................21-137
AUTOMATIC TRANSMISSION - 42RE -
REMOVAL
.........................21-159
AUTOMATIC TRANSMISSION - 44RE -
ASSEMBLY
.........................21-337
AUTOMATIC TRANSMISSION - 44RE -
CLEANING
.........................21-336
AUTOMATIC TRANSMISSION - 44RE -
DESCRIPTION
......................21-306
AUTOMATIC TRANSMISSION - 44RE -
DISASSEMBLY
......................21-331
AUTOMATIC TRANSMISSION - 44RE -
INSPECTION
.......................21-337
AUTOMATIC TRANSMISSION - 44RE -
INSTALLATION
......................21-344
AUTOMATIC TRANSMISSION - 44RE -
OPERATION
........................21-308
2 INDEXBR/BE
Description Group-Page Description Group-Page Description Group-Page

DOOR CYLINDER LOCK SWITCH -
OPERATION..........................8N-5
DOOR CYLINDER LOCK SWITCH -
REMOVAL...........................8N-6
DOOR FORE/AFT - ADJUSTMENT, FRONT . . 23-68
DOOR GLASS - INSTALLATION..........23-69
DOOR GLASS - REMOVAL.............23-69
DOOR GLASS RUN WEATHERSTRIP -
INSTALLATION, FRONT...............23-154
DOOR GLASS RUN WEATHERSTRIP -
REMOVAL, FRONT...................23-153
DOOR INNER BELT WEATHERSTRIP -
INSTALLATION, FRONT...............23-154
DOOR INNER BELT WEATHERSTRIP -
REMOVAL, FRONT...................23-154
DOOR IN/OUT - ADJUSTMENT, FRONT....23-69
DOOR LATCH - ADJUSTMENT, FRONT....23-72
DOOR LOCKS - INSPECTION, DOORS.....30-11
DOOR OPENING SEAL - INSTALLATION . . 23-153
DOOR OPENING SEAL - REMOVAL......23-153
DOOR OUTER BELT WEATHERSTRIP -
INSTALLATION, FRONT...............23-154
DOOR OUTER BELT WEATHERSTRIP -
REMOVAL, FRONT...................23-154
DOOR SEAL - INSTALLATION, B-PILLAR . 23-152
DOOR SEAL - REMOVAL, B-PILLAR.....23-152
DOOR SECOND WEATHERSTRIP -
INSTALLATION, FRONT...............23-155
DOOR SECOND WEATHERSTRIP -
REMOVAL, FRONT...................23-154
DOOR SILL TRIM - INSTALLATION......23-121
DOOR SILL TRIM - REMOVAL.........23-121
DOOR SPEAKER - INSTALLATION, FRONT . 8A-20
DOOR SPEAKER - INSTALLATION, REAR . . 8A-21
DOOR SPEAKER - REMOVAL, FRONT.....8A-20
DOOR SPEAKER - REMOVAL, REAR......8A-21
DOOR UP/DOWN - ADJUSTMENT, FRONT . 23-69
DOOR UPPER CORNER SEAL -
INSTALLATION, FRONT...............23-154
DOOR UPPER CORNER SEAL -
REMOVAL, FRONT...................23-154
DOORS AND DOOR LOCKS -
INSPECTION........................30-11
DOORS AND LOCKS - INSPECTION,
WINDOWS..........................30-14
DOUBLE INVERTED FLARING -
STANDARD PROCEDURE.................5-8
DRAIN AND REFILL - STANDARD
PROCEDURE, FLUID.....21-851,21-885,21-922
DRAIN MANIFOLD - DESCRIPTION, FUEL . . 14-86
DRAIN MANIFOLD - INSTALLATION,
FUEL..............................14-86
DRAIN MANIFOLD - OPERATION, FUEL . . . 14-86
DRAIN MANIFOLD - REMOVAL, FUEL.....14-86
DRAINBACK VALVE - DESCRIPTION,
TORQUE CONVERTER....21-262,21-432,21-605,
21-778
DRAINBACK VALVE - OPERATION,
TORQUE CONVERTER....21-262,21-432,21-605,
21-778
DRAINBACK VALVE - STANDARD
PROCEDURE, TORQUE
CONVERTER.....21-262,21-432,21-606,21-778
DRAINING AT FUEL FILTER - STANDARD
PROCEDURES, WATER................14-56
DRAINING COOLING SYSTEM
3.9L/5.2L/5.9L/8.0L ENGINES -
STANDARD PROCEDURE................7-15
DRAINING COOLING SYSTEM 5.9L
DIESEL ENGINE - STANDARD
PROCEDURE.........................7-15
DRAW TEST - STANDARD PROCEDURE,
IGNITION-OFF.......................8F-15
DRIVE - DIAGNOSIS AND TESTING,
VISCOUS FAN....................7-56,7-58
DRIVE BELT - DIAGNOSIS AND TESTING,
ACCESSORY.................7-24,7-27,7-31
DRIVE BELTS - 3.9L/5.2L/5.9L -
INSTALLATION........................7-27
DRIVE BELTS - 3.9L/5.2L/5.9L -
REMOVAL...........................7-26
DRIVE BELTS - 5.9L DIESEL -
INSTALLATION
........................7-34
DRIVE BELTS - 5.9L DIESEL - REMOVAL
. . . 7-33
DRIVE BELTS - 8.0L - INSTALLATION
......7-30
DRIVE BELTS - 8.0L - REMOVAL
.........7-30
DRIVE INDICATOR - DIAGNOSIS AND
TESTING, FOUR-WHEEL
...............8J-29DRIVE VISCOUS CLUTCH - 3.9L/5.2L/
5.9L/8.0L - DESCRIPTION, FAN...........7-56
DRIVE VISCOUS CLUTCH - 3.9L/5.2L/
5.9L/8.0L - OPERATION, FAN............7-56
DRIVE VISCOUS CLUTCH - 5.9L
DIESEL - DESCRIPTION, FAN............7-57
DRIVE VISCOUS CLUTCH - 5.9L
DIESEL - OPERATION, FAN..............7-57
DRIVER AIRBAG - ASSEMBLY..........8O-17
DRIVER AIRBAG - DESCRIPTION........8O-14
DRIVER AIRBAG - DISASSEMBLY........8O-15
DRIVER AIRBAG - INSTALLATION.......8O-18
DRIVER AIRBAG - OPERATION..........8O-14
DRIVER AIRBAG - REMOVAL...........8O-14
DRIVER POWER SEAT SWITCH -
DESCRIPTION.......................8N-16
DRIVER POWER SEAT SWITCH -
DIAGNOSIS & TESTING...............8N-16
DRIVER POWER SEAT SWITCH -
INSTALLATION......................8N-17
DRIVER POWER SEAT SWITCH -
OPERATION.........................8N-16
DRIVER POWER SEAT SWITCH -
REMOVAL..........................8N-17
DRIVER SEAT HEATER SWITCH -
DESCRIPTION........................8G-7
DRIVER SEAT HEATER SWITCH -
INSTALLATION.......................8G-9
DRIVER SEAT HEATER SWITCH -
OPERATION..........................8G-7
DRIVER SEAT HEATER SWITCH -
REMOVAL.............................8G-9
DROP - STANDARD PROCEDURE,
TESTING FOR A VOLTAGE............8W-01-7
DRUM - ADJUSTMENT, REAR BRAKE......5-34
DRUM - CLEANING....................5-33
DRUM - DESCRIPTION.................5-32
DRUM - DIAGNOSIS AND TESTING,
BRAKE..............................5-33
DRUM - INSPECTION..................5-33
DRUM - OPERATION...................5-32
DRUM BRAKES - INSTALLATION, REAR
PARK BRAKE CABLE 2500/3500
SERIES WITH........................5-39
DRUM BRAKES - REMOVAL, REAR PARK
BRAKE CABLES 2500/3500 SERIES
WITH...............................5-38
DRUM IN HAT PARK BRAKE SHOES -
2500/3500 - INSTALLATION, REAR........5-42
DRUM IN HAT PARK BRAKE SHOES -
2500/3500 - REMOVAL, REAR...........5-41
DRUM MACHINING - STANDARD
PROCEDURE, BRAKE...................5-33
DUAL REAR WHEEL INSTALLATION -
STARDARD PROCEDURE...............22-10
DUCT ADAPTER - INSTALLATION,
DEFROSTER AND DEMISTER
...........24-35
DUCT ADAPTER - REMOVAL,
DEFROSTER AND DEMISTER
...........24-35
DUCTS - INSTALLATION, DEFROSTER
AND DEMISTER
......................24-35
DUCTS - REMOVAL, DEFROSTER AND
DEMISTER
..........................24-34
DUCTS - REMOVAL, INSTRUMENT
PANEL
.............................24-37
DUCTS - REMOVAL, INSTRUMENT
PANEL DEMISTER
....................24-37
DUTY ENGINE (1500 AND 2500 MODELS
EXCEPT 8.0L) MAINTENANCE
SCHEDULES, MAINTENANCE
SCHEDULES - LIGHT
....................0-7
DUTY ENGINE (FEDERAL ONLY - 2500
8.0L HD AND 3500 5.9L& 8.0L
MODELS) MAINTENANCE SCHEDULES
- DESCRIPTION, HEAVY
................0-17
DUTY TRUCK MAINTENANCE SCHEDULE
(8.0L 2500 & 3500 MODELS -
CALIFORNIA ONLY) - DESCRIPTION,
MEDIUM
............................0-13
DUTY/8.0L - DESCRIPTION, CATALYTIC
CONVERTER - 5.9L HEAVY
..............11-6
DUTY/8.0L - INSPECTION, CATALYTIC
CONVERTER - 5.9L HEAVY
..............11-7
DUTY/8.0L - INSPECTION, EXHAUST
PIPE - 5.9L HEAVY
....................11-9
DUTY/8.0L - INSPECTION, TAILPIPE -
5.9L HEAVY
.........................11-12DUTY/8.0L - INSTALLATION, CATALYTIC
CONVERTER - 5.9L HEAVY..............11-7
DUTY/8.0L - INSTALLATION, EXHAUST
PIPE - 5.9L HEAVY....................11-9
DUTY/8.0L - INSTALLATION, TAILPIPE -
5.9L HEAVY.........................11-12
DUTY/8.0L - OPERATION, CATALYTIC
CONVERTER - 5.9L HEAVY..............11-6
DUTY/8.0L - REMOVAL, CATALYTIC
CONVERTER - 5.9L HEAVY..............11-6
DUTY/8.0L - REMOVAL, EXHAUST PIPE -
5.9L HEAVY..........................11-8
DUTY/8.0L - REMOVAL, TAILPIPE - 5.9L
HEAVY .............................11-12
EASY ENTRY SEAT TRACK -
INSTALLATION......................23-142
EASY ENTRY SEAT TRACK - REMOVAL . . 23-142
ECM - DESCRIPTION..................8E-13
ECM - OPERATION...................8E-13
EFFECTS OF INCORRECT FLUID LEVEL -
DIAGNOSIS AND TESTING......21-199,21-370,
21-545,21-715
ELECTRICAL CONTROLS - DIAGNOSIS
AND TESTING, OVERDRIVE.....21-215,21-386,
21-579,21-732
ELECTROLYTE LEVEL - STANDARD
PROCEDURE, CHECKING BATTERY........8F-8
ELECTRONIC FEATURES - DESCRIPTION,
PROGRAMMABLE....................30-20
ELECTRONIC FEATURES - OPERATION,
PROGRAMMABLE....................30-20
ELECTRONIC GOVERNOR -
DESCRIPTION....21-194,21-365,21-540,21-710
ELECTRONIC GOVERNOR -
INSTALLATION....21-197,21-367,21-543,21-713
ELECTRONIC GOVERNOR - OPERATION
. 21-194,
21-365,21-541,21-711
ELECTRONIC GOVERNOR - REMOVAL
. . . 21-196,
21-367,21-542,21-712
ELEMENT - DESCRIPTION, HEATED
SEAT
..............................8G-10
ELEMENT - INSTALLATION, AIR
CLEANER
...........................9-245
ELEMENT - OPERATION, HEATED SEAT
. . . 8G-10
ELEMENT - REMOVAL, AIR CLEANER
.....9-244
ELEMENT AND SENSOR - DIAGNOSIS &
TESTING, HEATED SEAT
...............8G-11
EMERGENCY SIGNALS - INSPECTION,
TURN
..............................30-19
END SPLASH SHIELDS - INSTALLATION,
FRONT
.............................23-92
END SPLASH SHIELDS - REMOVAL,
FRONT
.............................23-92
ENGINE - DESCRIPTION, COOLING
SYSTEM FLOW - 3.9L/5.2L/5.9L
...........7-1
ENGINE - DESCRIPTION, FUEL
REQUIREMENTS - DIESEL
...............0-2
ENGINE - DIAGNOSIS AND TESTING,
COOLING SYSTEM DIESEL
..............7-12
ENGINE - DIAGNOSIS AND TESTING,
COOLING SYSTEM GAS
.................7-7
ENGINE - DIAGNOSIS AND TESTING,
DIESEL
.............................11-4
ENGINE - DIAGNOSIS AND TESTING,
GAS
................................11-4
ENGINE - ENGINE FIRING ORDER, 3.9L
V-6
.................................8I-2
ENGINE - IGNITION COIL RESISTANCE,
8.0L V-10
............................8I-3
ENGINE - INSTALLATION
...............9-241
ENGINE - INSTALLATION, DIESEL
........19-35
ENGINE - INSTALLATION, GASOLINE
.....19-35
ENGINE - REMOVAL
..................9-238
ENGINE - REMOVAL, DIESEL
...........19-33
ENGINE - REMOVAL, GASOLINE
.........19-33
ENGINE - SPARK PLUG CABLE ORDER,
8.0L V-10
............................8I-2
ENGINE - STANDARD PROCEDURE,
DRAINING COOLING SYSTEM 5.9L
DIESEL
.............................7-15
ENGINE - STANDARD PROCEDURE,
REFILLING COOLING SYSTEM 5.9L
DIESEL
.............................7-15
ENGINE - TORQUE, DIESEL
.............14-90
ENGINE - VISUAL INSPECTION, 8.0L
.....14-32
12 INDEXBR/BE
Description Group-Page Description Group-Page Description Group-Page

HORN RELAY - DIAGNOSIS AND
TESTING............................8H-3
HORN RELAY - OPERATION.............8H-3
HORN SWITCH - DESCRIPTION..........8H-4
HORN SWITCH - DIAGNOSIS AND
TESTING............................8H-5
HORN SWITCH - OPERATION............8H-5
HOSE - OPERATION, CRANKCASE VENT . . . 25-32
HOSE CLAMPS - DESCRIPTION...........7-2
HOSE CLAMPS - OPERATION.............7-2
HOSE WITH AIR CONDITIONING -
INSTALLATION, WATER PUMP BYPASS....7-77
HOSE WITH AIR CONDITIONING -
REMOVAL, WATER PUMP BYPASS........7-74
HOSE WITHOUT AIR CONDITIONING -
INSTALLATION, WATER PUMP BYPASS....7-78
HOSE WITHOUT AIR CONDITIONING -
REMOVAL, WATER PUMP BYPASS........7-77
HOSES - PRESSURE - DESCRIPTION.....19-37
HOSES - PRESSURE - OPERATION.......19-37
HOSES - RETURN - DESCRIPTION.......19-37
HOSES - RETURN - OPERATION.........19-37
HOSES/LINES/TUBES PRECAUTIONS -
CAUTION, REFRIGERANT..............24-42
HOSES/TUBES - DESCRIPTION, WASHER . . 8R-8
HOSES/TUBES - OPERATION, WASHER....8R-8
HOUSING - ASSEMBLY, HVAC...........24-36
HOUSING - DIAGNOSIS AND TESTING,
CLUTCH.............................6-11
HOUSING - DISASSEMBLY, HVAC........24-36
HOUSING - INSTALLATION, CLUTCH......6-13
HOUSING - INSTALLATION, GEAR........9-305
HOUSING - INSTALLATION, HVAC........24-37
HOUSING - INSTALLATION, LOCK
CYLINDER..........................19-11
HOUSING - REMOVAL, CLUTCH..........6-13
HOUSING - REMOVAL, GEAR...........9-304
HOUSING - REMOVAL, HVAC...........24-35
HOUSING - REMOVAL, LOCK CYLINDER . . 19-10
HOUSING BUSHING - INSTALLATION,
EXTENSION......21-198,21-369,21-544,21-714
HOUSING BUSHING - REMOVAL,
EXTENSION......21-198,21-369,21-544,21-714
HOUSING BUSHING AND SEAL -
INSTALLATION, EXTENSION.....21-850,21-885,
21-921
HOUSING BUSHING AND SEAL -
REMOVAL, EXTENSION . . . 21-850,21-885,21-921
HOUSING COVER - INSTALLATION, GEAR . 9-307
HOUSING COVER - REMOVAL, GEAR.....9-306
HOUSING FLUID LEAK - DIAGNOSIS AND
TESTING, CONVERTER . . . 21-148,21-319,21-491,
21-662
HOUSING INLET BAFFLE -
INSTALLATION, HVAC.................24-37
HOUSING INLET BAFFLE - REMOVAL,
HVAC..............................24-36
HOUSING PLUG - INSTALLATION,
STEERING GEAR.....................19-27
HOUSING PLUG - REMOVAL, STEERING
GEAR..............................19-27
HOUSING SEAL - INSTALLATION,
ADAPTER.....................21-132,21-87
HOUSING SEAL - INSTALLATION,
EXTENSION......21-132,21-198,21-369,21-544,
21-715,21-87
HOUSING SEAL - REMOVAL, ADAPTER . . 21-132,
21-87
HOUSING SEAL - REMOVAL,
EXTENSION......21-132,21-198,21-369,21-544,
21-714,21-87
HOW TO USE WIRING DIAGRAMS -
DESCRIPTION.....................8W-01-1
H.P. - DESCRIPTION, FUEL PUMP 235....14-66
H.P. - DESCRIPTION, FUEL PUMP 245....14-65
HUB / BEARING - INSTALLATION..........2-9
HUB / BEARING - REMOVAL..............2-9
HVAC HOUSING - ASSEMBLY...........24-36
HVAC HOUSING - DISASSEMBLY........24-36
HVAC HOUSING - INSTALLATION........24-37
HVAC HOUSING - REMOVAL
............24-35
HVAC HOUSING INLET BAFFLE -
INSTALLATION
.......................24-37
HVAC HOUSING INLET BAFFLE -
REMOVAL
..........................24-36
HVAC SYSTEM AIRFLOW - DESCRIPTION
. 24-31
HYDRAULIC BOOSTER - DIAGNOSIS
AND TESTING
........................5-17HYDRAULIC LIFTERS - CLEANING . . 9-152,9-208
HYDRAULIC LIFTERS - INSTALLATION . . . 9-152,
9-208
HYDRAULIC LIFTERS - REMOVAL . . . 9-152,9-207
HYDRAULIC LIFTERS (CAM IN BLOCK) -
CLEANING.......................9-39,9-96
HYDRAULIC LIFTERS (CAM IN BLOCK) -
INSTALLATION....................9-39,9-96
HYDRAULIC LIFTERS (CAM IN BLOCK) -
REMOVAL.......................9-39,9-96
HYDRAULIC PRESSURE TEST -
DIAGNOSIS AND TESTING......21-144,21-315,
21-487,21-658
HYDRAULIC SCHEMATICS, SCHEMATICS
AND DIAGRAMS . . 21-174,21-345,21-520,21-690
HYDRAULIC TAPPETS - DIAGNOSIS AND
TESTING..............9-151,9-206,9-38,9-95
HYDRAULIC/MECHANICAL -
DESCRIPTION.........................5-4
HYDRAULIC/MECHANICAL - WARNING.....5-5
HYDROMETER TEST - STANDARD
PROCEDURE........................8F-12
HYDROSTATIC LOCK - STANDARD
PROCEDURE......9-11,9-125,9-181,9-238,9-68
IDENTIFICATION - DESCRIPTION,
FASTENER.........................Intro.-3
IDENTIFICATION LAMP - INSTALLATION,
OUTBOARD.........................8L-29
IDENTIFICATION LAMP - REMOVAL,
OUTBOARD.........................8L-28
IDENTIFICATION NUMBER -
DESCRIPTION, VEHICLE.............Intro.-10
IDENTIFICATION PLATE - DESCRIPTION,
EQUIPMENT......................Intro.-12
IDLE AIR CONTROL MOTOR -
DESCRIPTION.......................14-41
IDLE AIR CONTROL MOTOR -
OPERATION.........................14-41
I.F.S. - STANDARD PROCEDURES,
ALIGNMENT...........................2-2
IGNITION - SPECIFICATIONS, TORQUE.....8I-2
IGNITION CIRCUIT SENSE -
DESCRIPTION.......................8E-17
IGNITION CIRCUIT SENSE - OPERATION . . 8E-19
IGNITION COIL RESISTANCE, 3.9L/5.2L/
5.9L ENGINES........................8I-3
IGNITION COIL RESISTANCE, 8.0L V-10
ENGINE..............................8I-3
IGNITION SWITCH - DESCRIPTION.......19-11
IGNITION SWITCH - DESCRIPTION,
KEY-IN..............................19-9
IGNITION SWITCH - DIAGNOSIS AND
TESTING...........................19-11
IGNITION SWITCH - INSTALLATION......19-12
IGNITION SWITCH - OPERATION........19-11
IGNITION SWITCH - REMOVAL..........19-12
IGNITION SWITCH AND KEY LOCK
CYLINDER - DIAGNOSIS AND TESTING . . . 19-10
IGNITION TIMING, SPECIFICATIONS.......8I-3
IGNITION-OFF DRAW TEST - STANDARD
PROCEDURE........................8F-15
IMPORTANCE OF CAREFUL NEW
VEHICLE PREPARATION -
DESCRIPTION, THE....................30-1
INCH - INSTALLATION, 12 1/8...........5-28
INCH - INSTALLATION, REAR BRAKE
SHOES-11...........................5-27
INCH - REMOVAL, 12 1/8...............5-26
INCH - REMOVAL, REAR BRAKE
SHOES-11...........................5-25
INCORRECT FLUID LEVEL - DIAGNOSIS
AND TESTING, EFFECTS OF.....21-199,21-370,
21-545,21-715
INDEPENDENT FRONT SUSPENSION,
SPECIAL TOOLS.......................2-9
INDICATOR - DESCRIPTION, ABS........8J-14
INDICATOR - DESCRIPTION, AIRBAG.....8J-15
INDICATOR - DESCRIPTION, BRAKE/
PARK BRAKE........................8J-16
INDICATOR - DESCRIPTION, CHECK
GAUGES............................8J-17
INDICATOR - DESCRIPTION, CRUISE
.....8J-18
INDICATOR - DESCRIPTION, GEAR
SELECTOR
..........................8J-21
INDICATOR - DESCRIPTION, HIGH BEAM
. . 8J-21
INDICATOR - DESCRIPTION, LOW FUEL
. . . 8J-23
INDICATOR - DESCRIPTION, OVERDRIVE
OFF
...............................8J-27INDICATOR - DESCRIPTION, SEATBELT . . . 8J-27
INDICATOR - DESCRIPTION, SERVICE
REMINDER..........................8J-28
INDICATOR - DESCRIPTION,
TRANSMISSION OVERTEMP............8J-31
INDICATOR - DESCRIPTION, UPSHIFT....8J-33
INDICATOR - DESCRIPTION, VTSS........8Q-3
INDICATOR - DESCRIPTION, WAIT-TO-
START .............................8J-34
INDICATOR - DESCRIPTION, WASHER
FLUID..............................8J-35
INDICATOR - DESCRIPTION, WATER-IN-
FUEL..............................8J-36
INDICATOR - DIAGNOSIS AND TESTING,
BRAKE.............................8J-16
INDICATOR - DIAGNOSIS AND TESTING,
FOUR-WHEEL DRIVE..................8J-29
INDICATOR - DIAGNOSIS AND TESTING,
HIGH BEAM.........................8J-22
INDICATOR - DIAGNOSIS AND TESTING,
VTSS...............................8Q-3
INDICATOR - DIAGNOSIS AND TESTING,
WASHER FLUID......................8J-36
INDICATOR - OPERATION, ABS..........8J-14
INDICATOR - OPERATION, AIRBAG.......8J-15
INDICATOR - OPERATION, BRAKE/PARK
BRAKE.............................8J-16
INDICATOR - OPERATION, CHECK
GAUGES............................8J-17
INDICATOR - OPERATION, CRUISE.......8J-18
INDICATOR - OPERATION, GEAR
SELECTOR...........................8J-21
INDICATOR - OPERATION, HIGH BEAM....8J-22
INDICATOR - OPERATION, LOW FUEL.....8J-23
INDICATOR - OPERATION, OVERDRIVE
OFF ...............................8J-27
INDICATOR - OPERATION, SEATBELT.....8J-27
INDICATOR - OPERATION, SERVICE
REMINDER..........................8J-28
INDICATOR - OPERATION,
TRANSMISSION OVERTEMP............8J-31
INDICATOR - OPERATION, UPSHIFT......8J-33
INDICATOR - OPERATION, VTSS.........8Q-3
INDICATOR - OPERATION, WAIT-TO-
START .............................8J-35
INDICATOR - OPERATION, WASHER
FLUID..............................8J-35
INDICATOR - OPERATION, WATER-IN-
FUEL..............................8J-37
INDICATOR LAMP (MIL) - DESCRIPTION,
MALFUNCTION.......................8J-24
INDICATOR LAMP (MIL) - OPERATION,
MALFUNCTION.......................8J-24
INDICATOR TEST - STANDARD
PROCEDURE, BUILT-IN................8F-11
INDICATOR (TRANSFER CASE) -
DESCRIPTION, SHIFT.................8J-29
INDICATOR (TRANSFER CASE) -
OPERATION, SHIFT...................8J-29
INDICATORS - DESCRIPTION, TURN
SIGNAL............................8J-32
INDICATORS - DIAGNOSIS AND
TESTING, TREAD WEAR................22-7
INDICATORS - DIAGNOSIS AND
TESTING, TURN SIGNAL...............8J-32
INDICATORS - OPERATION, TURN
SIGNAL............................8J-32
INITIAL OPERATION - STANDARD
PROCEDURE, POWER STEERING
PUMP
.............................19-31
INJECTION - SPECIFICATIONS, TORQUE -
GAS FUEL
..........................14-35
INJECTION PUMP - DESCRIPTION, AIR
. . . 25-28
INJECTION PUMP - DIAGNOSIS AND
TESTING, AIR
.......................25-28
INJECTION PUMP - INSTALLATION, AIR
. . . 25-29
INJECTION PUMP - INSTALLATION, FUEL
. 14-71
INJECTION PUMP - OPERATION, AIR
.....25-28
INJECTION PUMP - OPERATION, FUEL
....14-66
INJECTION PUMP - REMOVAL, AIR
......25-29
INJECTION PUMP - REMOVAL, FUEL
.....14-68
INJECTION PUMP DATA PLATE,
SPECIFICATIONS - FUEL
...............14-73
INJECTION PUMP RELAY -
DESCRIPTION, FUEL
..................14-99
INJECTION PUMP RELAY - OPERATION,
FUEL
..............................14-99
18 INDEXBR/BE
Description Group-Page Description Group-Page Description Group-Page

MOUNTED - INSTALLATION, SIDE VIEW
MIRROR - LOW......................23-98
MOUNTED - REMOVAL, SIDE VIEW
MIRROR - LOW......................23-98
MOUNTED STOP LAMP - INSTALLATION,
CENTER HIGH........................8L-6
MOUNTED STOP LAMP - REMOVAL,
CENTER HIGH........................8L-6
MOUNTED STOP LAMP UNIT -
INSTALLATION, CENTER HIGH...........8L-6
MOUNTED STOP LAMP UNIT -
REMOVAL, CENTER HIGH...............8L-6
MOUNTING - STANDARD PROCEDURES,
MATCH .............................22-2
MUFFLER - 3.9L/5.2L/5.9L/8.0L -
INSTALLATION.......................11-11
MUFFLER - 3.9L/5.2L/5.9L/8.0L -
REMOVAL..........................11-10
MUFFLER - 5.9L DIESEL - INSTALLATION . 11-11
MUFFLER - 5.9L DIESEL - REMOVAL.....11-11
MULTI-FUNCTION SWITCH -
DESCRIPTION.......................8L-23
MULTI-FUNCTION SWITCH - DIAGNOSIS
AND TESTING.......................8L-25
MULTI-FUNCTION SWITCH -
INSTALLATION.......................8L-28
MULTI-FUNCTION SWITCH - OPERATION . . 8L-24
MULTI-FUNCTION SWITCH - REMOVAL . . . 8L-27
NAME PLATES - INSTALLATION,
EXTERIOR..........................23-89
NAME PLATES - REMOVAL, EXTERIOR....23-89
NECK SEAL - DIAGNOSIS AND TESTING,
RADIATOR CAP-TO-FILLER..............7-66
NEGATIVE CABLE INSTALLATION,
GASOLINE..........................8F-24
NEGATIVE CABLE REMOVAL, GASOLINE . . . 8F-23
NEUTRAL SAFETY SWITCH -
INSPECTION........................30-19
NEW VEHICLE PREPARATION -
DESCRIPTION, THE IMPORTANCE OF
CAREFUL............................30-1
NEW VEHICLE PREPARATION FORM,
FINAL STEPS........................30-22
NIGHT MIRROR - DESCRIPTION,
AUTOMATIC DAY.....................8N-10
NIGHT MIRROR - INSTALLATION,
AUTOMATIC DAY.....................8N-12
NIGHT MIRROR - OPERATION,
AUTOMATIC DAY.....................8N-11
NIGHT MIRROR - REMOVAL,
AUTOMATIC DAY.....................8N-12
NOISE - DIAGNOSIS AND TESTING,
WIND...............................23-3
NOISE - INSPECTION, SQUEAKS,
RATTLES AND WIND..................30-15
NOISE OR VIBRATION - DIAGNOSIS AND
TESTING, TIRE.......................22-8
NOISE SUPPRESSION COMPONENTS -
DESCRIPTION, RADIO.................8A-12
NOISE SUPPRESSION COMPONENTS -
DIAGNOSIS AND TESTING, RADIO.......8A-12
NON-DEPLOYED AIRBAGS - STANDARD
PROCEDURE, HANDLING...............8O-4
NON-MONITORED CIRCUITS - DIESEL -
OPERATION.........................25-23
NON-MONITORED CIRCUITS - GAS
ENGINES - OPERATION................25-22
NOZZLE - DESCRIPTION, WASHER.......8R-9
NOZZLE - INSTALLATION, WASHER.......8R-9
NOZZLE - OPERATION, WASHER.........8R-9
NOZZLE - REMOVAL, WASHER...........8R-9
NUMBER - DESCRIPTION, VEHICLE
IDENTIFICATION...................Intro.-10
NV231HD - ASSEMBLY, TRANSFER CASE . 21-834
NV231HD - CLEANING, TRANSFER CASE . 21-831
NV231HD - DESCRIPTION, TRANSFER
CASE.............................21-820
NV231HD - DISASSEMBLY, TRANSFER
CASE.............................21-822
NV231HD - INSPECTION, TRANSFER
CASE.............................21-832
NV231HD - INSTALLATION, TRANSFER
CASE
.............................21-847
NV231HD - OPERATION, TRANSFER
CASE
.............................21-820
NV231HD - REMOVAL, TRANSFER CASE
. 21-822
NV231HD - TRANSFER CASE
..........21-849
NV241HD - ASSEMBLY, TRANSFER CASE
. 21-904NV241HD - CLEANING, TRANSFER CASE . 21-902
NV241HD - DESCRIPTION, TRANSFER
CASE.............................21-890
NV241HD - DISASSEMBLY, TRANSFER
CASE.............................21-894
NV241HD - INSPECTION, TRANSFER
CASE.............................21-902
NV241HD - INSTALLATION, TRANSFER
CASE.............................21-919
NV241HD - OPERATION, TRANSFER
CASE.............................21-892
NV241HD - REMOVAL, TRANSFER CASE . 21-894
NV241HD - TRANSFER CASE..........21-920
NV241LD - ASSEMBLY, TRANSFER CASE . 21-869
NV241LD - CLEANING, TRANSFER CASE . 21-866
NV241LD - DESCRIPTION, TRANSFER
CASE.............................21-855
NV241LD - DISASSEMBLY, TRANSFER
CASE.............................21-858
NV241LD - INSPECTION, TRANSFER
CASE.............................21-867
NV241LD - INSTALLATION, TRANSFER
CASE.............................21-882
NV241LD - OPERATION, TRANSFER
CASE.............................21-855
NV241LD - REMOVAL, TRANSFER CASE . 21-858
NV241LD - TRANSFER CASE...........21-884
NV3500 - ASSEMBLY, MANUAL.........21-17
NV3500 - CLEANING, MANUAL..........21-15
NV3500 - DESCRIPTION, MANUAL........21-1
NV3500 - DISASSEMBLY, MANUAL........21-5
NV3500 - INSPECTION, MANUAL........21-15
NV3500 - INSTALLATION, MANUAL......21-40
NV3500 - MANUAL...................21-41
NV3500 - OPERATION, MANUAL..........21-1
NV3500 - REMOVAL, MANUAL...........21-3
NV4500 - ASSEMBLY, MANUAL.........21-65
NV4500 - CLEANING, MANUAL..........21-64
NV4500 - DESCRIPTION, MANUAL.......21-44
NV4500 - DISASSEMBLY, MANUAL.......21-48
NV4500 - INSTALLATION, MANUAL......21-82
NV4500 - MANUAL...................21-83
NV4500 - OPERATION, MANUAL.........21-46
NV4500 - REMOVAL, MANUAL..........21-47
NV4500 - SPECIFICATIONS.............21-83
NV5600 - ASSEMBLY, MANUAL........21-110
NV5600 - DESCRIPTION, MANUAL.......21-91
NV5600 - DISASSEMBLY, MANUAL.......21-95
NV5600 - INSTALLATION, MANUAL.....21-125
NV5600 - OPERATION, MANUAL.........21-93
NV5600 - REMOVAL, MANUAL..........21-94
NV5600 - SPECIFICATIONS............21-126
NV5600 MANUAL TRANSMISSION,
SPECIAL TOOLS....................21-127
O2 SENSOR - DESCRIPTION............14-46
O2 SENSOR - INSTALLATION...........14-48
O2 SENSOR - OPERATION.............14-46
O2 SENSOR - REMOVAL...............14-47
ODOMETER - DESCRIPTION............8J-24
ODOMETER - OPERATION..............8J-25
OFF INDICATOR - DESCRIPTION,
OVERDRIVE.........................8J-27
OFF INDICATOR - OPERATION,
OVERDRIVE.........................8J-27
OFF SWITCH - DESCRIPTION,
OVERDRIVE........................21-215
OFF SWITCH - INSTALLATION,
OVERDRIVE........................21-215
OFF SWITCH - OPERATION, OVERDRIVE . 21-215
OFF SWITCH - REMOVAL, OVERDRIVE . . . 21-215
OIL - DESCRIPTION, ENGINE..........0-3,0-4
OIL - DESCRIPTION, REFRIGERANT......24-56
OIL - OPERATION, REFRIGERANT........24-56
OIL - STANDARD PROCEDURE, ENGINE . . 9-104,
9-160,9-217,9-47
OIL - STANDARD PROCEDURE-ENGINE
OIL LEVEL..........................9-295
OIL - STANDARD PROCEDURE-ENGINE
OIL SERVICE........................9-295
OIL COOLER - INSTALLATION, AIR TO
.....7-88
OIL COOLER & LINES - CLEANING AND
INSPECTION
........................9-296
OIL COOLER - REMOVAL, AIR TO
.........7-87
OIL COOLER - REMOVAL, WATER TO
......7-87
OIL COOLER - STANDARD PROCEDURE,
FLUSHING COOLER AND TUBES -
WITHOUT RADIATOR IN-TANK
TRANSMISSION
..............7-80,7-83,7-86OIL COOLER - STANDARD PROCEDURE,
FLUSHING COOLERS AND TUBES -
WITH RADIATOR IN-TANK
TRANSMISSION..............7-79,7-83,7-85
OIL FILTER - INSTALLATION . 9-105,9-161,9-218,
9-296,9-48
OIL FILTER - REMOVAL.....9-105,9-161,9-218,
9-296,9-48
OIL LEAKS - DIAGNOSIS AND TESTING,
ENGINE..............9-104,9-160,9-215,9-47
OIL LEVEL - STANDARD PROCEDURE,
REFRIGERANT.......................24-57
OIL LEVEL, OIL - STANDARD
PROCEDURE-ENGINE.................9-295
OIL PAN - CLEANING . . 9-106,9-162,9-218,9-297,
9-49
OIL PAN - INSPECTION.....9-106,9-162,9-219,
9-297,9-49
OIL PAN - INSTALLATION . . . 9-106,9-162,9-219,
9-297,9-49
OIL PAN - REMOVAL . . 9-105,9-161,9-218,9-296,
9-48
OIL PRESSURE - DIAGNOSIS AND
TESTING, ENGINE . 9-104,9-160,9-215,9-295,9-47
OIL PRESSURE GAUGE - DESCRIPTION . . . 8J-25
OIL PRESSURE GAUGE - OPERATION.....8J-26
OIL PRESSURE RELIEF VALVE -
CLEANING..........................9-297
OIL PRESSURE RELIEF VALVE -
INSPECTION........................9-297
OIL PRESSURE RELIEF VALVE -
INSTALLATION.......................9-298
OIL PRESSURE RELIEF VALVE -
REMOVAL............................9-297
OIL PRESSURE SENSOR/SWITCH -
DESCRIPTION...................9-298,9-49
OIL PRESSURE SENSOR/SWITCH -
INSTALLATION.......................9-299
OIL PRESSURE SENSOR/SWITCH -
OPERATION.....................9-298,9-49
OIL PRESSURE SENSOR/SWITCH -
REMOVAL..........................9-298
OIL PUMP - ASSEMBLE..........9-109,9-165
OIL PUMP - ASSEMBLY................9-51
OIL PUMP - ASSEMBLY . . 21-212,21-382,21-558,
21-729
OIL PUMP - CLEANING.......9-220,9-299,9-50
OIL PUMP - CLEANING . . 21-211,21-381,21-557,
21-728
OIL PUMP - DESCRIPTION......21-208,21-379,
21-554,21-724
OIL PUMP - DISASSEMBLE . . . 9-107,9-163,9-50
OIL PUMP - DISASSEMBLY.....21-209,21-380,
21-555,21-726
OIL PUMP - INSPECTION....9-107,9-163,9-220,
9-299,9-50
OIL PUMP - INSPECTION . 21-211,21-382,21-557,
21-728
OIL PUMP - INSTALLATION . . 9-109,9-165,9-221,
9-300,9-52
OIL PUMP - OPERATION . 21-208,21-379,21-554,
21-724
OIL PUMP - REMOVAL......9-107,9-162,9-219,
9-299,9-50
OIL PUMP VOLUME CHECK - STANDARD
PROCEDURE.....21-209,21-379,21-554,21-724
OIL SEAL - FRONT - DESCRIPTION,
CRANKSHAFT...............9-147,9-34,9-91
OIL SEAL - FRONT - INSTALLATION,
CRANKSHAFT..........9-148,9-277,9-34,9-91
OIL SEAL - FRONT - OPERATION,
CRANKSHAFT...............9-147,9-34,9-91
OIL SEAL - FRONT - REMOVAL,
CRANKSHAFT..........9-147,9-276,9-34,9-91
OIL SEAL - FRONT COVER INSTALLED -
INSTALLATION, FRONT................9-205
OIL SEAL - FRONT COVER INSTALLED -
REMOVAL, FRONT....................9-204
OIL SEAL - FRONT COVER REMOVED -
INSTALLATION, FRONT
................9-205
OIL SEAL - FRONT COVER REMOVED -
REMOVAL, FRONT
....................9-204
OIL SEAL - REAR - DESCRIPTION,
CRANKSHAFT
...............9-148,9-34,9-91
OIL SEAL - REAR - INSTALLATION,
CRANKSHAFT
.....9-149,9-206,9-278,9-35,9-92
OIL SEAL - REAR - OPERATION,
CRANKSHAFT
...............9-148,9-34,9-92
BR/BEINDEX 23
Description Group-Page Description Group-Page Description Group-Page

OIL SEAL - REAR - REMOVAL,
CRANKSHAFT.....9-149,9-206,9-278,9-35,9-92
OIL SEAL RETAINER - INSTALLATION,
CRANKSHAFT REAR.............9-206,9-279
OIL SEAL RETAINER - REMOVAL,
CRANKSHAFT REAR.............9-206,9-278
OIL SERVICE, OIL - STANDARD
PROCEDURE-ENGINE.................9-295
ON-BOARD DIAGNOSTICS (OBD) -
DIAGNOSIS AND TESTING...............7-4
ONE WAY CHECK VALVE - DESCRIPTION . . 25-30
ONE WAY CHECK VALVE - INSTALLATION . 25-30
ONE WAY CHECK VALVE - OPERATION....25-30
ONE WAY CHECK VALVE - REMOVAL.....25-30
ONE-WAY CHECK VALVE - DIAGNOSIS
AND TESTING.......................25-30
ON/OFF SWITCH - DESCRIPTION,
PASSENGER AIRBAG.................8O-23
ON/OFF SWITCH - INSTALLATION,
PASSENGER AIRBAG.................8O-25
ON/OFF SWITCH - OPERATION,
PASSENGER AIRBAG.................8O-24
ON/OFF SWITCH - REMOVAL,
PASSENGER AIRBAG.................8O-24
OPEN-CIRCUIT VOLTAGE TEST -
STANDARD PROCEDURE...............8F-13
OPENING COVER - INSTALLATION,
STEERING COLUMN.................23-116
OPENING COVER - REMOVAL, STEERING
COLUMN..........................23-115
OPENING DIMENSIONS, SPECIFICATIONS
- BODY............................23-60
OPENING SEAL - INSTALLATION, DOOR . . 23-153
OPENING SEAL - REMOVAL, DOOR.....23-153
OPENING UPPER TRIM - INSTALLATION,
GLOVE BOX........................23-114
OPENING UPPER TRIM - REMOVAL,
GLOVE BOX........................23-114
OPERATION, WIPERS/WASHERS.........8R-2
ORDER, 3.9L V-6 ENGINE - ENGINE
FIRING..............................8I-2
ORDER, 5.2L/5.9L V-8 ENGINES -
ENGINE FIRING.......................8I-2
ORDER, 8.0L V-10 ENGINE - SPARK
PLUG CABLE.........................8I-2
ORDER, DIESEL - FUEL INJECTOR
FIRING.............................14-58
ORIFICE TUBE - DESCRIPTION, A/C......24-53
ORIFICE TUBE - DIAGNOSIS AND
TESTING, FIXED.....................24-54
ORIFICE TUBE - OPERATION, A/C........24-53
ORIFICE TUBE - REMOVAL, A/C.........24-54
OTHER - INSPECTION.................30-15
OUT - STANDARD PROCEDURE, OWNER
CHECK.............................30-22
OUTBOARD IDENTIFICATION LAMP -
INSTALLATION.......................8L-29
OUTBOARD IDENTIFICATION LAMP -
REMOVAL..........................8L-28
OUTER BELT WEATHERSTRIP -
INSTALLATION, FRONT DOOR..........23-154
OUTER BELT WEATHERSTRIP -
REMOVAL, FRONT DOOR.............23-154
OUTLET - DESCRIPTION, CIGAR
LIGHTER.........................8W-97-2
OUTLET - DESCRIPTION, POWER......8W-97-9
OUTLET - DIAGNOSIS & TESTING,
POWER.........................8W-97-10
OUTLET - INSTALLATION, CIGAR
LIGHTER.........................8W-97-3
OUTLET - INSTALLATION, POWER
....8W-97-11
OUTLET - OPERATION, CIGAR LIGHTER
. 8W-97-2
OUTLET - OPERATION, POWER
......8W-97-10
OUTLET - REMOVAL, CIGAR LIGHTER
. . 8W-97-3
OUTLET - REMOVAL, POWER
........8W-97-10
OUTLET BARRELS - INSTALLATION,
PANEL
.............................24-32
OUTLET BARRELS - REMOVAL, PANEL
. . . 24-32
OUTPUT - DESCRIPTION, PCM
...........8I-3
OUTPUT - DIAGNOSIS AND TESTING,
VACUUM PUMP
.......................7-35
OUTPUT - OPERATION, PCM
............14-53
OUTPUT - OPERATION, PCM
.............8I-3
OUTPUT SHAFT FRONT BEARING -
INSTALLATION
....21-213,21-384,21-560,21-730
OUTPUT SHAFT FRONT BEARING -
REMOVAL
.......21-213,21-384,21-559,21-730OUTPUT SHAFT REAR BEARING -
INSTALLATION....21-213,21-384,21-560,21-731
OUTPUT SHAFT REAR BEARING -
REMOVAL.......21-213,21-384,21-560,21-731
OUTPUT SHAFT SEAL - INSTALLATION,
FRONT................21-852,21-886,21-922
OUTPUT SHAFT SEAL - REMOVAL,
FRONT................21-851,21-886,21-922
OVERDRIVE CLUTCH - DESCRIPTION . . . 21-214,
21-385,21-560,21-731
OVERDRIVE CLUTCH - OPERATION.....21-214,
21-385,21-560,21-731
OVERDRIVE ELECTRICAL CONTROLS -
DIAGNOSIS AND TESTING......21-215,21-386,
21-579,21-732
OVERDRIVE OFF INDICATOR -
DESCRIPTION.......................8J-27
OVERDRIVE OFF INDICATOR -
OPERATION.........................8J-27
OVERDRIVE OFF SWITCH -
DESCRIPTION......................21-215
OVERDRIVE OFF SWITCH -
INSTALLATION......................21-215
OVERDRIVE OFF SWITCH - OPERATION . . 21-215
OVERDRIVE OFF SWITCH - REMOVAL . . . 21-215
OVERDRIVE SWITCH - DESCRIPTION . . . 21-385,
21-578,21-732
OVERDRIVE SWITCH - INSTALLATION . . . 21-386,
21-579,21-733
OVERDRIVE SWITCH - OPERATION.....21-385,
21-579,21-732
OVERDRIVE SWITCH - REMOVAL......21-386,
21-579,21-733
OVERDRIVE UNIT - ASSEMBLY . . 21-225,21-395,
21-569,21-742
OVERDRIVE UNIT - CLEANING . . . 21-224,21-394,
21-568,21-741
OVERDRIVE UNIT - DISASSEMBLY.....21-217,
21-387,21-562,21-734
OVERDRIVE UNIT - INSPECTION . 21-224,21-394,
21-569,21-741
OVERDRIVE UNIT - INSTALLATION.....21-234,
21-404,21-577,21-750
OVERDRIVE UNIT - REMOVAL . . . 21-216,21-387,
21-560,21-733
OVERFLOW VALVE - DESCRIPTION......14-83
OVERFLOW VALVE - DIAGNOSIS AND
TESTING...........................14-84
OVERFLOW VALVE - INSTALLATION......14-85
OVERFLOW VALVE - OPERATION........14-83
OVERFLOW VALVE - REMOVAL..........14-84
OVERHEAD CONSOLE - DESCRIPTION....8M-1
OVERHEAD CONSOLE - INSTALLATION....8M-8
OVERHEAD CONSOLE - OVERHEAD
CONSOLE ASSEMBLY..................8M-7
OVERHEAD CONSOLE - OVERHEAD
CONSOLE DISASSEMBLY...............8M-7
OVERHEAD CONSOLE - REMOVAL........8M-6
OVERHEAD CONSOLE ASSEMBLY,
OVERHEAD CONSOLE.................8M-7
OVERHEAD CONSOLE DISASSEMBLY,
OVERHEAD CONSOLE.................8M-7
OVERHEAD CONSOLE SYSTEMS,
SPECIAL TOOLS......................8M-8
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
ASSEMBLY.......21-236,21-406,21-581,21-752
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
CLEANING.......21-236,21-406,21-580,21-752
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
DESCRIPTION....21-235,21-405,21-580,21-751
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
DISASSEMBLY....21-235,21-405,21-580,21-751
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
INSPECTION
.....21-236,21-406,21-580,21-752
OVERRUNNING CLUTCH CAM/
OVERDRIVE PISTON RETAINER -
OPERATION
......21-235,21-405,21-580,21-751
OVERTEMP INDICATOR - DESCRIPTION,
TRANSMISSION
......................8J-31
OVERTEMP INDICATOR - OPERATION,
TRANSMISSION
......................8J-31
OWNER CHECK OUT - STANDARD
PROCEDURE
........................30-22PAD - INSTALLATION, SILENCER.......23-103
PAD - REMOVAL, SILENCER...........23-103
PAINT CODE - DESCRIPTION..........23-129
PAINT COLOR CODES, SPECIFICATIONS -
2001 BR..........................23-129
PAINT TOUCH-UP - DESCRIPTION......23-129
PAN - CLEANING, OIL . 9-106,9-162,9-218,9-297,
9-49
PAN - INSPECTION, OIL.....9-106,9-162,9-219,
9-297,9-49
PAN - INSTALLATION, OIL . . . 9-106,9-162,9-219,
9-297,9-49
PAN - REMOVAL, OIL . . 9-105,9-161,9-218,9-296,
9-48
PANEL - INSTALLATION, QUARTER TRIM . 23-128
PANEL - INSTALLATION, TRIM.....23-74,23-84
PANEL - REMOVAL, QUARTER TRIM....23-127
PANEL - REMOVAL, TRIM.........23-74,23-84
PANEL ANTENNA CABLE -
INSTALLATION, INSTRUMENT...........8A-10
PANEL ANTENNA CABLE - REMOVAL,
INSTRUMENT........................8A-9
PANEL DEMISTER DUCTS - REMOVAL,
INSTRUMENT.......................24-37
PANEL DUCTS - REMOVAL,
INSTRUMENT.......................24-37
PANEL OUTLET BARRELS -
INSTALLATION.......................24-32
PANEL OUTLET BARRELS - REMOVAL....24-32
PANEL SPEAKER - INSTALLATION, REAR
CAB SIDE............................8A-21
PANEL SPEAKER - REMOVAL, REAR CAB
SIDE..............................8A-20
PANEL SYSTEM - DESCRIPTION,
INSTRUMENT......................23-104
PANEL SYSTEM - INSTALLATION,
INSTRUMENT......................23-107
PANEL SYSTEM - OPERATION,
INSTRUMENT......................23-105
PANEL SYSTEM - REMOVAL,
INSTRUMENT......................23-106
PANEL TOP COVER - INSTALLATION,
INSTRUMENT......................23-115
PANEL TOP COVER - REMOVAL,
INSTRUMENT......................23-114
PANEL TRIM - INSTALLATION, REAR
CLOSURE..........................23-121
PANEL TRIM - REMOVAL, REAR
CLOSURE..........................23-120
PANEL/DEFROST DOOR - INSTALLATION . . 24-39
PANEL/DEFROST DOOR - REMOVAL......24-38
PANEL/DEFROST DOOR ACTUATOR -
INSTALLATION.......................24-27
PANEL/DEFROST DOOR ACTUATOR -
REMOVAL..........................24-27
PARK BRAKE CABLE - 2500/3500 WITH
REAR DISC BRAKES - INSTALLATION,
REAR...............................5-38
PARK BRAKE CABLE - 2500/3500 WITH
REAR DISC BRAKES - REMOVAL,
REAR
...............................5-37
PARK BRAKE CABLE 2500/3500 SERIES
WITH DRUM BRAKES - INSTALLATION,
REAR
...............................5-39
PARK BRAKE CABLES - 1500 SERIES -
INSTALLATION, REAR
..................5-39
PARK BRAKE CABLES - 1500 SERIES -
REMOVAL, REAR
......................5-37
PARK BRAKE CABLES 2500/3500 SERIES
WITH DRUM BRAKES - REMOVAL,
REAR
...............................5-38
PARK BRAKE SHOES - 2500/3500 -
INSTALLATION, REAR DRUM IN HAT
......5-42
PARK BRAKE SHOES - 2500/3500 -
REMOVAL, REAR DRUM IN HAT
..........5-41
PARKING BRAKE - INSPECTION
.........30-17
PARKING BRAKE CABLE -
INSTALLATION, FRONT
.................5-39
PARKING BRAKE CABLE - REMOVAL,
FRONT
..............................5-37
PARK/NEUTRAL POSITION SWITCH -
DIAGNOSIS AND TESTING
......21-237,21-408,
21-583,21-755
PARK/NEUTRAL POSITION SWITCH -
INSTALLATION
....21-238,21-408,21-583,21-755
PARK/NEUTRAL POSITION SWITCH -
REMOVAL
.......21-238,21-408,21-583,21-755
24 INDEXBR/BE
Description Group-Page Description Group-Page Description Group-Page

PARK/TURN SIGNAL LAMP -
INSTALLATION.......................8L-29
PARK/TURN SIGNAL LAMP - REMOVAL . . . 8L-29
PARK/TURN SIGNAL LAMP UNIT -
INSTALLATION.......................8L-29
PARK/TURN SIGNAL LAMP UNIT -
REMOVAL..........................8L-29
PARTS - STANDARD PROCEDURES,
CLEANING FUEL SYSTEM..............14-57
PASSENGER AIRBAG - DESCRIPTION....8O-21
PASSENGER AIRBAG - INSTALLATION....8O-23
PASSENGER AIRBAG - OPERATION......8O-21
PASSENGER AIRBAG - REMOVAL........8O-21
PASSENGER AIRBAG ON/OFF SWITCH -
DESCRIPTION.......................8O-23
PASSENGER AIRBAG ON/OFF SWITCH -
INSTALLATION......................8O-25
PASSENGER AIRBAG ON/OFF SWITCH -
OPERATION.........................8O-24
PASSENGER AIRBAG ON/OFF SWITCH -
REMOVAL..........................8O-24
PASSENGER POWER SEAT SWITCH -
DESCRIPTION.......................8N-19
PASSENGER POWER SEAT SWITCH -
DIAGNOSIS & TESTING...............8N-19
PASSENGER POWER SEAT SWITCH -
INSTALLATION......................8N-20
PASSENGER POWER SEAT SWITCH -
OPERATION.........................8N-19
PASSENGER POWER SEAT SWITCH -
REMOVAL..........................8N-20
PASSENGER SEAT HEATER SWITCH -
DESCRIPTION.......................8G-13
PASSENGER SEAT HEATER SWITCH -
INSTALLATION......................8G-16
PASSENGER SEAT HEATER SWITCH -
OPERATION.........................8G-14
PASSENGER SEAT HEATER SWITCH -
REMOVAL..........................8G-15
PATTERNS - DIAGNOSIS AND TESTING,
TIRE WEAR..........................22-7
PCM - DESCRIPTION..................8E-14
PCM - GAS ENGINES - OPERATION......8E-17
PCM INPUT - OPERATION, ASD SENSE.....8I-3
PCM OUTPUT - DESCRIPTION............8I-3
PCM OUTPUT - OPERATION............14-53
PCM OUTPUT - OPERATION.............8I-3
PCV FILTER - DESCRIPTION............25-35
PCV VALVE - V-6/V-8 ENGINES -
DIAGNOSIS AND TESTING.............25-36
PEDAL - DESCRIPTION.................5-16
PEDAL - INSTALLATION............5-17,5-36
PEDAL - INSTALLATION, ACCELERATOR . . . 14-37
PEDAL - INSTALLATION, CLUTCH.........6-19
PEDAL - OPERATION...................5-16
PEDAL - REMOVAL................5-16,5-36
PEDAL - REMOVAL, ACCELERATOR......14-37
PEDAL - REMOVAL, CLUTCH............6-18
PEDAL POSITION SENSOR -
DESCRIPTION, ACCELERATOR..........14-91
PEDAL POSITION SENSOR -
INSTALLATION, ACCELERATOR..........14-93
PEDAL POSITION SENSOR - OPERATION,
ACCELERATOR.......................14-91
PEDAL POSITION SENSOR - REMOVAL,
ACCELERATOR.......................14-91
PEDAL POSITION SWITCH -
DESCRIPTION, CLUTCH.................6-22
PEDAL POSITION SWITCH - OPERATION,
CLUTCH.............................6-22
PER MILE, SPECIFICATIONS - TIRE
REVOLUTIONS........................22-9
PERFORMANCE - DIAGNOSIS AND
TESTING...............9-118,9-173,9-4,9-61
PERFORMANCE - DIAGNOSIS AND
TESTING, A/C........................24-2
PERFORMANCE - DIAGNOSIS AND
TESTING, HEATER.....................24-6
PERFORMANCE - INSPECTION, ENGINE . . . 30-16
PILOT BEARING - DESCRIPTION..........6-17
PILOT BEARING - INSTALLATION.........6-18
PILOT BEARING - OPERATION
...........6-18
PILOT BEARING - REMOVAL
.............6-18
PINION GEAR/RING GEAR -
INSTALLATION
....................3-42,3-74
PINION GEAR/RING GEAR - REMOVAL
. 3-40,3-72
PINION GEAR/RING GEAR/TONE RING -
INSTALLATION
........3-105,3-137,3-166,3-195PINION GEAR/RING GEAR/TONE RING -
REMOVAL...........3-103,3-135,3-165,3-193
PINION SEAL - INSTALLATION.....3-125,3-157,
3-185,3-34,3-66,3-95
PINION SEAL - REMOVAL . . . 3-125,3-156,3-185,
3-34,3-66,3-95
PIPE - 3.9L/5.2L/5.9L - INSPECTION,
EXHAUST............................11-7
PIPE - 3.9L/5.2L/5.9L - INSTALLATION,
EXHAUST............................11-7
PIPE - 3.9L/5.2L/5.9L - REMOVAL,
EXHAUST............................11-7
PIPE - 5.9L DIESEL - INSPECTION,
EXHAUST............................11-9
PIPE - 5.9L DIESEL - INSTALLATION,
EXHAUST...........................11-10
PIPE - 5.9L DIESEL - REMOVAL,
EXHAUST............................11-9
PIPE - 5.9L HEAVY DUTY/8.0L -
INSPECTION, EXHAUST.................11-9
PIPE - 5.9L HEAVY DUTY/8.0L -
INSTALLATION, EXHAUST...............11-9
PIPE - 5.9L HEAVY DUTY/8.0L -
REMOVAL, EXHAUST...................11-8
PISTON & CONNECTING ROD -
CLEANING........9-154,9-209,9-285,9-41,9-98
PISTON & CONNECTING ROD -
CONNECTING RODS..................9-286
PISTON & CONNECTING ROD -
DESCRIPTION.....9-153,9-208,9-282,9-40,9-97
PISTON & CONNECTING ROD -
INSPECTION......9-154,9-209,9-285,9-41,9-98
PISTON & CONNECTING ROD -
INSTALLATION......9-154,9-210,9-287,9-41,9-98
PISTON & CONNECTING ROD -
REMOVAL........9-154,9-209,9-285,9-40,9-97
PISTON FITTING - STANDARD
PROCEDURE...........9-153,9-208,9-40,9-97
PISTON GRADING - STANDARD
PROCEDURE........................9-282
PISTON RETAINER - ASSEMBLY,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-236,21-406,21-581,21-752
PISTON RETAINER - CLEANING,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-236,21-406,21-580,21-752
PISTON RETAINER - DESCRIPTION,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-235,21-405,21-580,21-751
PISTON RETAINER - DISASSEMBLY,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-235,21-405,21-580,21-751
PISTON RETAINER - INSPECTION,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-236,21-406,21-580,21-752
PISTON RETAINER - OPERATION,
OVERRUNNING CLUTCH CAM/
OVERDRIVE
......21-235,21-405,21-580,21-751
PISTON RING FITTING - STANDARD
PROCEDURE
................9-154,9-41,9-98
PISTON RINGS - STANDARD
PROCEDURE, FITTING
.................9-211
PISTON RINGS - STANDARD
PROCEDURE-PISTON RING FITTING
......9-288
PISTONS - DESCRIPTION
. 21-238,21-408,21-584,
21-755
PISTONS - OPERATION
. . 21-238,21-409,21-584,
21-755
PITMAN BEARING - INSTALLATION
......19-21
PITMAN BEARING - REMOVAL
..........19-20
PITMAN SHAFT - INSTALLATION
........19-23
PITMAN SHAFT - REMOVAL
............19-22
PITMAN SHAFT SEAL - INSTALLATION
....19-24
PITMAN SHAFT SEAL - REMOVAL
.......19-23
PLANETARY GEARTRAIN/OUTPUT
SHAFT - ASSEMBLY
.....21-241,21-412,21-588,
21-760
PLANETARY GEARTRAIN/OUTPUT
SHAFT - DESCRIPTION
. . . 21-240,21-410,21-585,
21-757
PLANETARY GEARTRAIN/OUTPUT
SHAFT - DISASSEMBLY
. . 21-240,21-411,21-586,
21-757
PLANETARY GEARTRAIN/OUTPUT
SHAFT - INSPECTION
....21-241,21-411,21-587,
21-760PLANETARY GEARTRAIN/OUTPUT
SHAFT - OPERATION....21-240,21-410,21-585,
21-757
PLATE - DESCRIPTION, BODY CODE....Intro.-1
PLATE - DESCRIPTION, ENGINE DATA....9-244
PLATE - DESCRIPTION, EQUIPMENT
IDENTIFICATION...................Intro.-12
PLATE - DESCRIPTION, PRESSURE.......6-15
PLATE - INSTALLATION, SUPPORT........5-32
PLATE - INSTALLATION, TRANSFER
CASE SKID.........................13-11
PLATE - OPERATION, PRESSURE.........6-16
PLATE - REMOVAL, SUPPORT...........5-32
PLATE - REMOVAL, TRANSFER CASE
SKID..............................13-11
PLATE LAMP - INSTALLATION, LICENSE . . 8L-22
PLATE LAMP - REMOVAL, LICENSE......8L-22
PLATE LAMP UNIT - INSTALLATION,
LICENSE...........................8L-22
PLATE LAMP UNIT - REMOVAL, LICENSE . . 8L-22
PLATE, SPECIFICATIONS - FUEL
INJECTION PUMP DATA...............14-73
PLATES - INSTALLATION, EXTERIOR
NAME.............................23-89
PLATES - REMOVAL, EXTERIOR NAME....23-89
PLUG - CLEANING, SPARK.............8I-19
PLUG - DESCRIPTION, SPARK...........8I-16
PLUG - INSTALLATION, SPARK..........8I-19
PLUG - INSTALLATION, STEERING GEAR
HOUSING............................19-27
PLUG - OPERATION, SPARK............8I-16
PLUG - REMOVAL, SPARK..............8I-18
PLUG - REMOVAL, STEERING GEAR
HOUSING...........................19-27
PLUG CABLE - DESCRIPTION, SPARK.....8I-19
PLUG CABLE - INSTALLATION, SPARK....8I-20
PLUG CABLE - OPERATION, SPARK.......8I-19
PLUG CABLE - REMOVAL, SPARK........8I-20
PLUG CABLE ORDER, 8.0L V-10 ENGINE
- SPARK .............................8I-2
PLUG CABLE RESISTANCE,
SPECIFICATIONS - SPARK...............8I-3
PLUG CABLES - DIAGNOSIS AND
TESTING, SPARK.....................8I-19
PLUG CONDITIONS - DIAGNOSIS AND
TESTING, SPARK.....................8I-16
PLUGS, SPECIFICATIONS - SPARK........8I-3
PLUMBING - CLEANING, CHARGE AIR
COOLER............................11-18
PLUMBING - DESCRIPTION............24-40
PLUMBING - DESCRIPTION, CHARGE
AIR COOLER........................11-17
PLUMBING - INSPECTION, CHARGE AIR
COOLER............................11-18
PLUMBING - INSTALLATION, CHARGE
AIR COOLER........................11-18
PLUMBING - OPERATION..............24-41
PLUMBING - OPERATION, CHARGE AIR
COOLER............................11-17
PLUMBING - REMOVAL, CHARGE AIR
COOLER............................11-17
POLISHING - DESCRIPTION, WET
SANDING/BUFFING..................23-130
PORT - DESCRIPTION, REFRIGERANT
SYSTEM SERVICE.....................24-1
PORT - OPERATION, REFRIGERANT
SYSTEM SERVICE.....................24-2
POSITION SENSOR - DESCRIPTION,
ACCELERATOR PEDAL.................14-91
POSITION SENSOR - DESCRIPTION,
THROTTLE..........................14-51
POSITION SENSOR - INSTALLATION,
ACCELERATOR PEDAL.................14-93
POSITION SENSOR - OPERATION,
ACCELERATOR PEDAL.................14-91
POSITION SENSOR - OPERATION,
THROTTLE..........................14-51
POSITION SENSOR - REMOVAL,
ACCELERATOR PEDAL
.................14-91
POSITION SWITCH - DESCRIPTION,
CLUTCH PEDAL
.......................6-22
POSITION SWITCH - DIAGNOSIS AND
TESTING, PARK/NEUTRAL
......21-237,21-408,
21-583,21-755
POSITION SWITCH - INSTALLATION,
PARK/NEUTRAL
. . . 21-238,21-408,21-583,21-755
POSITION SWITCH - OPERATION,
CLUTCH PEDAL
.......................6-22
BR/BEINDEX 25
Description Group-Page Description Group-Page Description Group-Page

SWITCH - DESCRIPTION, KEY-IN
IGNITION............................19-9
SWITCH - DESCRIPTION, LUMBAR
CONTROL..........................8N-17
SWITCH - DESCRIPTION, MIRROR........8G-3
SWITCH - DESCRIPTION, MULTI-
FUNCTION..........................8L-23
SWITCH - DESCRIPTION, OVERDRIVE . . . 21-385,
21-578,21-732
SWITCH - DESCRIPTION, OVERDRIVE
OFF ..............................21-215
SWITCH - DESCRIPTION, PASSENGER
AIRBAG ON/OFF.....................8O-23
SWITCH - DESCRIPTION, PASSENGER
POWER SEAT.......................8N-19
SWITCH - DESCRIPTION, PASSENGER
SEAT HEATER .......................8G-13
SWITCH - DESCRIPTION, POWER LOCK . . . 8N-8
SWITCH - DESCRIPTION, POWER
MIRROR...........................8N-12
SWITCH - DESCRIPTION, POWER
WINDOW...........................8N-24
SWITCH - DESCRIPTION, PTO..........14-48
SWITCH - DESCRIPTION, SEAT BELT.....8O-28
SWITCH - DESCRIPTION, WASHER
FLUID LEVEL.........................8R-7
SWITCH - DIAGNOSIS & TESTING, DOOR
CYLINDER LOCK......................8N-5
SWITCH - DIAGNOSIS & TESTING,
DRIVER POWER SEAT................8N-16
SWITCH - DIAGNOSIS & TESTING,
HEATED SEAT...................8G-14,8G-8
SWITCH - DIAGNOSIS & TESTING,
PASSENGER POWER SEAT.............8N-19
SWITCH - DIAGNOSIS AND TESTING,
A/C HIGH PRESSURE.................24-20
SWITCH - DIAGNOSIS AND TESTING,
A/C LOW PRESSURE..................24-21
SWITCH - DIAGNOSIS AND TESTING,
BLOWER MOTOR....................24-25
SWITCH - DIAGNOSIS AND TESTING,
BRAKE LAMP........................8L-5
SWITCH - DIAGNOSIS AND TESTING,
DOOR AJAR.........................8L-34
SWITCH - DIAGNOSIS AND TESTING,
HEADLAMP.........................8L-18
SWITCH - DIAGNOSIS AND TESTING,
HEATED MIRROR.....................8G-3
SWITCH - DIAGNOSIS AND TESTING,
HORN..............................8H-5
SWITCH - DIAGNOSIS AND TESTING,
IGNITION...........................19-11
SWITCH - DIAGNOSIS AND TESTING,
MULTI-FUNCTION....................8L-25
SWITCH - DIAGNOSIS AND TESTING,
PARK/NEUTRAL POSITION......21-237,21-408,
21-583,21-755
SWITCH - DIAGNOSIS AND TESTING,
POWER LOCK........................8N-8
SWITCH - DIAGNOSIS AND TESTING,
POWER WINDOW....................8N-24
SWITCH - DIAGNOSIS AND TESTING,
SEAT BELT .........................8O-28
SWITCH - INSPECTION, NEUTRAL
SAFETY............................30-19
SWITCH - INSTALLATION..............8P-13
SWITCH - INSTALLATION, A/C HIGH
PRESSURE.........................24-21
SWITCH - INSTALLATION, A/C LOW
PRESSURE.........................24-22
SWITCH - INSTALLATION, BRAKE LAMP . . . 8L-5
SWITCH - INSTALLATION, DOOR AJAR . . . 8L-35
SWITCH - INSTALLATION, DOOR
CYLINDER LOCK......................8N-6
SWITCH - INSTALLATION, DRIVER
POWER SEAT.......................8N-17
SWITCH - INSTALLATION, DRIVER SEAT
HEATER.............................8G-9
SWITCH - INSTALLATION, GLOVE BOX
LAMP..............................8L-35
SWITCH - INSTALLATION, HEADLAMP
....8L-20
SWITCH - INSTALLATION, IGNITION
......19-12
SWITCH - INSTALLATION, MULTI-
FUNCTION
..........................8L-28
SWITCH - INSTALLATION, OVERDRIVE
. . 21-386,
21-579,21-733
SWITCH - INSTALLATION, OVERDRIVE
OFF
..............................21-215SWITCH - INSTALLATION, PARK/
NEUTRAL POSITION.....21-238,21-408,21-583,
21-755
SWITCH - INSTALLATION, PASSENGER
AIRBAG ON/OFF.....................8O-25
SWITCH - INSTALLATION, PASSENGER
POWER SEAT.......................8N-20
SWITCH - INSTALLATION, PASSENGER
SEAT HEATER .......................8G-16
SWITCH - INSTALLATION, POWER
MIRROR...........................8N-13
SWITCH - INSTALLATION, POWER
WINDOW...........................8N-26
SWITCH - INSTALLATION, WASHER
FLUID LEVEL.........................8R-8
SWITCH - OPERATION................8P-12
SWITCH - OPERATION, A/C HIGH
PRESSURE.........................24-20
SWITCH - OPERATION, A/C LOW
PRESSURE.........................24-21
SWITCH - OPERATION, BLOWER MOTOR . . 24-25
SWITCH - OPERATION, BRAKE LAMP......8L-4
SWITCH - OPERATION, CLUTCH PEDAL
POSITION...........................6-22
SWITCH - OPERATION, DOOR CYLINDER
LOCK...............................8N-5
SWITCH - OPERATION, DRIVER POWER
SEAT ..............................8N-16
SWITCH - OPERATION, DRIVER SEAT
HEATER.............................8G-7
SWITCH - OPERATION, HEADLAMP......8L-18
SWITCH - OPERATION, HORN...........8H-5
SWITCH - OPERATION, IGNITION........19-11
SWITCH - OPERATION, LUMBAR
CONTROL..........................8N-18
SWITCH - OPERATION, MIRROR.........8G-3
SWITCH - OPERATION, MULTI-FUNCTION . 8L-24
SWITCH - OPERATION, OVERDRIVE....21-385,
21-579,21-732
SWITCH - OPERATION, OVERDRIVE OFF . 21-215
SWITCH - OPERATION, PASSENGER
AIRBAG ON/OFF.....................8O-24
SWITCH - OPERATION, PASSENGER
POWER SEAT.......................8N-19
SWITCH - OPERATION, PASSENGER
SEAT HEATER .......................8G-14
SWITCH - OPERATION, POWER LOCK.....8N-8
SWITCH - OPERATION, POWER MIRROR . . 8N-12
SWITCH - OPERATION, POWER WINDOW . 8N-24
SWITCH - OPERATION, PTO......14-104,14-48
SWITCH - OPERATION, SEAT BELT.......8O-28
SWITCH - OPERATION, WASHER FLUID
LEVEL..............................8R-7
SWITCH - REMOVAL..................8P-13
SWITCH - REMOVAL, A/C HIGH
PRESSURE.........................24-21
SWITCH - REMOVAL, A/C LOW
PRESSURE.........................24-21
SWITCH - REMOVAL, BLOWER MOTOR . . . 24-25
SWITCH - REMOVAL, BRAKE LAMP.......8L-5
SWITCH - REMOVAL, DOOR AJAR.......8L-35
SWITCH - REMOVAL, DOOR CYLINDER
LOCK...............................8N-6
SWITCH - REMOVAL, DRIVER POWER
SEAT ..............................8N-17
SWITCH - REMOVAL, DRIVER SEAT
HEATER.............................8G-9
SWITCH - REMOVAL, GLOVE BOX LAMP . . 8L-35
SWITCH - REMOVAL, HEADLAMP........8L-19
SWITCH - REMOVAL, IGNITION.........19-12
SWITCH - REMOVAL, LUMBAR
CONTROL..........................8N-18
SWITCH - REMOVAL, MULTI-FUNCTION . . . 8L-27
SWITCH - REMOVAL, OVERDRIVE......21-386,
21-579,21-733
SWITCH - REMOVAL, OVERDRIVE OFF . . . 21-215
SWITCH - REMOVAL, PARK/NEUTRAL
POSITION.......21-238,21-408,21-583,21-755
SWITCH - REMOVAL, PASSENGER
AIRBAG ON/OFF.....................8O-24
SWITCH - REMOVAL, PASSENGER
POWER SEAT
.......................8N-20
SWITCH - REMOVAL, PASSENGER SEAT
HEATER
............................8G-15
SWITCH - REMOVAL, POWER MIRROR
. . . 8N-12
SWITCH - REMOVAL, POWER WINDOW
. . 8N-25
SWITCH - REMOVAL, WASHER FLUID
LEVEL
..............................8R-8SWITCH AND KEY LOCK CYLINDER -
DIAGNOSIS AND TESTING, IGNITION.....19-10
SWITCHES - DESCRIPTION, REMOTE.....8A-15
SWITCHES - DIAGNOSIS AND TESTING,
REMOTE...........................8A-16
SWITCHES - INSPECTION, LIGHTS.......30-12
SWITCHES - OPERATION, REMOTE......8A-15
SYMBOLS - DESCRIPTION,
INTERNATIONAL....................Intro.-6
SYMBOLS - DESCRIPTION,
INTERNATIONAL.......................0-3
SYSTEM AIRFLOW - DESCRIPTION,
HVAC..............................24-31
SYSTEM CHARGE - STANDARD
PROCEDURE, REFRIGERANT............24-46
SYSTEM CLEANING/REVERSE FLUSHING
- STANDARD PROCEDURE, COOLING......7-16
SYSTEM DIESEL ENGINE - DIAGNOSIS
AND TESTING, COOLING................7-12
SYSTEM EVACUATE - STANDARD
PROCEDURE, REFRIGERANT............24-45
SYSTEM FLOW - 3.9L/5.2L/5.9L ENGINE
- DESCRIPTION, COOLING...............7-1
SYSTEM FLOW - 5.9L DIESEL -
DESCRIPTION, COOLING.................7-1
SYSTEM GAS ENGINE - DIAGNOSIS AND
TESTING, COOLING.....................7-7
SYSTEM LEAKS - DIAGNOSIS AND
TESTING, COOLING.....................7-5
SYSTEM LEAKS - DIAGNOSIS AND
TESTING, REFRIGERANT...............24-43
SYSTEM PARTS - STANDARD
PROCEDURES, CLEANING FUEL...........14-57
SYSTEM PRESSURE - GAS ENGINES -
SPECIFICATIONS, FUEL.................14-4
SYSTEM PRESSURE RELEASE -
STANDARD PROCEDURE, FUEL..........14-3
SYSTEM PRESSURES, DIESEL ENGINES
- FUEL.............................14-58
SYSTEM REQUIREMENTS -
DESCRIPTION, COOLING................24-1
SYSTEM SERVICE EQUIPMENT -
STANDARD PROCEDURE,
REFRIGERANT.......................24-44
SYSTEM SERVICE PORT - DESCRIPTION,
REFRIGERANT........................24-1
SYSTEM SERVICE PORT - OPERATION,
REFRIGERANT........................24-2
SYSTEM, SPECIAL TOOLS - DIESEL
FUEL..............................14-59
SYSTEM, SPECIAL TOOLS - FUEL . . . 14-36,14-4
SYSTEM, SPECIFICATIONS - STARTING . . . 8F-38
SYSTEMS - DESCRIPTION, MONITORED . . 25-15
SYSTEMS, SPECIAL TOOLS - AUDIO......8A-4
SYSTEMS, SPECIAL TOOLS - OVERHEAD
CONSOLE...........................8M-8
SYSTEMS, SPECIAL TOOLS - POWER
DISTRIBUTION....................8W-97-2
TABLE, SPECIFICATIONS - A/C
APPLICATION........................24-8
TACHOMETER - DESCRIPTION..........8J-30
TACHOMETER - OPERATION............8J-31
TAIL LAMP - DESCRIPTION............8L-29
TAIL LAMP - INSTALLATION............8L-30
TAIL LAMP - OPERATION..............8L-29
TAIL LAMP - REMOVAL................8L-29
TAIL LAMP UNIT - INSTALLATION.......8L-30
TAIL LAMP UNIT - REMOVAL...........8L-30
TAILGATE - INSTALLATION.............23-66
TAILGATE - REMOVAL.................23-66
TAILPIPE - 3.9L/5.2L/5.9L - INSPECTION . . 11-11
TAILPIPE - 3.9L/5.2L/5.9L -
INSTALLATION.......................11-12
TAILPIPE - 3.9L/5.2L/5.9L - REMOVAL....11-11
TAILPIPE - 5.9L DIESEL - INSPECTION....11-12
TAILPIPE - 5.9L DIESEL - INSTALLATION . . 11-12
TAILPIPE - 5.9L DIESEL - REMOVAL.....11-12
TAILPIPE - 5.9L HEAVY DUTY/8.0L -
INSPECTION........................11-12
TAILPIPE - 5.9L HEAVY DUTY/8.0L -
INSTALLATION.......................11-12
TAILPIPE - 5.9L HEAVY DUTY/8.0L -
REMOVAL..........................11-12
TANK - DESCRIPTION, DIESEL FUEL
.....14-78
TANK - DESCRIPTION, FUEL
............14-19
TANK - INSTALLATION, FUEL
...........14-20
TANK - OPERATION, FUEL
..............14-19
TANK - REMOVAL, FUEL
...............14-19
34 INDEXBR/BE
Description Group-Page Description Group-Page Description Group-Page