2000 MITSUBISHI MONTERO service

HEATER, AIR CONDITIONER AND VENTILATION -Troubleshooting 55B-15
Inspection procedure 10
The condenser fan does not operate .
Probable cause
If the condenser fan does not operate, the condenser fan relay or motor may be
defective.DMalfunction of the condenser fan relay
DMalfunction of harness or connector
DMalfunction of the engine-A/T-ECU or
engine-ECU
NG
Check the harness wire between the condenser fan relay and
the ignition switch (IG2), and repair if necessary.
NG
Repair
NG
Check the harness wire between the condenser fan motor and
body earth, and repair if necessary.
NG
Repair
NG
Repair
OK
Replace the engine-A/T-ECU or engine-ECU
.
NG
Check the harness wire between the condenser fan relay and
fusible link (1), and repair if necessary.
NG
Repair
NG
Check the harness wires between the condenser fan relay
and the condenser fan motor, between the condenser fan
relay and the engine-A/T-ECU or the
engine-ECU.NG
Repair
OK
Check the trouble symptoms.
OK
Check the following connectors:A-10X, A-27,A-04 drive vehicles>, D-143, D-116,
D-119, D-110<4M41>
OK
Check the trouble symptoms.
OK
Measure at condenser fan motor connector A-27.
DDisconnect the connector and measure at the harness
side.
DContinuity between terminal 2 and body earth
OK:ContinuityNGCheck the following connector:A-27
OK
Check the trouble symptoms.
Check the following connector:A-10X
(2) NG
OK
Check the trouble symptoms.
OK
Measure at condenser fan relay connector A-10X.
DDisconnect the connector, and measure at the J/B side.
DIgnition switch: ON
(1) Voltage between terminal 3 and body earth
OK:System voltage
(2) Voltage between terminal 5 and body earth
OK:System voltage(1) NGCheck the following connectors:A-10X, A-15, D-27, D-210,
D-208
OK
Check the condenser fan motor
(Refer to GROUP 55A - Condenser Fan).NG
Replace
Check the condenser fan relay
(Refer to GROUP 55A - On-vehicle Service).NG
Replace


www.WorkshopManuals.co.uk


Purchased from www.WorkshopManuals.co.uk

HEATER, AIR CONDITIONER AND VENTILATION -Troubleshooting 55B-16
Inspection procedure 11
The condenser fan does not operate <4D56>.
Probable cause
If the condenser fan does not operate, the condenser fan relay or motor may be
defective.DMalfunction of the condenser fan relay
DMalfunction of harness or connector
DMalfunction of the engine-A/T-ECU or
engine-ECU
NG
Check the harness wire between the condenser fan relay and
the ignition switch (IG2), and repair if necessary.
NG
Repair
NG
Check the harness wire between the condenser fan motor and
body earth, and repair if necessary.
NG
Repair
NG
Repair
OK
NG
Check the harness wire between the condenser fan relay and
fusible link (1), and repair if necessary.
NG
Repair
NG
Check the harness wires between the condenser fan relay
and the condenser fan motor and between the condenser fan
relay and theengine coolant temperaturesensor, and repair if
necessary.
OK
Check the trouble symptoms.
OK
Check the following connectors:A-10X, A-27, A-04 drive vehicles>, D-143, B-47
OK
Check the trouble symptoms.
OK
Measure at condenser fan motor connector A-27.
DDisconnect the connector and measure at the harness
side.
DContinuity between terminal 2 and body earth
OK:ContinuityNGCheck the following connector:A-27
OK
Check the trouble symptoms.
Check the following connector:A-10X
(2) NG
OK
Check the trouble symptoms.
OK
Measure at condenser fan relay connector A-10X.
DDisconnect the connector, and measure at the J/B side.
DIgnition switch: ON
(1) Voltage between terminal 3 and body earth
OK:System voltage
(2) Voltage between terminal 5 and body earth
OK:System voltage(1) NGCheck the following connectors:A-10X, A-15, D-27, D-210,
D-208
OK
Check the condenser fan motor
(Refer to GROUP 55A - Condenser Fan).NG
Replace
Check the condenser fan relay
(Refer to GROUP 55A - On-vehicle Service).NG
Replace
NG
ReplaceReplace the engine coolant temperaturesensor.


www.WorkshopManuals.co.uk


Purchased from www.WorkshopManuals.co.uk

HEATER, AIR CONDITIONER AND VENTILATION -Troubleshooting 55B-22
Inspection procedure 3
The rear blower does not operate.
Probable cause
If no air comes out of the air vents even if the rear fan switch or the front rear
fan switch is turned on, the rear blower relay circuit may be defective.DMalfunction of the rear blower relay
DMalfunction of the blower motor
DMalfunction of the rear A/C switch
DMalfunction of harness or connector
OK
Replace the rear A/C control unit.
OK
NG
Repair
NG
Repair
NG
Check the harness wire between the rear blower relay and
the ignition switch (IG2), and repair if necessary.
NG
Repair
NG
Check the harness wire between the rear blower relay and
fusible link (2), and repair if necessary.
NG
Repair
NG
Check the harness wires between the rear blower relay and
the rear A/C switch and between the rear blower relay and
the front rear fan switch, and repair if necessary.
NG
Repair
NG
Check the harness wire between the blower motor and the
rear A/C switch and between the rear A/C switch and body
earth, and repair if necessary.
NG
Repair
OK
Check the trouble symptoms.
OK
Check the following connectors:D-214, D-123, G-22,
G-22-1
OK
Check the trouble symptoms.
OK
Measure at blower motor connector G-22-1.
DDisconnect the connector and measure at the harness
side.
DAir volume adjusting switch: 3
DContinuity between terminal 1 and body earth
OK:ContinuityNGCheck the following connectors:G-22-1, G-22, E-119
OK
Check the trouble symptoms.
Check the following connectors:D-214, D-123, E-119,
E-109, E-14
(3) NG
OK
Check the trouble symptoms.
Check the following connectors:D-214, D-27(2) NG
OK
Check the trouble symptoms.
OK
Measure at rear blower relay connector D-214.
DDisconnect the connector and measure at the harness
side.
DIgnition switch: ON
(1) Voltage between terminal 1 and body earth
OK:System voltage
(2) Voltage between terminal 5 and body earth
OK:System voltage
(3) Voltage between terminal 3 and body earth
OK:0 V (Rear fan switch or front rear fan switch: ON)(1) NGCheck the following connectors:D-214, D-32, D-210, D-208
OK
Check the rear A/C switch (air volume adjusting switch)
(Refer to GROUP 55A - Rear Heater/Rear Cooler).NG
Replace
OK
Check the blower motor
(Refer to GROUP 55A - Rear Heater/Rear Cooler).NG
Replace
Check the rear blower relay
(Refer to GROUP 55A - On-vehicle Service).NG
Replace
Check the harness wire between the blower motor and the
rear blower relay.


www.WorkshopManuals.co.uk


Purchased from www.WorkshopManuals.co.uk