1996 FORD AEROSTAR oil pressure

83 %
*
[LG07500(ALL)05/94]
Engine Oil Pressure Gauge
*
[LG07601(ALL)06/93]
This gauge indicates the engine's oil pressure,
not the oil level. However, if your engine's oil
level is low, it could affect the oil pressure. With
the engine running, the pointer should move
into the NORMAL band. If the pointer drops
below the NORMAL band while the engine is
running, you have lost oil pressure and
continued operation will cause severe engine
damage.
*
[LG07701(ALL)03/95]
If you lose engine oil pressure:
*
[LG07801(ALL)03/95]
1. Pull off the road as soon as safely possible.
*
[LG07901(ALL)04/95]
2. Shut off the engine immediately or severe
engine damage could result.
*
[LG08001(ALL)02/95]
3. Check the engine's oil level, following the
instructions on checking and adding engine
oil. Refer toEngine oilin the Index. If you
do not follow these instructions, you or
others could be injured. To assure an
accurate reading, your vehicle should be on
level ground.
*
[LG08051(ALL)03/93]
4. If the level is low, add only as much oil as
necessary before you start the engine again.
Do not overfill. Do not operate the engine if
the pointer is below the NORMAL band,
regardless of the oil level. Contact your
nearest dealer for further service actions.
*
[LG08200(ALL)03/93]
quarter page art:0020057-D
Engine oil pressure gauge
File:05cplga.ex
Update:Tue Aug 29 17:36:50 1995

306
*
[SV33200(ALL)01/95]
RWARNING
Batteries normally produce explosive gases
which can cause personal injury.
Therefore, do not allow flames, sparks or
lit tobacco to come near the battery. When
charging or working near a battery, always
cover your face and protect your eyes, and
also provide ventilation.
%*
[SV33300(ALL)07/95]
RWARNING
Batteries contain sulfuric acid which burns
skin, eyes, and clothing.
*
[SV33310(ALL)07/95]
If the acid touches someone's skin, eyes, or
clothing, immediately flush the area with water
for at least 15 minutes. If someone swallows the
acid, have him or her drink lots of milk or water
first, then Milk of Magnesia, a beaten egg, or
vegetable oil. Call a doctor immediately.
%*
[SV33400(ALL)06/95]
RWARNING
Applying too much pressure on the ends
when lifting a battery could cause acid to
spill. Lift the battery with a carrier or
with your hands on the opposite corners.
%
*
[SV33500(ALL)01/95]
Automatic Transmission Fluid
*
[SV33601(ALL)06/95]
Under normal driving conditions automatic
transmission fluid should be changed every
30,000 miles (48,000 km) or 21,000 miles
(34,000 km) if under severe duty conditions.
However, if the transmission is not working
properly, for instance, the transmission may slip
or shift slowly, or you may notice some sign of
fluid leakage, the fluid level should be checked.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

331
%*
[SV48600(ALL)03/95]
Emission Control System
*
[SV48700(ALL)05/95]
Your vehicle is equipped with a catalytic
converter which enables your vehicle to comply
with applicable exhaust emission requirements.
*
[SV48800(ALL)05/95]
To make sure that the catalytic converter and the
other emission control parts continue to work
properly:
*
[SV48900(ALL)01/95]
q
Use only unleaded fuel.
*
[SV49000(ALL)01/95]
q
Avoid running out of fuel.
*
[SV49100(ALL)01/95]
q
Do not turn off the ignition while your
vehicle is moving, especially at high speeds.
*
[SV49200(ALL)03/95]
q
Have the services listed in yourMaintenance
Schedule and Recordbooklet performed
according to the specified schedule.
*
[SV49300(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[SV49400(ALL)05/95]
RWARNING
On vehicles without original equipment
floor covering or insulation, do not let
passengers ride in your truck in a manner
that allows contact between skin and the
metal floor.
*
[SV49500(ALL)05/95]
Watch for fluid leaks, strange odors, smoke, loss
of oil pressure, the charge warning light, the
check engine light, or the temperature warning
light. These sometimes indicate that the emission
system is not working properly.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

366 Index
Engine coolant temperature gauge..... 85
Engine fan............... 266
Engine idle speed control......... 67
Engine knocking............. 276
Engine oil............... 282
checking and adding......... 283
dipstick............... 283
disposal............... 266
engine oil pressure gauge........ 83
filter, specifications.......... 337
refill capacities............ 335
specifications...........282, 338
synthetic oil............. 282
ªbreak-inº oils............. 7
viscosity............... 282
Entry system, illuminated........ 107
Exhaust fumes.............. 71
Extended Service Plan, Ford........ 4
F
Fan, engine fan, avoiding injury..... 266
Federal Communications Commission . . . 184
Federal Highway Administration
Regulation............... 6
Flashers, hazard............. 113
Flashing the lamps........... 110
Flat tire................. 229
Fluid refill capacities........... 335
Ford Customer Assistance Center..... 247
Ford Dispute Settlement Board...... 248
Ford Extended Service Plan........ 4
Ford Motor Company of Canada..... 253
Ford of Canada Customer
Assistance Centre........... 253
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

368 Index
G
Gas cap (see Fuel cap).......... 273
Gas mileage (see Fuel economy)..... 280
Gasohol................ 277
Gasoline (see Fuel)............ 273
Gauges
battery voltage gauge.......... 82
charging system gauge......... 82
engine coolant temperature gauge.... 85
engine oil pressure gauge........ 83
fuel gauge............... 84
odometer................ 88
speedometer.............. 87
trip odometer.............. 88
GAWR (Gross Axle Weight Rating)
calculating.............. 211
definition............... 209
driving with a heavy load....... 202
Gearshift
automatic operation.......... 186
gearshift override......... 66,187
locking the gearshift........... 61
positions............... 186
shifting the gears........... 186
shift-lock............. 66,187
GVWR (Gross Vehicle Weight Rating) . . . 202
calculating.............. 211
definition............... 209
driving with a heavy load....... 202
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995

Index 371
Lamps (continued)
interior lamps............ 101
replacing bulbs............ 322
trailer................ 219
Lane change indicator (see Turn signal) . . 109
Lap belts................. 20
Lights, warning and indicator
airbag................. 81
brake................. 75
charging system............ 81
check engine.............. 78
door ajar................ 77
engine oil pressure........... 83
hazard warning light......... 113
high beam............... 84
oil pressure.............. 83
safety belt............... 77
service engine soon........... 78
turn signal indicator......... 109
Load limits............... 202
GAWR................ 202
GVWR................ 202
trailer towing............. 205
Lubricant specifications......... 338
Luggage rack.............. 223
Lug nuts................ 237
standard............... 239
tightening sequence.......... 241
Lumbar support, seats.......... 142
Lumbar support pad.......... 142
M
Maintenance schedule and record
(see separate Maintenance Schedule
and Record booklet).......... 3
Maintenance (see Servicing)....... 265
Master cylinder, brakes......... 309
Methanol in fuel............ 277
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995