1996 FORD AEROSTAR tow

221
*
[DR39000(ALL)08/95]
Trailer Towing Tips
*
[DR39100(ALL)11/89]
Before starting on a trip, practice turning,
stopping and backing in an area away from
heavy traffic. Get to know the ªfeelº of the
vehicle/trailer combination.
*
[DR39200(ALL)05/90]
Practice backing up. Back up very slowly, with
someone outside at the rear of your trailer to
guide you. Place your hand at the bottom of the
steering wheel and move it in the direction you
want the rear of the trailer to swing. Slight
movement of the steering wheel results in a
much larger movement of the rear of the trailer.
*
[DR39300(ALL)11/89]
Allow more room for stopping with a trailer
attached. Trailer brakes should be applied first,
whether manually or automatically controlled,
when approaching a stop.
*
[DR39400(ALL)11/89]
For a good handling truck-trailer combination,
the trailer tongue load should be approximately
10-15% of the loaded trailer weight.
*
[DR39500(ALL)05/95]
Make a thorough check of your equipment
before starting out on the road. After you have
traveled about 50 miles (80 km) stop in a
protected area and double-check your hitch and
electrical connections. Also check trailer wheel
lug nuts for tightness.
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995

222
*
[DR39600(ALL)11/89]
When turning, drive slightly beyond the normal
turning point so the trailer wheels will clear
curbs or other obstructions.
*
[DR39725(ALL)03/95]
When stopped in traffic for long periods of time
in hot weather, place the gearshift selector lever
in P (PARK) to increase the engine idle speed.
This aids in engine cooling and air conditioner
efficiency. If the engine overheats, move the
function selector knob to VENT to stop the
compressor and increase the engine speed for a
short time.
*
[DR39800(ALL)05/90]
RWARNING
Do not tow a trailer when using a
temporary spare tire.
*
[DR39900(ALL)05/90]
Vehicles with trailers should not be parked on a
grade. However, if you must park on a grade,
place wheel chocks under the trailer's wheels as
follows:
*
[DR40000(ALL)05/95]
q
Apply the brake pedal and hold.
*
[DR40100(ALL)11/89]
q
Have another person place the wheel chocks
under the trailer wheels.
*
[DR40200(ALL)08/95]
q
With the chocks in place, release the brake
pedal, making sure the chocks are holding.
[DR40350(ALL)08/95]
q
Apply the parking brake by pressing the
brake pedal down firmly with your right foot
while applying the parking brake with your
right hand.
*
[DR40575(ALL)06/95]
q
Shift the gearshift lever into P (Park).
File:10cpdra.ex
Update:Tue Aug 29 17:45:28 1995

231
*
[RE04300(ALL)01/95]
When you drive with the temporary spare tire,
DO NOT:
*
[RE04400(ALL)01/95]
q
exceed 50 mph (80 km/h) under any
circumstances.
*
[RE04500(ALL)01/95]
q
load your vehicle so that it is heavier than
the maximum vehicle load rating listed on
the tire decal.
*
[RE04600(ALL)01/95]
q
tow a trailer.
*
[RE04700(ALL)01/95]
q
use tire chains on this tire.
*
[RE04800(ALL)01/95]
q
try to repair the temporary spare tire or
remove it from its wheel.
*
[RE04900(ALL)01/95]
q
use the wheel for any other type of vehicle.
*
[RE05000(ALL)01/95]
q
drive through an automatic car wash with
this tire. Because the temporary spare tire is
smaller than a conventional tire, it reduces
the ground clearance. Your vehicle may get
caught in the rails and it could be damaged.
%*
[RE05100(ALL)03/95]
Spare Tire Location
[RE05200(ALL)03/95]
If your vehicle is a standard length van model,
the spare tire is mounted inside a carrier at the
left rear quarter panel. To remove the spare tire,
remove the wing nut and plate. A flat tire can
be temporarily stowed in the same location.
[RE05300(ALL)01/89]
quarter page art:0020264-A
A side mounted spare tire
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

232 [RE05400(ALL)05/94]If your vehicle is the model with a standard
length body or extended length (all models), the
temporary spare tire is stowed at the rear of the
vehicle under the body.
[RE05450(ALL)05/94]
The standard length E-4WD model spare tire is
mounted on the floor.
[RE05500(ALL)08/95]
To remove underbody temporary spare tire:
[RE05600(ALL)11/89]
1. Insert lug nut wrench into the actuator hole
and turn counterclockwise until the cable
extends to allow the spare tire to be pulled
rearward from under the vehicle.
*
[RE05700(ALL)10/94]
2. Slide the spare tire to the rear and remove
the retainer from the wheel.
[RE05800(ALL)11/89]
3. To stow cable/retainer with spare tire
removed, insert cable fitting into carrier rear
wall slot, place wheel retainer against the
carrier, and turn lug nut wrench clockwise
until slack is removed.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

234 [RE06000(ALL)08/95]To stow underbody temporary spare tire:
[RE06100(ALL)11/89]
1. Insert lug nut wrench into the actuator hole
and turn counterclockwise until the
cable/retainer is extended for insertion into
the wheel.
*
[RE06200(ALL)10/94]
2. Install the retainer through wheel center
with valve stem facing up.
[RE06300(ALL)11/89]
3. Rotate wrench clockwise until tire is secured.
(Raising mechanism will slip.)
*
[RE06400(ALL)03/91]
4. Check for proper seating against underbody
supports and retighten if necessary.
[RE06500(ALL)11/89]
half page art:0020266-B
Spare tire Ð underbody carrier
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

235 [RE06600(ALL)05/95]
RWARNING
Do not stow any conventional spare tire
or flat temporary spare tire in the
underbody position. Doing so may cause
damage to the tire, rear axle, or brake
lines. (Standard length only)
[RE06800(ALL)01/89]
A flat tire can be temporarily secured to the
floor pan under the rear-most seat. To
temporarily secure a flat tire:
[RE06900(ALL)01/89]
1. Remove the spare tire ªJº bolt, plate and
wing nut from their stowed location on the
jack.
[RE07000(ALL)01/89]
2. Position the flat tire, valve stem up, under
the rear-most seat and over the ªJº bolt
attaching bracket on the floor pan.
[RE07100(ALL)01/89]
3. Insert the ªJº hook bolt through the center of
the wheel and hook on bracket.
[RE07200(ALL)06/95]
4. Install plate over ªJº hook bolt and secure
with wing nut.
[RE07300(ALL)05/89]
quarter page art:0020267-A
Stowed position of ªJº bolt, plate and wing nut (Standard
length model)
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

236 [RE07400(ALL)05/89]
one third page art:0020268-AFlat tire stowage (Standard length model)
[RE07600(ALL)08/95]
half page art:0020270-A
Extended van underbody outside spare wheel/flat tire
storage
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995

237
*
[RE15100(ALL)05/95]
RWARNING
Make sure the spare tire and jacking
equipment are stowed and secured in the
proper storage location.
%*
[RE15200(ALL)03/95]
Preparing to Change the Tire
*
[RE15250(ALL)12/91]
NOTE: To lift your vehicle by other than the
front or rear jacking points, be sure to
use only hoist adapters with a wide
contact surface.
*
[RE15325(ALL)03/95]
1. Make sure that your vehicle will not move
or roll. Put the gearshift in P (Park). Set the
parking brake and block the wheel that is
diagonally opposite the tire that you are
changing.
*
[RE15335(ALL)12/91]
NOTE: Make sure the ignition is in the OFF
position.
*
[RE15420(ALL)06/95]
When one of the back wheels is off the ground,
the transmission alone will not prevent the
vehicle from moving or slipping off the jack,
even if the vehicle is in P (Park). To prevent the
vehicle from moving when you change a tire, be
sure the parking brake is set, then block the
wheel (both directions) that is diagonally
opposite (other side and end of the vehicle) to
the tire being changed.
*
[RE15430(ALL)05/95]
RWARNING
If the vehicle slips off the jack, you or
someone else could be seriously injured.
File:12cprea.ex
Update:Tue Aug 29 17:46:27 1995