1996 FORD AEROSTAR coolant temperature

68
*
[ST07450(ALL)05/95]
RWARNING
Do not park, idle, or drive your vehicle in
dry grass or other dry ground cover. The
emission system heats up the engine
compartment and exhaust system, which
can start a fire.
*
[ST07500(ALL)03/95]
If you consistently start your vehicle in subzero
temperatures, use an engine block heater (if
your vehicle has this option).
%*
[ST07600(ALL)06/95]
Engine Block Heater (If equipped)
*
[ST07700(ALL)03/95]
Engine block heaters are strongly recommended
if you live in a region where temperatures reach
-10ÊF (-23ÊC) orbelow. An engine block heater
warms the engine coolant, which improves
starting, warms up the engine faster, and allows
the heater-defrost system to respond quickly.
*
[ST08000(ALL)05/95]
RWARNING
To prevent electrical shock, do not use
your heater with ungrounded electrical
systems or two-pronged (cheater) adapters.
*
[ST08100(ALL)03/95]
For best results, plug the heater in at least three
hours before you start your vehicle. Using the
heater for longer than three hours will not
damage the engine, so you can plug it in at
night to start your vehicle the following
morning.
*
[ST08150(ALL)12/91]
NOTE: Be sure to disconnect the engine block
heater before driving your vehicle.
File:04cpsta.ex
Update:Tue Aug 29 17:35:31 1995

85 [LG10000(ALL)05/91]
one inch art:0020061-C
Fuel gauge
%*
[LG11100(ALL)01/95]
Engine Coolant Temperature Gauge
*
[LG11201(ALL)03/95]
This gauge indicates the temperature of the
engine coolant, not the coolant level. If the
coolant is not at its proper level or mixture, the
gauge indication will not be accurate.
*
[LG11301(ALL)08/95]
The pointer moves from the C (cold) mark into
the Normal band as the engine coolant warms
up. It is acceptable for the pointer to fluctuate
within the Normal band under normal driving
conditions. Under certain driving conditions,
such as heavy stop and go traffic or driving up
hills in hot weather, the pointer may move to
the top of the Normal band.
*
[LG11401(ALL)05/95]
If, under any circumstances, the pointer moves
above the NORMAL band, the engine coolant is
overheating and continued operation may cause
engine damage.
File:05cplga.ex
Update:Tue Aug 29 17:36:50 1995

86
*
[LG11501(ALL)01/95]
If your engine coolant overheats:
*
[LG11601(ALL)03/95]
1. Pull off the road as soon as it is safely
possible.
*
[LG11701(ALL)01/95]
2. Turn off the engine.
*
[LG11801(ALL)05/95]
3. Let the engine cool.DO NOT REMOVE
COOLANT SYSTEM FILL CAP UNTIL
THE ENGINE IS COOL.
*
[LG11901(ALL)04/95]
4. Check the coolant level following the
instructions on checking and adding coolant
to your engine. Refer toEngine coolantin the
Index. If you do not follow these
instructions, you or others could be injured.
[LG12325(ALL)03/93]
quarter page art:0020541-B
Engine coolant temperature gauge
File:05cplga.ex
Update:Tue Aug 29 17:36:50 1995

288 [SV20375()08/95]Always dispose of used automotive fluids in a
responsible manner. Follow your community's
regulations and standards for recycling and
disposing of automotive fluids.
[SV20400()08/95]
Coolant refill capacity
[SV20425()08/95]
To find out how much fluid your vehicle's
cooling system can hold, seeRefill capacities for
fluidsin the Index.
[SV20450()08/95]
Have your dealer check the engine cooling
system for leaks if you have to add more than a
quart (liter) of engine coolant per month.
[SV20475()08/95]
Severe winter climate
[SV20490()08/95]
If you drive in extremely cold climates (less than
-34ÊF [-36ÊC]), it may benecessary to increase
the coolant concentration above 50%. Refer to
the chart on the coolant container to ensure the
coolant concentration in your vehicle is such that
the coolant will not freeze at the temperature
level in which you drive during winter months.
Never increase the engine coolant concentration
above 60%. Leave a 50/50 mixture of engine
coolant and water in your vehicle year-round in
non-extreme climates.
%*
[SV20500(ALL)08/95]
Checking Hoses
*
[SV20600(ALL)10/89]
Inspect all engine and heater system hoses for
deterioration, leaks and loose clamps before
adding or replacing engine coolant. Make
whatever repairs or replacements that are
necessary using Motorcraft parts or their
equivalents.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

290 [SV22000(ALL)03/91]3. Turn the heater (temperature and mode
selection) knobs to maximum heat positions
and operate the engine at fast idle
(approximately 2000 RPM) for three to four
minutes.
*
[SV22200(ALL)05/95]
4. Shut off the engine and allow the engine to
cool. Cover the radiator cap with a thick
cloth and cautiously remove it. Step back
while the pressure releases.
[SV22300(ALL)05/89]
5. Add the engine coolant mixture to a level
approximately 1 to 1 1/2 inches (38 mm)
below the filler neck seat.
[SV22400(ALL)05/89]
6. Reinstall the radiator cap fully and back off
to the first stop. Once again, turn the engine
at fast idle until the upper radiator hose is
warm and the thermostat is open.
[SV22550(ALL)05/89]
7. Finally, check the radiator and add more
engine coolant if needed, following the
procedures noted above. Reinstall the
radiator cap securely, when finished.
[SV22555(ALL)05/95]
8. If more engine coolant is necessary, remove
the small plug from the top of the engine
coolant recovery reservoir (not the large cap
of the windshield washer reservoir) and add
1.1 quarts (1 liter) of the 50/50 engine
coolant mixture. Replace the plug in its
original position.
*
[SV22565(ALL)08/95]
NOTE: Due to air being trapped in the 4.0L
engine cooling system, it is not
unusual to experiencea4to7ounce
(120 to 210 ml) coolant loss up to 7,500
miles (12,000 km) after initial system
fill.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

291
*
[SV22620(ALL)06/95]
In order to bleed the cooling system properly
after initial fill with coolant, it might need up
to five cycles of:
*
[SV22630(ALL)06/95]
q
heating up the system (thermostat open)
*
[SV22640(ALL)06/95]
q
making sure coolant is at least up to the
cold fill mark of overflow bottle
*
[SV22650(ALL)06/95]
q
letting the coolant cool down (engine
coolant temperature gauge below the N of
NORMAL)
*
[SV22660(ALL)06/95]
q
topping off the coolant overflow bottle to
the cold fill mark
*
[SV22680(ALL)06/95]
If coolant loss continues after 7,500 miles
(12,000 km), consult your Ford Dealer.
%
*
[SV22700(ALL)03/95]
Windshield Washer Fluid and
Wipers
%*
[SV22800(ALL)03/95]
Washer Fluid
*
[SV22900(ALL)01/95]
Check the level of the windshield washer fluid
every time you stop for fuel. The reservoir for
the windshield washer fluid is located in the
engine compartment.
*
[SV23300(ALL)05/95]
RWARNING
Do not put windshield washer fluid in the
container for the engine coolant.
[SV23400(ALL)01/89]
quarter page art:0020358-A
Windshield washer reservoir
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

311
%*
[SV37600(ALL)03/95]
Power Steering Fluid
*
[SV37700(ALL)01/95]
Check the level of the power steering fluid at
least twice a year (i.e., every Spring and Fall).
%*
[SV37800(ALL)03/95]
Checking and Adding Power Steering
Fluid
*
[SV37900(ALL)02/95]
1. Start the engine and let it run until the
power steering fluid reaches normal
operating temperature. The power steering
fluid will be at the right temperature when
the engine coolant temperature gauge in the
instrument cluster is near the center of the
NORMAL operating temperature range.
*
[SV38000(ALL)01/95]
2. While the engine idles, turn the steering
wheel back and forth several times. Make
sure that the cap assembly is installed at this
time.
*
[SV38100(ALL)05/95]
3. Turn the engine off.
%*
[SV38200(ALL)03/94]
4. Check the fluid level on the dipstick (which
is highlighted in yellow in your vehicle). The
fluid level should be between the arrows in
the FULL HOT range, which is marked on
the side of the dipstick, opposite the side
marked FULL COLD. Do not add fluid if the
level is within the FULL HOT range.
File:15cpsva.ex
Update:Tue Aug 29 17:51:51 1995

Index 363
Cleaning your vehicle (continued)
rustproofing.............. 9
safety belts............... 23
tail lamps.............. 102
upholstery and interior trim...... 142
washing................ 8
waxing................ 8
wheels................ 303
windows............... 100
Climate control system.......... 91
air conditioning............ 92
heating only system........... 95
Clock...............155, 171
Clutch, specifications.......... 338
Cold engine starting............ 65
Combination lap and shoulder belts . . 11, 13
Compact disc player
(see Electronic sound system)..... 156
Compact disc radio
(see Electronic sound system)..... 150
Console, description........... 145
Controls
instrument panel............ 89
mirrors............... 144
steering column........... 109
Coolant (see Engine coolant)....... 284
checking and adding......... 284
drain and flush............ 289
preparing for storage......... 344
proper solution............ 286
refill capacities..........289, 335
specifications............. 338
temperature gauge........... 85
warnings............... 284
Cruise control (see Speed control).... 115
File:cpixa.ex
Update:Tue Aug 29 17:47:05 1995