1997 GMC SAVANA Owners Manual

Engine Compartment Fuse Relay Center
The fuse block is on the driver's side of the engine
compartment at the rear.
[-I
[)
[T]
Name
BLOWER
ABS
Circuits Protected
Blower Motor
Electronic Brake Control Module
Name
IGN-B
IGN-A
BATT
LIGHTING
RR BLOWER
ENG-
1
A/C SPARE
AUX A
AUX-B
RH-HDLP
Circuits Protected
Ignition Switch
Starter Relay, Ignition Switch
Instrument Panel Fuse Block
Instrument Panel Fuse Block,
Headlamp Switch
Rear Auxiliary Blower
Motor Relays
Heated
02 Sensors, Mass Air
Flow Sensor, EGR Valve
Solenoid, Evap Canister Purge
Valve, Crankshaft Position Sensor,
Secondary Air Injection Relay
(Diesel), Water in Fuel Sensor
(Diesel), Fuel Heater (Diesel),
Glowplug Relay (Diesel),
Wastegate Solenoid (Diesel)
Air Conditioning Clutch Relay
Spare Fuses
Upfitter Provisions
Upfitter Provisions
Right-hand Headlamp
(Export Only)
6-63
ProCarManuals.com

Name
RH-HIBM
ECM-I
HORN
LH-HDLP
LH-HIBM
FUEL SOL
IGN-E
ECM-B
Circuits Protected
Right-hand High-beam Headlamp
(Export Only)
Ignition Coil, Crankshaft Position Sensor, VCM, Fuel Injectors,
Coil Driver
Horn Relay, Underhood Lamp(
s)
Left-hand Headlamp
(Export Only)
Left-hand High-beam Headlamp
(Export Only)
PCM, Fuel Solenoid Driver,
Engine Shutoff Solenoid
Air Conditioning Clutch Relay
Fuel Pump Relay, VCM, PCM,
Fuel Pump and Engine Oil
Pressure Switch
Capacities and Specifications
Replacement Parts
Replacement part numbers listed in this section are
based on the latest information available at the time of
printing, and are subject to change. If a part listed in this
manual is not the same as the part used in your vehicle
when
it was built, or if you have any questions, please
contact your GM truck dealer.
These specifications
are for information only. If you
have
any questions, see the service manual for the
chassis or refer to the body manufacturer’s publications.
6-64
ProCarManuals.com

Engine Identification -- Gasoline Engines
Engine “VORTEC”4300 “VORTEC”5000
Type V6 V8
VIN Code
w M
Fuel System CSFI’ CSFI*
]Central
Sequential Fuel Injection
2Sequential Fuel Injection
Wheel Nut Torque
MODEL TORQUE
All 140 ft-lb (190 N-m)
Cooling System Capacity
ENGINE VIN
“VORTEC”4300
“VORTEC”5000
“VORTEC”5700
“VORTEC”7400 W
M
R
J
QTJ “VORTEC”5700
V8
R
CSFI’
1 Without Rear Heater*
11
Quarts (10.4 L)
17 Quarts (16 L)
17 Quarts (16 L)
23 Quarts (2 1.8 L)
“VORTEC”7400
V8
J
SF12
rl With Rear Heater 8
14 Quarts (13.2 L)
20 Quarts (18.9 L)
20 Quarts (18.9 L)
26 Quarts (24.6 L)
After refill, the level MUST be checked as outlined under “Engine Cooling System” in Section 5.
*All quantities are approximate.
6-65
ProCarManuals.com

Crankcase Capacity
ENGINE VIN Quantity With Filter
“VORTEC”4300 W 4.5 Quarts (4.3 L)
“VORTEC”5000
“VORTEC”5700
“VORTEC”7400 M
R
J
5 Quarts (4.8 L)
5 Quarts (4.8 L)
7 Quarts (6.5 L)
Fuel Tank Capacity
TYPE QUANTITY
Standard Tank 3 1 Gallons (1 17.33 L)
Optional Tank* * 55 Gallons (208.18 L)
*All quantities are approximate.
** 159’’ , 177” Wheelbase Vehicles Only.
All quantities are approximate. After refill, the level MUST be checked as outlined
under “Engine Oil And Filter Recommendations’’ in
Section
5.
**Add one additional quart for RPO 5Z1 and
WO KL5 Models.
6-66
ProCarManuals.com

Normal Replacement Parts
Engine “VORTEC”4300 “VORTEC”5000 “VORTEC”5700 “VORTEC”\
7400
VIN w M R J
Oil Filter PF52 PF1218 PF1218 PF1218
Air Cleaner Filter* A917C A917C A917C A917C
PCV Valve CV789C cv774c cv774c cv774c
Spark Plugs 41-932 4 1-932 41-932 4 1-932
Fuel Filter GF48
1 GF48 1 GF48 1 GF48 1
Radiator Cap RC36 RC36 RC36 RC36
*Replace with
AC Air Filter, Part No. A917C and for severe dusty conditions, use, AC Air Filter, Part No. 1236C.
Air Conditioning Refrigerant Capacity
I NOTICE:
~~
R-134A refrigerant is not compatible with R-12
refrigerant in an air conditioning system. R-12 in
an R-134A system
will cause compressor failure,
refrigerant oil sludge,
or poor air conditioning
system performance. TYPE
QTY Front Only QTY Front and Rear
Refrigerant 3.00 lbs. (1.36 kg) 4.875 lbs. (2.21 kg)
R- 134A
Air Conditioning Refrigerants
Not all air conditioning refrigerants are the same.
If the air conditioning system in your vehicle needs
refrigerant, be sure the proper refrigerant is used.
If you’re not sure, ask your GM dealer.
6-67
ProCarManuals.com

Lamp and Bulb Data
LAMP OR BULB
HEADLAMPS
2 Headlamp System (Sealed Beam System)
Low/High Beam
4 Headlamp System (Composite Headlamp System)
Low/High Beam
High Beam
LAMP OR BULB
EXTERIOR
Front Sidemarker Lamp
Front Park and Turn Lamp
Rear Parking Lamp
Rear Stop and
Turn Lamp
Back-up Lamp
Back-up Lamp
Rear Park, Stop, and
Turn Lamp
CHMSL
License Plate Lamp
Underhood Lamp
Reel Lamp
TRADE NO.
H6054
6052
9005
TRADE NO.
194
2357NA
3057
3057
3156 1156
1157 921
194
232
232
POWER RATING AT
12.8V, WATTS
35/65
51
60
QTY.
2
4
2
2
2
6-68
ProCarManuals.com

LAMP OR BULB INTERIOR
Dome Lamps
Reading Lamps
IP Courtesy Lamp
Stepwell Lamp
Instrument Panel Compartment Lamp
Ashtray Lamp
Sunshade Vanity Mirror
LAMP OR BULB
INSTRUMENT PANEL
Daytime Running Lamps Indicator
Charging System Indicator Lamp
Instrument Cluster Illumination
Headlamp Beam Indicator
Turn Signal Indicator
Brake Warning Indicator
SIR (Air Bag)
Safety Belt Warning
Check Gages Indicator
Malfunction Indicator (“Service Engine Soon”) Lamp
TRADE NO.
211-2
211-2
194
194
194 194 74
TRADE NO.
74 74
194 74 74
74
74
74
74
74
QTY.
3
6
2
214
1
1
4
QTY.
1 1
6
1
2
1
1
1
1
1
6-69
ProCarManuals.com

b NOTES
6-70
ProCarManuals.com