1998 ISUZU TROOPER 4WD

MANUAL TRANSMISSION7B±7
13. Disconnect the backup lamp switch, 4WD indicator
switch and 1±2 indicator switch harness connectors.
826RW023
14. Disconnect the speedometer sensor and 2WD-4WD
actuator harness connectors.
826RW024

MANUAL TRANSMISSION7B±15
141RW024
18. Connect the speedometer sensor and 2WD±4WD
actuator harness connector.
826RW024

7B±16MANUAL TRANSMISSION
19. Connect the backup lamp switch, 4WD indicator
switch, and 1-2 indicator switch harness connectors.
826RW023
20. Install the front and 3 way exhaust pipe (6VE1).
Install the exhaust pipe with catalytic converter
(4JX1).
Torque:
Exhaust pipe to exhaust manifold:
67 N´m (6.8 kg´m/49 Ib ft)
Exhaust pipe flange bolt:
43 N´m (4.4 kg´m/32 Ib ft)
(4JX1)
150RW041
21. Connect two oxygen sensor connectors to the
transmission harness (6VE1).
22. Install the front propeller shaft and tighten the fixing
bolts and nuts specified torque.
Torque: 63 N´m (6.4 kg´m/46 Ib ft)
23. Install the rear propeller shaft and tighten the fixing
bolts and nuts specified torque.
Torque: 63 N´m (6.4 kg´m/46 Ib ft)24. Install transfer protector and tighten the fixing bolts
specified torque.
Torque: 37 N´m (3.8 kg´m/27 Ib ft)
25. Install the transmission control lever and transfer
control lever.
235RW014
26. Install the grommet assembly.
27. Install the front console assembly.
28. Install the gear control lever knob.
29. Connect battery ground cable.
30. Install engine hood.

MUA MODEL 7B1 – 53
Front Propeller Shaft
Remove the splined yoke flange bolt at the transfer case
side.
Do not allow the splined yoke to fall away from the front
propeller shaft.
If the splined yoke should fall away from the front
propeller shaft, align the setting marks
3on the splined
yoke 1and the propeller shaft 2to reassemble the two
parts.
The setting marks 3are punched circles approximately 3
mm (0.12 in) in diameter.
TDC Sensor (4JA1TC Model)
Disconnect the TDC sensor from the transmission
housing.
Harness Connector
Disconnect the 4WD switch connectors, back up light
switch connector and the speedometer sensor connector.
220R200001
Slave Cylinder
Remove the slave cylinder from the transmission case.
220LV019
Engine LIfting Hanger
1. Attach the engine lifting hanger to the front portion of
the engine.
2. Attach the lifting wire to both ends of the engine
lifting hange.

MUA MODEL 7B1 – 57
Starter Motor
1. Install the starter motor to the engine rear plate.
Starter Motor Bolt Torque kg·m (lb·ft/N·m)
8.0 ± 1.6 (58 ± 12/78 ± 16)
Engine Rear Mounting and Mounting Member
1. Install the engine rear mounting to the transmission.
Rear Mounting Bolt Torque kg·m (lb·ft/N·m)
4.2 ± 0.5 (30 ± 3.6/41 ± 4.9)
2. Install the mounting member 1to the mounting
rubber 2.
Mounting Rubber Nut Torque kg·m (lb·ft/N·m)
5.1 ± 0.6 (37 ± 4.3/50 ± 6)
3. Install the mounting member to the sidemembers.
Mounting Member Bolt Torque kg·m (lb·ft/N·m)
5.1 ± 0.6 (37 ± 4.3/50 ± 6)
Slave Cylinder
Install the slave cylinder to the transmission case.
Slave Cylinder Bolt Torque kg·m (lb·ft/N·m)
4.1 ± 1.0 (30 ± 7.2/40 ± 10)
Harness Connector
Disconnect the 4WD switch connectors back up light
switch connector and speedometer sensor connector.
220LV019
TDC Sensor (4JA1TC Model)
Connect the TDC sensor from the transmission housing.
220R200001

LIGHTING SYSTEM8A–29
Light NameRated PowerNumber of
BulbsLens ColorRemarks
Headlight60w/55w2WhiteHalogen
FrontTurn signal light21w2Whitecombination
lightClearance light5w2Amber
FRT fog light55w2WhiteHalogen
Taillight/Stoplight5w/21w2Red
RearBumperTurn signal light21w2Ambercombination
lightTaillight/Stoplight5w/21w2RedBodyTurn signal light21w2Amber
Backup light21w2White
RR fog light21w2Red
Side turn signal light5w2Amber
License plate lightBumper5w2White
Body5W1White
High mount stoplight——RedLED
Map light5w2White
Dome light10w1White
Luggage room light8w1White
Courtesy light3.8w2White
A/C SW60mA1
RR defogger SW0.84w1
Mirror defogger SW0.84w1
FRT fog light SW0.7w1
RR fog light SW0.7w1
Cruise (Set)1.4w1Meter
Cruise (Main)1.4w1Meter
Check trans3w1Meter
Anti-theft3w1Warning box
Turn signal1.4w2Meter
Golw1.4w1Meter
Water sedimenter1.4w1Meter
Indicator/High beam1.4w1MeterWarning
lightABS1.4w1Meter
Check engine1.4w1Meter
Low fuel1.4w1Meter
4WD1.4w1Meter
Oil Pressure1.4w1Meter
Brake system1.4w1Meter
Charge1.4w1Meter
Seat belt2w1Meter
A/T shift position0.91w7Meter
A/T oil temp3w1Meter

WIRING SYSTEM 8DÐ11
Abbreviation Meaning of Abbreviation
A
ABS
ASM
AC
A/C
ACC
A/T
C/B
CSD
DIS
EBCM
ECGI
ECM
ECU
EFE
EGR
4A/T
4WD
FL
FRT
H/L
IC
IGAmpere (S)
Anti-lock brake system
Assembly
Alternating current
Air conditioner
Accessories
Automatic transmission
Circuit breaker
Cold start device
Direct ignition system
Electronic brake control module
Electronic control gasoline injection
Engine control module
Electronic control unit
Early fuel evaporation
Exhaust gas recirculation
4-speed automatic transmission
Four-wheel drive
Fusible link
Front
Headlight
Integrated circuit
IgnitionAbbreviation Meaning of Abbreviation
kW
LH
LWB
M/T
OD
OPT
PCM
QOS
RH
RR
SDM
SRS
ST
STD
SW
SWB
3A/T
V
VSV
W
WOT
W/
W/OKilowatt
Left hand
Long wheel base
Manual transmission
Over drive
Option
Powertrain control module
Quick on start
Right hand
Rear
Sensing and diagnostic module
Supplemental restraint system
Start
Standard
Switch
Short wheel base
3-speed automatic transmission
Volt
Vacuum switching valve
Watt (S)
Wide open throttle
With
Without
Abbreviations

WIRING SYSTEM 8DÐ33
Grounding Point
Reference Table
(6VD1 RHD)
Connector No. Cable harness Location Parts (Load)
B-1
Door mirror defogger (LH), Fan SW, FRT power
window & door lock SW-LH, Cruise control
unit, FRT door key SW-LH, FRT door lock
actuator-LH, FRT door lock SW-LH
B-2Sun roof SW, Sun roof control unit,
Safety SW, Limit SW
Body-LH
B-18
FRT door key SW-RH, FRT door lock & power
window SW-RH, FRT door lock actuator & lock
SW-RH, FRT door lock SW-RH, Door mirror
defogger (RH), RR wiper intermittent relay,
Mode SW (A/T), Starter relay
B-19
B-26RR Power window SW-RH, Mirror control SW,
Mirror defogger SW, Mirror folding SW,
Car telephone, Shift lock controller, POWER &
WINTER SW, Seat heater, Seat heater SW,
RR door lock actuator-LH, EBCM Body-RH
Body harness
Body-center
C-16
Pump & VSV, Headlight wiper timer2
C-16
4WD SW, VSV;FRT axle, FRT axle SW3
C-16
FRT fog light 4
C-16P/S pressure SW, Headlight leveling actuator-LH7
C-16
Side turn signal light (LH)
8Fender-LH Engine room
harness
Cigar lighter, Dimmer·passing SW, Illumination
controller, RR defogger SW, Flasher unit,
Power window relay, Cruise main indicator
light, Lighting SW, Glove box illumination light,
Ashtray illumination light, Headlight wiper SW,
Clock, FRT fog light SW, Variable intermittent
(FRT wiper & washer SW), Kick down SW,
Anti-theft controller, Turn signal indicator light,
Heater & A/C relay
C-16
5
Headlight wiper motor
C-16Clearance light, FRT turn signal light1
C-16O2 Sensor, Headlight leveling actuator-RH
6B-28
RR power window SW-RH, Power & winter SW,
Power seat SW, Tilt motor & SW, Recliner
motor & SW, RR door lock actuator-RH, EBCM