1994 PONTIAC GRAND-AM suspension

NOTICE: ~ ~~
Towing a
vehicle over rough
surfaces could damage a vehicle.
Damage can occur from vehicle to
ground or vehicle to wheel-lift
equipment.
To help avoid damage,
install a towing dolly and raise the
vehicle
until adequate clearance is
obtained between the ground and/or
wheel-lift equipment.
Do not attach winch cables or
J-hooks to suspension components
when using car carrier equipment.
Always use T-hooks inserted
in the
T-hook slots.
00. 154
Attach T-hook chains into the slots in the
bottom
of the floor pan, just behind the
front wheels on both sides.
Attach a separate safety chain around the
outboard end of each lower control arm.
ProCarManuals.com

Towing from the
Rear-Vehicle Hook-Up
Before hooking up to a tow truck, be sure
to read all the information
in “Towing
Your Pontiac” earlier
in this section. Also
be sure to use the proper hook-up for
your particular vehicle.
NOTE: The ignition key must be in the
OFF position to avoid the automatic door
lock from locking during tow.
Attach T-hook chains on both sides of the
underbody just ahead of the wheels.
NOTICE:
Do not tow with sling-type
equipment or rear bumper valance
will be damaged. Use wheel-lift or
car carrier equipment (additional
ramping may be required for car
carrier equipment). Use safety chains and wheel straps.
32
NOTICE:
Towing a vehicle over rough
surfaces
could damage a vehicle.
Damage occur from vehicle to
ground or vehicle to wheel-lift’
equipment.
To help avoid damage,
install a towing dolly and raise the
vehicle
until adequate clearance is
obtained between the ground md/w
wheel-lift equipment.
Do not attach winch cables or
J-hooks to suspension
componxmts
when using car carrier equipment.
Always
use T-hooks inserted in the
T-hook slots.
155...
ProCarManuals.com

Maintenance Schedule
Explanation of Scheduled Maintenance
Services
Following are explanations of the services listed in Schedule I
and Schedule 11.
The proper fluids and lubricants to use are listed in Section D.
Make sure whoever services your vehicle uses these. All parts
should be replaced and all necessary repairs done before you or
anyone else drives the vehicle.
NOTE: To determine your engine’s displacement and code, see
“Engine Identification”
in the Index.
1.
2.
Engine Oil and Filter Change* -- Always use SH or SG
Energy Conserving I1 oils of proper viscosity. The “SH” or
“SG” designation may be shown alone or in combination
with others, such as “SH/CD,” “SH, SG, CD,” “SG/CD,”
etc. To determine the preferred viscosity for your vehicle’s
engine (e.g., SAE 5W-30 or SAE 10W-30), see “Engine
Oil”
in the Index.
Chassis Lubrication -- Lubricate suspension and steering
linkage. Lubricate the transaxle shift linkage, underbody
contact points and linkage.
3.
4.
5.
Tire and Wheel Rotation and Inspection -- For proper
wear and maximum tire life, rotate your tires following the
instructions
in this manual. See “Tires, Inspection &
Rotation” in the Index. Check the tires for uneven wear or
damage. If you see irregular or premature wear, check the
wheel alignment, Check for damaged wheels also.
Engine Accessory Drive Belt(s) Inspection -- Inspect the
belt(s) for cracks, fraying, wear and proper tension. Replace
as needed. (Belts can have many small cracks
in individual
ribs without affecting performance.)
Cooling System Service* -- Drain, flush and refill the
system with new or approved recycled coolant conforming
to
GM Specification 1825M. Keep coolant at the proper
mixture as specified. See “Coolant”
in the Index. This
provides proper freeze and boil protection, corrosion
inhibitor level and maintains proper engine operating
temperature.
Inspect hoses and replace if they are cracked, swollen or
deteriorated. Tighten screw-type hose clamps. Clean the
outside of the radiator and air conditioning condenser. Wash
the pressure cap and neck.
To help ensure proper operation, we recommend a pressure
test of both the cooling system and the pressure cap.
. . 230
ProCarManuals.com

Maintenance Schedule
CHECK OR SERVICE
Underbody Flushing
WHAT TO DO
At least every spring, use plain water to
flush any corrosive materials from the
underbody. Take care to clean
thoroughly any areas where mud and
other debris can collect.
Section C: Periodic Maintenance
Inspections
hted below are inspections and services which should be
Ierformed at least twice a year (for instance, each spring and
all). You should let your
GM dealer’s service department or
Ither qualified service center do these jobs. Make sure any
lecessary repairs are completed at once.
INSPECTION
OR SERVICE
testraint Systems
Steering,
Suspension and
?ront-Wheel-Drive
4xle Boot and Seal
[nspection
Exhaust System
[nspection
WHAT SHOULD BE DONE
Now and then, make sure all your belts,
buckles, latch plates, retractors,
anchorages and reminder systems are
working properly. Look for any loose
parts or damage. If you see anything that
might keep a restraint system from doing
its job, have it repaired.
Inspect the front and rear suspension and
steering system for damaged, loose or
missing parts, signs of wear, or lack of
lubrication. Inspect the power steering
lines and hoses for proper hookup,
binding, leaks, cracks, chafing, etc.
Clean and then inspect the drive axle
boot seals for damage, tears or leakage.
Replace seals
if necessary.
Inspect the complete exhaust system.
Inspect the body near the exhaust
system.
Look for broken, damaged,
missing or out-of-position parts as well
as open seams, holes, loose connections,
or other conditions which could cause a
heat build-up
in the floor pan or could let
exhaust fumes into the vehicle. See “Engine Exhaust”
in the Index.
236
ProCarManuals.com

1994 PONTIAC SERVICE PUBLICATIONS ORDERING INFORMATION
The following publications covering the operation and servicing of your vehicle can be purchased by filling out the Service Publications Order Form
in this book and mailing it with your check, money order or credit card information to Helm, lncorporated (address listed below).
CURRENT PUBLICATIONS FOR 1994 PONTIAC GRAND AM
PRODUCT SERVICE PUBLICATIONS
Product Service Publications (PSP’s), are bulletins, letters \
and articles
published for trained dealer service personnel. See Service Publica-
tions listed previously in this section.
A cumulative index is published quarterly during the current model
year. The indexes list all PSP’s published by Pontiac in the model year.
PSP Index
Year Form Number Price
1994 PSPI-94-P ........................ . . Free
1993 PSPI-93-P
.......................... Free
1992 PSPI-92-P
.......................... Free
1991 PSPI-91-P
............................... Free
PSP Bound Bulletin Book (Complete Year Bulletins)
Year Description Form Number Price
1992 All PSP’S .................... S-92-PSP-4 15.00
1991 All PSP’S .................... S-91-PSP-4 15.00
For subscription information call Helm, lncorporated.
SERVICE MANUALS
Service Manuals have the diagnosis, repair and overhaul information
on engines, transmission, axle, suspension, brakes, electrical, steer-
ing, body, etc.
Model Form Number Price
1994 Pontiac Grand Am
............. S-9410-N TBA*
NOTE: Please specify special body or engine types on order form.
Write information in the Form Number column. For example: Turbo,
Convertible.
*Price to be announced at a later date. Call 1-800-782-4356 for further information.
OWNER’S INFORMATION
Owner publications are written directly for owners and intended
to pro-
vide basic operational information about the vehicle. The Owner’s
Manual includes the Maintenance Schedule for all models.
1994 Pontiac Grand Am Owner’s Manual
In Portfolio: lncludes
Porffolio, Owner‘s Manual and Warranty Booklet.
1994 Pontiac Grand Am In-Portfolio
........ .10260946 $15.00
Without Portfolio: Includes Owner’s Manual.
1994 Pontiac Grand Am Without Portfolio
... .lo260961 $10.00
CURRENT & PAST MODEL ORDER FORMS
Service Publications are available for current and past model Pontiac
vehicles. To request an order form, please specify year and model
name
of vehicle.
Address all inquiries to: HELM, INCORPORATED
PO. Box 07130 ~~ ~
Detroit, MI 48207
For
information and inquiriescall: 1-800-782-4356
253..
ProCarManuals.com