1996 FORD WINDSTAR light

261
Roadside Emergencies
%*
[RE00700(ALL)03/95]
Jump-Starting Your Vehicle
*
[RE00800(ALL)01/93]
Your vehicle's battery may discharge if you leave the lights or
any electrical equipment on after you turn the engine off. If this
happens, you may be able to jump-start from a booster battery
to start your vehicle.
*
[RE00900(ALL)02/95]
RWARNING
The gases around the battery can explode if exposed to
flames, sparks, or lit cigarettes. An explosion could result
in injury or vehicle damage.
*
[RE01000(ALL)02/95]
RWARNING
To protect yourself when charging a battery, always
shield your face and eyes. Make sure that you can
breathe fresh air.
%*
[RE01100(ALL)05/95]
RWARNING
Applying too much pressure on the ends when lifting a
battery could cause acid to spill. Lift the battery with a
carrier or with your hands on the opposite corners.
%*
[RE01200(ALL)05/95]
RWARNING
Batteries contain sulfuric acid which burns skin, eyes,
and clothing.
*
[RE01220(ALL)05/95]
If the acid touches someone's skin, eyes, or clothing,
immediately flush the area with water for at least 15 minutes. If
someone swallows the acid, have him or her drink lots of milk
or water first, then Milk of Magnesia, a beaten egg, or vegetable
oil. Call a doctor immediately.
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996

262
*
[RE01400(ALL)03/95]
To avoid damaging your vehicle or your battery, and to avoid
injury to yourself, follow these directions for preparing your
vehicle to jump-start and connecting the jumper cables in the
order they are given. If in doubt, call for road service.
[RE01500(ALL)02/95]
To prepare your vehicle for jump-starting:
[RE01600(ALL)02/95]1.
Use only a 12-volt battery to jump-start your vehicle. Your
vehicle has a 12-volt starting system, so you need to use a
12-volt jumper system. You can damage your starting motor,
ignition system, and other electrical parts if you connect
them to a 24-volt power supply (either two 12-volt batteries
in series or a 24-volt motor generator set).
*
[RE01700(ALL)03/95]2.
Do not disconnect the battery of the vehicle that needs a
jump-start. You could damage the vehicle's electrical system.
*
[RE01800(ALL)03/95]3.
Park the second vehicle close to the hood of your vehicle,
but make sure the vehicles do not touch each other. Set the
parking brake on both vehicles and stay clear of the engine
cooling fan.
*
[RE01900(ALL)03/95]4.
Check the battery terminals and remove any excessive
corrosion before you attach the jumper cables.
*
[RE02000(ALL)01/93]5.
Turn on the heater blower in both vehicles. Turn off all other
switches and lights in both vehicles to prevent possible
damage to either vehicle's electrical systems.
File:wnres.ex
Update:Tue Mar 19 08:18:21 1996

286
*
[HS03300(ALL)03/95]
If you still have a service or product complaint, you may wish
to contact the Dispute Settlement Board (U.S. only) or the
Canadian Motor Vehicle Arbitration Plan (CAMVAP) in Canada.
%*
[HS03500(ALL)02/95]
The Dispute Settlement Board (U.S. Only)
*
[HS03600(ALL)03/95]
The Dispute Settlement Board is a voluntary, independent
dispute-settlement program available free to owners or lessees
of qualifying Ford Motor Company vehicles.
*
[HS03700(ALL)01/95]
The Dispute Settlement Board may not be available in all states.
Ford Motor Company reserves the right to change eligibility
limitations, modify procedures and/or to discontinue this
process at any time without notice and without incurring
obligations.
*
[HS03800(ALL)01/93]
What Kinds of Cases Does the Board Review?
[HS03900(ALL)02/95]
The Board reviews all product performance and service
complaints on Ford, Mercury and Lincoln cars and Ford and
Mercury light trucks under warranty that have not been
resolved by a dealer or Ford Motor Company, except those
involving:
*
[HS04000(ALL)01/95]
n
A non-Ford product
*
[HS04100(ALL)01/95]
n
A non-Ford dealership
*
[HS04200(ALL)01/95]
n
A vehicle sales transaction
*
[HS04300(ALL)01/95]
n
A request for reimbursement of consequential expenses
unless incidental to a service or product complaint being
reviewed
*
[HS04400(ALL)01/95]
n
Items not covered by your warranty
*
[HS04500(ALL)01/95]
n
Alleged liability claims
*
[HS04600(ALL)01/95]
n
Property damage where such damage is significant when
compared to the economic loss alleged under the warranty
dispute
File:wnhss.ex
Update:Tue Mar 19 08:17:31 1996

301
Servicing Your Windstar
*
[SV01300(ALL)03/95]
How Ford Makes Servicing Your Vehicle
Easy
*
[SV01400(ALL)01/95]
Ford has two goals for servicing your vehicle.
*
[SV01500(ALL)01/95]1.
When we can, we design parts that do not need to be
serviced.
*
[SV01600(ALL)01/95]2.
We want to make servicing your vehicle as easy as possible.
To help you:
*
[SV01700(ALL)01/93]
n
We highlight do-it-yourself items in yellow in your engine
compartment so that you can find them easily.
*
[SV01800(ALL)01/95]
n
When possible, we design parts Ð such as the headlamp
bulbs Ð that can be replaced without tools.
[SV01900(ALL)03/94]
n
We give you aMaintenance Schedule and Recordbooklet that
makes tracking routine service for your vehicle easy.
*
[SV02000(ALL)01/95]
This chapter tells you about the basic parts that you need to
check and service regularly.
[SV02100(ALL)03/94]
If you need professional servicing, see the chapter onCustomer
Assistancein this Owner Guide.
[SV02200(ALL)02/95]
Check yourWarranty InformationBooklet to find out which parts
are covered.
%*
[SV02300(ALL)03/95]
Precautions When Servicing Your Vehicle
*
[SV02400(ALL)01/95]
Be especially careful when inspecting or servicing your vehicle.
Here are some general precautions for your safety:
*
[SV02500(ALL)03/95]
n
If you must work with the engine running, avoid wearing
loose clothing or jewelry that could get caught in moving
parts.
*
[SV02600(ALL)01/95]
n
Do not work on a vehicle in an enclosed space with the
engine running, unless you are sure you have enough
ventilation.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

310
*
[SV06700(ALL)05/95]
A venting fuel tank is not an abnormal condition. It may be
caused by:
*
[SV06800(ALL)05/95]
n
too volatile a fuel for the weather conditions. Service stations
sometimes sell winter grade fuel in the summer.
*
[SV06900(ALL)01/93]
n
pulling a heavy load on hot days, or at high altitudes.
*
[SV07000(ALL)05/95]
n
extended periods of idling with the engine RPM increased
above the normal idle range.
*
[SV07100(ALL)05/95]
n
parking the vehicle in full sunlight for extended periods on
extremely hot days.
%*
[SV07200(ALL)05/95]
Choosing the Right Fuel
*
[SV07300(ALL)05/95]
Use only UNLEADED FUEL in your vehicle. Using leaded fuel
is prohibited by federal law. Any vehicle damage may not be
covered by your warranty.
% [SV07450(ALL)02/95]
Octane recommendations
*
[SV07550(ALL)04/95]
Your vehicle is designed to use regular gasoline with an
octane rating of 87.
*
[SV07650(ALL)03/95]
6 pica art:0040193-A
Typical octane rating label
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
311
[SV07750(ALL)02/95]
We do not recommend gasolines labeled ªregularº that are sold
with octane ratings of 86 or even less in high altitude areas.
%*
[SV07850(ALL)05/95]
Do not be concerned if your vehicle sometimes knocks lightly.
However, if it knocks heavily under most driving conditions on
the recommended octane rating fuel, see your dealer or a
qualified service technician to prevent any engine damage.
%*
[SV07950(ALL)05/95]
Fuel quality
*
[SV08050(ALL)02/95]
If you are experiencing starting, rough idle, or hesitation
problems try a different brand of fuel. If the condition persists,
see your dealer or qualified service technician.
*
[SV08850(ALL)05/95]
It should not be necessary to add any aftermarket products to
your fuel tank if you continue to use a high-quality fuel.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

318
[SV16400(ALL)02/95]
7-1/2 pica art:0050073-D
Engine oil dipstick
*
[SV16500(ALL)02/95]6.
Carefully, pull the dipstick out again. If the oil level is below
the ªADD 1 QT.º line, add engine oil as necessary. If the oil
level is beyond the letter ªFº in FULL, engine damage or
high oil consumption may occur and some oil must be
removed from the engine.
*
[SV16600(ALL)01/95]7.
Put the dipstick back in and make sure it is fully seated.
*
[SV16700(ALL)01/95]
It may be necessary to add some oil between oil changes. Make
sure you use a CERTIFIED engine oil of the preferred viscosity.
Your vehicle's warranty coverage may not apply if engine
damage is caused by the use of improper engine oil.
*
[SV16800(ALL)03/95]
Add engine oil through the oil filler cap highlighted in yellow.
To add oil, remove the filler cap and use a funnel to pour oil
into the opening. Be careful not to overfill the engine. Recheck
the oil level after you finish adding oil.
%*
[SV16900(ALL)01/95]
Changing the Engine Oil and the Oil Filter
*
[SV17200(ALL)04/95]
Refer to theMaintenance Schedule and Recordbooklet for
additional information.
% [SV18200(ALL)12/93]
NOTE: Always dispose of used automotive fluids in a
responsible manner. Follow your community's
standards for disposing of these types of fluids. Call
your local recycling center to find out about recycling
automotive fluids.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996

Servicing Your Windstar
319
*
[SV18300(ALL)05/95]
RWARNING
Continuous contact with USED motor oil has caused
cancer in laboratory mice.
*
[SV18320(ALL)05/95]
Protect your skin by washing with soap and water.
%*
[SV18400(ALL)03/95]
Engine Coolant
%*
[SV18500(ALL)02/95]
Checking the engine coolant
[SV18600(ALL)11/93]
Your vehicle's engine coolant protects the engine from
overheating in the summer and from freezing in the winter.
Check the level of the engine coolant at least once a month, but
preferably each time you stop for fuel. Simply check the coolant
reservoir, located in the engine compartment. The coolant
should stay slightly above the ªFULL COLDº mark.
*
[SV18700(ALL)01/95]
Adding engine coolant
*
[SV18900(ALL)05/95]
RWARNING
Do not put engine coolant in the container for the
windshield washer fluid.
*
[SV18920(ALL)05/95]
If sprayed to clean the glass, engine coolant or antifreeze could
make it difficult to see through the windshield.
File:wnsvs.ex
Update:Tue Mar 19 08:16:43 1996