1997 GMC SIERRA radiator cap

Checking Coolant
If your vehicle has a diesel engine, see “Checking
Coolant”
in the Diesel Engine Supplement. Adding Coolant
If you need more
coolant, add the proper DEX-COOL@
coolant mixture
at the coolant recovery tank.
The coolant recovery tank is located on the passenger’s
side at the rear corner
of the engine compartment.
When your engine is cold,
the coolant level should be at
the
COLD mark, or a little higher. When your engine is
warm, the level should be up to the HOT mark, or a
little higher.
A CAUTION:
Turning the radiator pressure cap when the
engine and radiator are hot can allow steam and
scalding liquids to blow out and burn you badly.
With the coolant recovery tank, you will almost
never have to add coolant at the radiator.
Never turn the radiator pressure cap
-- even a
little -- when the engine and radiator are hot.
Add coolant mixture at the recovery tank, but be careful
not to spill
it.
You can be burned if you spill coolant on hot
engine parts. Coolant contains ethylene glycol,
and it will burn if the engine parts are hot
enough. Don’t spill coolant on a hot engine.
6-31
~ .
ProCarManuals.com

Radiator Pressure Cap
(Gasoline Engine)
The radiator pressure cap must be tightly installed with
the arrows
on the cap lined up with the overflow tube on
the radiator filler neck.
NOTICE:
Your radiator cap is a 15 psi (105 kPa)
pressure-type cap and must be tightly installed to
prevent coolant loss and possible engine damage
from overheating. Be sure the arrows on the cap line up with the overflow tube on the radiator
filler neck.
Thermostat
Engine coolant temperature is controlled by a thermostat
in the engine coolant system. The thermostat stops the
flow
of coolant through the radiator until the coolant
reaches a preset temperature.
When you replace your thermostat, an
AC@ thermostat
is recommended.
6-32
ProCarManuals.com

Adding Washer Fluid
Open the cap labeled WASHER FLUID ONLY. Add
washer fluid until the tank is full.
NOTICE:
0
0
0
When using concentrated washer fluid,
follow the manufacturer’s instructions for
adding water.
Don’t mix water with ready-to-use washer
fluid. Water can cause the solution to freeze
and damage your washer fluid tank and
other parts
of the washer system. Also,
water doesn’t clean as well as washer fluid.
Fill your washer fluid tank only
three-quarters full when it’s very cold. This
allows for expansion if freezing occurs,
which could damage the tank if it
is
completely full.
Don’t use radiator antifreeze in your
windshield washer. It can damage your
washer system and paint.
6-34
ProCarManuals.com

Short TripKity Maintenance Schedule =- Gasoline Engines
100,000 Miles (166 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid and filter do not
require changing.
Manual transmission fluid doesn’t
require change.
valve.
An Emission Control Service.
0 Inspect Positive Crankcase Ventilation (PCV)
DATE ACTUAL MILEAGE SERVICED BY:
I I I I
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant’’ in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test cooling
system and pressure cap.
An Emission Control Service.
7-30
ProCarManuals.com

Long Tripmighway Maintenance Schedule -- Gasoline Engines
100,000 Miles (166 000 km) (Continued)
- When doing frequent trailer towing.
- Uses such as found in taxi, police or
delivery service.
If you do not use your vehicle under any of
these conditions, the fluid and.filter do not
require changing.
Manual transmission fluid doesn’t
require change.
0 Inspect Positive Crankcase Ventilation
(Pcv) valve. An Emission Control Service.
DATE ACTUAL MILEAGE
~~
SERVICED BY
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system
(or every
60 months since last service,
whichever occurs first). See “Engine
Coolant” in the Index for what to use.
Inspect hoses. Clean radiator, condenser,
pressure cap and neck. Pressure test the cooling system and pressure cap.
An Emission Control Service.
1
DATE ACTUAL MILEAGE SERVICED BY
-
ProCarManuals.com

Methanol ...................................... 6-4
Mirrors
....................................... 2-48
Convex Outside
.............................. 2-51
Electrochromic Daymight Rearview
.............. 2-48
Inside Daymight Rearview
..................... 2-48
Manual
..................................... 2-51
Power Remote Control
......................... 2-5 1
MMT ......................................... 6-4
Model Reference
................................. vi
MountainRoads ................................ 4-35
New Vehicle Break-In
.......................... 2- IO
Nightvision ................................... 4-28
Noise Control System
........................... 6- 14
Normal Maintenance Replacement Parts
............. 6-77
Odometer
.................................... 2-65
Odometer. Trip
................................. 2-65
Off-Road Driving
.............................. 4- 14
Off-Road Recovery
............................. 4- I 1
Oil. Engine .................................... 6-15
Opener. Garage Door
............................ 2-52
Overheating Engine
............................. 5- 1 I
Owner Checks and Services ....................... 7-45
Owner Publications. Ordering
................ 8- I I. 8- 12
Paint Spotting. Chemical ........................ 6-67
Park. Shifting Into
.............................. 2-28
Park. Shifting Out of
............................ 2-30
Parking
AtNight
.................................... 2-10 Brake
...................................... 2-27
Brake Mechanism Check
....................... 7-48
Lots
....................................... 2-10
Over Things That Burn
........................
Passenger Position .............................. 1-23
Passing
....................................... 4-12
Periodic Maintenance Inspections
.................. 7-49
Power Accessory Outlet
............................. 2-61
DoorLocks
................................... 2-6
Driver’sSeat
................................. 1-3
Option Fuses ................................ 6-70
Remote Control Mirror
........................ 2-51
Steering
..................................... 4-9
Steering
Fluid ................................ 6-33
Take-0
ff .................................... 4-59
Winches
.................................... 4-59
Windows ................................... 2-33
Pregnancy, Use of Safety Belts
.................... 1-22
Problems on the Road
............................ 5-1
PTO ......................................... 4-59
Publications, Service and Owner
.............. 8- 1 1, 8- 12
Radiator ..................................... 5-18
Radiator Pressure Cap
........................... 6-32
Radio Reception ................................ 3-23
Radios
........................................ 3-7
Rain, Driving
In ................................ 4-29
ReadingLamps
................................ 2-46
9-7
ProCarManuals.com