1995 JEEP YJ hood release

HOOD REMOVAL
(1) Raise hood.
(2) Disconnect the underhood lamp wire harness
connector, if equipped (Fig. 13).
(3) Drill out and remove the rivets that attach the
hood release cable bellcrank to the hood (Fig. 14).
(4) Disconnect the bellcrank from the latch con-
necting rod and the release cable. Remove the
bellcrank from the hood.
(5) Remove the latch release cable clips and re-
move the cable from the hood (Fig. 12).
(6) Remove the screws that attach the latches to
the hood (Fig. 15).
(7) Disconnect the latches from the hood and latch
connecting rod. Remove the latches from the hood.
(8) Remove the nuts that attach the safety latch to
the hood. Remove the safety latch from the hood.
(9) Remove the clips and latch connecting rod from
the hood.
(10) Mark the location of hood, the hinges and the
hinge shims for installation (Fig. 16).(11) Remove the screws that attach the hinges to
the hood. Remove the hood from the vehicle with the
aid of a helper.
(12) Remove the insulation panel from the hood
(Fig. 17).
HOOD INSTALLATION
(1) Install the insulation panel on the hood.
(2) Position the hood on the shims and hinges; fin-
ger-tighten the hinge bolts.
(3) Align the hinges and shims with the reference
marks. Tighten the hinge bolts to 30 Nzm (22 ft-lbs)
torque.
(4) Connect the latch release cable and latch con-
necting rod to the bellcrank.
(5) Position the bellcrank on the hood and install
the rivets.
Fig. 13 Underhood Lamp
Fig. 14 Hood Release Cable Bellcrank
Fig. 15 Hood Latch & Safety Latch
Fig. 16 Hood Hinges and Support Rod
JEXTERIOR COMPONENTSÐXJ 23 - 9

(6) Attach the latch release cable to the clips.
(7) Connect the latches to the latch rod and posi-
tion them on the hood.
(8) Install the screws to attach the latches to the
hood.
Tighten the screws to 9 Nzm (77 in-lbs) torque.
(9) Position the safety latch on the hood and install
the attaching nuts. Tighten the screws to 13 Nzm
(115 in-lbs) torque.
(10) Test latch release cable and latches for proper
operation.
(11) Connect the underhood lamp wire harness
connector.
(12) Inspect the hood for proper alignment and ad-
just as necessary.
HOOD ADJUSTMENTÐXJ
The hood bolt holes are elongated for fore and aft
and side-to-side adjustment.
(1) If hood is low to the cowl panel, insert shims
between the hinge and hood at the rear hinge bolts.
(2) Adjust the hood bumper (Fig. 18) in or out to
provide proper hood-to-fender height alignment.
(3) Adjust the hood strikers (Fig. 19) with shims as
necessary. Tighten the screws to 22 Nzm (16 ft-lbs)
torque after adjustment.
(4) Align each latch and striker so that the striker
enters latch squarely.
HOOD HINGE REPLACEMENTÐXJ
REMOVAL
(1) Remove the hood from the vehicle.
(2) Remove the seal from the hinge base (Fig. 20).
(3) Remove the hinge retaining nuts from the
studs.
(4) Remove the restraint cable and hinge from the
cowl panel.
INSTALLATION
(1) Position the hinge over the studs and place the
restraint cable on the right side, lower stud.
Fig. 17 Hood Insulation PanelFig. 18 Hood Bumper
Fig. 19 Hood Latch Striker
Fig. 20 Hood Hinge and Seal
23 - 10 EXTERIOR COMPONENTSÐXJJ

(2) Install the hinge nuts on the studs. Tighten the
restraint cable nut to 4 Nzm (38 in-lbs) torque.
Tighten the remaining nuts to 9 Nzm (77 in-lbs)
torque.
If a replacement hinge seal is being installed,
position it around the hinge arm, force it
against the hinge base.
(3) Position the hinge seal around the hinge arm
and on hinge base.
(4) Install the hood.
(5) Adjust the hood as necessary.
HOOD LATCH REPLACEMENTÐXJ
REMOVAL
(1) Remove the screw that attaches the latch to the
hood inner panel (Fig. 15).
(2) Disconnect the latch from the hood and latch
connecting rod. Remove the latch from the hood.
INSTALLATION
(1) Connect the latch to the latch connecting rod
and position it on the hood inner panel.
(2) Install the screw that attaches the latch to the
hood inner panel.
(3) Tighten the screw to 9 Nzm (77 in-lbs) torque.
(4) Test the operation of the latch release cable and
latch.
HOOD LATCH STRIKER REPLACEMENTÐXJ
REMOVE
(1) Remove the grille opening panel (GOP).
(2) Remove the screws that attach the striker to
the radiator baffle (Fig. 19).
(3) Remove the striker and shims from the baffle.
INSTALLATION
(1) Position the shims and striker on the radiator
baffle and install the screws.
(2) Tighten the screws to 21 Nzm (15 ft-lbs) torque.
(3) Test the striker/hood alignment by opening and
closing the hood several times. Adjust the striker, if
necessary.
LATCH RELEASE CABLE REPLACEMENTÐXJ
REMOVAL
(1) Drill out the bellcrank to hood rivet heads and
remove the rivets (Fig. 14).
(2) Disconnect the bellcrank from the latch rod and
the latch release cable. Remove the bellcrank from
the hood.
(3) Disconnect the latch release cable from the
clips on the hood.
(4) Remove the left cowl side trim panel.
(5) Remove the cable bracket screws from the cowl
side panel.(6) Pull the cable through the dash panel and re-
move it from under the instrument panel.
INSTALLATION
(1) Insert the replacement cable end through the
hole in the dash panel into the engine compartment.
(2) Pull the cable forward and seat the grommet in
the dash panel.
(3) Position the cable bracket on the cowl side
panel and install the screws. Tighten the screws to
13 Nzm (111 in-lbs) torque.
(4) Install the left cowl side trim panel.
(5) Connect the cable and latch rod to the
bellcrank.
(6) Position the bellcrank on the hood and install
the rivets.
(7) Attach the cable to the clips.
(8) Test release the cable for proper operation.
SAFETY LATCH STRIKER REPLACEMENTÐXJ
REMOVAL
(1) Remove the striker screws from the radiator
support crossmember (Fig. 21).
(2) Remove the striker from the crossmember.
INSTALLATION
(1) Position the striker on the radiator support
crossmember and install the screws. Tighten the
screws to 9 Nzm (77 in-lbs) torque.
(2) Test the safety latch operation.
COWL WEATHERSTRIP SEAL/CROSSMEMBER AIR
DEFLECTORÐXJ
WEATHERSTRIP SEAL REPLACEMENT
(1) Pry upward along the length of seal (Fig. 22).
(2) Detach the seal retainers from the cowl panel.
(3) Remove the seal from cowl panel.
Fig. 21 Hood Safety Latch StrikerÐ2.5L Engine
(Typical)
JEXTERIOR COMPONENTSÐXJ 23 - 11

EXTERIOR COMPONENTS
INDEX
page page
Battery TrayÐYJ......................... 110
Body Side Step MoldingÐYJ................ 115
Body Stripes/DecalsÐYJ................... 116
Cowl Grille and ScreenÐYJ................ 109
Cowl Weatherstrip SealÐYJ................ 109
Exterior Nameplates (Adhesive-Backed)ÐYJ.... 120
External Spare/Wheel Tire CarrierÐYJ........ 133
Fender FlareÐYJ........................ 114
Fender Inner Splash ShieldsÐYJ............. 116
Fender Splash ApronsÐYJ................. 115
FendersÐYJ............................ 110
Fuel Filler Protector/NozzleÐYJ............. 121
Half Metal Door Mirror (External)ÐYJ......... 121
Hard Top Liftgate GlassÐYJ................ 124
Hard Top RepairÐYJ..................... 127
Hard Top Roof VentÐYJ................... 127
Hard TopÐYJ........................... 126Hood AlignmentÐYJ...................... 107
Hood Insulator PanelÐYJ.................. 107
Hood Safety LatchÐYJ.................... 109
HoodÐYJ.............................. 107
Liftgate Glass Weatherstrip Seal ReplacementÐYJ. 125
Radiator Grille AppliqueÐYJ................ 104
Soft Top Service InformationÐYJ............. 127
Soft Top ServiceÐYJ..................... 129
Sport BarÐYJ........................... 132
Tailgate AdjustmentÐYJ................... 121
Tailgate HingeÐYJ....................... 121
Tailgate Latch and Release HandleÐYJ........ 122
Tailgate Latch StrikerÐYJ.................. 123
Tailgate Lock CylinderÐYJ................. 122
Tailgate Weatherstrip SealÐYJ.............. 123
TailgateÐYJ............................ 121
Wheelhouse Splash LinersÐYJ.............. 115
RADIATOR GRILLE APPLIQUEÐYJ
REMOVAL
(1) Raise the hood.
(2) Remove the headlamp bezels (Fig. 1).(3) Remove the headlamp bulb retainer screws
(Fig. 2).
(4) Disconnect and remove the headlamps and
buckets as a unit (Fig. 2).
Fig. 1 Grille Applique, Headlamp Bezel and Grille Panel
23 - 104 EXTERIOR COMPONENTSÐYJJ

INDEX, DIAGRAM; FRONT LIGHTING
(XJ).............................8W-50-2
INDEX, DIAGRAM; FRONT LIGHTING
(XJ-RHD).........................8W-50-3
INDEX, DIAGRAM; FRONT LIGHTING
(YJ).............................8W-50-2
INDEX, DIAGRAM; FUEL/IGNITION (YJ) . 8W-30-5
INDEX, DIAGRAM; FUSE/FUSE BLOCK
(XJ).............................8W-10-1
INDEX, DIAGRAM; FUSE/FUSE BLOCK
(XJ-RHD).........................8W-10-1
INDEX, DIAGRAM; FUSE/FUSE BLOCK
(YJ).............................8W-10-1
INDEX, DIAGRAM; GROUND
DISTRIBUTION (XJ)................8W-15-1
INDEX, DIAGRAM; GROUND
DISTRIBUTION (XJ-RHD)............8W-15-1
INDEX, DIAGRAM; GROUND
DISTRIBUTION (YJ)................8W-15-1
INDEX, DIAGRAM; HEATED REAR
WINDOW (XJ).....................8W-48-1
INDEX, DIAGRAM; HEATED REAR
WINDOW (XJ-RHD).................8W-48-1
INDEX, DIAGRAM; HEATED REAR
WINDOW (YJ).....................8W-48-1
INDEX, DIAGRAM; HORN/CIGAR
LIGHTER............................8E-1
INDEX, DIAGRAM; HORN/CIGAR
LIGHTER (YJ).....................8W-41-1
INDEX, DIAGRAM; INSTRUMENT
CLUSTER (XJ).............8W-40-1,8W-40-3
INDEX, DIAGRAM; INSTRUMENT
CLUSTER (XJ-RHD)................8W-40-3
INDEX, DIAGRAM; INSTRUMENT
CLUSTER (YJ).....................8W-40-2
INDEX, DIAGRAM; INTERIOR LIGHTING
(XJ).............................8W-44-2
INDEX, DIAGRAM; INTERIOR LIGHTING
(XJ-RHD).........................8W-44-2
INDEX, DIAGRAM; INTERIOR LIGHTING
(YJ).............................8W-44-2
INDEX, DIAGRAM; OVERHEAD CONSOLE
(XJ).............................8W-49-1
INDEX, DIAGRAM; OVERHEAD CONSOLE
(XJ-RHD).........................8W-49-1
INDEX, DIAGRAM; POWER
DISTRIBUTION (XJ)................8W-11-1
INDEX, DIAGRAM; POWER
DISTRIBUTION (XJ-RHD)............8W-11-1
INDEX, DIAGRAM; POWER
DISTRIBUTION (YJ)................8W-11-1
INDEX, DIAGRAM; POWER DOOR LOCKS
(XJ).............................8W-61-1
INDEX, DIAGRAM; POWER DOOR LOCKS
(XJ-RHD).........................8W-61-1
INDEX, DIAGRAM; POWER MIRRORS
(XJ).............................8W-62-1
INDEX, DIAGRAM; POWER MIRRORS
(XJ-RHD).........................8W-62-1
INDEX, DIAGRAM; POWER SEAT (XJ) . . 8W-63-1
INDEX, DIAGRAM; POWER SEAT
(XJ-RHD).........................8W-63-1
INDEX, DIAGRAM; POWER WINDOWS
(XJ).............................8W-60-2
INDEX, DIAGRAM; POWER WINDOWS
(XJ-RHD).........................8W-60-2
INDEX, DIAGRAM; REAR LIGHTING
(XJ).............................8W-51-1
INDEX, DIAGRAM; REAR LIGHTING
(XJ-RHD).........................8W-51-1
INDEX, DIAGRAM; REAR LIGHTING
(YJ).............................8W-51-1
INDEX, DIAGRAM; STARTING SYSTEM
(XJ).............................8W-21-1
INDEX, DIAGRAM; STARTING SYSTEM
(XJ-RHD).........................8W-21-1
INDEX, DIAGRAM; STARTING SYSTEM
(YJ).............................8W-21-1
INDEX, DIAGRAM; TRAILER TOW (XJ) . . 8W-54-1
INDEX, DIAGRAM; TRAILER TOW
(XJ-RHD)
.........................8W-54-1
INDEX, DIAGRAM; TRANSMISSION
CONTROLS (XJ)
...................8W-31-1
INDEX, DIAGRAM; TRANSMISSION
CONTROLS (XJ-RHD)
...............8W-31-1
INDEX, DIAGRAM; TRANSMISSION
CONTROLS (YJ)
...................8W-31-1
INDEX, DIAGRAM; TURN SIGNALS (XJ)
. 8W-52-1INDEX, DIAGRAM; TURN SIGNALS
(XJ-RHD).........................8W-52-1
INDEX, DIAGRAM; TURN SIGNALS (YJ) . 8W-52-1
INDEX, DIAGRAM; VEHICLE SPEED
CONTROL (XJ)....................8W-33-1
INDEX, DIAGRAM; VEHICLE SPEED
CONTROL (XJ-RHD)................8W-33-1
INDEX, DIAGRAM; WIPERS (XJ).......8W-53-2
INDEX, DIAGRAM; WIPERS (XJ-RHD) . . 8W-53-2
INDEX, DIAGRAM; WIPERS (YJ).......8W-53-2
INDEX, DIAGRAM; FUEL/IGNITION
(XJ-RHD).........................8W-30-5
INDEX, GROUP; COOLING SYSTEM.......8E-1
INDEX, GROUP; INSTRUMENT PANEL
AND GAUGES........................8E-1
INDEX, SPLICE; SPLICE INFORMATION
(XJ).............................8W-70-1
INDEX, SPLICE; SPLICE INFORMATION
(XJ-RHD).........................8W-70-1
INDEX, SPLICE; SPLICE INFORMATION
(YJ).............................8W-70-1
INDEXÐ2.5L ENGINE, DIAGRAM......8W-30-6
INDEXÐ4.0L ENGINE, DIAGRAM......8W-30-6
INDICATOR LAMP, CHARGING SYSTEM . 8W-40-3
INDICATOR LAMP, HIGH-BEAM;
INSTRUMENT CLUSTER (XJ).........8W-40-2
INDICATOR LAMP, HIGH-BEAM;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
INDICATOR LAMP (MIL), MALFUNCTION;
FUEL/IGNITION (XJ)................8W-30-5
INDICATOR LAMP (MIL), MALFUNCTION;
FUEL/IGNITION (YJ)................8W-30-5
INDICATOR LAMP (MIL), MALFUNCTION;
INSTRUMENT CLUSTER (XJ).........8W-40-2
INDICATOR LAMP (MIL), MALFUNCTION;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-1
INDICATOR LAMP (MIL), MALFUNCTION;
FUEL/IGNITION (XJ-RHD)............8W-30-4
INDICATOR LAMPÐPCM OUTPUT,
MALFUNCTION......................14-28
INDICATOR LAMPS.....8E-12,8E-25,8E-32,8E-3
INDICATOR LAMPS, TURN SIGNAL;
INSTRUMENT CLUSTER (XJ).........8W-40-2
INDICATOR LAMPS, TURN SIGNAL;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
INDICATOR (SRI) LAMP, SERVICE
REMINDER..........................25-1
INDICATOR WARNING LAMP, SEAT BELT;
INSTRUMENT CLUSTER (XJ).........8W-40-2
INDICATOR WARNING LAMP, SEAT BELT;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
INDICATORÐPCM OUTPUT, SHIFT.......14-29
INDICATORS, TREAD WEAR.............22-3
INFLATION PRESSURES, TIRE...........22-2
INFORMATIONÐXJ, DOME/COURTESY
LAMP SERVICE......................8L-16
INFORMATIONÐXJ, UNDERHOOD LAMP
SERVICE...........................8L-12
INFORMATIONÐYJ, DOME/COURTESY
LAMP SERVICE......................8L-31
INFORMATIONÐYJ, SOFT TOP SERVICE . 23-127
INFORMATIONÐYJ, UNDERHOOD LAMP
SERVICE...........................8L-28
INITIALIZATION, ABS SYSTEM
POWER-UP..........................5-35
INJECTION (MFI)ÐCOMPONENT
DESCRIPTION/SYSTEM OPERATION,
MULTI-PORT FUEL...................14-19
INJECTION (MFI)ÐCOMPONENT
REMOVAL/INSTALLATION, MULTI-PORT
FUEL..............................14-58
INJECTION (MFI)ÐGENERAL
DIAGNOSIS, MULTI-PORT FUEL.........14-35
INJECTOR DIAGNOSISÐVEHICLE RUNS
ROUGH AND/OR HAS A MISS...........14-52
INJECTOR, FUEL.....................14-60
INJECTOR TEST, FUEL.................14-51
INJECTORS, FUEL; FUEL/IGNITION (XJ) . 8W-30-1
INJECTORS, FUEL; FUEL/IGNITION (YJ) . 8W-30-2
INJECTORS, FUEL; FUEL/IGNITION
(XJ-RHD).........................8W-30-1
INJECTORSÐPCM OUTPUT, FUEL
.......14-27
IN-LINE FUSE
........................8F-1
INNER AXLE SHAFT OIL SEAL
REPLACEMENT
.......................2-35
INNER SCUFF PLATE/COWL SIDE TRIM
PANELÐXJ, FRONT
...................23-86
INNER SPLASH SHIELDSÐYJ, FENDER
. . 23-116INPUT, AIR CONDITIONING (A/C)
CONTROLSÐPCM....................14-21
INPUT, AUTOMATIC SHUTDOWN (ASD)
SENSEÐPCM.......................14-21
INPUT, BATTERY VOLTAGEÐPCM........14-21
INPUT, BRAKE SWITCH; ANTI-LOCK
BRAKES (XJ)......................8W-32-2
INPUT, BRAKE SWITCH; ANTI-LOCK
BRAKES (XJ-RHD).................8W-32-2
INPUT, BRAKE SWITCH; ANTI-LOCK
BRAKES (YJ)......................8W-32-2
INPUT, BRAKE SWITCH; FUEL/IGNITION
(XJ).............................8W-30-5
INPUT, BRAKE SWITCH; FUEL/IGNITION
(YJ).............................8W-30-5
INPUT, BRAKE SWITCH; FUEL/IGNITION
(XJ-RHD).........................8W-30-5
INPUT, BRAKE SWITCHÐPCM..........14-22
INPUT, CAMSHAFT POSITION SENSORÐ
PCM...............................14-22
INPUT, CRANKSHAFT POSITION
SENSORÐPCM......................14-22
INPUT, DATA LINK CONNECTORÐPCM . . . 14-22
INPUT, ENGINE COOLANT
TEMPERATURE SENSORÐPCM.........14-23
INPUT, EXTENDED IDLE SWITCHÐPCM . . . 14-23
INPUT, IGNITION CIRCUIT SENSEÐPCM . . 14-23
INPUT, INTAKE MANIFOLD AIR
TEMPERATURE SENSORÐPCM.........14-22
INPUT, MANIFOLD ABSOLUTE
PRESSURE (MAP) SENSORÐPCM.......14-23
INPUT, OXYGEN (O2S) SENSORÐPCM.....14-24
INPUT, PARK/NEUTRAL SWITCHÐPCM . . . 14-24
INPUT, POWER STEERING PRESSURE
SWITCHÐPCM......................14-24
INPUT, SCI RECEIVEÐPCM............14-24
INPUT, SENSOR RETURNÐPCM.........14-25
INPUT SIGNALS, WHEEL/TIRE SIZE........5-3
INPUT, SPEED CONTROLÐPCM.........14-25
INPUT, THROTTLE POSITION SENSOR
(TPS)ÐPCM........................14-25
INPUT, VEHICLE SPEED SENSORÐPCM . . 14-25
INSERTÐXJ, REAR QUARTER WINDOW
GLASS/REAR QUARTER PLASTIC........23-73
INSIDE LATCH RELEASE AND LOCK
RODSÐXJ, DOOR....................23-50
INSIDE RELEASE AND LOCK HANDLEÐ
YJ, FULL-METAL DOOR LATCH.........23-137
INSPECTION AND ADJUSTMENT,
PRELIMINARY......................21-176
INSPECTION AND DIAGNOSIS CHARTS.....6-4
INSPECTION AND PARK LOCK
COMPONENT OVERHAUL, ADAPTER/
EXTENSION HOUSING................21-127
INSPECTION, CALIPER CLEANING........5-50
INSPECTION (ENGINE OIL LEAKS IN
GENERAL)............................9-6
INSPECTION, GEAR CLEANING..........19-42
INSPECTION, OVERHAUL CLEANING....21-294,
21-318
INSPECTION, PRE-ALIGNMENT............2-6
INSPECTION, RUBBER AND PLASTIC
COMPONENT.........................0-20
INSPECTION, TORQUE CONVERTER
STATOR CLUTCH....................21-199
INSPECTION, TRANSMISSION CASE
CLEANING.........................21-125
INSPECTION, VALVE BODY
DISASSEMBLY......................21-147
INSTALLATION, 30RH/32RH
TRANSMISSION REMOVAL............21-115
INSTALLATION, ACCELERATION SWITCH . . . 5-39
INSTALLATION AND ADJUSTMENT, REAR
WHEEL SENSOR......................5-38
INSTALLATION, AW-4 TRANSMISSION
REMOVAL.........................21-198
INSTALLATION, BRAKE PEDAL...........5-31
INSTALLATION, BRAKELIGHT SWITCH.....5-32
INSTALLATION, CALIPER................5-51
INSTALLATION, CLUTCH COVER AND
DISC...............................6-10
INSTALLATION, CLUTCH HYDRAULIC
LINKAGE
............................6-14
INSTALLATION, CLUTCH PEDAL
..........6-15
INSTALLATION, DIFFERENTIAL
...........2-44
INSTALLATION, DIFFERENTIAL
MEASUREMENT
.......................3-25
INSTALLATION, DISC BRAKESHOE
........5-47
14 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

LAMP, OIL PRESSURE WARNING;
INSTRUMENT CLUSTER (XJ).........8W-40-2
LAMP, OIL PRESSURE WARNING;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-1
LAMP RELAY, STOP; TRAILER TOW (XJ) . 8W-54-1
LAMP RELAY, STOP; TRAILER TOW
(XJ-RHD).........................8W-54-1
LAMP REPLACEMENTÐXJ, DOME.......8L-17
LAMP REPLACEMENTÐXJ, FOG..........8L-9
LAMP REPLACEMENTÐXJ, UNDERHOOD . 8L-13
LAMP REPLACEMENTÐYJ, FOG.........8L-25
LAMP REPLACEMENTÐYJ, UNDERHOOD . 8L-29
LAMP, SEAT BELT INDICATOR WARNING;
INSTRUMENT CLUSTER (XJ).........8W-40-2
LAMP, SEAT BELT INDICATOR WARNING;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
LAMP SERVICE INFORMATIONÐXJ,
DOME/COURTESY....................8L-16
LAMP SERVICE INFORMATIONÐXJ,
UNDERHOOD........................8L-12
LAMP SERVICE INFORMATIONÐYJ,
DOME/COURTESY....................8L-31
LAMP SERVICE INFORMATIONÐYJ,
UNDERHOOD........................8L-28
LAMP, SERVICE REMINDER INDICATOR
(SRI)...............................25-1
LAMP SWITCH REPLACEMENTÐXJ, FOG . 8L-10
LAMP SWITCH REPLACEMENTÐYJ, FOG . 8L-26
LAMP SWITCH, STOP.............8H-1,8H-6
LAMP, TRANSMISSION RANGE.......8W-44-1
LAMP TROUBLE DIAGNOSISÐXJ,
DOME/COURTESY....................8L-16
LAMP TROUBLE DIAGNOSISÐYJ,
DOME/COURTESY....................8L-31
LAMP, UNDERHOOD; INTERIOR
LIGHTING (XJ)....................8W-44-2
LAMP, UNDERHOOD; INTERIOR
LIGHTING (XJ-RHD)................8W-44-1
LAMP, UNDERHOOD; INTERIOR
LIGHTING (YJ)....................8W-44-1
LAMP, UPSHIFT; FUEL/IGNITION (XJ) . . . 8W-30-5
LAMP, UP-SHIFT; INSTRUMENT
CLUSTER (YJ).....................8W-40-2
LAMP, UPSHIFT; TRANSMISSION
CONTROLS (XJ)...................8W-31-1
LAMP, UPSHIFT; TRANSMISSION
CONTROLS (YJ)...................8W-31-1
LAMPÐPCM OUTPUT, EMR............14-27
LAMPÐPCM OUTPUT, GENERATOR......14-27
LAMPÐPCM OUTPUT, MALFUNCTION
INDICATOR.........................14-28
LAMPÐXJ, CARGO...................23-94
LAMPÐXJ, DOME
....................23-93
LAMPÐXJ, I/P ASH RECEIVER TRAY
.....23-80
LAMPÐXJ, LICENSE PLATE
............8L-12
LAMPS
............................8L-19
LAMPS AND CHMSL LAMPS, STOP;
REAR LIGHTING (XJ)
...............8W-51-1
LAMPS AND CHMSL LAMPS, STOP;
REAR LIGHTING (XJ-RHD)
...........8W-51-1
LAMPS AND CHMSL LAMPS, STOP;
REAR LIGHTING (YJ)
...............8W-51-1
LAMPS AND DOME LAMP, CARGO LAMP,
COURTESY; INTERIOR LIGHTING (XJ)
. . 8W-44-1
LAMPS AND DOME LAMPS, COURTESY
. 8W-44-1
LAMPS AND LICENSE PLATE LAMPS,
TAIL; REAR LIGHTING (YJ)
...........8W-51-1
LAMPS AND REAR LICENSE PLATE
LAMPS, TAIL; REAR LIGHTING (XJ)
....8W-51-1
LAMPS AND REAR LICENSE PLATE
LAMPS, TAIL; REAR LIGHTING
(XJ-RHD)
.........................8W-51-1
LAMPS, BACK-UP; REAR LIGHTING
(XJ)
.............................8W-51-1
LAMPS, BACK-UP; REAR LIGHTING
(XJ-RHD)
.........................8W-51-1
LAMPS, BACK-UP; REAR LIGHTING (YJ)
. 8W-51-1
LAMPS, CLUSTER ILLUMINATION
. . 8E-16,8E-26,
8E-34,8E-4
LAMPS, COURTESY LAMPS AND DOME;
INTERIOR LIGHTING (YJ)
............8W-44-1
LAMPS, FOG; FRONT LIGHTING (XJ)
. . . 8W-50-1
LAMPS, FOG; FRONT LIGHTING
(XJ-RHD)
.........................8W-50-2
LAMPS, FOG; FRONT LIGHTING (YJ)
. . . 8W-50-1
LAMPS, INDICATOR
....8E-12,8E-25,8E-32,8E-3LAMPS, INSTRUMENT PANEL
ILLUMINATION; INTERIOR LIGHTING
(XJ).............................8W-44-1
LAMPS, INSTRUMENT PANEL
ILLUMINATION; INTERIOR LIGHTING
(XJ-RHD).........................8W-44-1
LAMPS, INTERIOR...............8L-16,8L-31
LAMPS, PARKING; FRONT LIGHTING
(XJ).............................8W-50-1
LAMPS, PARKING; FRONT LIGHTING
(XJ-RHD).........................8W-50-2
LAMPS, PARKING; FRONT LIGHTING
(YJ).............................8W-50-1
LAMPS, READING; INTERIOR LIGHTING
(XJ).............................8W-44-2
LAMPS, READING; INTERIOR LIGHTING
(XJ-RHD).........................8W-44-1
LAMPS, READING AND COURTESY.......8C-1
LAMPS, STOP LAMPS AND CHMSL;
REAR LIGHTING (XJ)...............8W-51-1
LAMPS, STOP LAMPS AND CHMSL;
REAR LIGHTING (XJ-RHD)...........8W-51-1
LAMPS, STOP LAMPS AND CHMSL;
REAR LIGHTING (YJ)...............8W-51-1
LAMPS, TAIL LAMPS AND LICENSE
PLATE; REAR LIGHTING (YJ).........8W-51-1
LAMPS, TAIL LAMPS AND REAR
LICENSE PLATE; REAR LIGHTING (XJ) . . 8W-51-1
LAMPS, TAIL LAMPS AND REAR
LICENSE PLATE; REAR LIGHTING
(XJ-RHD).........................8W-51-1
LAMPS, TURN SIGNAL INDICATOR;
INSTRUMENT CLUSTER (XJ).........8W-40-2
LAMPS, TURN SIGNAL INDICATOR;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
LAMPS, VISOR VANITY MIRROR;
INTERIOR LIGHTING (XJ)............8W-44-2
LAMPS, VISOR VANITY MIRROR;
INTERIOR LIGHTING (XJ-RHD)........8W-44-1
LAMPSÐXJ, EXTERIOR...............8L-18
LAMPSÐXJ, FOG.....................8L-7
LAMPSÐXJ, INTERIOR................8L-18
LAMPSÐYJ, EXTERIOR...............8L-32
LAMPSÐYJ, FOG....................8L-23
LAMPSÐYJ, INTERIOR................8L-32
LATCH ADJUSTMENTÐXJ, DOOR........23-48
LATCH AND RELEASE HANDLEÐYJ,
TAILGATE..........................23-122
LATCH EXTERNAL RELEASE HANDLEÐ
YJ, FULL-METAL DOOR...............23-140
LATCH INSIDE RELEASE AND LOCK
HANDLEÐYJ, FULL-METAL DOOR......23-137
LATCH RELEASE AND LOCK RODSÐXJ,
DOOR INSIDE.......................23-50
LATCH RELEASE CABLE
REPLACEMENTÐXJ..................23-11
LATCH REPLACEMENTÐXJ, HOOD.......23-11
LATCH STRIKER AND BUMPERÐXJ,
REAR SEATBACK.....................23-84
LATCH STRIKER REPLACEMENTÐXJ,
HOOD.............................23-11
LATCH STRIKER REPLACEMENTÐXJ,
SAFETY............................23-11
LATCH STRIKERÐYJ, HALF-METAL
DOOR............................23-135
LATCH STRIKERÐYJ, TAILGATE........23-123
LATCH/KEY LOCK CYLINDER/STRIKERÐ
XJ, LIFTGATE........................23-61
LATCHÐXJ, DOOR...................23-49
LATCHÐYJ, FULL-METAL DOOR........23-140
LATCHÐYJ, HOOD SAFETY............23-109
LEAF SPRING; FRONT SUSPENSION AND
AXLE...............................2-16
LEAF SPRING; REAR SUSPENSION AND
AXLES............................3-4,3-7
LEAF SPRING EYE BUSHING
REPLACEMENT; FRONT SUSPENSION
AND AXLE...........................2-17
LEAF SPRING EYE BUSHING
REPLACEMENT; REAR SUSPENSION
AND AXLES
........................3-5,3-7
LEAK DETECTION AND REPAIRÐXJ,
STATIONARY GLASS WATER
............23-76
LEAK DETECTION AND REPAIRÐYJ,
STATIONARY GLASS WATER
...........23-150
LEAK DIAGNOSIS, CONVERTER
HOUSING
...........................21-75
LEAK DOWN TEST, FUEL PRESSURE
......14-8LEAK TESTING REFRIGERANT..........24-11
LEAKAGE DIAGNOSIS, INTAKE
MANIFOLD............................9-5
LEAKAGE DIAGNOSIS, PUMP...........19-10
LEAKAGE TEST, CYLINDER COMBUSTION
PRESSURE...........................9-6
LEAKAGE TEST DIAGNOSIS, CYLINDER
COMBUSTION PRESSURE................9-7
LEAKS, REPAIRING....................22-3
LEAKS, TESTING COOLING SYSTEM.......7-22
LEFT TURN RELAY; TRAILER TOW (XJ) . 8W-54-1
LEFT TURN RELAY; TRAILER TOW
(XJ-RHD).........................8W-54-1
LETTERS, JEEP BODY CODE..............5-2
LEVEL AND CONDITION, CHECKING
FLUID............................21-182
LEVEL, BRAKE FLUID..................5-10
LEVEL CHECK, FLUID............21-70,21-99
LEVEL, CLUTCH FLUID.................6-14
LEVEL, RECOMMENDED LUBRICANT/
CAPACITY/FILL.....................21-307
LEVEL, TRANSFER CASE LUBRICANT
AND FILL..........................21-284
LEVER INSTALLATION (XJ), SHIFT......21-286,
21-309
LEVER INSTALLATION (XJ WITH FULL
CONSOLE), PARKING BRAKE............5-64
LEVER INSTALLATION (XJ WITH MINI
CONSOLE), PARKING BRAKE............5-63
LEVER INSTALLATION (XJ WITHOUT
CONSOLE), PARKING BRAKE..............5-65
LEVER INSTALLATION (YJ), SHIFT......21-286
LEVER POSITIONS, TRANSMISSION
RANGES AND SHIFT.................21-166
LEVER REMOVAL (XJ), SHIFT....21-286,21-309
LEVER REMOVAL (XJ WITH FULL
CONSOLE), PARKING BRAKE............5-63
LEVER REMOVAL (XJ WITH MINI
CONSOLE), PARKING BRAKE............5-62
LEVER REMOVAL (XJ WITHOUT
CONSOLE), PARKING BRAKE............5-64
LEVER REMOVAL (YJ), SHIFT..........21-286
LICENSE PLATE LAMP HOUSINGÐXJ,
LIFTGATE...........................23-65
LICENSE PLATE LAMPÐXJ.............8L-12
LICENSE PLATE LAMPS, TAIL LAMPS;
REAR LIGHTING (YJ)...............8W-51-1
LICENSE PLATE LAMPS, TAIL LAMPS
AND REAR; REAR LIGHTING (XJ)......8W-51-1
LICENSE PLATE LAMPS, TAIL LAMPS
AND REAR; REAR LIGHTING (XJ-RHD) . 8W-51-1
LICENSE PLATE SCREW ANCHOR AND
BUMPERÐXJ, LIFTGATE...............23-65
LIFTGATE ADJUSTMENTÐXJ...........23-63
LIFTGATE GLASS WEATHERSTRIP SEAL
REPLACEMENTÐYJ.................23-125
LIFTGATE GLASSÐYJ, HARD TOP......23-124
LIFTGATE HINGEÐXJ.................23-60
LIFTGATE LATCH/KEY LOCK CYLINDER/
STRIKERÐXJ.......................23-61
LIFTGATE LICENSE PLATE LAMP
HOUSINGÐXJ.......................23-65
LIFTGATE LICENSE PLATE SCREW
ANCHOR AND BUMPERÐXJ............23-65
LIFTGATE OPENING WEATHERSTRIP
SEALÐXJ..........................23-64
LIFTGATE PILLAR TRIM COVERSÐXJ,
B/C-PILLAR.........................23-88
LIFTGATE SUPPORT ROD BALL STUD
REPLACEMENTÐXJ..................23-63
LIFTGATE SUPPORT ROD CYLINDER
DISPOSALÐXJ......................23-63
LIFTGATE SUPPORT ROD CYLINDERÐXJ . 23-62
LIFTGATE TRIM PANELÐXJ............23-59
LIFTGATE WASHER NOZZLE REMOVE/
INSTALL...........................8K-24
LIFTGATE WASHER SYSTEM............8K-5
LIFTGATE WINDOW GLASSÐXJ.........23-74
LIFTGATE WIPER ARM REMOVE/INSTALL . 8K-17
LIFTGATE WIPER MOTOR REMOVE/
INSTALL.......................8K-20,8K-6
LIFTGATE WIPER SYSTEM
..............8K-4
LIFTGATE WIPER/WASHER SWITCH
. . 8K-16,8K-5
LIFTGATE WIPER/WASHER SWITCH
REMOVE/INSTALL
................8K-24,8K-8
LIFTGATE WIPER/WASHER SYSTEM
.....8K-10,
8K-16,8K-1
LIFTGATEÐXJ
.......................23-58
16 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

RELAY TESTING, AUTOMATIC
SHUTDOWN (ASD)...................14-46
RELAY TESTING, FUEL PUMP...........14-47
RELAY, TORQUE CONVERTER CLUTCH....14-65
RELAY, TORQUE CONVERTER CLUTCH
(TCC) SOLENOID; FUEL/IGNITION (XJ) . . 8W-30-4
RELAY, TORQUE CONVERTER CLUTCH
(TCC) SOLENOID; TRANSMISSION
CONTROLS (YJ)...................8W-31-1
RELAY, TURN SIGNAL; TURN SIGNALS
(XJ-RHD).........................8W-52-1
RELAY, UNLOCK; POWER DOOR LOCKS
(XJ).............................8W-61-1
RELAY, UNLOCK; POWER DOOR LOCKS
(XJ-RHD).........................8W-61-1
RELAYÐ2.5L ENGINE ONLY, TORQUE
CONVERTER CLUTCH (TCC)
SOLENOID; TRANSMISSION
CONTROLS (XJ)...................8W-31-1
RELAYÐPCM OUTPUT, AIR
CONDITIONING (A/C) CLUTCH..........14-26
RELAYÐPCM OUTPUT, AUTO
SHUTDOWN (ASD)...................14-26
RELAYÐPCM OUTPUT, FUEL PUMP......14-27
RELAYÐPCM OUTPUT, RADIATOR FAN . . . 14-28
RELAYÐPCM OUTPUT, TORQUE
CONVERTER CLUTCH.................14-29
RELAYS, POWER LOCK/UNLOCK.........8P-1
RELAY/TIMER, DEFOGGER..............8N-1
RELAY/TIMER REMOVE/INSTALL,
DEFOGGER..........................8N-4
RELEASE AND LOCK HANDLEÐYJ,
FULL-METAL DOOR LATCH INSIDE.......23-137
RELEASE AND LOCK RODSÐXJ, DOOR
INSIDE LATCH.......................23-50
RELEASE BEARING REPLACEMENT.......6-11
RELEASE CABLE REPLACEMENTÐXJ,
LATCH .............................23-11
RELEASE HANDLEÐYJ, FULL-METAL
DOOR LATCH EXTERNAL..............23-140
RELEASE HANDLEÐYJ, TAILGATE LATCH . 23-122
RELEASE PROCEDURE, FUEL PRESSURE . . . 14-6
RELEASE PROCEDURE, FUEL SYSTEM
PRESSURE.........................14-62
RELIEF/ROLLOVER VALVE, FUEL TANK
PRESSURE....................14-16,14-62
RELIEF/ROLLOVER VALVE, PRESSURE . 25-6,25-7
REMINDER INDICATOR (SRI) LAMP,
SERVICE............................25-1
REMOTE GARAGE DOOR OPENER
STORAGE...........................8C-1
REMOTE KEYLESS ENTRY MODULE;
POWER DOOR LOCKS (XJ)...........8W-61-1
REMOVAL, ACCELERATION SWITCH.......5-39
REMOVAL AND INSTALLATION,
30RH/32RH TRANSMISSION...........21-115
REMOVAL AND INSTALLATION, AW-4
TRANSMISSION.....................21-198
REMOVAL, BRAKE PEDAL...............5-31
REMOVAL, BRAKELIGHT SWITCH.........5-32
REMOVAL, CALIPER...................5-48
REMOVAL, CLUTCH COVER AND DISC.....6-10
REMOVAL, CLUTCH HYDRAULIC
LINKAGE............................6-13
REMOVAL, CLUTCH PEDAL..............6-15
REMOVAL, DIFFERENTIAL; FRONT
SUSPENSION AND AXLE................2-34
REMOVAL, DIFFERENTIAL; REAR
SUSPENSION AND AXLES...............3-18
REMOVAL, DISC BRAKESHOE............5-46
REMOVAL, DRUM BRAKESHOE...........5-55
REMOVAL, FRONT WHEEL SENSOR.......5-38
REMOVAL (NON-ABS), MASTER
CYLINDER...........................5-15
REMOVAL, REAR WHEEL SENSOR........5-38
REMOVAL, ROTOR....................5-51
REMOVAL, TRANSFER CASE.....21-287,21-309
REMOVAL, TRANSMISSION........21-35,21-3
REMOVAL, TRANSMISSION AND
CONVERTER.......................21-115
REMOVAL, TRANSMISSION AND
TORQUE CONVERTER................21-198
REMOVAL, TRANSMISSION VALVE BODY
. 21-186
REMOVAL, VALVE BODY
..............21-104
REMOVAL, WHEEL CYLINDER
...........5-57
REMOVAL (WITH ABS), MASTER
CYLINDER AND COMBINATION VALVE
.....5-17
REMOVAL (XJ), HCU
...................5-41REMOVAL (XJ MODELS), ECU...........5-40
REMOVAL (XJ), SHIFT LEVER....21-286,21-309
REMOVAL (XJ WITH ABS), POWER
BRAKE BOOSTER.....................5-24
REMOVAL (XJ WITH FULL CONSOLE),
PARKING BRAKE LEVER................5-63
REMOVAL (XJ WITH MINI CONSOLE),
PARKING BRAKE LEVER................5-62
REMOVAL (XJ WITHOUT ABS), POWER
BRAKE BOOSTER.....................5-29
REMOVAL (XJ WITHOUT CONSOLE),
PARKING BRAKE LEVER................5-64
REMOVAL (YJ), HCU...................5-44
REMOVAL (YJ), PARKING BRAKE PEDAL . . . 5-66
REMOVAL (YJ), POWER BRAKE
BOOSTER............................5-30
REMOVAL (YJ), SHIFT LEVER..........21-286
REMOVAL/DISASSEMBLY, PINION;
FRONT SUSPENSION AND AXLE..........2-36
REMOVAL/DISASSEMBLY, PINION; REAR
SUSPENSION AND AXLES...............3-19
REMOVAL/INSTALLATION, COMPONENT;
EMISSION CONTROL SYSTEMS..........25-7
REMOVAL/INSTALLATION, COMPONENT;
IGNITION SYSTEMS..................8D-17
REMOVAL/INSTALLATION, MULTI-PORT
FUEL INJECTION (MFI)ÐCOMPONENT....14-58
REMOVAL/INSTALLATION (YJ MODELS),
ECU ................................5-41
REMOVAL/INSTALLATIONÐXJ, DOOR....23-35
REMOVE/INSTALL - XJ, ANTENNA........8F-8
REMOVE/INSTALL - XJ, MULTI-
FUNCTION SWITCH....................8J-5
REMOVE/INSTALL - XJ, RADIO...........8F-6
REMOVE/INSTALL - XJ, SOUND BAR......8F-8
REMOVE/INSTALL - XJ, SPEAKERS........8F-6
REMOVE/INSTALL - YJ, ANTENNA.......8F-10
REMOVE/INSTALL - YJ, RADIO...........8F-9
REMOVE/INSTALL - YJ, SOUND BAR.....8F-10
REMOVE/INSTALL - YJ, SPEAKERS........8F-9
REMOVE/INSTALL - YJ, TURN
SIGNAL/HAZARD WARNING SWITCH......8J-5
REMOVE/INSTALL, AIRBAG MODULE.....8M-3
REMOVE/INSTALL, BATTERY.............8B-1
REMOVE/INSTALL, CLUSTER ASSEMBLY . . 8E-17,
8E-35
REMOVE/INSTALL, DEFOGGER
RELAY/TIMER........................8N-4
REMOVE/INSTALL, DEFOGGER SWITCH....8N-4
REMOVE/INSTALL, GAUGES.......8E-17,8-E39
REMOVE/INSTALL, HEADLAMP OR
PANEL DIMMER SWITCH..............8E-42
REMOVE/INSTALL, HEADLAMP SWITCH . . . 8E-19
REMOVE/INSTALL, HORN...............8G-3
REMOVE/INSTALL, HORN SWITCH........8G-3
REMOVE/INSTALL, INSTRUMENT PANEL . . 8E-20
REMOVE/INSTALL, KEYLESS ENTRY
MODULE...........................8P-10
REMOVE/INSTALL, LIFTGATE WASHER
NOZZLE............................8K-24
REMOVE/INSTALL, LIFTGATE WIPER
ARM ..............................8K-17
REMOVE/INSTALL, LIFTGATE WIPER
MOTOR........................8K-20,8K-6
REMOVE/INSTALL, LIFTGATE WIPER/
WASHER SWITCH................8K-24,8K-8
REMOVE/INSTALL, OVERHEAD CONSOLE . . . 8C-6
REMOVE/INSTALL, POWER LOCK
MOTOR.............................8P-8
REMOVE/INSTALL, POWER LOCK
SWITCH.............................8P-8
REMOVE/INSTALL, POWER LOCK/
UNLOCK RELAY......................8P-12
REMOVE/INSTALL, POWER MIRROR......8T-4
REMOVE/INSTALL, POWER MIRROR
SWITCH.............................8T-4
REMOVE/INSTALL, POWER SEAT
ADJUSTER/MOTORS...................8R-3
REMOVE/INSTALL, POWER SEAT
SWITCH
............................8R-3
REMOVE/INSTALL, POWER WINDOW
MOTOR
.............................8S-7
REMOVE/INSTALL, POWER WINDOW
SWITCH
.............................8S-7
REMOVE/INSTALL, PRINTED CIRCUIT
....8E-19,
8E-40
REMOVE/INSTALL, READING/COURTESY
LAMP BULB
.........................8C-8REMOVE/INSTALL, SERVO CABLE.......8H-10
REMOVE/INSTALL, SPEED CONTROL
SERVO.............................8H-9
REMOVE/INSTALL, SPEED CONTROL
SWITCH............................8H-9
REMOVE/INSTALL, STARTER RELAY.......8B-6
REMOVE/INSTALL, SUNGLASSES
STORAGE BIN........................8C-7
REMOVE/INSTALL, VACUUM RESERVOIR . . 8H-10
REMOVE/INSTALL, WASHER PUMP......8K-24
REMOVE/INSTALL, WASHER PUMP/
RESERVOIR..........................8K-8
REMOVE/INSTALL, WINDSHIELD WIPER
ARM ..............................8K-17
REMOVE/INSTALL, WINDSHIELD WIPER
BLADE.............................8K-17
REMOVE/INSTALL, WINDSHIELD WIPER
LINKAGE AND PIVOTS................8K-17
REMOVE/INSTALL, WINDSHIELD WIPER
MOTOR........................8K-19,8K-6
REMOVE/INSTALL, WINDSHIELD
WIPER/WASHER SWITCH..........8K-20,8K-7
REMOVE/INSTALLÐ2.5L, STARTER.......8B-4
REMOVE/INSTALLÐ4.0L, STARTER.......8B-5
REMOVE/INSTALLÐLEFT-HAND DRIVE,
GENERATOR.........................8B-6
REMOVE/INSTALLÐRIGHT-HAND DRIVE,
GENERATOR.........................8B-7
REMOVEÐINSTALL, AIRBAG MODULE....19-49
REPAIR DAMAGED OR WORN THREADS....9-4
REPAIR PRODUCTSÐXJ, AFTERMARKET
PAINT AND TRIM...................23-159
REPAIR PRODUCTSÐYJ, AFTERMARKET
PAINT AND TRIM...................23-160
REPAIR, WIRING; WIRING DIAGRAMSÐ
GENERAL INFORMATION (XJ)...........8W-6
REPAIRING LEAKS....................22-3
REPAIRÐMOLEX CONNECTORS,
TERMINAL/CONNECTOR; WIRING
DIAGRAMSÐGENERAL INFORMATION
(XJ)...............................8W-6
REPAIRÐXJ, STATIONARY GLASS
WATER LEAK DETECTION..............23-76
REPAIRÐYJ, HARD TOP..............23-127
REPAIRÐYJ, STATIONARY GLASS
WATER LEAK DETECTION.............23-150
REPAIRS, FRAME....................13-13
REPAIRS, REAR WINDOW GLASS GRID;
REAR WINDOW DEFOGGER.............8N-3
REPLACEÐCYLINDER HEAD NOT
REMOVED, VALVE COMPONENT......9-23,9-65
REPLACEMENTÐXJ, BACK-UP/REAR
TURN SIGNAL/TAIL LAMP BULB
.........8L-12
REPLACEMENTÐXJ, DOME LAMP
.......8L-17
REPLACEMENTÐXJ, DOOR HINGE/
HINGE PIN
..........................23-52
REPLACEMENTÐXJ, DOOR RESTRAINT
. . . 23-41
REPLACEMENTÐXJ, DRL MODULE
......8L-15
REPLACEMENTÐXJ, FOG LAMP
..........8L-9
REPLACEMENTÐXJ, FOG LAMP SWITCH
. 8L-10
REPLACEMENTÐXJ, FRONT PARK/TURN
SIGNAL LAMP BULB
...................8L-9
REPLACEMENTÐXJ, HEADLAMP BULB
....8L-7
REPLACEMENTÐXJ, HEADLAMP DELAY
MODULE
...........................8L-14
REPLACEMENTÐXJ, HOOD HINGE
.......23-10
REPLACEMENTÐXJ, HOOD LATCH
.......23-11
REPLACEMENTÐXJ, HOOD LATCH
STRIKER
...........................23-11
REPLACEMENTÐXJ, INTERIOR
REARVIEW MIRROR SUPPORT
BRACKET
...........................23-68
REPLACEMENTÐXJ, LATCH RELEASE
CABLE
.............................23-11
REPLACEMENTÐXJ, LIFTGATE SUPPORT
ROD BALL STUD
.....................23-63
REPLACEMENTÐXJ, SAFETY LATCH
STRIKER
...........................23-11
REPLACEMENTÐXJ, SIDE MARKER
LAMP BULB
.........................8L-10
REPLACEMENTÐXJ, UNDERHOOD LAMP
. 8L-13
REPLACEMENTÐXJ, UNDERHOOD LAMP
BULB
..............................8L-13
REPLACEMENTÐXJ VEHICLES, DRIVE
AXLE ASSEMBLY; FRONT SUSPENSION
AND AXLE
...........................2-23
JINDEX 23
Description Group-Page Description Group-Page Description Group-Page

REPLACEMENTÐXJ VEHICLES, DRIVE
AXLE ASSEMBLY; REAR SUSPENSION
AND AXLES......................3-14,3-31
REPLACEMENTÐXJ, WINDSHIELD
GLASS.............................23-69
REPLACEMENTÐYJ, BACK-UP/REAR
TURN SIGNAL/TAIL LAMP BULB.........8L-28
REPLACEMENTÐYJ, DOOR FRAME
GLASS CHANNEL...................23-142
REPLACEMENTÐYJ, DOOR
WEATHERSTRIP SEAL................23-142
REPLACEMENTÐYJ, DRL MODULE......8L-30
REPLACEMENTÐYJ, FOG LAMP.........8L-25
REPLACEMENTÐYJ, FOG LAMP SWITCH . 8L-26
REPLACEMENTÐYJ, FRONT PARK/TURN
SIGNAL LAMP BULB..................8L-25
REPLACEMENTÐYJ, HEADLAMP BULB . . . 8L-23
REPLACEMENTÐYJ, HEADLAMP
DIMMER SWITCH....................8L-26
REPLACEMENTÐYJ, LIFTGATE GLASS
WEATHERSTRIP SEAL................23-125
REPLACEMENTÐYJ, SIDE MARKER
LAMP BULB.........................8L-25
REPLACEMENTÐYJ, UNDERHOOD LAMP . 8L-29
REPLACEMENTÐYJ, UNDERHOOD LAMP
BULB..............................8L-29
REPLACEMENTÐYJ VEHICLES, DRIVE
AXLE ASSEMBLY; FRONT SUSPENSION
AND AXLE...........................2-24
REPLACEMENTÐYJ VEHICLES, DRIVE
AXLE ASSEMBLY; REAR SUSPENSION
AND AXLES..........................3-14
REPLACEMENTÐYJ VEHICLES,
HARDTOP DOME/CARGO LAMP BULB....8L-31
REQUIREMENTS, FUEL..................0-1
REQUIRING NO LUBRICATION,
COMPONENTS.........................0-2
RESERVE/OVERFLOW SYSTEM,
COOLANT............................7-24
RESERVOIR REPLACEMENT (2-PIECE
MASTER CYLINDER)...................5-19
RESERVOIR, VACUUM.................8H-1
RESISTANCE, IGNITION COIL............8D-9
RESISTANCE (OHMS)ÐCOOLANT
TEMPERATURE SENSOR/MANIFOLD
AIR TEMPERATURE, SENSOR...........14-46
RESISTANCE, SPARK PLUG CABLE......8D-14
RESISTORS REPLACEMENT, BLOWER
MOTOR............................24-31
RESTRAINT REPLACEMENTÐXJ, DOOR . . . 23-41
RETAINER AND PISTON
SPECIFICATIONS, AW-4...............21-340
RETAINING BRACKETÐYJ, REARVIEW
MIRROR..........................23-144
RETURNÐPCM INPUT, SENSOR.........14-25
REVEAL MOLDINGÐXJ, WINDSHIELD....23-66
REVEAL MOLDINGÐYJ, WINDSHIELD . . . 23-144
RHD, STEERING.....................19-74
RIGHT HAND DRIVE, AUTOMATIC BELT
TENSIONERÐXJ MODELS WITH.........7-42
RIGHT HAND DRIVE, BELT SERVICEÐ
EXCEPT.............................7-40
RIGHT HAND DRIVE, BELT SERVICEÐXJ
MODELS WITH.......................7-42
RIGHT HAND DRIVE (RHD), BELT
TENSIONÐEXCEPT....................7-38
RIGHT HAND DRIVE (RHD) MODELS,
BELT TENSIONÐEXCEPT...............7-45
RIGHT HAND DRIVE VEHICLES...........23-1
RIGHT TURN RELAY; TRAILER TOW
(XJ).............................8W-54-1
RIGHT TURN RELAY; TRAILER TOW
(XJ-RHD).........................8W-54-1
RING CHARTÐAX 15 MANUAL
TRANSMISSION, SELECTIVE SNAP......21-334
RING/THRUST WASHER/THRUST PLATE
SPECIFICATIONS, 30RH/32RH SNAP.....21-335
ROCKER ARMS AND PUSH RODS....9-23,9-65
ROD AND PAWL SERVICE, PARK.......21-190
ROD BALL STUD REPLACEMENTÐXJ,
LIFTGATE SUPPORT
..................23-63
ROD BEARING FITTING CHART,
CONNECTING
.....................9-41,9-83
ROD CYLINDER DISPOSALÐXJ,
LIFTGATE SUPPORT
..................23-63
ROD CYLINDERÐXJ, LIFTGATE
SUPPORT
..........................23-62
ROD, TIE
......................19-16,19-19RODS, PISTONS AND CONNECTING . . . 9-39,9-81
RODS, ROCKER ARMS AND PUSH....9-23,9-65
RODSÐXJ, DOOR INSIDE LATCH
RELEASE AND LOCK..................23-50
ROOF VENTÐYJ, HARD TOP..........23-127
ROTOR, DISTRIBUTOR.................8D-8
ROTOR, IGNITION CABLES,
DISTRIBUTOR CAP....................0-20
ROTOR INSTALLATION.................5-51
ROTOR REFINISHING, DISC BRAKE.......5-53
ROTOR REMOVAL.....................5-51
ROTOR RUNOUT, DISC BRAKE...........5-52
ROTOR THICKNESS, DISC BRAKE........5-52
ROTORÐSPEEDOMETER DRIVE GEAR,
SPEED SENSOR.....................21-193
ROUGH AND/OR HAS A MISS, INJECTOR
DIAGNOSISÐVEHICLE RUNS...........14-52
ROUTING SCHEMATICÐ2.5L 4
CYLINDER ENGINE, VACUUM............25-3
ROUTING SCHEMATICÐ4.0L 6
CYLINDER ENGINE, VACUUM............25-3
ROUTING SCHEMATICS, VACUUM HOSE . . . 25-2
ROUTING, SYSTEM COOLANT.............7-1
RUBBER AND PLASTIC COMPONENT
INSPECTION.........................0-20
RUBBER AND PLASTIC HOSES/TUBING....0-26
RUNNING LAMP (DRL) MODULE,
DAYTIME.........................8W-50-2
RUNNING LAMP (DRL) MODULEÐ
CANADIAN VEHICLES ONLY, DAYTIME. . . 8W-50-2
RUNNING LIGHTS (CANADA ONLY)ÐXJ,
DAYTIME...........................8L-15
RUNNING LIGHTS (CANADA ONLY)ÐYJ,
DAYTIME...........................8L-30
RUNOUT............................16-4
RUNOUT, CLUTCH COVER AND DISC.......6-3
RUNOUT, DISC BRAKE ROTOR...........5-52
RUNOUT, FLYWHEEL....................6-3
RUNOUT SPECIFICATIONS..............16-4
RUNOUT, TIRE AND WHEEL.............22-8
RUNS ROUGH AND/OR HAS A MISS,
INJECTOR DIAGNOSISÐVEHICLE........14-52
SAFETY CERTIFICATION LABEL, VEHICLE . Intro.-4
SAFETY LATCH STRIKER
REPLACEMENTÐXJ..................23-11
SAFETY LATCHÐYJ, HOOD............23-109
SAFETY PRECAUTIONS AND WARNINGS . . 13-10
SAFETY PRECAUTIONS, BRAKE...........5-2
SAFETY PRECAUTIONS, CLUTCH.........6-10
SANDING,BUFFING AND POLISHING,
WET..............................23-158
SCAN TOOL, DRB; BRAKES...............5-3
SCAN TOOL, DRB; COOLING SYSTEM......7-5
SCAN TOOL, DRB; EMISSION CONTROL
SYSTEMS...........................25-2
SCAN TOOL, DRB; FUEL SYSTEM........14-54
SCAN TOOL, DRB; IGNITION SYSTEMS....8D-8
SCHEDULES, MAINTENANCE.............0-4
SCHEMATIC - YJ, BUZZER MODULE......8U-4
SCHEMATICÐ2.5L 4 CYLINDER ENGINE,
VACUUM ROUTING....................25-3
SCHEMATICÐ4.0L 6 CYLINDER ENGINE,
VACUUM ROUTING....................25-3
SCHEMATICÐXJ, AIR CONDITIONING.....24-5
SCHEMATICÐXJ, HEATING..............24-2
SCHEMATICS, BELT....................7-38
SCHEMATICS, PCM SYSTEM............14-41
SCHEMATICS, VACUUM HOSE ROUTING . . . 25-2
SCI RECEIVEÐPCM INPUT.............14-24
SCI TRANSMITÐPCM OUTPUT.........14-29
SCREENÐXJ, COWL GRILLE...........23-12
SCREENÐXJ, HEADLAMP/FOG LAMP
ADJUSTMENT USING ALIGNMENT........8L-7
SCREENÐYJ, COWL GRILLE..........23-109
SCREENÐYJ, HEADLAMP/FOG LAMP
ADJUSTMENT USING ALIGNMENT.......8L-23
SCREW ANCHOR AND BUMPERÐXJ,
LIFTGATE LICENSE PLATE..............23-65
SCUFF PLATE/COWL SIDE TRIM
PANELÐXJ, FRONT INNER.............23-86
SCUFF PLATESÐXJ, INTERIOR TRIM
PANELS
............................23-84
SCUFF PLATESÐXJ, OUTER
............23-89
SEAL AND BEARING, AXLE SHAFT
........3-17
SEAL AND BEARING SERVICE, AXLE
SHAFT
..............................3-32
SEAL AND SPRING REPLACEMENT,
VALVE STEM
.........................9-65SEAL REPLACEMENT, INNER AXLE
SHAFT OIL...........................2-35
SEAL REPLACEMENT, MANUAL VALVE
SHAFT............................21-187
SEAL REPLACEMENT, OIL PUMP.......21-199
SEAL REPLACEMENT, PINION; FRONT
SUSPENSION AND AXLE................2-25
SEAL REPLACEMENT, PINION; REAR
SUSPENSION AND AXLES...............3-33
SEAL REPLACEMENT, PINION SHAFT......3-15
SEAL REPLACEMENT, PITMAN SHAFT....19-37
SEAL REPLACEMENT, TIMING CASE
COVER OIL......................9-30,9-73
SEAL REPLACEMENTÐYJ, DOOR
WEATHERSTRIP....................23-142
SEAL REPLACEMENTÐYJ, LIFTGATE
GLASS WEATHERSTRIP..............23-125
SEAL/CROSSMEMBER AIR
DEFLECTORÐXJ, COWL
WEATHERSTRIP.....................23-11
SEALÐDRIVE PLATE SERVICE,
CONVERTERÐPUMP.................21-116
SEALÐXJ, LIFTGATE OPENING
WEATHERSTRIP.....................23-64
SEALÐYJ, BELTLINE.................23-142
SEALÐYJ, COWL WEATHERSTRIP......23-109
SEALÐYJ, TAILGATE WEATHERSTRIP . . . 23-123
SEALÐYJ, WINDSHIELD FRAME
WEATHERSTRIP....................23-146
SEALS AND BEARING REPLACEMENT,
PITMAN SHAFT......................19-34
SEALS, REAR MAIN OIL..............9-49,9-89
SEALS, VALVE SPRINGS AND OIL........9-23
SEALSÐIN CAR REPLACEMENT, PITMAN
SHAFT.............................19-23
SEALSÐXJ, DOOR WINDOW GLASS
AND DOOR OPENING WEATHERSTRIP....23-55
SEALSÐYJ, FULL-METAL DOOR
WEATHERSTRIP....................23-141
SEAT ADJUSTER/MOTORS, POWER . . . 8R-1,8R-2
SEAT ADJUSTER/MOTORS REMOVE/
INSTALL, POWER.....................8R-3
SEAT BELT INDICATOR WARNING LAMP;
INSTRUMENT CLUSTER (XJ).........8W-40-2
SEAT BELT INDICATOR WARNING LAMP;
INSTRUMENT CLUSTER (XJ-RHD).....8W-40-2
SEAT BELT SWITCH, DRIVER'S......8U-1,8U-3
SEAT CUSHION AND COVERÐXJ,
BUCKET............................23-81
SEAT CUSHION COVERÐXJ, REAR......23-82
SEAT CUSHIONÐXJ, REAR.............23-82
SEAT PLATFORMÐXJ, BUCKET.........23-82
SEAT, POWER; POWER SEAT (XJ).....8W-63-1
SEAT, POWER; POWER SEAT (XJ-RHD) . 8W-63-1
SEAT SWITCH CONTINUITY, POWER......8R-2
SEAT SWITCH, POWER............8R-1,8R-2
SEAT SWITCH REMOVE/INSTALL,
POWER.............................8R-3
SEATBACK COVER AND FRAMEÐXJ,
BUCKET............................23-81
SEATBACK COVERÐXJ, REAR..........23-84
SEATBACK LATCH STRIKER AND
BUMPERÐXJ, REAR..................23-84
SEATBACKÐXJ, REAR................23-83
SEATÐYJ, REAR BENCH..............23-153
SEATSÐXJ, FRONT BUCKET............23-81
SEATSÐYJ........................23-153
SEATSÐYJ, BUCKET.................23-153
SECOND (2) RANGE, HYDRAULIC FLOW
IN MANUAL.........................21-96
SECOND BRAKE OVERHAUL...........21-241
SECONDARY CABLES, SPARK PLUG.....8D-14,
8D-24
SECONDARY CIRCUIT DIAGNOSIS,
IGNITION...........................8D-10
SECTION IDENTIFICATION; WIRING
DIAGRAMS (XJ)......................8W-1
SECTION IDENTIFICATION; WIRING
DIAGRAMS (XJ-RHD)..................8W-1
SECTION IDENTIFICATION; WIRING
DIAGRAMS (YJ)
......................8W-1
SELECTIVE SNAP RING CHARTÐAX 15
MANUAL TRANSMISSION
.............21-334
SELF-DIAGNOSTIC TEST, COMPASS/
DISPLAY
............................8C-2
SENDING UNIT, FUEL GAUGE
...........14-16
SENSEÐPCM INPUT, AUTOMATIC
SHUTDOWN (ASD)
...................14-21
24 INDEXJ
Description Group-Page Description Group-Page Description Group-Page