1996 FORD WINDSTAR warning light

334
*
[SV28900(ALL)05/95]
RWARNING
When using snow tires, make sure they are the same size
and grade as the tires you normally use on your vehicle.
*
[SV29000(ALL)02/95]
Do not use chains when using a temporary spare. For full size
tires, use chains on the tires only in an emergency or if the law
requires them where you live. When you use the tire chains:
*
[SV29100(ALL)01/95]
n
Make sure the chains are the right size for your tires. Use
only SAE Class ªSº chains. Other types may damage your
vehicle.
*
[SV29200(ALL)01/93]
n
Put chains on tightly with the ends held down securely.
Follow the chain manufacturer's instructions.
*
[SV29300(ALL)01/93]
n
Drive slowly. If you can hear the chains rub or bang against
your vehicle, stop the vehicle and tighten the chains. If you
continue to hear the chains rub or bang against your vehicle,
remove the chains to prevent damage to your vehicle.
*
[SV29400(ALL)10/94]
n
Avoid fully loading your vehicle if possible.
*
[SV29500(ALL)05/94]
n
Remove tire chains at the first opportunity after using them
on snow and ice. Do not use the chains on dry roads.
[SV29520(ALL)10/93]
Limited chain clearance exists with P215/70R15 tires. If your
vehicle is equipped with these tires, extra care must be observed
to avoid damage with chains.
[SV29530(ALL)10/93]
Be sure:
[SV29535(ALL)10/93]
n
The chains are fully tightened
[SV29540(ALL)05/95]
n
The vehicle is driven below 30 MPH (50 km/h)
[SV29550(ALL)10/93]
n
The vehicle is lightly loaded
[SV29560(ALL)10/93]
n
To avoid sharp turns
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
337
%*
[SV32300(ALL)01/95]
Adding Automatic Transaxle Fluid
*
[SV32400(ALL)04/95]
The fluid type is stamped on the dipstick. Before adding any
fluid, be sure that the correct type will be used.
*
[SV32500(ALL)05/95]
Add fluid in 1/2 pint (0.25 liter) increments through the filler
tube to bring the level to the correct area on the dipstick. If an
overfill occurs, excess fluid should be removed by a qualified
technician.
%*
[SV32600(ALL)01/93]
NOTE: Always dispose of used automotive fluids in a
responsible manner. Follow your community's
standards for disposing of these types of fluids. Call
your local recycling center to find out about recycling
automotive fluids.
*
[SV32700(ALL)06/94]
NOTE: Always use Motorcraft MERCONHor equivalent
MERCONHautomatic transaxle fluid when you refill
your automatic transaxle fluid.
%*
[SV32800(ALL)02/95]
Brake Fluid
*
[SV32900(ALL)05/90]
Your vehicle is equipped with a brake fluid level indicator in
the master cylinder which lights the BRAKE warning light on
the instrument panel when the brake fluid level is low.
*
[SV33000(ALL)01/93]
Under normal circumstances, your vehicle should not use up
brake fluid rapidly. However, expect the level of the brake fluid
to slowly fall as you put more mileage on your vehicle and the
brake pads wear.
*
[SV33100(ALL)10/89]
Check the brake fluid at least once a year. You can do this by
looking at the fluid level in the plastic reservoir on the master
cylinder. The fluid level should be at or near the MAX mark.
*
[SV33200(ALL)05/95]
RWARNING
Brake fluid is toxic.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

352
%*
[SV39500(ALL)01/95]
The alignment of your headlamps should be checked if:
*
[SV39600(ALL)01/95]
n
oncoming motorists frequently signal you to turn off your
vehicle's high beams when you do not have the high beams
on
*
[SV39700(ALL)01/95]
n
the headlamps do not seem to give you enough light to see
clearly at night
*
[SV39800(ALL)01/93]
n
the headlamp beams are not pointed slightly down and to
the right
%*
[SV39900(ALL)03/95]
Replacing the Headlamp Bulb
*
[SV40000(ALL)01/93]
The headlamps on your vehicle use replaceable bulbs. When the
lamp burns out, simply replace the bulb, rather than the whole
lamp.
*
[SV40100(ALL)05/95]
RWARNING
Handle a halogen headlamp bulb carefully and keep out
of children's reach. Grasp the bulb only by its plastic
base and do not touch the glass. The oil from your hand
could cause the bulb to break the next time the
headlamps are operated.
*
[SV40200(ALL)01/93]
Do not remove the burned out bulb unless you can immediately
replace it with a new one. If a bulb is removed for an extended
period of time, contaminants may enter the headlamp and affect
its performance.
*
[SV40300(ALL)03/95]
To remove the headlamp bulb:
*
[SV40400(ALL)01/93]1.
Make sure that the engine is off and the headlamp switch on
the instrument panel is in the OFF position.
[SV40500(ALL)11/93]2.
Lift the hood and locate the headlamp bulb installed in the
rear of the headlamp. Remove the electrical connector from
the bulb by pulling the connector away from the bulb
assembly.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

360
*
[SV43925(ALL)05/95]
RWARNING
Exhaust leaks may result in the entry of harmful and
potentially lethal fumes into the passenger compartment.
Under extreme conditions excessive exhaust temperatures
could damage the fuel system, the interior floor covering,
or other vehicle components, possibly causing a fire.
*
[SV43950(ALL)03/95]
The Scheduled Maintenance Services listed in theMaintenance
Schedule and Recordbooklet are required because they are
considered essential to the life and performance of your vehicle
and to its emissions system.
*
[SV44000(ALL)05/95]
Watch for fluid leaks, strange odors, smoke and loss of oil
pressure. Also watch for the charge warning light, the check
engine light, or the temperature warning light. These sometimes
indicate that the emission system is not working properly.
*
[SV44100(ALL)01/95]
Do not make any unauthorized changes to your vehicle or
engine. Changes that cause more unburned fuel to reach the
exhaust system can increase the temperature of the engine or
exhaust system.
*
[SV44200(ALL)01/93]
By law, anyone who manufactures, repairs, services, sells, leases
vehicles, trades vehicles, or supervises a fleet of vehicles is not
permitted to intentionally remove an emission control device or
prevent it from working. In some of the United States and in
Canada, vehicle owners may be liable if their emission control
device is removed or is prevented from working.
%*
[SV44225(ALL)05/95]
In general, maintenance, replacement, or service of the emission
control devices or systems in your new Ford Motor Company
vehicle or engine may be performed at your expense by any
automotive repair establishment or individual using automotive
parts equivalent to those with which your vehicle or engine was
originally equipped.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

368
[SV47350(ALL)10/93]
RWARNING
Fuel system components may be damaged by torches and
welding equipment.
%*
[SV47400(ALL)01/95]
Cooling system
*
[SV47500(ALL)01/93]
n
Protect your vehicle against freezing temperatures.
%*
[SV47600(ALL)01/95]
Battery
*
[SV47700(ALL)01/93]
n
Check and recharge the battery as necessary.
*
[SV47800(ALL)01/95]
n
Keep connections clean and covered with a light coat of
grease.
%*
[SV47900(ALL)01/95]
Brakes
*
[SV48000(ALL)01/93]
n
Make sure the brakes and parking brake are fully released.
%*
[SV48100(ALL)01/95]
Tires
*
[SV48200(ALL)05/95]
n
Maintain recommended air pressure.
*
[SV48300(ALL)01/95]
Miscellaneous
*
[SV48400(ALL)01/93]
n
Make sure all linkages, cables, levers and clevis pins under
the vehicle are covered with grease to prevent rust.
*
[SV48500(ALL)01/93]
n
Lubricate working parts to prevent corrosion.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Index
381
A
ABS warning light (see Anti-lock brake system).... 69,88
Accessory position on the ignition............. 55
Additives, engine oil.................. 317
Air bag supplemental restraint system......... 19,40
and child safety seats............... 20,39
description.................... 19,21
disposal....................... 25
driver air bag................... 19,21
indicator light................... 74,85
operation....................... 21
passenger air bag................... 21
proper seating.................... 20
tone generator.................... 25
wearing safety belts.................. 19
Air conditioning, manual heating and
air conditioning system............. 108
Alarm, activating remote personal............ 152
Alcohol, in fuel.................... 312
Aluminum wheels................... 272
Antenna, radio (see Electronic sound system).....128, 195
Antifreeze (see Engine coolant)............. 319
Anti-lock brake system (ABS)
description..................... 240
noise........................ 241
see also Brake.................... 240
warning light................... 69,88
Anti-theft lug nuts and key............... 273
Anti-theft system
arming the system.................. 156
description..................... 156
disarming an untriggered system........... 157
disarming a triggered system............. 157
triggering....................156, 157
warning light.................... 104
Assistance (see Customer assistance)........... 283
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

382
Audio system (see Electronic sound system)....... 195
Autolamp system (see Headlamps)........... 123
Autolock (see Keyless entry).............. 154
Automatic transaxle
driving with.................... 235
fluid, adding.................... 337
fluid, checking................... 336
fluid, refill capacities................ 363
fluid, specification.................. 365
B
Backing up...................... 236
Basic vehicle warranty.................. 3
Battery
acid, treating emergencies............261, 325
battery saver.................... 151
charging system warning light........... 72,85
how to service................... 323
jumping a disabled battery.............. 261
maintenance-free.................. 323
proper disposal, recycling.............. 324
when storing your vehicle.............. 368
Brake fluid
brake warning light................ 68,84
checking and adding................ 337
specifications..................338, 365
Brakelamp, bulb replacement.............. 354
Brakes
adjustment..................... 240
anti-lock...................... 240
anti-lock brake system (ABS) warning light..... 69,88
applying the brakes................. 243
brake warning light................ 68,84
fluid, checking and adding.............. 337
fluid, specifications...............338, 365
front disc...................... 240
if brakes do not grip well.............. 242
new brake linings................... 4
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996

383
Index
Brakes (continued)
noise........................ 242
parking...................... 244
stopping distances.................. 243
trailer....................... 256
when storing your vehicle.............. 368
Brake-shift interlock.................. 236
Break-in period..................... 4
Built-in child seat
cleaning....................... 37
operation....................... 27
Bulbs, replacing
headlamps..................... 352
specifications.................... 358
C
Canada, customer assistance.............. 292
Canadian Motor Vehicle Arbitration Plan (CAMVAP) . . . 292
Capacities for refilling fluids.............. 363
Carbon monoxide in exhaust............... 62
Cargo net....................... 192
Car seats for children (see Child safety seats)....... 39
Cassette tape player
(see Electronic sound system)......213, 225, 228
Catalytic converter................... 359
CD player (see Electronic sound system)......... 201
Chains, tires...................... 333
Changing a tire.................... 267
Charging system warning light............ 72,85
Childproof locks.................... 144
Child safety restraints.................. 25
built-in child seat................... 27
child safety belts................... 38
child safety seats................... 39
Child safety seats
and air bags................... 20,39
attaching with tether straps.............. 50
File:wnixs.ex
Update:Tue Mar 19 08:12:49 1996