1996 FORD PROBE check engine

242
*
[SV29675(ALL)06/95]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
%*
[SV29690(ALL)05/95]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
*
[SV29700(ALL)03/01]
Automatic Transaxle Fluid
*
[SV29800(ALL)03/95]
Under normal circumstances, you do not need to
check the fluid level of the transaxle, since your
vehicle does not use up transaxle fluid. Refer to
theMaintenance Schedule and Recordbooklet for
replacement intervals. However, if the transaxle
is not working properly Ð for instance, the
transaxle may slip or shift slowly, or you may
notice some sign of fluid leakage Ð the fluid
level should be checked.
[SV29900(ALL)01/94]
If you must check the transaxle fluid in an
emergency, make sure that your vehicle is on
level ground, start the engine, and move the
gearshift through all of the gears allowing
sufficient time for each position to engage.
Securely latch the gearshift in P (Park). Set the
parking brake and leave the engine running.
[SV29950(ALL)04/93]
Wipe off the dipstick cap, pull the dipstick out
and wipe the indicator end clean. Put the
dipstick back into the filler tube. Make sure the
dipstick is fully seated in the filler tube;
otherwise, you will not get an accurate reading.
Pull the dipstick out and read the fluid level.
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

244 [SV30350(ALL)06/93]
one third page art:0032151-BAutomatic transaxle fluid dipstick on 2.0L engine vehicles
*
[SV30400(ALL)03/95]
If you must add transaxle fluid in an emergency,
use only MERCONHfluid, such as Motorcraft
MERCONHMulti-Purpose ATF. Add the fluid in
1/2-pint increments until you raise the fluid
level to within the crosshatched area on the
dipstick. Never overfill the transaxle. If the fluid
level gets too high, remove the excess fluid as
soon as possible; otherwise, you could damage
the transaxle.
*
[SV30500(ALL)01/89]
Manual Transaxle Fluid
*
[SV30600(ALL)08/91]
The lubricant level and quality should not
deteriorate under normal use. However, you
should periodically have your Ford Dealer check
the fluid level during regular oil changes.
%*
[SV31350(ALL)04/95]
NOTE: Always dispose of used automotive
fluids in a responsible manner. Follow
your community's standards for
disposing of these types of fluids. Call
your local recycling center to find out
about recycling automotive fluids.
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

245 [SV31400(ALL)02/95]
Constant Velocity Joints
[SV31500(ALL)02/95]
Inspect all rubber boots for signs of cracks, tears,
or splits. Inspect underneath of your car for any
indication of grease splatter in the areas of
constant velocity joint boots, outboard and
inboard locations; grease splatter is an indication
of boot and/or clamp damage.
*
[SV31600(ALL)02/95]
Brake Fluid
*
[SV31700(ALL)03/95]
Under normal circumstances, your vehicle
should not use up brake fluid rapidly. However,
expect the level of the brake fluid to slowly fall
as you put more mileage on your vehicle and
the brake pads wear.
[SV31800(ALL)04/93]
Check the brake fluid at least once a year. You
can do this by looking at the fluid level in the
plastic reservoir on the master cylinder. (SeeThe
Engine Typesearlier in this chapter to locate the
master cylinder.) The fluid level should be at or
near the MAX mark.
*
[SV31850(ALL)05/95]
RWARNING
Brake fluid is toxic.
*
[SV31860(ALL)06/95]
If brake fluid contacts eyes, flush eyes with
running water for 15 minutes. Get medical
attention if irritation persists. If taken internally,
drink water and induce vomiting. Get medical
attention immediately.
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

247
*
[SV32800(ALL)03/95]
Power Steering Fluid
*
[SV32900(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
*
[SV33000(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV33100(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV33200(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV33300(ALL)01/95]
3. Turn the engine off and check the level on
the power steering reservoir.
[SV33550(ALL)08/91]
one third page art:0032043-A
Where to check for power steering fluid
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

262
*
[SV47800(ALL)05/95]
To make sure that the catalytic converter and the
other emission control parts continue to work
properly:
*
[SV47900(ALL)01/95]
q
Use only unleaded fuel.
*
[SV48000(ALL)01/95]
q
Avoid running out of fuel.
*
[SV48100(ALL)01/95]
q
Do not turn off the ignition while your
vehicle is moving, especially at high speeds.
*
[SV48150(ALL)01/95]
q
Do not push start your vehicle.
*
[SV48200(ALL)03/95]
q
Have the services listed in yourMaintenance
Schedule and Recordbooklet performed
according to the specified schedule.
*
[SV48300(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV48400(ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
*
[SV48500(ALL)01/95]
Do not make any unauthorized changes to your
vehicle or engine. Changes that cause more
unburned fuel to reach the exhaust system can
increase the temperature of the engine or
exhaust system.
%*
[SV48550(ALL)05/95]
In general, maintenance, replacement, or service
of the emission control devices or systems in
your new Ford Motor Company vehicle or
engine may be performed at your expense by
any automotive repair establishment or
individual using automotive parts equivalent to
those with which your vehicle or engine was
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

272 %
*
[SV52200(ALL)01/95]
Engine
*
[SV52300(ALL)01/95]
q
Start engine every 15 days. Run at fast idle
until it reaches normal operating temperature.
*
[SV52400(ALL)01/95]
q
With your foot on the brake, shift through all
the gears while the engine is running.
%*
[SV52500(ALL)01/95]
Fuel system
%*
[SV52600(ALL)07/94]
q
Fill fuel tank with high-quality unleaded fuel
until the first automatic shutoff of the fuel
pump nozzle.
*
[SV52800(ALL)03/95]
NOTE: During extended periods of vehicle
storage (60 days or more), fuel may
deteriorate due to oxidation. This can
damage rubber and other polymers in
the fuel system and may also clog
small orifices.
*
[SV52900(ALL)01/95]
Ford Gas Stabilizer should be added whenever
actual or expected storage periods exceed 60
days. Follow the instructions on the label. The
vehicle should then be operated at idle speed to
circulate the additive throughout the fuel system.
*
[SV53000(ALL)01/95]
A volatile corrosion inhibitor added to the fuel
system will protect the fuel system's inner
surfaces from corrosion. Follow the instructions
packaged with the product.
%*
[SV53100(ALL)01/95]
Cooling system
*
[SV53200(ALL)01/95]
q
Protect against freezing temperatures.
%*
[SV53300(ALL)01/95]
Battery
*
[SV53400(ALL)01/95]
q
Check and recharge as necessary.
*
[SV53500(ALL)01/95]
q
Keep connections clean and covered with a
light coat of grease.
File:prsvp.ex
Update:Fri Jun 23 19:33:26 1995

294 Index
Cleaning your vehicle (continued)
wheels................ 239
windows................ 72
Clock................127, 143
Clutch
operation while driving........ 153
recommended shift speeds....... 156
shifting the gears........... 154
Cold engine starting............ 43
Combination lap and shoulder belts..... 9
Compact disc player
(see Electronic sound system) . . . 122, 128
Compact disc radio
(see Electronic sound system)..... 122
Console, description........... 114
Controls
instrument panel............ 63
mirrors................ 113
steering column............. 77
Coolant (see Engine coolant)
checking and adding......... 221
drain and flush............ 226
preparing for storage......... 272
specifications............. 226
temperature gauge........... 61
Cooling fan............... 204
Crankcase emission filter......... 268
Cruise control (see Speed control)...... 89
Customer Assistance Center,
Ford (U.S.).............. 187
Customer Assistance Centre,
Ford of Canada............ 192
D
Dashboard (see Instrument panel)...... 63
Daytime running light system....... 78
Defects, reporting............ 192
Dipstick
engine oil.............. 218
power steering fluid.......... 247
Disabled vehicle (see Towing)...... 181
File:prixp.ex
Update:Fri Jun 23 19:30:26 1995

Index 295
Dispute Settlement Board........ 188
Doors.................. 95
Driving under special conditions
bad weather............. 162
heavy load.............. 164
high water.............. 164
slippery roads............ 162
tips for safe driving.......... 162
towing a trailer............ 166
E
Electronic radio with cassette
(see Electronic sound system)..... 134
Electronic sound system
antenna................ 75
atenna................. 75
radio reception............ 143
tuning the radio.........123, 137
warranty and service information . . . 146
Electronic stereo cassette radio
(see Electronic sound system)..... 134
Electronic stereo radio
(see Electronic sound system)..... 134
Emergencies, roadside
assistance.............. 185
battery acid spills.........169, 242
jump-starting............. 169
towing................ 181
Emergency brake (parking brake) . . . 158, 160
Emission control system
catalytic converter.......... 261
emissions warranty........261±262
Engine
check engine warning light....... 58
does not start............. 44
fuel injected engine, starting.....42±43
fuel pump shut-off switch........ 46
preparing to start............ 42
starting.............. 37,43
starting after a collision......... 46
File:prixp.ex
Update:Fri Jun 23 19:30:26 1995