1996 CHRYSLER VOYAGER airbag

CENTER MESSAGE
5LAMP WARNING
ABS
AIRBAG
WARNING
LAMP
11
10
ST-RUN A21
20A
FUSE
6
DRIVER 16
ABS
WARNING
LAMP
BRAKE ANTI-LOCK
CONTROLLER
R41
18
BK/TN
BLOCK JUNCTION
C2
7
MODULE CONTROL
AIRBAG
AIRBAG
WARNING
LAMP
DRIVER
G19
20
LG/OR
A3
P34
G19
18
LG/OR
B23
14C4
BR/PK18 V23
C110
V23
18
BR/PK
C2
BODY
CONTROL
LAMP WARNINGABS
17
DRIVER
MODULE
G19
20
LG/OR
ENGINE
COOLANT
TEMPERATURE
6
LAMP
VT22 G2
LAMP 6
ENGINE
TEMPERATURE
C2
DRIVER
LAMP
8PRESSURE OIL
LOW
SENSE
C2
PRESSUREOIL ENGINE
33
SWITCHG6
22
GY
OIL
PRESSURE
SWITCH
SENSE
52C1
1
E36 B331
G6
16
GY
SWITCH PRESSURE
OIL
ENGINE
POWER
DISTRIBUTION
CENTER
C35
28FUSE10A
MEMORY
SEAT/
MODULE MIRROR
VTSS
LAMP
(ST-RUN) IGNITIONFUSED
A/C
CONTROL
12
BATT A0
13
16
VTSS
DRIVER
C2
LAMP
BK/OR22 G69
16C1
FUSED
B (+)
C46
13C1
M1
20
PK
M1
20
PK
M1
20
PK
3
HEATER
B (+) FUSED 3
ENTRY
MODULE KEYLESS REMOTE
M1 20PK
*8
*7 *9 *12 *1 *2
* RHDDIESEL GAS
9B33
E36
G6 20GY
7P50
NOT
USED
M1
22
PK
WARNINGENGINE (8W-12-9)(8W-10-16)
(8W-35-3)(8W-12-2)
(8W-43-3)
(8W-45-5)
(8W-45-6)(8W-10-9)
(8W-10-11)
(8W-62-3)
(8W-63-4)
(8W-42-4)(8W-10-8)
(8W-61-5) (8W-12-20)
8W - 46 - 2 8W-46 MESSAGE CENTERNS/GS
J988W-3GS004602

8W-80 CONNECTOR PIN-OUTS
Component Page
A/C Heater Control - C1................8W-80-5
A/C Heater Control - C2................8W-80-5
A/C Compressor Clutch.................8W-80-5
A/C Pressure Transducer (Gas)...........8W-80-6
A/C Pressure Transducer (Diesel).........8W-80-6
A/C Zone Door Actuator.................8W-80-6
Accelerator Pedal Position Sensor (Diesel) . .8W-80-6
Airbag Control Module - C1.............8W-80-6
Airbag Control Module - C2.............8W-80-7
All Wheel Drive Solenoid - C1............8W-80-7
All Wheel Drive Solenoid - C2............8W-80-7
Ambient Air Temperature Sensor.........8W-80-7
Ash Receiver Lamp (LHD)...............8W-80-8
Ash Receiver Lamp (RHD)..............8W-80-8
Automatic Day/Night Mirror.............8W-80-8
B09 HS5D...........................8W-80-9
B09S02.............................8W-80-9
B13AW4............................8W-80-9
B17 LJ01............................8W-80-9
B23P18............................8W-80-10
B23P34............................8W-80-11
B33 E120...........................8W-80-12
B33E36............................8W-80-12
B56 HS5P..........................8W-80-12
B56S02............................8W-80-12
B70E43............................8W-80-13
B75C20............................8W-80-13
B98T08............................8W-80-14
B99T05............................8W-80-14
Back-Up Switch......................8W-80-14
Blend Door Actuator..................8W-80-14
Body Control Module - C1..............8W-80-15
Body Control Module - C2..............8W-80-16
Brake Pressure Switch................8W-80-16
C19EC1 ...........................8W-80-17
Camshaft Position Sensor..............8W-80-17
Center Dome Lamp...................8W-80-17
Center High Mounted Stop Lamp........8W-80-17
Clockspring - C1.....................8W-80-18
Clockspring - C2.....................8W-80-18
Clutch Interlock Switch................8W-80-18
Clutch Interlock Switch Jumper.........8W-80-18
Clutch Switch.......................8W-80-18
Controller Anti-Lock Brake.............8W-80-19
Crank Case Heater...................8W-80-19
Crankshaft Position Sensor.............8W-80-19
D01D B02..........................8W-80-20
D01P B03..........................8W-80-20
D02B01 ...........................8W-80-20
D02 B120 (LHD).....................8W-80-21
D02 B120 (RHD).....................8W-80-21
Data Link Connector..................8W-80-22Component Page
Downstream Heated Oxygen Sensor......8W-80-22
Driver Door Arm/Disarm Switch.........8W-80-22
Driver Door Courtesy Lamp............8W-80-22
Driver Door Lock Motor................8W-80-23
Driver Door Lock Switch...............8W-80-23
Driver Heated Seat Back...............8W-80-23
Driver Heated Seat Cushion............8W-80-23
Driver Heated Seat Module.............8W-80-23
Driver Heated Seat Switch.............8W-80-24
Driver Power Mirror - C1..............8W-80-24
Driver Power Mirror - C2..............8W-80-24
Driver Power Seat Switch..............8W-80-25
Driver Power Window Switch...........8W-80-25
Driver Seat Front Vertical Motor.........8W-80-25
Driver Seat Horizontal Motor...........8W-80-25
Driver Seat Rear Vertical Motor.........8W-80-26
Driver Seat Recliner Motor.............8W-80-26
Driver Window Motor.................8W-80-26
E40RF3 ...........................8W-80-26
E69F09............................8W-80-27
E78F02............................8W-80-27
E95 B107...........................8W-80-27
E96 B108...........................8W-80-28
E97 B106...........................8W-80-28
EGR Solenoid (2.4L MTX/3.3L/3.8L)......8W-80-28
EGR Solenoid (Diesel).................8W-80-28
Electric Wiper De-Icer - C1.............8W-80-29
Electric Wiper De-Icer - C2.............8W-80-29
Engine Coolant Temperature Sensor
(Diesel)..........................8W-80-29
Engine Coolant Temperature Sensor
(Gas)............................8W-80-29
Engine Oil Pressure Switch.............8W-80-29
Engine Speed Sensor (Diesel)...........8W-80-30
Evap Leak Detection Pump
(Except Built-Up-Export).............8W-80-30
Evap/Purge Solenoid..................8W-80-30
Evaporator Temperature Sensor.........8W-80-30
Flexible Fuel Sensor..................8W-80-30
Front Blower Motor...................8W-80-31
Front Blower Motor Resistor Block.......8W-80-31
Front Cigar Lighter/Power Outlet........8W-80-31
Front Reading Lamps/Switch...........8W-80-32
Front Reading Lamps/Switch
(Overhead Console).................8W-80-32
Front Washer Motor..................8W-80-32
Fuel Heater.........................8W-80-32
Fuel Injector No. 1 (2.0L/2.4L)...........8W-80-33
Fuel Injector No. 1 (3.3L/3.8L)...........8W-80-33
Fuel Injector No. 2 (2.0L/2.4L)...........8W-80-33
Fuel Injector No. 2 (3.3L/3.8L)...........8W-80-33
Fuel Injector No. 3 (2.0L/2.4L)...........8W-80-33
NS/GS8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 1

Component Page
P30 J01D...........................8W-80-60
P50 ...............................8W-80-61
Park/Neutral Position Switch (EATX).....8W-80-61
Park/Neutral Position Switch (MTX)......8W-80-61
Passenger Airbag Squib................8W-80-61
Passenger Door Arm/Disarm Switch......8W-80-61
Passenger Door Courtesy Lamp..........8W-80-62
Passenger Door Lock Motor.............8W-80-62
Passenger Door Lock Switch............8W-80-62
Passenger Heated Seat Back............8W-80-62
Passenger Heated Seat Cushion.........8W-80-62
Passenger Heated Seat Module..........8W-80-62
Passenger Heated Seat Switch..........8W-80-63
Passenger Power Mirror C1.............8W-80-63
Passenger Power Mirror C2.............8W-80-63
Passenger Power Seat Switch...........8W-80-64
Passenger Power Window Switch........8W-80-64
Passenger Seat Front Vertical Motor......8W-80-64
Passenger Seat Horizontal Motor........8W-80-64
Passenger Seat Rear Vertical Motor......8W-80-65
Passenger Seat Recliner Motor..........8W-80-65
Passenger Window Motor..............8W-80-65
Power Distribution Center - C1..........8W-80-65
Power Distribution Center - C2..........8W-80-66
Power Distribution Center - C3..........8W-80-66
Power Distribution Center - C4..........8W-80-67
Power Distribution Center - C5..........8W-80-67
Power Distribution Center - C6..........8W-80-67
Power Distribution Center - C7..........8W-80-68
Power Distribution Center - C8..........8W-80-68
Power Folding Mirror Switch...........8W-80-68
Power Mirror Switch..................8W-80-68
Power Seat Circuit Breaker.............8W-80-68
Powertrain Control Module (Diesel)......8W-80-69
Powertrain Control Module - C1.........8W-80-71
Powertrain Control Module - C2.........8W-80-72
PRNDL Feed........................8W-80-72
PRNDL Switch......................8W-80-73
Radiator Fan Disconnect...............8W-80-73
Radiator Fan No. 1...................8W-80-73
Radiator Fan No. 2...................8W-80-73
Radiator Fan Relay (Gas)..............8W-80-73
Radiator Fan Relay No. 1 (Diesel)........8W-80-74
Radiator Fan Relay No. 2 (Diesel)........8W-80-74
Radiator Fan Relay No. 3 (Diesel)........8W-80-74
Radio - C1..........................8W-80-74
Radio - C2..........................8W-80-75Component Page
Radio - C3..........................8W-80-75
Radio Choke........................8W-80-75
Rear A/C Heater Unit.................8W-80-75
Rear Blower Front Control Switch.......8W-80-76
Rear Blower Rear Control Switch........8W-80-76
Rear Cigar Lighter/Power Outlet.........8W-80-76
Rear Dome Lamp....................8W-80-77
Rear Washer Motor...................8W-80-77
Rear Wiper Motor....................8W-80-77
Recirculation Door Actuator............8W-80-77
Remote Keyless Entry Module...........8W-80-77
Right Combination Relay...............8W-80-78
Right Door Speaker...................8W-80-78
Right Fog Lamp (Built-Up-Export).......8W-80-78
Right Fog Lamp (Except Built-Up-Export) .8W-80-78
Right Front Panel Speaker.............8W-80-78
Right Front Park/Turn Signal Lamp
(Built-Up-Export)..................8W-80-79
Right Front Park/Turn Signal Lamp
(Except Built-Up-Export)............8W-80-79
Right Front Speaker..................8W-80-79
Right Front Wheel Speed Sensor.........8W-80-79
Right Headlamp (Built-Up-Export).......8W-80-79
Right Headlamp (Except Built-Up-Export) .8W-80-80
Right Headlamp Leveling Motor
(Built-Up-Export)..................8W-80-80
Right High Headlamp (Chrysler)
(Except Built-Up-Export)............8W-80-80
Right Liftgate Flood Lamp.............8W-80-80
Right Low Headlamp (Chrysler)
(Except Built-Up-Export).............8W-80-80
Right Mid Reading Lamp..............8W-80-81
Right Rear Door Ajar Switch............8W-80-81
Right Rear Lamp Assembly
(Built-Up-Export)..................8W-80-81
Right Rear Lamp Assembly
(Except Built-Up-Export).............8W-80-81
Right Rear Pillar Speaker..............8W-80-81
Right Rear Reading Lamp..............8W-80-81
Right Rear Sliding Door Contacts........8W-80-82
Right Rear Speaker...................8W-80-82
Right Rear Vent Motor (LHD)...........8W-80-82
Right Rear Vent Motor (RHD)...........8W-80-82
Right Rear Wheel Speed Sensor.........8W-80-82
Right Repeater Lamp.................8W-80-82
Right Stop/Turn Signal Relay...........8W-80-83
Right Visor/Vanity Mirror Lamps........8W-80-83
NS/GS8W - 80 CONNECTOR PIN-OUTS 8W - 80 - 3

FUNCTION
-CIRCUIT
-SENSOR GROUND
5 VOLT SUPPLY
AC PRESSURE SIGNALCAV
1
2
3
4K4 18BK/LB
K6 18VT/WT
C18 18DB
FUNCTION
-CIRCUIT
-SENSOR GROUND
5 VOLT SUPPLY
A/C PRESSURE SIGNALCAV
1
2
3
4K4 20BK/LB
K7 20OR
C18 20DB
GRAY
21
43
FUNCTIONCIRCUIT
DUAL ZONE A/C ACTUATOR (+/-)
SENSOR GROUND
ZONE DOOR FEEDBACK SIGNAL
5 VOLT SUPPLY
DUAL ZONE A/C ACTUATOR (+/-)CAV
1
2
3
4
5C61 20DB
C57 20DB/GY
C102 20LG
C26 20PK/DB
C62 20DB/PKNATURAL
1 5
FUNCTION
CIRCUIT
PASSENGER AIRBAG LINE NO. 1
PASSENGER AIRBAG LINE NO. 2
DRIVER AIRBAG LINE NO. 1
DRIVER AIRBAG LINE NO. 2CAV
1
2
3
4R42 18BK/YL
R44 18DG/YL
R43 18BK/LB
R45 18DG/LB
1
3 2
4
GRAY
14
YELLOW
A/C
PRESSURE
TRANSDUCER
(GAS)
A/C
ZONE DOOR
ACTUATOR
AIRBAG
CONTROL
MODULE - C1(DIESEL) TRANSDUCERPRESSUREA/C
105
6 1
(DIESEL)SENSOR
- -- -- -- -
CIRCUIT FUNCTION
CAV
1
2
3K4 20BK/LB SENSOR GROUND
6K151 20WT LOW IDLE POSITION SWITCH
54
ACCELERATOR PEDAL SENSOR SIGNAL K22 20OR/DB
7
8K167 20BR/YL
9
K6 20VT/WT
10
ACCELERATOR
PEDAL POSITION
- -
ACCELERATOR PEDAL SENSOR GROUND
5 VOLT SUPPLY BLACK
(DUAL ZONE A/C)
8W - 80 - 6 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8006

FUNCTION
-
-
-
-
-
-
-CIRCUIT
-
-
-
-
-
-
-FUSED IGNITION (ST-RUN)
FUSED IGNITION (RUN)
CCD BUS(+)
CCD BUS(-)
AIRBAG WARNING LAMP DRIVER
GROUNDCAV
1
2
3
4
5
6
7
8
9
10
11
12
13F14 18LG/YL
F23 18 DB/YL
D1 20VT/BR
D2 20WT/BK
R41 18BK/TN
Z2 18BK/LG
7
BLACK
FUNCTION
CIRCUIT
AMBIENT TEMPERATURE SENSOR SIGNAL
SENSOR GROUNDCAV
1
2G31 20VT/LG
G32 20BK/LB
GRAY
21
FUNCTIONCIRCUIT
GROUND
BACK-UP LAMP FEEDCAV
1
2Z1 18BK
L1 18VT/BK
GRAY
21
13
16
21GROUND
BACK-UP LAMP FEED CIRCUIT
Z1 18BK
L1 18VT/BK CAV
2 1
FUNCTION GRAY
AIRBAG
CONTROL
MODULE - C2
ALL WHEEL
DRIVE
SOLENOID - C1
(3.8L ONLY)
AMBIENT AIR
TEMPERATURE
SENSOR (3.8L ONLY) SOLENOID - C2DRIVE ALL WHEEL
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 7
NSGS8007J988W-3

GROUND Z1 20BK
SWITCH
(DIESEL)CLUTCH
RED
CLUTCH SWITCH CIRCUIT FUNCTION
CAV
K119 20LG/BK
1
2
1 2
IGNITION SWITCH OUTPUT (START) T141 20YL/RD
2
1F45 20YL/RD CAV FUNCTION CIRCUIT
FUSED B(+) ENGINE STARTER MOTOR RELAY
BLACK
12
4NATURAL1
V37 20RD/LG Z2 20BK/LG X3 20BK/RD
4 3 2 1 CAV SPEED CONTROL SWITCH SIGNAL
GROUND HORN RELAY DRIVER
- CIRCUIT
- FUNCTION
12YELLOW
R45 18DG/LB R43 18BK/LB
2 1 CAV DRIVER AIRBAG LINE NO.2
DRIVER AIRBAG LINE NO.1 CIRCUIT
FUNCTION
CLOCKSPRING - C2CLOCKSPRING - C1
2 1BLACKCIRCUIT FUNCTION
CAV
1
2T141 20YL/RD IGNITION SWITCH OUTPUT (START)
CLUTCH
INTERLOCK
SWITCH
(MTX)
CLUTCH
INTERLOCK
SWITCH
JUMPER
(EATX)
T141 20YL/RD IGNITION SWITCH OUTPUT (START)
8W - 80 - 18 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8018

(LHD) MESSAGE CENTER
* DIESEL WAIT-TO START WARNING LAMP DRIVER G85 20OR/BK * 7
BLUE
7 1
136
G69 22BK/OR M1 20PK
R41 18BK/TN V23 18BR/PK G9 20GY/BK
G6 22GY G3 20BK/PK G2 22VT
G19 20LG/OR L62 18BR/RD Z1 20BK
L63 18DG/RD L34 20RD/OR
13 12 11 10 9 8 7 6 5 4
3 2 1 CAV VTSS INDICATOR LAMP DRIVER
FUSED B (+)
AIRBAG WARNING LAMP DRIVER FUSED IGNITION (ST-RUN) RED BRAKE WARNING LAMP DRIVER
ENGINE OIL PRESSURE SWITCH SENSE SERVICE ENGINE SOON INDICATOR LAMP DRIVER ENGINE TEMPERATURE WARNING LAMP DRIVER
ABS WARNING LAMP DRIVER RIGHT TURN SIGNAL GROUND
LEFT TURN SIGNAL FUSED HIGH BEAM RELAY OUTPUT CIRCUIT
FUNCTION
SWITCH MEMORY SET
BLUE564
1 2 3
P23 20PK/RD P22 20PK/BK P24 20PK/WT Z1 20BK
6 5 4 3 2
1 CAV MEMORY NO. 2 MEMORY SET MEMORY NO. 1 GROUND - - CIRCUIT
- - FUNCTION
MODULE - C3 MEMORY SEAT/MIRROR
21 10
11 NATURAL
1
P29 20BR/WT P25 22VT/RD P47 22LB P40 22GY/LB P15 22YL/LB
P11 22YL/WT P19 22YL/LG P9 20RD
P28 20BR/RD P26 22BR P27 22LB/RD P48 22GY/WT P17 22RD/LB P13 22RD/WT
P21 22RD/LG
21 20 19
18 17 16
15 14 13
12 11 10 9 8 7
6
5 4 3
2 1 CAV 6 VOLT SUPPLY SEAT HORIZONTAL POSITION SENSE SEAT RECLINER POSITION SENSE SEAT RECLINER (FORWARD) SEAT HORIZONTAL (FORWARD) SEAT REAR VERTICAL (UP) SEAT FRONT VERTICAL (UP)
FUSED B (+) SEAT POSITION SENSE COMMON SEAT FRONT VERTICAL POSITION SENSE SEAT REAR VERTICAL POSITION SENSE SEAT RECLINER (REARWARD) SEAT HORIZONTAL (REARWARD)
SEAT REAR VERTICAL (DOWN)
SEAT FRONT VERTICAL (DOWN)
- - - - - - CIRCUIT
- - - - - - - FUNCTION
8W - 80 - 58 8W-80 CONNECTOR PIN-OUTSNS/GS
J988W-3NSGS8058

SWITCH MULTI-FUNCTION
8 127BLACK
1
L324 22WT/LG V10 20BR
L94 20OR/WT L93 22PK Z1 18BK
F1 20DB V52 20DG//YL V16 20WT
L305 22LB/WT L302 22LB/YL L91 22DB/PK
12 11 10 9 8 7
6
5 4 3 2 1 CAV HIGH BEAM RELAY CONTROL
FRONT WASHER MOTOR CONTROL LOW BEAM RELAY CONTROL HIGH/LOW BEAM RELAY CONTROL
GROUND FUSED B(+) WIPER MUX SIGNAL
HIGH SPEED RELAY DRIVER RIGHT TURN SIGNAL SENSE LEFT TURN SIGNAL SENSE COMBO FLASHER SWITCHED GROUND
- CIRCUIT
- FUNCTION
ACTUATOR MODE DOOR
5BLACK1
C35 20DG/YL C57 20DB/GY C37 20YL
C26 20PK/DB
C34 20DB/WT
5 4
3 2 1 CAV MODE DOOR DRIVER SENSOR GROUND MODE DOOR FEEDBACK SIGNAL
5 VOLT SUPPLY DOOR COMMON CIRCUIT
FUNCTION
FUSED RIGHT HIGH BEAM OUTPUT L34 20RD/OR7 131 6ENGINE TEMPERATURE WARNING LAMP DRIVER CIRCUIT FUNCTION
CAV
G2 22VT
1
2G19 20LG/OR
3L63 18DG/RD LEFT TURN SIGNAL
6L62 18BR/RD RIGHT TURN SIGNALSGROUND Z1 20BK
54
G69 22BK/OR
7
8M1 20PK
9R41 18BK/OR
V23 18BR/PK
10
13G3 20BK/PKENGINE OIL PRESSURE SWITCH SENSE G6 22GY
12G9 20GY/BK RED BRAKE WARNING LAMP DRIVER
11ABS WARNING LAMP DRIVER
FUSED B(+)
FUSED IGNITION (ST-RUN)
(RHD) MESSAGE CENTER
VTSS INDICATOR LAMP DRIVER
AIRBAG WARNING LAMP DRIVER
SERVICE ENGINE SOON INDICATOR LAMP DRIVER
NS/GS8W-80 CONNECTOR PIN-OUTS 8W - 80 - 59
NSGS8059J988W-3