1998 TOYOTA LAND CRUISER steering

MA02V-02
- MAINTENANCEBODY
MA-1 1
59 Author
: Date
:
2004 LAND CRUISER (RM1071U)
BODY
INSPECTION
1. TIRE ROTATION
Check the owner's manual supplement in which the maintenance schedule is shown.
2. FINAL INSPECTION
(a) Check the operation of the body parts:

Hood:

Auxiliary catch operates properly

Hood locks securely when closed

Front and rear doors:

Door locks operate properly

Doors close properly

Back door:

Door lock operates properly

Seats:

Seat adjusts easily and locks securely in any position

Front seat back locks securely in any position

Folding-down rear seat backs look securely.
(b) Be sure to deliver a clean car. Especially check:

Steering wheel

Shift lever knob

All switch knobs

Door handles

Seats

MA02U-07
B04566
Dust Cover
B04567
B06414
MA-8
- MAINTENANCECHASSIS
56 Author
: Date
:
CHASSIS
INSPECTION
1. INSPECT STEERING LINKAGE
(a) Check the steering linkage for looseness or damage.
(b) Check the tie rod ends do not have excessive play.
(c) Check the dust seals and boots are not damaged.
(d) Check the boot clamps are not loose.
(e) Check the inspect the dust cover for damage.
2. INSPECT SRS AIRBAG (See pages RS-18, RS-32)
3. INSPECT STEERING GEAR HOUSING OIL
Check the steering gear housing for oil leakage.
If leakage is found, check for cause and repair.
4. INSPECT BALL JOINTS AND DUST COVERS
(a) Jack up the front of the vehicle and support it with stands.
(b) Make sure the front wheels are in a straight-ahead posi-
tion, and depress the brake pedal.
(c) Jack up the lower suspension arm until there is about half
a load on the front suspension.
(d) Inspect the dust cover for damage.
5. INSPECT DRIVE SHAFT BOOTS
Inspect the drive shaft boots for clamp looseness, grease leak-
age or damage.
6. INSPECT AUTOMATIC TRANSMISSION OIL LEVEL
(See page AT-3-1)
7. INSPECT TRANSFER AND DIFFERENTIAL OIL LEVEL
(a) Transfer:
Remove the filler plug and feel inside the hole with your
finger. Check that the oil comes to within 5 mm (0.20 in.)
of the bottom edge of the hole. If the level is low, add oil
until it begins to run out of the filler hole.
Transfer oil: See page TR-6

MA02Q-01
MA-2
- MAINTENANCEINSIDE VEHICLE
50 Author
: Date
:
2004 LAND CRUISER (RM1071U)
INSIDE VEHICLE
GENERAL MAINTENANCE
These are the maintenance and inspection items which are considered to be owner's responsibility. They
can be done by the owner or be can have them done at a service shop. These items include those which
should be checked on a daily basis, those which, in most cases, do not require (special) tools and those
which are considered to be reasonable for the owner to do. Items and procedures for general maintenance
are as follows.
1. GENERAL NOTES

Maintenance items may very from country and country. Check the owner's manual supplement in
which the maintenance schedule is shown.

Every service items in the periodic maintenance schedule must be performed.

Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).

Maintenance service after the last period should be performed at the same time interval as before un-
less otherwise noted.

Failure to do even one item an cause the engine to run poorly and increase exhaust emissions.
2. LIGHTS
(a) Check that the headlights, stop lights, taillights, turn signal lights, and other lights are all working.
(b) Check the headlights aim.
3. WARNING LIGHTS AND BUZZERS
Check that all warning lights and buzzers function properly.
4. HORN
Check that it is working.
5. WINDSHIELD GLASS
Check for scratches, pits or abrasions.
6. WINDSHIELD WIPER AND WASHER
(a) Check operation of the wipers and washer.
(b) Check that the wipers do not streak.
7. WINDSHIELD DEFROSTER
Check that air comes out from the defroster outlet when operating the heater or air conditioner at defroster
mode.
8. REAR VIEW MIRROR
Check that it is mounted securely.
9. SUN VISORS
Check that they move freely and mounted securely.
10. STEELING WHEEL
Check that it has the specified freeplay. Be alert for changes in steering condition, such as hard steering,
excessive freeplay or strange noises.
11. SEATS
(a) Check that all front seat controls such as seat adjusters, seatback recliner, etc. operate smoothly.
(b) Check that all latches lock securely in any position.
(c) Check that the head restraints move up and down smoothly and that the locks hold securely in any
latch position.
(d) For folding-down rear seat backs, check that the latches look securely.
12. SEAT BELTS
(a) Check that the seat belt system such as buckles, retractors and anchors operate properly and smooth-
ly.
(b) Check that the belt webbing is not cut, frayed, worn or damaged.

MA02R-05
MA-4
- MAINTENANCEUNDER HOOD
52 Author
: Date
:
2004 LAND CRUISER (RM1071U)
UNDER HOOD
GENERAL MAINTENANCE
1. GENERAL NOTICE

Maintenance items may vary from country to country. Check the owner's manual supplement in which
the maintenance schedule is shown.

Every service item in the periodic maintenance schedule must be performed.

Periodic maintenance service must be performed according to whichever interval in the periodic main-
tenance schedule occurs first, the odometer reading (miles) or the time interval (months).

Maintenance services after the last period should be performed at the same interval as before unless
otherwise noted.

Failure to do even one item can cause the engine to run poorly and increase exhaust emissions.
2. WINDSHIELD WASHER FLUID
Check that there is sufficient fluid in the tank.
3. ENGINE COOLANT LEVEL
Check that the coolant level is between the LEVEL lines on the see-through reservoir at normal tem-
perature (20°C (68°F)).
4. RADIATOR AND HOSES
(a) Check that the front of the radiator is clean and not blocked with leaves, dirt or bugs.
(See page CO-14)
(b) Check the hoses for cracks, kinks, rot or loose connections.
5. BATTERY ELECTROLYTE LEVEL

Check the indicator.

When the indicator color is blue, the condition is satisfactory. A red color indicates that distilled water
must be added, and white indicates that charging is necessary.
6. BRAKE FLUID LEVELS
Check that the brake fluid level is near the upper level line on the see-through reservoir.
(See page BR-4)
7. ENGINE DRIVE BELTS
Check drive belt for fraying, cracks, wear or oiliness.
8. ENGINE OIL LEVEL
Check the level on the dipstick with the engine turned off.
9. POWER STEERING FLUID LEVEL

Check the level on the dipstick.

The level should be in the ºHOTº or ºCOLDº range depending on the fluid temperature.
10. AUTOMATIC TRANSMISSION FLUID LEVEL
Visually check the overflow plug and oil pan for fluid leaks or traces of fluid.

PP0O1-19
PP-70
- PREPARATIONBODY ELECTRICAL
129 Author
: Date
:
2004 LAND CRUISER (RM1071U)
RECOMMENDED TOOLS
09041-00030Torx Driver T30 .For removing and installing
steering wheel pad
09042-00010Torx Socket T30 .For removing and installing
steering wheel pad
09082-00040TOYOTA Electrical Tester.

PP2AA-02
- PREPARATIONBRAKE
PP-53
11 2 Author
: Date
:
2004 LAND CRUISER (RM1071U)
BRAKE
SST (Special Service Tools)
09023-00100Union Nut Wrench 10 mm
09318-12010Transfer Bearing Adjusting Nut
Wrench
09630-00014Power Steering Gear Housing
Overhaul Tool Set
(09631-00142)Overhaul Stand
09709-29018LSPV Gauge Set
09717-20010Brake Shoe Return Spring Remover
09718-20010Brake Shoe Return Spring
Replacer
09843-18020Diagnosis Check Wire
09950-60010Replacer Set
(09951-00180)Replacer 18
(09951-00190)Replacer 19
09990-00150ABS Actuator Checker and
Sub-harness

PP-44
- PREPARATIONSUSPENSION AND AXLE
103 Author
: Date
:
2004 LAND CRUISER (RM1071U)
09554-3001 1Differential Oil Seal ReplacerFront differential
09556-22010Drive Pinion Front Bearing
RemoverFront differential
Rear differential
09607-60020Front Wheel Adjusting Nut WrenchFront axle
09628-6201 1Ball Joint PullerFront axle
Front drive shaft
Front suspension
09631-12090Seal Ring ToolRear axle
09631-32020Seal Ring ToolFront suspension
09649-17010Steering Knuckle ToolRear differential (w/ LSD)
09710-14013Rear Suspension Bushing Tool SetRear suspension
(09710-00061)Replacer
09710-22021Front Suspension Bushing Tool
SetFront suspension
(09710-01071)Lower Arm Bushing Remover
09710-28012Front Suspension Bushing Tool
SetFront suspension
Rear suspension
(09710-07031)Bushing Replacer

PP0U3-05
- PREPARATIONSFI
PP-9
68 Author
: Date
:
2004 LAND CRUISER (RM1071U)
SFI
SST (Special Service Tools)
09023-12700Union Nut Wrench 17mmFuel line flare nut
09268-41047Injection Measuring Tool Set
(09268-41091)NO.7 Union
(09268-41 110)Adaptor
(09268-41300)Clamp
09268-45014EFI Fuel Pressure Gauge
(09268-41 190)Adaptor
(90405-06167)I Union
09612-24014Steering Gear Housing Overhaul
Tool Set
(09617-2401 1)Steering Rack WrenchFuel pressure pulsation damper
09816-30010Oil Pressure Switch SocketKnock sensor
09842-30070Wiring ºFº EFI Inspection