1994 JEEP CHEROKEE water pump

HEATING AND AIR CONDITIONING
CONTENTS
page page
CLIMATE CONTROL SYSTEMÐXJ VEHICLES . 22
CLIMATE CONTROL SYSTEMÐYJ VEHICLES . 37
COMPRESSOR OVERHAUL............... 17
GENERAL INFORMATION.................. 1SERVICE DIAGNOSISÐELECTRICAL........ 14
SERVICE DIAGNOSISÐMECHANICAL........ 8
TORQUE SPECIFICATIONS................ 45
GENERAL INFORMATION
INDEX
page page
A/C Operation............................ 1
Compressor Oil Level...................... 6
Pressure Gauge and Manifold Assembly........ 2
Refrigerant (R-12)......................... 1
Service Precautions........................ 2Service Valves........................... 3
System Charge........................... 5
System Discharge......................... 4
System Evacuation........................ 4
A/C OPERATION
The compressor increases the pressure and temper-
ature of the refrigerant. The heated refrigerant vapor
is then pumped into the condenser where it cools by
the air passing over the condenser fins. As the refrig-
erant cools in the condenser, it condenses into a liq-
uid. Still under high pressure, the liquid refrigerant
passes into the receiver. The receiver acts as a reser-
voir to furnish refrigerant to the expansion (H) valve
at all times. From the receiver, the high pressure liq-
uid refrigerant passes to the expansion (H) valve.
The expansion (H) valve meters refrigerant into the
evaporator where a low pressure is maintained by
the suction side of the compressor. As it enters the
evaporator, the refrigerant immediately begins to
boil by absorbing heat from the air passing over the
evaporator core. Having given up its heat to boil the
refrigerant, the air is cooled and passes into the pas-
senger compartment of the vehicle. From the evapo-
rator the vaporized refrigerant is drawn back to the
compressor to repeat the cycle.
REFRIGERANT (R-12)
It is illegal to release R-12 into the atmosphere.
SAFETY PRECAUTIONS
WARNING: EXTREME CARE MUST BE TAKEN TO
PREVENT ANY LIQUID REFRIGERANT FROM COM-
ING IN CONTACT WITH THE SKIN AND ESPE-
CIALLY THE EYES. ALWAYS WEAR SAFETYGOGGLES WHEN SERVICING ANY PART OF THE
REFRIGERANT SYSTEM. IF EYE CONTACT IS
MADE, APPLY A FEW DROPS OF MINERAL OIL TO
THE EYES AND FLUSH WITH WATER FOR SEV-
ERAL MINUTES. SEEK MEDICAL ATTENTION IMME-
DIATELY.
The refrigerant used in the air conditioner system
is Refrigerant-12 (R-12). R-12 is nonexplosive, non-
flammable, non-corrosive, has practically no odor and
is heavier than air. Although it is classified as a safe
refrigerant, certain precautions must be observed to
protect the parts involved and the person who is
working on the unit. Liquid R-12, at normal atmo-
sphere pressures and temperatures, evaporates so
quickly that it has the tendency to freeze anything it
contacts.
WARNING: TO AVOID A DANGEROUS EXPLOSION,
NEVER WELD OR STEAM CLEAN NEAR AIR CON-
DITIONING LINES OR COMPONENTS. DO NOT
HEAT R-12 ABOVE 52ÉC (125ÉF).
The R-12 in the system is always under pressure.
Because the system is tightly sealed, heat applied to
any part could cause this pressure to build up exces-
sively.
JHEATING AND AIR CONDITIONING 24 - 1

CRANKSHAFT POSITION SENSORÐPCM
INPUT.............................14-20
CRANKSHAFT POSITION SENSOR TEST;
FUEL SYSTEM.......................14-44
CRANKSHAFT POSITION SENSOR TEST;
IGNITION SYSTEMS...................8D-9
CROSSMEMBER COVER, FRAME..........13-14
CROSSMEMBER, RADIATOR SUPPORT......23-5
CUSHION AND COVER, BUCKET SEAT......23-98
CUSHION COVERÐXJ VEHICLES, REAR
SEAT .............................23-107
CUSHION, ENGINE FRONT SUPPORT.......13-15
CUSHION RECONDITIONINGÐXJ
VEHICLES, REAR SEAT...............23-108
CUSHIONÐXJ VEHICLES, REAR SEAT.....23-107
CYLINDER BLOCK..................9-45,9-85
CYLINDER BORES, HONING................9-2
CYLINDER COMBUSTION PRESSURE
LEAKAGE TEST DIAGNOSIS...........9-5,9-6
CYLINDER DISPOSAL, LIFTGATE
SUPPORT ROD......................23-70
CYLINDER, DOOR KEY LOCK.............23-54
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ2.5L 4...................25-2
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ4.0L 6...................25-3
CYLINDER, FULL-METAL DOOR KEY
LOCK.............................23-178
CYLINDER HEAD COVER, ENGINE......9-18,9-59
CYLINDER HEAD, ENGINE............9-19,9-60
CYLINDER HEAD GASKET FAILURE
DIAGNOSIS, ENGINE....................9-5
CYLINDER INSTALLATION, MASTER....5-20,5-50
CYLINDER INSTALLATION, WHEEL.........5-37
CYLINDER, LIFTGATE SUPPORT ROD......23-69
CYLINDER, MASTER.....................5-40
CYLINDER OVERHAUL, WHEEL............5-36
CYLINDER OVERHAUL, MASTER...........5-20
CYLINDER REMOVAL, MASTER........5-20,5-50
CYLINDER REMOVAL, WHEEL.............5-36
CYLINDER REPLACEMENT, LIFTGATE
LOCK...............................8P-7
CYLINDER, STANDARD MASTER...........5-20
CYLINDER, TAILGATE LOCK.............23-160
CYLINDER/POWER BOOSTER TEST,
MASTER............................5-11
CYLINDER/STRIKER, LIFTGATE LATCH/
KEY LOCK..........................23-68
CYLINDERS, KEY LOCK............23-2,23-132
D RANGE FIRST GEAR, HYDRAULIC
FLOW IN...........................21-87
D RANGE SECOND GEAR, HYDRAULIC
FLOW IN...........................21-88
D RANGE THIRD GEAR, HYDRAULIC
FLOW IN...........................21-89
DAMAGE TORQUE, COLLISION............13-1
DAMAGED OR WORN THREADS, REPAIR.....9-4
DAMPENER, STEERING............19-15,19-18
DAMPER, ENGINE......................9-13
DAMPER, VIBRATION................9-26,9-67
DASH PANEL INSULATION PANEL.........23-95
DASH PANEL INSULATOR PANEL.........23-11
DATA LINK CONNECTORÐPCM INPUT.....14-20
DATA LINK CONNECTORÐPCM OUTPUT....14-24
DATA, VEHICLE DIMENSION . . . INTRO.-3,INTRO.-4
DATA, VEHICLE LOAD................INTRO.-3
DATA, XJ VEHICLE LOAD.............INTRO.-5
DATA, YJ-VEHICLE LOAD.............INTRO.-6
DAYTIME RUNNING LIGHTS (CANADA
ONLY) .............................8L-16
DECODING, VEHICLE CODE...........INTRO.-3
DECODING, VEHICLE IDENTIFICATION
NUMBER (VIN)....................INTRO.-2
DEFLECTOR, COWL WEATHERSTRIP
SEAL/CROSSMEMBER AIR.............23-10
DEFOGGER GRID REPAIR, REAR
WINDOW............................8N-2
DEFOGGER GRID TEST, REAR
WINDOW............................8N-1
DEFOGGER, REAR WINDOW..............8A-1
DEFOGGER RELAY, REAR
................8N-4
DEFOGGER SWITCH REPLACEMENT,
REAR WINDOW
.......................8N-4
DEFOGGER/FOG LAMP/REAR WIPER
SWITCHES, REAR
....................8E-21
DEFROSTER DUCT REPLACEMENT
........24-29DEFROSTER NOZZLE AND DUCT..........24-40
DELAY FUNCTION TROUBLE
DIAGNOSISÐXJ VEHICLES, HEADLAMP . . . 8L-16
DELAY MODULE REPLACEMENTÐXJ
VEHICLES, HEADLAMP................8L-16
DELAY MODULEÐXJ VEHICLES,
SENTINEL HEADLAMP.................8L-15
DELIVERY SYSTEM, FUEL................14-2
DEPTH INFORMATION, PINION GEAR;
FRONT SUSPENSION AND AXLE..........2-37
DEPTH INFORMATION, PINION GEAR;
REAR SUSPENSION AND AXLES..........3-19
DEPTH VARIANCE, PINION GEAR; FRONT
SUSPENSION AND AXLE................2-38
DEPTH VARIANCE, PINION GEAR; REAR
SUSPENSION AND AXLES...........3-20,3-38
DESCRIPTION (AIR CONDITIONING).......24-41
DESCRIPTION; AUDIO SYSTEMS...........8F-1
DESCRIPTION (HEATING)................24-37
DESCRIPTION; HEATING AND AIR
CONDITIONING.................24-17,24-22
DESCRIPTION; OVERHEAD CONSOLE.......8C-1
DESCRIPTION; POWER DOOR LOCKS.......8P-1
DESCRIPTION; POWER WINDOWS.........8S-1
DESCRIPTION; TRANSMISSION AND
TRANSFER CASE....................21-156
DESCRIPTION; TURN SIGNALS AND
HAZARD WARNING FLASHER........8J-1,8J-2
DESCRIPTION/SYSTEM OPERATION,
MULTI-PORT FUEL INJECTION (MFI)Ð
COMPONENT........................14-17
DESIGNATION CODES, VEHICLE........INTRO.-1
DESIGNATIONS, LABELS/PLATES, CODES
AND DIMENSIONS.................INTRO.-1
DESIGNATIONS, VEHICLE.............INTRO.-1
DETECTION AND REPAIR, FIXED GLASS
WATER LEAK..................23-83,23-189
DIAGNOSING INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING NON-INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING PARKING BRAKE
PROBLEMS..........................5-10
DIAGNOSING POWER DOOR LOCKS....8P-1,8P-9
DIAGNOSING REAR WIPER...............8K-6
DIAGNOSING REAR WIPER WASHER.......8K-6
DIAGNOSING REAR WIPER/WASHER......8K-14
DIAGNOSING SERVICE BRAKE
PROBLEMS...........................5-8
DIAGNOSING WINDSHIELD WASHER
(INTERMITTENT)......................8K-4
DIAGNOSING WINDSHIELD WASHER
(NON-INTERMITTENT)..................8K-4
DIAGNOSING WINDSHIELD WIPERS . . . 8K-3,8K-11
DIAGNOSINGÐALL LAMPS OUT..........8E-16
DIAGNOSINGÐTURN SIGNAL
INOPERATIVE.........................8J-2
DIAGNOSIS, 2.5L STARTER MOTOR NOISE . . . 8A-13
DIAGNOSIS, 30RH/32RH TRANSMISSION . . 21-69,
21-77,21-78,21-79,21-80,21-81,21-82,21-83,21-84,
21-85
DIAGNOSIS, ABS BRAKE..................5-3
DIAGNOSIS, ABS FAULT................5-4,5-6
DIAGNOSIS, AIR CONDITIONING
SYSTEM............................24-12
DIAGNOSIS AND REPAIR............8G-1,8G-2
DIAGNOSIS; AUDIO SYSTEMS.............8F-1
DIAGNOSIS, AW-4 TRANSMISSION
.......21-167
DIAGNOSIS, AXLE NOISE/VIBRATION;
FRONT SUSPENSION AND AXLE
..........2-16
DIAGNOSIS, AXLE NOISE/VIBRATION;
REAR SUSPENSION AND AXLES
..........3-7
DIAGNOSIS, BELT
.......................7-31
DIAGNOSIS CHARTS, INSPECTION
..........6-4
DIAGNOSIS; CHIME/BUZZER WARNING
SYSTEMS
...........................8U-1
DIAGNOSIS, CLUTCH
.....................6-3
DIAGNOSIS, COMPRESSOR
..............24-13
DIAGNOSIS, CONVERTER HOUSING
LEAK
..............................21-73
DIAGNOSIS; COOLING SYSTEM
.............7-4
DIAGNOSIS, CYLINDER COMBUSTION
PRESSURE LEAKAGE TEST
...............9-6
DIAGNOSIS, DISCONNECT AXLE/SHIFT
MOTOR
.............................2-27DIAGNOSIS, DOME/COURTESY LAMP
TROUBLE...........................8L-19
DIAGNOSIS, ECU........................5-4
DIAGNOSISÐELECTRICAL, SERVICE.......24-14
DIAGNOSIS, ENGINE.....................9-5
DIAGNOSIS, ENGINE CYLINDER HEAD
GASKET FAILURE......................9-5
DIAGNOSIS, EXHAUST SYSTEM............11-2
DIAGNOSIS, FOG LAMP TROUBLE.........8L-12
DIAGNOSIS, GAUGE PACKAGE............8E-22
DIAGNOSIS, GEAR LEAKAGE..............19-8
DIAGNOSIS GUIDES AND CHARTS........21-76
DIAGNOSISÐHAZARD LAMPS
INOPERATIVE.....................8J-1,8J-2
DIAGNOSIS, HCU........................5-4
DIAGNOSIS, HEATING SYSTEM...........24-11
DIAGNOSIS, IGNITION OFF DRAW (IOD).....8A-8
DIAGNOSIS, IGNITION SECONDARY
CIRCUIT...........................8D-12
DIAGNOSIS, ILLUMINATED ENTRY
SYSTEM TROUBLE..............8L-21,8L-22
DIAGNOSIS INFORMATION, GENERAL;
CLUTCH..............................6-3
DIAGNOSIS INFORMATION, GENERAL;
TRANSMISSION AND TRANSFER
CASE.............................21-167
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐXJ.........................8E-3
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐYJ........................8E-14
DIAGNOSIS, INTAKE MANIFOLD LEAKAGE.....9-5
DIAGNOSIS, LIGHTED VANITY MIRROR
TROUBLE...........................8L-19
DIAGNOSIS, MANUAL STEERING
SYSTEM............................19-36
DIAGNOSISÐMECHANICAL, SERVICE;
ENGINES.............................9-8
DIAGNOSISÐMECHANICAL, SERVICE;
HEATING AND AIR CONDITIONING........24-8
DIAGNOSIS, MULTI-PORT FUEL
INJECTION (MFI)ÐGENERAL...........14-32
DIAGNOSIS, NOISE.....................3-45
DIAGNOSIS, NP231 SERVICE............21-274
DIAGNOSIS, NP242 SERVICE............21-295
DIAGNOSIS, PERFORMANCE.............24-10
DIAGNOSIS; POWER MIRRORS............8T-1
DIAGNOSIS; POWER SEATS..............8R-1
DIAGNOSIS, POWER STEERING SYSTEM....19-3,
19-4,19-5,19-6,19-7
DIAGNOSIS, PRELIMINARY..............21-69
DIAGNOSIS, PRESSURE..................24-9
DIAGNOSIS PROCEDURES; BRAKES......5-3,5-7
DIAGNOSIS, PUMP LEAKAGE..............19-8
DIAGNOSIS, RADIO NOISE................8F-2
DIAGNOSIS; REAR WINDOW DEFOGGER....8N-2
DIAGNOSIS, SERPENTINE DRIVE BELT......7-32
DIAGNOSIS, SERVICE BRAKE..............5-7
DIAGNOSIS, SERVICE; FRONT
SUSPENSION AND AXLE................2-18
DIAGNOSIS, SERVICE; REAR
SUSPENSION AND AXLES................3-9
DIAGNOSIS, SERVICE; TRANSMISSION
AND TRANSFER CASE . 21-2,21-33,21-171,21-172
DIAGNOSIS, SPRING AND SHOCK;
FRONT SUSPENSIONAND AXLE
......2-12,2-14
DIAGNOSIS, SPRING AND SHOCK; REAR
SUSPENSIONAND AXLES
.............3-3,3-5
DIAGNOSIS, STARTING SYSTEM
..........8A-10
DIAGNOSIS; STEERING
.................19-35
DIAGNOSIS, SUSPENSION AND
STEERING SYSTEM
.....................2-7
DIAGNOSIS, SYSTEM
.....................7-7
DIAGNOSISÐTURN SIGNAL
INOPERATIVE
.........................8J-1
DIAGNOSISÐVEHICLE RUNS ROUGH
AND/OR HAS A MISS, INJECTOR
........14-49
DIAGNOSIS, VIBRATION
.............22-9,22-10
DIAGNOSISÐXJ VEHICLES, HEADLAMP
DELAY FUNCTION TROUBLE
............8L-16
DIAGNOSISÐXJ VEHICLES, HEADLAMP
TROUBLE
............................8L-1
DIAGNOSISÐYJ VEHICLES,
HEADLAMP TROUBLE
..................8L-2
6 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

FILTER REPLACEMENT, OIL.............21-100
FILTER SHIELD AND BRACKET, FUEL.......13-17
FINAL ASSEMBLY; FRONT SUSPENSION
AND AXLE...........................2-44
FINAL ASSEMBLY; REAR SUSPENSION
AND AXLES..........................3-26
FIRING ORDERÐ2.5L ENGINE, ENGINE....8D-33
FIRING ORDERÐ4.0L ENGINE, ENGINE....8D-33
FIRST GEAR (1) POSITION, HYDRAULIC
FLOW IN MANUAL...................21-94
FIRST GEAR, HYDRAULIC FLOW IN D
RANGE.............................21-87
FIRST-REVERSE BRAKE PISTON AND
TRANSMISSION CASE OVERHAUL......21-237
FIRST, SYMPTOM AND ACTIONÐSEE
PRELIMINARY CHECKS..................7-6
FIRSTÐTHIRDÐREVERSE GEAR
COMPONENTS......................21-159
FITTING CHART, CONNECTING ROD
BEARING........................9-36,9-76
FITTING CHART, MAIN BEARING.......9-43,9-83
FITTING O-RING SEAL, FLOW CONTROL
VALVE .............................19-12
FITTINGS, QUICK-CONNECT..........14-9,14-59
FITTINGS, SERVICING TRANSMISSION
COOLER LINES.....................21-106
FITTINGS, TRANSMISSION COOLER LINE . . 21-187
FIXED GLASS WATER LEAK DETECTION
AND REPAIR ..................23-83,23-189
FIXED WINDOW GLASS...........23-73,23-183
FIXED WINDOW GLASS, REAR DOOR......23-53
FLARE, FENDER......................23-144
FLARES AND LINERS, REAR
WHEELHOUSE.......................23-18
FLASHER, TURN SIGNALS AND HAZARD
WARNING...........................8A-1
FLOOR BRACKETSÐXJ VEHICLES,
SPARE TIRE/WHEEL HOLDDOWN.......23-128
FLOOR CONSOLEÐXJ VEHICLES, FULL . . . 23-125
FLOOR CONSOLES....................23-197
FLOOR MATS, CARPETS................23-129
FLOW CONTROL VALVE FITTING O-RING
SEAL..............................19-12
FLOW DURING FULL THROTTLE 3-2
DOWNSHIFT, HYDRAULIC..............21-92
FLOW DURING PART THROTTLE 3-2
DOWNSHIFT, HYDRAULIC..............21-91
FLOW IN D RANGE FIRST GEAR,
HYDRAULIC.........................21-87
FLOW IN D RANGE SECOND GEAR,
HYDRAULIC.........................21-88
FLOW IN D RANGE THIRD GEAR,
HYDRAULIC.........................21-89
FLOW IN MANUAL FIRST GEAR
(1) POSITION, HYDRAULIC.............21-94
FLOW IN MANUAL SECOND (2) RANGE,
HYDRAULIC.........................21-93
FLOW IN PARK AND NEUTRAL,
HYDRAULIC.........................21-86
FLOW IN REVERSE, HYDRAULIC..........21-95
FLOW IN THIRD GEAR (CONVERTER
CLUTCH ENGAGED), HYDRAULIC........21-90
FLOW TESTING, TRANSMISSION
COOLER...........................21-106
FLUID AND LEVELÐBRAKELINES
AND HOSES, BRAKE BLEEDINGÐ
BRAKE..............................5-13
FLUID CAPACITIES.......................0-4
FLUID, CLUTCH LINKAGE
..................6-1
FLUID CONTAMINATION, BRAKE
...........5-13
FLUID, IMPORTANCE OF CLEAN BRAKE
.....5-48
FLUID LEVEL AND CONDITION
...........21-69
FLUID LEVEL AND CONDITION,
CHECKING
....................21-96,21-173
FLUID LEVEL, BRAKE
....................5-13
FLUID LEVEL, CLUTCH
...................6-14
FLUID LEVEL, CORRECT
.................5-48
FLUID, RECOMMENDED
............21-66,21-96
FLUID, RECOMMENDED BRAKE; BRAKES
....5-13,
5-48
FLUID TUBE RETAINER CLIP, FUEL AND
BRAKE; BODY COMPONENTSÐXJ
VEHICLES
..........................23-86
FLUID TUBE RETAINER CLIP, FUEL
AND BRAKE; FRAME AND BUMPERS
.....13-16FLUID/LUBRICANTS/CLEANING
SOLVENTS, BRAKE.....................5-1
FLUSHING, COOLING SYSTEM CLEANING/
REVERSE............................7-17
FLUSHING, TRANSMISSION COOLER
REVERSE..........................21-105
FLYWHEEL SERVICE.....................6-15
FOG LAMP BEAM ADJUSTMENT..........8L-12
FOG LAMP BULB/ELEMENT
REPLACEMENT......................8L-13
FOG LAMP REPLACEMENT..............8L-15
FOG LAMP SERVICE INFORMATION........8L-12
FOG LAMP SWITCH REPLACEMENT.......8L-14
FOG LAMP TROUBLE DIAGNOSIS.........8L-12
FOG LAMPÐYJ RENEGADE VEHICLES....23-150
FORM-IN-PLACE GASKETS.................9-1
FORMULAS AND EQUIVALENT VALUES,
CONVERSION.....................INTRO.-8
FORWARD CLUTCH OVERHAUL..........21-223
FOURTH GEAR OVERDRIVE COMPONENTS . . 21-158
FRAME ALIGNMENT....................13-10
FRAME, BUCKET SEATBACK COVER......23-100
FRAME CROSSMEMBER COVER..........13-14
FRAME INSPECTION/MEASUREMENTS.....13-10
FRAME REPAIR SERVICE................13-13
FRAME WEATHERSTRIP SEAL,
WINDSHIELD.......................23-185
FRAME, WINDSHIELD.................23-184
FRAME, YJ............................13-8
FRESH AIR DOOR VACUUM MOTOR.......24-41
FRESH AIR INTAKE DUCT...............24-41
FRESH AIR VENTILATION................24-39
FRONT AND REAR AXLES................0-26
FRONT AXLE, MODEL 30.................2-46
FRONT BAND ADJUSTMENT.............21-99
FRONT BUCKET SEATS..................23-97
FRONT BUMPER...................13-3,13-14
FRONT CABLE REPLACEMENT (YJ),
PARKING BRAKE......................5-62
FRONT CARPET/MATÐXJ VEHICLES......23-129
FRONT CLUTCH OVERHAUL.............21-125
FRONT DOOR SPACER BLOCKSÐTWO-
DOOR VEHICLES.....................23-60
FRONT DOOR VENT WINDOW............23-50
FRONT DOOR WINDOW GLASS...........23-49
FRONT DOOR WINDOW GLASS
REGULATOR........................23-48
FRONT DRIVE AXLE......................2-3
FRONT FASCIA AND SKID PLATEÐYJ
RENEGADE VEHICLES................23-148
FRONT FENDER.......................23-14
FRONT FENDER EXTENSION PANELÐYJ
RENEGADE VEHICLES................23-149
FRONT INNER SCUFF PLATE/COWL SIDE
TRIM PANELÐXJ VEHICLES...........23-114
FRONT PARK/TURN SIGNAL LAMP BULB
REPLACEMENT.......................8L-8
FRONT PLANETARY GEAR OVERHAUL.....21-228
FRONT SERVO AND BAND OVERHAUL....21-136
FRONT SHOULDER BELT/BUCKLEÐXJ
VEHICLES.........................23-119
FRONT SHOULDER BELTS..............23-196
FRONT SKID PLATE....................23-84
FRONT SUPPORT CUSHION, ENGINE.......13-15
FRONT SUSPENSION.....................2-1
FRONT SUSPENSION COMPONENTS, XJ.....2-47
FRONT SUSPENSION COMPONENTS, YJ.....2-47
FRONT SUSPENSION, XJ.................2-10
FRONT SUSPENSION, YJ.................2-13
FRONT TOW HOOKS
....................13-5
FRONT WHEEL ALIGNMENT
................2-5
FRONT WHEEL BEARINGS
................0-31
FRONT WHEEL SENSOR INSTALLATION
.....5-49
FRONT WHEEL SENSOR REMOVAL
.........5-49
FRONT WIPER ARM AND PIVOT
ASSEMBLY REPLACEMENT
..............8K-9
FRONT WIPER ARM REPLACEMENT
........8K-8
FRONT WIPER BLADE REPLACEMENT
......8K-8
FRONT WIPER MOTOR
.................8K-10
FRONT WIPERS/WASHERS
...............8K-1
FRONT WIPERS/WASHERS GENERAL
INFORMATION
........................8K-8
FUEL AND BRAKE FLUID TUBE RETAINER
CLIP; BODY COMPONENTSÐXJ
VEHICLES
..........................23-86FUEL AND BRAKE FLUID TUBE
RETAINER CLIP; FRAME AND BUMPERS . . . 13-16
FUEL DELIVERY SYSTEM.................14-2
FUEL FILLER DOOR BUMPERS...........23-31
FUEL FILLER HOSE SPLASH SHIELDÐXJ
VEHICLES..........................23-86
FUEL FILLER NOZZLE/TUBE..............23-30
FUEL FILLER PROTECTOR/NOZZLE.......23-158
FUEL FILTER......................14-8,14-55
FUEL FILTER BRACKET..................23-86
FUEL FILTER SHIELD AND BRACKET.......13-17
FUEL GAUGE..........................8E-2
FUEL GAUGE INOPERATIVE...............8E-3
FUEL GAUGE SENDING UNIT.............14-15
FUEL INJECTION (MFI)ÐCOMPONENT
DESCRIPTION/SYSTEM OPERATION,
MULTI-PORT........................14-17
FUEL INJECTION (MFI)ÐCOMPONENT
REMOVAL/INSTALLATION, MULTI-PORT . . . 14-54
FUEL INJECTION (MFI)ÐGENERAL
DIAGNOSIS, MULTI-PORT..............14-32
FUEL INJECTOR.......................14-55
FUEL INJECTORSÐPCM OUTPUT.........14-25
FUEL PRESSURE LEAK DOWN TEST........14-7
FUEL PRESSURE REGULATOR............14-30
FUEL PRESSURE RELEASE PROCEDURE.....14-5
FUEL PUMP CAPACITY TEST..............14-7
FUEL PUMP ELECTRICAL CONTROL........14-5
FUEL PUMP MODULE..............14-2,14-56
FUEL PUMP RELAY....................14-56
FUEL PUMP RELAYÐPCM OUTPUT.......14-25
FUEL PUMP RELAY TESTING.............14-44
FUEL RAIL...........................14-30
FUEL RAIL ASSEMBLY..................14-56
FUEL REQUIREMENTS....................0-2
FUEL SYSTEM........................14-62
FUEL SYSTEM PRESSURE RELEASE
PROCEDURE........................14-56
FUEL SYSTEM PRESSURE TEST......14-5,14-48
FUEL TANK...........................14-12
FUEL TANK CAPACITIES............14-12,14-62
FUEL TANK FILLER TUBE CAP;
EMISSION CONTROL SYSTEMS......25-4,25-9
FUEL TANK FILLER TUBE CAP; FUEL
SYSTEM............................14-12
FUEL TANK FILLER TUBE, NO-LEAD.......14-12
FUEL TANK PRESSURE RELIEF/
ROLLOVER VALVE...............14-15,14-56
FUEL TANK SKID PLATE; BODY
COMPONENTSÐXJ VEHICLES..........23-84
FUEL TANK SKID PLATE; FRAME AND
BUMPERS..........................13-16
FUEL TANK SUPPORT STRAP............23-86
FUEL TANKS.....................14-12,14-56
FUEL TUBES/LINES/HOSES AND CLAMPS . . . 14-9,
14-56
FUEL USAGE STATEMENT................14-1
FUEL USAGE STATEMENTÐGAS
ENGINES............................0-17
FUEL WARNING INOPERATIVE, LOW........8E-4
FUEL WARNING LAMP, LOW..............8E-2
FULL FLOOR CONSOLEÐXJ VEHICLES....23-125
FULL-METAL DOOR ASSIST HANDLE.....23-175
FULL-METAL DOOR HINGES............23-179
FULL-METAL DOOR KEY LOCK
CYLINDER.........................23-178
FULL-METAL DOOR LATCH.............23-179
FULL-METAL DOOR LATCH EXTERNAL
RELEASE HANDLE...................23-178
FULL-METAL DOOR LATCH INSIDE
RELEASE AND LOCK HANDLE..........23-175
FULL-METAL DOOR SERVICE............23-181
FULL-METAL DOOR TRIM PANEL........23-175
FULL-METAL DOOR VENT WINDOW
GLASS............................23-177
FULL-METAL DOOR WATERDAM.........23-176
FULL-METAL DOOR WEATHERSTRIP
SEALS............................23-180
FULL-METAL DOOR WINDOW GLASS.....23-178
FULL-METAL DOOR WINDOW GLASS
REGULATOR
.......................23-177
FULL-METAL DOOR WINDOW GLASS
REGULATOR HANDLE
................23-175
FUNCTION TROUBLE DIAGNOSISÐXJ
VEHICLES, HEADLAMP DELAY
..........8L-16
FUSE CHARTS AND RELAY BANKS
.........8W-8
JINDEX9
Description Group-Page Description Group-Page Description Group-Page

INSTRUMENT PANEL ILLUMINATION
LAMPS............................8E-16
INSTRUMENT PANEL LAMPS..............8E-4
INSTRUMENT PANEL REPLACEMENT.......8E-8
INSTRUMENT PANEL SERVICE..........23-192
INSULATION PANEL, DASH PANEL........23-95
INSULATOR PANEL, DASH PANEL.........23-11
INSULATOR PANEL, HOOD..............23-138
INTAKE AIR TEMPERATURE SENSOR......14-54
INTAKE AIR TEMPERATURE SENSORÐ
PCM INPUT.........................14-20
INTAKE AIR TEMPERATURE SENSOR TEST . . . 14-43
INTAKE DUCT, FRESH AIR...............24-41
INTAKE MANIFOLD.....................14-57
INTAKE MANIFOLDÐ2.5L ENGINE..........11-8
INTAKE MANIFOLDÐ4.0L ENGINE..........11-9
INTAKE MANIFOLD AIR TEMPERATURE
SENSOR.......................8D-5,8D-27
INTAKE MANIFOLD AIR TEMPERATURE
SENSOR TEST.......................8D-14
INTAKE MANIFOLD LEAKAGE DIAGNOSIS.....9-5
INTERCHANGEABILITY, PARTS............21-66
INTERIOR COMPONENTS..........23-91,23-190
INTERIOR LAMPS......................8L-19
INTERIOR LAMPS, XJ..................8L-23
INTERIOR LAMPS, YJ..................8L-23
INTERIOR PAINT CODES, XJ............23-205
INTERIOR PAINT CODES, YJ............23-206
INTERIOR REARVIEW MIRROR...........23-74
INTERIOR REARVIEW MIRROR
SUPPORT BRACKET REPLACEMENT......23-75
INTERIOR TRIM PANELS AND SCUFF
PLATESÐXJ VEHICLES...............23-112
INTERLOCK CABLE ADJUSTMENT (XJ),
PARK........................21-97,21-186
INTERMEDIATE (COUPLING) SHAFT . . 19-21,19-43
INTERMITTENT WINDSHIELD WASHER,
DIAGNOSING........................8K-12
INTERMITTENT WIPER MODULE...........8K-5
INTERMITTENT WIPER WASHER..........8K-20
INTERNATIONAL VEHICLE CONTROL
AND DISPLAY SYMBOLS............INTRO.-3
IN-VEHICLE SERVICE, 30RH/32RH.........21-96
IN-VEHICLE SERVICE, AW-4.............21-173
ISOLATION, COMPRESSOR..............24-17
JACK STORAGEÐXJ VEHICLES..........23-127
JOINT ANGLE MEASUREMENT,
UNIVERSAL..........................16-4
JOINT REPLACEMENT, UNIVERSAL.........16-9
JOINTS, UNIVERSAL....................16-2
JOUNCE BUMPER, REAR................13-18
JUMP STARTING........................0-7
JUMP STARTING, HOISTING AND TOWING.....0-7
KEY LOCK CYLINDER, DOOR.............23-54
KEY LOCK CYLINDER, FULL-METAL
DOOR............................23-178
KEY LOCK CYLINDERS.............23-2,23-132
KEY WARNING SWITCH REPLACEMENT,
IGNITION............................8U-4
KEYLESS ENTRY.......................8P-8
KNOCK, LOW SPEED; FRONT
SUSPENSION AND AXLE................2-17
KNOCK, LOW SPEED; REAR SUSPENSION
AND AXLES...........................3-8
KNUCKLE AND BALL STUDS, STEERING.....2-30
LABEL, TIRE INFLATION PRESSURE.....INTRO.-3
LABEL, VEHICLE EMISSION CONTROL
INFORMATION (VECI)
..................25-1
LABEL, VEHICLE SAFETY CERTIFICATION
. INTRO.-1
LABELS/DECALS/PLATES
...........23-1,23-132
LABELS/PLATES, CODES AND
DIMENSIONS, DESIGNATIONS,
.......INTRO.-1
LAG TEST, TIME
......................21-169
LAMP, 4WD INDICATOR
..................8E-2
LAMP, ANTI-LOCK BRAKE SYSTEM (ABS)
INDICATOR
..........................8E-2
LAMP BEAM ADJUSTMENT, FOG
..........8L-12
LAMP, BRAKE INDICATOR; INSTRUMENT
PANEL AND GAUGESÐXJ
...............8E-2
LAMP, BRAKE INDICATOR; INSTRUMENT
PANEL AND GAUGESÐYJ
..............8E-16
LAMP BULB REPLACEMENT, BACK-UP/
REAR TURN SIGNAL/TAIL
...............8L-9
LAMP BULB REPLACEMENT, FRONT PARK/
TURN SIGNAL
........................8L-8LAMP BULB REPLACEMENT, SIDE
MARKER............................8L-7
LAMP BULB REPLACEMENT,
UNDERHOOD........................8L-18
LAMP BULB REPLACEMENTÐYJ
VEHICLES, HARDTOP DOME/CARGO.....8L-20
LAMP BULB/ELEMENT REPLACEMENT,
FOG ...............................8L-13
LAMP (CHECK ENGINE), MALFUNCTION
INDICATOR; INSTRUMENT PANEL
AND GAUGESÐXJ................8E-2,8E-4
LAMP (CHECK ENGINE), MALFUNCTION
INDICATOR; INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-16
LAMP (CHMSL)ÐXJ, CENTER HIGH
MOUNTED STOP.....................8L-10
LAMP (CHMSL)ÐYJ, CENTER HIGH
MOUNTED STOP.....................8L-11
LAMP, COOLANT TEMPERATURE
INDICATOR..........................8E-1
LAMP FOR DIAGNOSTIC TROUBLE CODES,
INDICATOR (CHECK ENGINE)...........8A-19
LAMP HOUSING, LIFTGATE LICENSE
PLATE .............................23-72
LAMP, I/P ASH RECEIVER TRAY..........23-92
LAMP, LICENSE PLATE..................8L-10
LAMP, LOW FUEL WARNING..............8E-2
LAMPÐPCM OUTPUT, EMR..............14-24
LAMPÐPCM OUTPUT, GENERATOR.......14-25
LAMPÐPCM OUTPUT, MALFUNCTION
INDICATOR.........................14-26
LAMP REPLACEMENT, DOME.............8L-20
LAMP REPLACEMENT, FOG..............8L-15
LAMP REPLACEMENT, UNDERHOOD.......8L-18
LAMP, SEAT BELT REMINDER............8E-16
LAMP SERVICE INFORMATION, DOME/
COURTESY.........................8L-19
LAMP SERVICE INFORMATION, FOG.......8L-12
LAMP SERVICE INFORMATION,
UNDERHOOD........................8L-17
LAMP, SERVICE REMINDER INDICATOR
(SRI)...............................25-1
LAMP SPEED CONTROL SWITCH TEST,
STOP...............................8H-7
LAMP SUPPORT BRACKET, I/P TWEETER
SPEAKER/COURTESY.................23-95
LAMP SWITCH REPLACEMENT, FOG.......8L-14
LAMP TROUBLE DIAGNOSIS, DOME/
COURTESY.........................8L-19
LAMP TROUBLE DIAGNOSIS, FOG.........8L-12
LAMP, UPSHIFT INDICATOR;
INSTRUMENT PANELAND GAUGESÐXJ....8E-2
LAMP, UPSHIFT INDICATOR;
INSTRUMENT PANELAND GAUGESÐYJ . . . 8E-16
LAMPÐYJ RENEGADE VEHICLES, FOG....23-150
LAMP/REAR WIPER SWITCHES, REAR
DEFOGGER/FOG......................8E-21
LAMPS, EXTERIOR......................8L-1
LAMPS, INDICATOR....................8E-14
LAMPS INOPERATIVE, DIAGNOSISÐ
HAZARD.........................8J-1,8J-2
LAMPS, INSTRUMENT PANEL.............8E-4
LAMPS, INSTRUMENT PANEL
ILLUMINATION......................8E-16
LAMPS, INTERIOR.....................8L-19
LAMPS OUT, DIAGNOSINGÐALL..........8E-16
LAMPS, XJ EXTERIOR..................8L-23
LAMPSÐXJ, HAZARD...................8J-1
LAMPS, XJ INTERIOR..................8L-23
LAMPS, YJ EXTERIOR..................8L-23
LAMPSÐYJ, HAZARD...................8J-2
LAMPS, YJ INTERIOR..................8L-23
LATCH ADJUSTMENT, DOOR.............23-55
LATCH AND RELEASE HANDLE,
TAILGATE..........................23-160
LATCH ASSEMBLY REPLACEMENT,
SOLENOID...........................8P-6
LATCH, DOOR.........................23-56
LATCH EXTERNAL RELEASE HANDLE,
FULL-METAL DOOR..................23-178
LATCH, FULL-METAL DOOR
.............23-179
LATCH, HOOD SAFETY
.................23-139
LATCH INSIDE RELEASE AND LOCK
HANDLE, FULL-METAL DOOR
..........23-175
LATCH RELEASE AND LOCK RODS,
DOOR INSIDE
.......................23-57LATCH RELEASE CABLE REPLACEMENT....23-10
LATCH REPLACEMENT, HOOD............23-10
LATCH STRIKER AND BUMPERÐXJ
VEHICLES, REAR SEATBACK...........23-111
LATCH STRIKER, HALF-METAL DOOR.....23-175
LATCH STRIKER REPLACEMENT, HOOD....23-10
LATCH STRIKER REPLACEMENT, SAFETY . . . 23-10
LATCH STRIKER, TAILGATE.............23-161
LATCH/KEY LOCK CYLINDER/STRIKER,
LIFTGATE...........................23-68
LEAD CORRECTION CHART...............22-5
LEAF SPRING; FRONT SUSPENSION AND
AXLE...............................2-14
LEAF SPRING; REAR SUSPENSION AND
AXLES............................3-3,3-6
LEAF SPRING EYE BUSHING
REPLACEMENT; FRONT SUSPENSION
AND AXLE...........................2-15
LEAF SPRING EYE BUSHING
REPLACEMENT; REAR SUSPENSION
AND AXLES........................3-4,3-6
LEAK DETECTION AND REPAIR, FIXED
GLASS WATER................23-83,23-189
LEAK DIAGNOSIS, CONVERTER HOUSING . . . 21-73
LEAK DOWN TEST, FUEL PRESSURE........14-7
LEAK TEST, REFRIGERANT................24-8
LEAKAGE DIAGNOSIS, GEAR
..............19-8
LEAKAGE DIAGNOSIS, INTAKE
MANIFOLD
............................9-5
LEAKAGE DIAGNOSIS, PUMP
..............19-8
LEAKAGE TEST, CYLINDER COMBUSTION
PRESSURE
...........................9-6
LEAKAGE TEST DIAGNOSIS, CYLINDER
COMBUSTION PRESSURE
................9-6
LEAKS, REPAIRING
.....................22-3
LEAKS, TESTING COOLING SYSTEM FOR
....7-18
LEFT HAND DRIVE, DRIVERS DOOR
POWER LOCK SWITCHÐ2-DOOR
.........8P-2
LEFT HAND DRIVE, DRIVERS DOOR
POWER WINDOW SWITCHÐ2-DOOR
......8S-6
LETTERS, JEEP BODY CODE
...............5-2
LEVEL AND CONDITION, CHECKING
FLUID
.......................21-96,21-173
LEVEL AND CONDITION, FLUID
...........21-69
LEVEL, BRAKE FLUID
....................5-13
LEVELÐBRAKELINES AND HOSES,
BRAKE BLEEDINGÐBRAKE FLUID
........5-13
LEVEL, CLUTCH FLUID
...................6-14
LEVEL, COMPRESSOR OIL
................24-6
LEVEL, CORRECT FLUID
.................5-48
LEVEL, TRANSFER CASE FILL
...........21-294
LEVELS, OPERATING SOUND
...............5-3
LEVER INSTALLATION (XJ WITH FULL
CONSOLE), PARKING BRAKE
............5-60
LEVER INSTALLATION (XJ WITH MINI
CONSOLE), PARKING BRAKE
............5-58
LEVER INSTALLATION (XJ WITHOUT
CONSOLE), PARKING BRAKE
............5-60
LEVER POSITIONS, TRANSMISSION
RANGES AND SHIFT
.................21-157
LEVER REMOVAL (XJ WITH FULL
CONSOLE), PARKING BRAKE
............5-59
LEVER REMOVAL (XJ WITH MINI
CONSOLE), PARKING BRAKE
............5-58
LEVER REMOVAL (XJ WITHOUT
CONSOLE), PARKING BRAKE
............5-60
LICENSE PLATE LAMP
..................8L-10
LICENSE PLATE LAMP HOUSING,
LIFTGATE
...........................23-72
LICENSE PLATE SCREW ANCHOR
AND BUMPER, LIFTGATE
..............23-72
LIFTGATE ADJUSTMENT
.................23-70
LIFTGATE GLASS, HARD TOP
............23-162
LIFTGATE GLASS WEATHERSTRIP SEAL
REPLACEMENT
.....................23-163
LIFTGATE HINGE
.......................23-67
LIFTGATE LATCH/KEY LOCK CYLINDER/
STRIKER
...........................23-68
LIFTGATE LICENSE PLATE LAMP
HOUSING
...........................23-72
LIFTGATE LICENSE PLATE SCREW
ANCHOR AND BUMPER
...............23-72
JINDEX13
Description Group-Page Description Group-Page Description Group-Page

PUMP REPLACEMENTÐLEFT HAND
DRIVE, WASHER......................8K-2
PUMP REPLACEMENT, REAR WASHER.....8K-13
PUMP REPLACEMENTÐRIGHT HAND
DRIVE, WASHER......................8K-3
PUMP REPLACEMENT, WASHER......8K-6,8K-11
PUMP SEAL REPLACEMENT, OIL.........21-189
PUMP TESTS, WATER....................7-9
PUMP WEAR LIMITS, AW-4 OIL.........21-325
PUMPSÐGENERAL INFORMATION, WATER . . . 7-9
PUMPSÐREMOVAL/INSTALLATION, WATER . . 7-10
PURGING COMPRESSOR OF AIR..........24-17
QUARTER AND WHEELHOUSE TRIM
PANELSÐXJ VEHICLES..............23-115
QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES, REAR..........23-151
QUARTER PLASTIC INSERT ÐXJ
VEHICLES, QUARTER WINDOW GLASS/
REAR..............................23-80
QUARTER TRIM PANEL EXTENSIONÐXJ
VEHICLES.........................23-115
QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES, REAR..................23-80
QUARTER WINDOW APPLIQUEÐXJ
VEHICLES..........................23-29
QUARTER WINDOW GLASS, HARD TOP . . . 23-188
QUARTER WINDOW GLASS/REAR QUARTER
PLASTIC INSERT ÐXJ VEHICLES, REAR . . 23-80
QUICK-CONNECT FITTINGS..........14-9,14-59
RACK PISTON AND WORM SHAFT
REPLACEMENT......................19-30
RACKÐXJ VEHICLES, LUGGAGE..........23-32
RADIATOR FAN RELAYÐPCM OUTPUT.....14-26
RADIATOR GRILLE APPLIQUE...........23-134
RADIATOR PRESSURE CAP...............7-20
RADIATOR SUPPORT CROSSMEMBER......23-5
RADIATORS...........................7-22
RADIO ANTENNA.......................8F-8
RADIO CONNECTOR PINS................8F-3
RADIO ILLUMINATION RELAY.............8F-3
RADIO NOISE DIAGNOSIS................8F-2
RADIO REPLACEMENT...............8F-4,8F-6
RADIO SPEAKERS..................8F-4,8F-6
RADIO/CLOCK ILLUMINATION.............8E-4
RAIL ASSEMBLY, FUEL..................14-56
RAIL, FUEL...........................14-30
RAIL MOULDINGÐXJ VEHICLES, DRIP.....23-29
RANGE FIRST GEAR, HYDRAULIC FLOW
IN D...............................21-87
RANGE, HYDRAULIC FLOW IN MANUAL
SECOND (2).........................21-93
RANGE SECOND GEAR, HYDRAULIC FLOW
IN D...............................21-88
RANGE THIRD GEAR, HYDRAULIC FLOW
IN D...............................21-89
RANGES AND SHIFT LEVER POSITIONS,
TRANSMISSION.....................21-157
RATE, CHARGE.........................8A-6
RATINGS, BATTERY CLASSIFICATIONS......8A-8
RATINGSÐLEFT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATINGSÐRIGHT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATIOS, GEAR.........................21-2
RATIOS, TRANSMISSION GEAR...........21-33
REAR AXLE 8 1/4 INCH..................3-50
REAR AXLE ALIGNMENT..................3-8
REAR AXLE MODEL 35..................3-50
REAR AXLES, FRONT....................0-26
REAR BAND ADJUSTMENT..............21-99
REAR BUMPER....................13-6,13-18
REAR CABLE REPLACEMENT (XJ),
PARKING BRAKE......................5-62
REAR CABLE REPLACEMENT (YJ),
PARKING BRAKE......................5-63
REAR CARPET/MATÐXJ VEHICLES.......23-130
REAR CLUTCH OVERHAUL..............21-128
REAR DEFOGGER RELAY.................8N-4
REAR DEFOGGER/FOG LAMP/REAR
WIPER SWITCHES....................8E-21
REAR DOOR FIXED WINDOW GLASS
......23-53
REAR DOOR WINDOW GLASS
............23-52
REAR DOOR WINDOW GLASS
REGULATOR
........................23-51
REAR FASCIA AND SKID PLATEÐYJ
RENEGADE VEHICLES
................23-152REAR JOUNCE BUMPER................13-18
REAR MAIN OIL SEALS..............9-44,9-84
REAR QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES................23-151
REAR QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES........................23-80
REAR SEAT CUSHION COVERÐ
XJ VEHICLES.......................23-107
REAR SEAT CUSHION
RECONDITIONINGÐXJ VEHICLES.......23-108
REAR SEAT CUSHIONÐXJ VEHICLES.....23-107
REAR SEATBACK COVERÐXJ VEHICLES . . . 23-111
REAR SEATBACK LATCH STRIKER AND
BUMPERÐXJ VEHICLES..............23-111
REAR SEATBACK RECONDITIONINGÐXJ
VEHICLES.........................23-111
REAR SEATBACKÐXJ VEHICLES.........23-109
REAR SERVO AND BAND OVERHAUL.....21-136
REAR SHOULDER BELTS...............23-196
REAR SHOULDER/LAP BELT/BUCKLEÐ
XJ VEHICLES.......................23-120
REAR SPEED SENSOR AIR GAP............5-3
REAR SUSPENSION COMPONENTS, XJ......3-50
REAR SUSPENSION COMPONENTS, YJ......3-50
REAR TOW HOOKÐXJ VEHICLES.........23-87
REAR WASHER PUMP REPLACEMENT.....8K-13
REAR WHEEL SENSOR INSTALLATION......5-50
REAR WHEEL SENSOR REMOVAL..........5-49
REAR WHEELHOUSE FLARES AND
LINERS............................23-18
REAR WINDOW DEFOGGER GRID
REPAIR .............................8N-2
REAR WINDOW DEFOGGER GRID TEST.....8N-1
REAR WINDOW DEFOGGER SWITCH
REPLACEMENT.......................8N-4
REAR WIPER ARM REPLACEMENT........8K-12
REAR WIPER, DIAGNOSING...............8K-6
REAR WIPER MOTOR REPLACEMENT......8K-13
REAR WIPER SWITCH REPLACEMENT.....8K-13
REAR WIPER WASHER, DIAGNOSING.......8K-6
REAR WIPER/WASHER, DIAGNOSING......8K-14
REAR WIPER/WASHER SWITCH TESTING . . . 8K-7,
8K-14
REARVIEW MIRROR...................23-183
REARVIEW MIRROR, INTERIOR...........23-74
REARVIEW MIRROR RETAINING
BRACKET..........................23-183
REARVIEW MIRROR SUPPORT
BRACKET REPLACEMENT, INTERIOR.....23-75
RECEIVER.............................8P-8
RECEIVER DRIERÐ4.0L ENGINES.........24-32
RECEIVER-DRIER REPLACEMENT.........24-42
RECEIVER SERVICE....................8P-11
RECIRCULATING AIR DOOR VACUUM
MOTOR REPLACEMENT, A/C............24-31
RECIRCULATING BALL POWER
STEERING GEAR.....................19-19
RECIRCULATING-BALL POWER STEERING
GEARS.............................19-69
RECOMMENDATIONS, TOWING.............0-8
RECOMMENDED BRAKE FLUID........5-13,5-48
RECOMMENDED FLUID; TRANSMISSION
AND TRANSFER CASE............21-66,21-96
RECOMMENDED LUBRICANT..............21-2
RECOMMENDED LUBRICANT AND
REPLACEMENT PARTS..................0-3
RECONDITIONING, BUCKET SEATBACK....23-102
RECONDITIONINGÐXJ VEHICLES, REAR
SEAT CUSHION.....................23-108
RECONDITIONINGÐXJ VEHICLES, REAR
SEATBACK.........................23-111
REFILLING COOLING SYSTEM.............7-17
REFINISHING, BRAKE DRUM..............5-37
REFINISHING, DISC BRAKE ROTOR.........5-32
REFRIGERANT LEAK TEST................24-8
REFRIGERANT (R-12)....................24-1
REGULATOR, FRONT DOOR WINDOW
GLASS.............................23-48
REGULATOR, FUEL PRESSURE...........14-30
REGULATOR, FULL-METAL DOOR
WINDOW GLASS
....................23-177
REGULATOR HANDLE, FULL-METAL
DOOR WINDOW GLASS
..............23-175
REGULATOR, REAR DOOR WINDOW
GLASS
.............................23-51
REGULATOR REPLACEMENT, WINDOW
......8S-9RELAY, AIR CONDITIONING (A/C)
CLUTCH............................14-54
RELAY, AUTOMATIC SHUT DOWN
(ASD); FUEL SYSTEM.................14-54
RELAY, AUTOMATIC SHUT DOWN (ASD);
IGNITION SYSTEMS..........8D-1,8D-8,8D-20
RELAY BANKS, FUSE CHARTS............8W-8
RELAY CONNECTIONS, STARTER..........8A-12
RELAY, FUEL PUMP....................14-56
RELAYÐPCM OUTPUT, AIR
CONDITIONING CLUTCH...............14-24
RELAYÐPCM OUTPUT, AUTO SHUT
DOWN (ASD)........................14-24
RELAYÐPCM OUTPUT, FUEL PUMP.......14-25
RELAYÐPCM OUTPUT, RADIATOR FAN.....14-26
RELAYÐPCM OUTPUT, TORQUE
CONVERTER CLUTCH.................14-27
RELAY, RADIO ILLUMINATION.............8F-3
RELAY, REAR DEFOGGER................8N-4
RELAY REPLACEMENT, DOOR LOCK/
UNLOCK...........................8P-12
RELAY REPLACEMENT, STARTER..........8B-4
RELAY TEST, STARTER MOTOR...........14-48
RELAY TEST, TORQUE CONVERTER
CLUTCH............................14-45
RELAY TESTING, AUTOMATIC
SHUTDOWN (ASD)...................14-43
RELAY TESTING, FUEL PUMP............14-44
RELAY, TORQUE CONVERTER CLUTCH.....14-60
RELEASE AND LOCK HANDLE, FULL-
METAL DOOR LATCH INSIDE..........23-175
RELEASE AND LOCK RODS, DOOR
INSIDE LATCH.......................23-57
RELEASE BEARING REPLACEMENT.........6-11
RELEASE CABLE REPLACEMENT, LATCH....23-10
RELEASE HANDLE, FULL-METAL DOOR
LATCH EXTERNAL...................23-178
RELEASE HANDLE, TAILGATE LATCH......23-160
RELEASE PROCEDURE, FUEL PRESSURE....14-5
RELEASE PROCEDURE, FUEL SYSTEM
PRESSURE.........................14-56
RELIEF/ROLLOVER VALVE, FUEL TANK
PRESSURE....................14-15,14-56
RELIEF/ROLLOVER VALVE, PRESSURE . . 25-5,25-9
REMINDER INDICATOR (SRI) LAMP,
SERVICE............................25-1
REMINDER LAMP, SEAT BELT............8E-16
REMOVAL, ACCELERATION SENSOR........5-52
REMOVAL AND INSTALLATION, 30RH/
32RH TRANSMISSION................21-108
REMOVAL AND INSTALLATION, AW-4
TRANSMISSION.....................21-189
REMOVALÐAX 15, TRANSMISSION.......21-34
REMOVAL, BRAKE PEDAL................5-65
REMOVAL, BRAKELIGHT SWITCH..........5-66
REMOVAL, CALIPER.....................5-27
REMOVAL, CLUTCH COVER AND DISC......6-10
REMOVAL, CLUTCH HYDRAULIC
LINKAGE............................6-11
REMOVAL, CLUTCH PEDAL...............6-15
REMOVAL, DIFFERENTIAL; FRONT
SUSPENSION AND AXLE................2-32
REMOVAL, DIFFERENTIAL; REAR
SUSPENSION AND AXLES...............3-16
REMOVAL, DISC BRAKESHOE.............5-25
REMOVAL, DRUM BRAKESHOE............5-34
REMOVAL, FRONT WHEEL SENSOR........5-49
REMOVAL, IGNITION SWITCH............8D-30
REMOVAL, MASTER CYLINDER........5-20,5-50
REMOVAL, POWER BRAKE BOOSTER . . . 5-22,5-51
REMOVAL, PRINTED CIRCUIT
............8E-24
REMOVAL, REAR WHEEL SENSOR
.........5-49
REMOVAL, ROTOR
......................5-30
REMOVAL, TRANSFER CASE
......21-276,21-296
REMOVAL, TRANSMISSION
...............21-3
REMOVAL, TRANSMISSION AND
CONVERTER
.......................21-108
REMOVAL, TRANSMISSION AND TORQUE
CONVERTER
.......................21-189
REMOVAL, TRANSMISSION VALVE BODY
. . 21-176
REMOVAL, VALVE BODY
...............21-100
REMOVAL, WHEEL CYLINDER
.............5-36
REMOVALÐXJ, HCU
....................5-53
REMOVAL (XJ WITH FULL CONSOLE),
PARKING BRAKE LEVER
................5-59
18 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

REMOVAL (XJ WITH MINI CONSOLE),
PARKING BRAKE LEVER................5-58
REMOVAL (XJ WITHOUT CONSOLE),
PARKING BRAKE LEVER................5-60
REMOVALÐYJ, HCU....................5-54
REMOVAL (YJ), PARKING BRAKE PEDAL....5-61
REMOVAL/DISASSEMBLY, PINION;
FRONT SUSPENSION AND AXLE..........2-34
REMOVAL/DISASSEMBLY, PINION; REAR
SUSPENSION AND AXLES...............3-17
REMOVAL/INSTALLATION, 2.5L STARTER
MOTOR.............................8B-5
REMOVAL/INSTALLATION, 4.0L
STARTER MOTOR.....................8B-6
REMOVAL/INSTALLATION, COMPONENT;
EMISSION CONTROL SYSTEMS..........25-8
REMOVAL/INSTALLATION, COMPONENT;
IGNITION SYSTEMS..................8D-20
REMOVAL/INSTALLATION, DOOR..........23-40
REMOVAL/INSTALLATION, LIFTGATE.......23-65
REMOVAL/INSTALLATION, MULTI-PORT
FUEL INJECTION (MFI)ÐCOMPONENT....14-54
RENEGADE VEHICLES, BODY EXTENSION
PANELS AND FASCIASÐYJ............23-147
RENEGADE VEHICLES, FOG LAMPÐYJ....23-150
RENEGADE VEHICLES, FRONT FASCIA
AND SKID PLATEÐYJ................23-148
RENEGADE VEHICLES, FRONT FENDER
EXTENSION PANELÐYJ..............23-149
RENEGADE VEHICLES, REAR FASCIA
AND SKID PLATEÐYJ................23-152
RENEGADE VEHICLES, REAR QUARTER
EXTENSION PANELÐYJ..............23-151
RENEGADE VEHICLES, ROCKER
EXTENSION PANELÐYJ..............23-150
REPAIR DAMAGED OR WORN THREADS......9-4
REPAIR, FIXED GLASS WATER LEAK
DETECTION...................23-83,23-189
REPAIR, HARD TOP...................23-165
REPAIR ON GALVANIZED METALS, PAINT . . 23-202
REPAIR PROCEDURES, COMPASS..........8C-4
REPAIR PROCEDURES, CONSOLE..........8C-6
REPAIR PROCEDURES, THERMOMETER
AND SENSOR SYSTEM.................8C-6
REPAIR, REAR WINDOW DEFOGGER GRID . . . 8N-2
REPAIR SERVICE, FRAME...............13-13
REPAIR, WIRING.......................8W-4
REPAIRING LEAKS......................22-3
REQUIREMENTS, AW-4 CLUTCH AND
BRAKE PACK.......................21-328
REQUIREMENTS, FUEL....................0-2
RESERVE/OVERFLOW SYSTEM, COOLANT . . . 7-19
RESERVOIR REPLACEMENT..............19-12
RESISTANCE, IGNITION COIL............8D-11
RESISTANCE (OHMS), SENSOR.....8D-12,8D-14
RESISTANCE (OHMS)ÐCOOLANT
TEMPERATURE SENSOR/MANIFOLD AIR
TEMPERATURE, SENSOR..............14-43
RESISTANCE, SPARK PLUG CABLE........8D-18
RESISTORS REPLACEMENT, BLOWER
MOTOR............................24-35
RESPONSE IN ANTILOCK MODE, VEHICLE....5-3
RESPONSE, STEERING....................5-3
RESTRAINT REPLACEMENT, DOOR........23-47
RETAINER AND PISTON SPECIFICATIONS,
AW-4 .............................21-327
RETAINER CLIP, FUEL AND BRAKE FLUID
TUBE; BODY COMPONENTSÐXJ
VEHICLES..........................23-86
RETAINER CLIP, FUEL AND BRAKE
FLUID TUBE; FRAME AND BUMPERS.....13-16
RETAINING BRACKET, REARVIEW
MIRROR..........................23-183
RETURN HOSE REPLACEMENT,
PRESSURE..........................19-9
RETURNÐPCM INPUT, SENSOR..........14-23
REVEAL MOULDING, WINDSHIELD . . 23-73,23-183
REVERSE FLUSHING, TRANSMISSION
COOLER...........................21-105
REVERSE, HYDRAULIC FLOW IN..........21-95
RHD MODELS, BELT TENSIONÐEXCEPT.....7-38
RHD SPLICE LOCATIONS, XJ
............8W-67
RHD, STEERING
.......................19-69
RHD, XJ WIRING
......................8W-43
RHEOSTAT, HEADLAMP
SWITCH/ILLUMINATION
...............8E-21RIGHT HAND DRIVE, BELT SERVICEÐ
EXCEPT.............................7-34
RIGHT HAND DRIVE, BELT SERVICEÐ
WITH...............................7-35
RIGHT HAND DRIVE, DRIVERS DOOR
POWER LOCK SWITCHÐ2-DOOR.........8P-3
RIGHT HAND DRIVE, DRIVERS DOOR
POWER WINDOW SWITCHÐ2-DOOR......8S-7
RIGHT HAND DRIVE (RHD), BELT
TENSIONÐEXCEPT....................7-33
RIGHT HAND DRIVE VEHICLES............23-1
RIGHT (R) POSITION, SWITCH TEST
WITH SWITCH IN.....................8T-3
RING CHARTÐAX 15 MANUAL
TRANSMISSION, SELECTIVE SNAP......21-321
RING GEAR INSTALLATION...............3-24
RING/THRUST WASHER/THRUST PLATE
SPECIFICATIONS, 30RH/32RH SNAP.....21-322
ROAD TEST, ANALYZING THE.............21-70
ROAD TEST, OPERATIONAL CHECK.........8H-7
ROAD TEST; TRANSMISSION AND
TRANSFER CASE.....................21-70
ROAD TEST; VEHICLE SPEED CONTROL
SYSTEM............................8H-5
ROAD TESTING.........................5-7
ROCKER ARMS....................9-19,9-59
ROCKER EXTENSION PANELÐYJ
RENEGADE VEHICLES................23-150
ROD AND PAWL SERVICE, PARK.........21-181
ROD BALL STUD REPLACEMENT,
LIFTGATE SUPPORT..................23-70
ROD BEARING FITTING CHART,
CONNECTING.....................9-36,9-76
ROD CYLINDER DISPOSAL, LIFTGATE
SUPPORT..........................23-70
ROD CYLINDER, LIFTGATE SUPPORT......23-69
ROD, TIE.......................19-14,19-17
RODS, DOOR INSIDE LATCH RELEASE
AND LOCK..........................23-57
RODS, PISTONS AND CONNECTING....9-34,9-74
ROOF VENT, HARD TOP................23-165
ROTATION, TIRES.......................22-3
ROTOR, DISTRIBUTOR.................8D-10
ROTOR, IGNITION CABLES, DISTRIBUTOR
CAP ................................0-18
ROTOR INSTALLATION...................5-30
ROTOR REFINISHING, DISC BRAKE.........5-32
ROTOR REMOVAL......................5-30
ROTOR RUNOUT, DISC BRAKE............5-31
ROTORÐSPEEDOMETER DRIVE GEAR,
SPEED SENSOR.....................21-183
ROTOR THICKNESS, DISC BRAKE..........5-31
ROTOR THICKNESS VARIATION, DISC
BRAKE..............................5-31
ROUGH AND/OR HAS A MISS, INJECTOR
DIAGNOSISÐVEHICLE RUNS...........14-49
ROUTINE SERVICE.......................0-2
ROUTING SCHEMATICÐ2.5L 4 CYLINDER
ENGINE, VACUUM.....................25-2
ROUTING SCHEMATICÐ4.0L 6 CYLINDER
ENGINE, VACUUM.....................25-3
ROUTING SCHEMATICS, VACUUM HOSE.....25-1
ROUTING, SYSTEM COOLANT..............7-1
RUBBER AND PLASTIC DUCTS/HOSES/
TUBING.............................0-19
RUBBER AND PLASTIC HOSES/
TUBING.............................0-28
RUNNING LIGHTS (CANADA ONLY),
DAYTIME...........................8L-16
RUNOUT..............................16-4
RUNOUT, DISC BRAKE ROTOR............5-31
RUNOUT SPECIFICATIONS................16-4
RUNOUT, TIRE AND WHEEL...............22-8
RUNS ROUGH AND/OR HAS A MISS,
INJECTOR DIAGNOSISÐVEHICLE........14-49
SAFETY CERTIFICATION LABEL, VEHICLE . INTRO.-1
SAFETY LATCH, HOOD.................23-139
SAFETY LATCH STRIKER REPLACEMENT . . . 23-10
SAFETY PRECAUTIONS................23-200
SAFETY PRECAUTIONS, BRAKE.............5-2
SAFETY PRECAUTIONS, CLUTCH...........6-10
SCAN TOOL, DRB; COOLING SYSTEM
........7-5
SCAN TOOL, DRB; EMISSION CONTROL
SYSTEMS
...........................25-2
SCAN TOOL, DRB; FUEL SYSTEM
.........14-51
SCAN TOOL, DRB; IGNITION SYSTEMS
.....8D-10SCHEDULES, MAINTENANCE...............0-5
SCHEMATICÐ2.5L 4 CYLINDER ENGINE,
VACUUM ROUTING....................25-2
SCHEMATIC, AIR CONDITIONING..........24-25
SCHEMATIC, HEATING..................24-24
SCHEMATICÐ4.0L 6 CYLINDER ENGINE,
VACUUM ROUTING....................25-3
SCHEMATICS, BELT.....................7-34
SCHEMATICS, SYSTEM.................14-38
SCHEMATICS, VACUUM HOSE ROUTING.....25-1
SCI RECEIVEÐPCM INPUT..............14-22
SCI TRANSMITÐPCM OUTPUT...........14-26
SCREEN, COWL GRILLE...........23-11,23-139
SCREW ANCHOR AND BUMPER,
LIFTGATE LICENSE PLATE..............23-72
SCUFF PLATE/COWL SIDE TRIM PANELÐ
XJ VEHICLES, FRONT INNER..........23-114
SCUFF PLATESÐXJ VEHICLES,
INTERIOR TRIM PANELS..............23-112
SCUFF PLATESÐXJ VEHICLES, OUTER....23-118
SEAL AND BEARING, AXLE SHAFT.........3-15
SEAL AND BEARING SERVICE, AXLE
SHAFT,..............................3-31
SEAL, COWL WEATHERSTRIP...........23-139
SEALÐDRIVE PLATE SERVICE,
CONVERTERÐPUMP.................21-109
SEAL, FLOW CONTROL VALVE FITTING
O-RING............................19-12
SEAL, LIFTGATE OPENING
WEATHERSTRIP.....................23-70
SEAL REPLACEMENT, ADAPTER HOUSING . . 21-182
SEAL REPLACEMENT, INNER AXLE
SHAFT OIL...........................2-33
SEAL REPLACEMENT, LIFTGATE GLASS
WEATHERSTRIP....................23-163
SEAL REPLACEMENT, MANUAL VALVE
SHAFT............................21-178
SEAL REPLACEMENT, OIL PUMP.........21-189
SEAL REPLACEMENT, PINION; FRONT
SUSPENSION AND AXLE................2-23
SEAL REPLACEMENT, PINION; REAR
SUSPENSION AND AXLES...............3-32
SEAL REPLACEMENT, PINION SHAFT.......3-13
SEAL REPLACEMENT, PITMAN SHAFT......19-35
SEAL REPLACEMENT, TIMING CASE
COVER OIL
......................9-26,9-67
SEAL, TAILGATE WEATHERSTRIP
........23-161
SEAL, WINDSHIELD FRAME
WEATHERSTRIP
....................23-185
SEAL/CROSSMEMBER AIR DEFLECTOR,
COWL WEATHERSTRIP
................23-10
SEALS AND BEARING REPLACEMENT,
PITMAN SHAFT
......................19-32
SEALS, DOOR WINDOW GLASS AND
DOOR OPENING WEATHERSTRIP
........23-62
SEALS, FULL-METAL DOOR
WEATHERSTRIP
....................23-180
SEALSÐIN CAR REPLACEMENT, PITMAN
SHAFT
.............................19-21
SEALS, REAR MAIN OIL
..............9-44,9-84
SEALS, VALVE SPRINGS AND OIL
......9-21,9-62
SEAT BELT INDICATOR
...................8E-4
SEAT BELT REMINDER LAMP
............8E-16
SEAT COMPONENTS, POWER BUCKET
....23-106
SEAT CUSHIONÐXJ VEHICLES, REAR
.....23-107
SEAT CUSHION AND COVER, BUCKET
......23-98
SEAT CUSHION COVERÐXJ VEHICLES,
REAR
.............................23-107
SEAT CUSHION RECONDITIONINGÐXJ
VEHICLES, REAR
....................23-108
SEAT MOTOR REPLACEMENT, POWER
......8R-2
SEAT PLATFORM AND TRACKS, BUCKET
. . . 23-105
SEAT, POWER
..........................8A-1
SEATBACK COVERÐXJ VEHICLES, REAR
. . 23-111
SEATBACK COVER AND FRAME, BUCKET
. . 23-100
SEATBACK LATCH STRIKER AND
BUMPERÐXJ VEHICLES, REAR
........23-111
SEATBACK RECONDITIONING, BUCKET
....23-102
SEATBACK RECONDITIONINGÐXJ
VEHICLES, REAR
....................23-111
SEATBACKÐXJ VEHICLES, REAR
........23-109
SEATS
..............................23-195
SEATS, FRONT BUCKET
.................23-97
JINDEX19
Description Group-Page Description Group-Page Description Group-Page

TEMPERATURE SENSOR TEST, ENGINE
COOLANT; FUEL SYSTEM..............14-43
TEMPERATURE SENSOR TEST, ENGINE
COOLANT; IGNITION SYSTEMS..........8D-12
TEMPERATURE SENSOR TEST, INTAKE
AIR ...............................14-43
TEMPERATURE SENSOR TEST, INTAKE
MANIFOLD AIR......................8D-14
TENSION, BELT.......................8B-10
TENSION, DRIVE BELT...............7-33,7-38
TENSIONÐRIGHT HAND DRIVE
(RHD),BELT..........................7-34
TENSION SPECIFICATIONS, BELT...........7-34
TENSIONER REPLACEMENT (XJ), PARKING
BRAKE CABLE........................5-61
TENSIONERÐXJ MODELS, AUTOMATIC
BELT ...............................7-36
TERMINAL ASSEMBLY REPLACEMENT,
CONNECTOR.........................8W-5
TERMINAL REPLACEMENT...............8W-5
TEST, A/C PERFORMANCE................24-8
TEST, ACTUATOR MOTOR STALL...........8P-6
TEST, AIR PRESSURE...................21-73
TEST, ANALYZING THE ROAD.............21-70
TEST, BATTERY LOAD...................8A-4
TEST, BATTERY OPEN CIRCUIT VOLTAGE....8A-3
TEST, CAMSHAFT POSITION SENSOR;
FUEL SYSTEM.......................14-43
TEST, CAMSHAFT POSITION SENSOR;
IGNITION SYSTEMS...................8D-8
TEST, CONVERTER STALL...............21-72
TEST, CRANKSHAFT POSITION SENSOR;
FUEL SYSTEM.......................14-44
TEST, CRANKSHAFT POSITION SENSOR;
IGNITION SYSTEMS...................8D-9
TEST, CYLINDER COMBUSTION
PRESSURE LEAKAGE...................9-6
TEST, CYLINDER COMBUSTION
PRESSURE LEAKAGE DIAGNOSIS..........9-6
TEST, CYLINDER COMPRESSION PRESSURE . . 9-5
TEST, ENGINE COOLANT TEMPERATURE
SENSOR......................8D-12,14-43
TEST, EXTENDED IDLE SWITCH...........14-45
TEST, FUEL PRESSURE LEAK DOWN........14-7
TEST, FUEL PUMP CAPACITY..............14-7
TEST, FUEL SYSTEM PRESSURE......14-5,14-48
TEST, HYDRAULIC PRESSURE......21-71,21-168
TEST, HYDROMETER....................8A-3
TEST, IDLE AIR CONTROL MOTOR........14-46
TEST, INJECTOR.......................14-48
TEST, INTAKE AIR TEMPERATURE SENSOR . . 8D-14,
14-43
TEST, MANIFOLD ABSOLUTE PRESSURE
(MAP) SENSOR.................8D-14,14-44
TEST, MANUAL SHIFTING...............21-168
TEST, MASTER CYLINDER/POWER
BOOSTER............................5-11
TEST, OXYGEN SENSOR (O2S)
HEATING ELEMENT...................14-45
TEST, POWER BOOSTER CHECK VALVE......5-11
TEST, POWER BOOSTER VACUUM..........5-12
TEST PROCEDURES, BATTERY............8A-2
TEST PROCEDURES ON VEHICLE,
ENGINE STARTER MOTOR..............8A-9
TEST PROCEDURES ON VEHICLE,
GENERATOR........................8A-14
TEST, PUMP PRESSURE.................19-3
TEST, REAR WINDOW DEFOGGER GRID.....8N-1
TEST, REFRIGERANT LEAK................24-8
TEST, ROAD; TRANSMISSION AND
TRANSFER CASE.....................21-70
TEST, ROAD; VEHICLE SPEED CONTROL
SYSTEM............................8H-5
TEST SPECIFICATIONS, 30RH/32RH
PRESSURE........................21-323
TEST, SPEED CONTROL SWITCH (TURN
SIGNAL LEVER)......................8H-7
TEST, STARTER MOTOR RELAY...........14-48
TEST, STARTING SYSTEM COLD
CRANKING...........................8A-9
TEST, STOP LAMP SPEED CONTROL
SWITCH
............................8H-7
TEST, THROTTLE POSITION SENSOR
......8D-18
TEST, THROTTLE POSITION SENSOR
(TPS)
..............................14-45
TEST, TIME LAG
......................21-169TEST, TORQUE CONVERTER CLUTCH
RELAY.............................14-45
TEST, TORQUE CONVERTER STALL.......21-169
TEST, VACUUM SUPPLY.................8H-7
TEST, VEHICLE SPEED SENSOR......8H-5,14-45
TESTING, AUTOMATIC SHUTDOWN
(ASD) RELAY........................14-43
TESTING COOLING SYSTEM FOR LEAKS.....7-18
TESTING, FUEL PUMP RELAY............14-44
TESTING GENERAL INFORMATION,
BATTERY............................8A-3
TESTING, IGNITION SWITCH.............8D-30
TESTING, POWER MIRROR SWITCH........8T-2
TESTING, REAR WIPER/WASHER
SWITCH.......................8K-7,8K-14
TESTING, SWITCH; POWER SEATS.........8R-2
TESTING, SWITCH; POWER WINDOWS......8S-5
TESTING, SWITCH; REAR WINDOW
DEFOGGER..........................8N-2
TESTING, TRANSMISSION COOLER FLOW . . 21-106
TESTING, WIPER SWITCH...............8K-19
TESTS - (VOLTAGE DROP METHOD),
STARTER FEED CIRCUIT................8A-9
TESTS, ANTENNA.......................8F-9
TESTS AT POWERTRAIN CONTROL
MODULE, ELECTRICAL.................8H-6
TESTS AT SERVO, ELECTRICAL............8H-5
TESTS, COMPRESSOR VALVE PLATEÐ
LEAK...............................24-8
TESTS, IGNITION SWITCH CONTINUITY....8D-31
TESTS, OXYGEN SENSOR...............8D-19
TESTS, STARTER CONTROL CIRCUIT......8A-11
TESTS, VEHICLE SPEED CONTROL
SYSTEM............................8H-5
TESTS, WATER PUMP....................7-9
THERMOMETER AND SENSOR SYSTEM
REPAIR PROCEDURES.................8C-6
THERMOSTAT..........................7-13
THERMOSTAT, TEMPERATURE CONTROL . . . 24-35
THICKNESS, AW-4 CLUTCH DISC AND
PLATE ............................21-325
THICKNESS, DISC BRAKE ROTOR..........5-31
THICKNESS VARIATION, DISC BRAKE
ROTOR.............................5-31
THIRD GEAR (CONVERTER CLUTCH
ENGAGED), HYDRAULIC FLOW IN.......21-90
THIRD GEAR, HYDRAULIC FLOW IN D
RANGE.............................21-89
THREAD NOTATIONÐSAE AND METRIC . . INTRO.-9
THREADS, REPAIR DAMAGED OR WORN.....9-4
THROTTLE 3-2 DOWNSHIFT, HYDRAULIC
FLOW DURING FULL..................21-92
THROTTLE 3-2 DOWNSHIFT, HYDRAULIC
FLOW DURING PART..................21-91
THROTTLE BODY; FUEL SYSTEM.....14-29,14-59
THROTTLE CABLE.....................14-16
THROTTLE CABLE, ACCELERATOR PEDAL . . 14-16,
14-54
THROTTLE CABLE ADJUSTMENT,
TRANSMISSION.....................21-185
THROTTLE CABLE ADJUSTMENT,
TRANSMISSION......................21-98
THROTTLE CABLE REPLACEMENT,
TRANSMISSION.....................21-184
THROTTLE POSITION SENSOR............8D-6
THROTTLE POSITION SENSOR TEST.......8D-18
THROTTLE POSITION SENSOR (TPS);
FUEL SYSTEM.......................14-59
THROTTLE POSITION SENSOR (TPS);
IGNITION SYSTEMS..................8D-29
THROTTLE POSITION SENSOR (TPS)
SERVICE..........................21-184
THROTTLE POSITION SENSOR (TPS)
TEST..............................14-45
THROTTLE POSITION SENSOR (TPS)Ð
PCM INPUT.........................14-23
THROTTLE VALVE CABLE ADJUSTMENT,
TRANSMISSION......................21-70
TIE ROD ........................19-14,19-17
TIGHTENING, WHEEL NUT............5-32,5-37
TILT STEERING COLUMN................19-59
TIME LAG TEST
......................21-169
TIMING CASE COVER
................9-27,9-67
TIMING CASE COVER OIL SEAL
REPLACEMENT
...................9-26,9-67
TIMING CHAIN AND SPROCKETS
......9-28,9-68TIMING, IGNITION.....................8D-14
TIMING, VALVE.....................9-26,9-66
TIPS, TRANSMISSION ASSEMBLY........21-146
TIRE AND WHEEL BALANCE..............22-6
TIRE AND WHEEL RUNOUT...............22-8
TIRE CARRIER, EXTERNAL SPARE/WHEEL . 23-172
TIRE INFLATION PRESSURE LABEL.....INTRO.-3
TIRE INFLATION PRESSURES.............22-2
TIRE NOISE OR VIBRATION...............22-4
TIRE WEAR PATTERNS..................22-4
TIRES; LUBRICATION AND MAINTENANCE....0-34
TIRES................................22-1
TIRES, CLEANING OF....................22-2
TIRES, REPLACEMENT...................22-2
TIRE/WHEEL HOLDDOWN AND FLOOR
BRACKETS.........................23-128
TOOL, DRB SCAN; COOLING SYSTEM........7-5
TOOL, DRB SCAN; EMISSION CONTROL
SYSTEMS...........................25-2
TOOL, DRB SCAN; FUEL SYSTEM.........14-51
TOOL, DRB SCAN; IGNITION SYSTEMS.....8D-10
TOP REPAIR, HARD...................23-165
TOP ROOF VENT......................23-165
TOP SERVICE............23-164,23-166,23-167
TORQUE; COOLING SYSTEM..............7-39
TORQUE; FUEL SYSTEM................14-62
TORQUE; IGNITION SYSTEMS............8D-33
TORQUE, COLLISION DAMAGE............13-1
TORQUE CONVERSION..............INTRO.-10
TORQUE CONVERTER; TRANSMISSION
AND TRANSFER CASE...........21-66,21-158
TORQUE CONVERTER CLUTCH RELAY......14-60
TORQUE CONVERTER CLUTCH RELAY
TEST..............................14-45
TORQUE CONVERTER CLUTCH RELAYÐ
PCM OUTPUT.......................14-27
TORQUE CONVERTER INSTALLATION,
TRANSMISSION.....................21-190
TORQUE CONVERTER REMOVAL,
TRANSMISSION.....................21-189
TORQUE CONVERTER STALL TEST.......21-169
TORQUE CONVERTER STATOR CLUTCH
INSPECTION.......................21-189
TORQUE SPECIFICATIONS, 30RH/32RH....21-323
TORQUE SPECIFICATIONSÐ AX 15
MANUAL TRANSMISSION.............21-320
TORQUE SPECIFICATIONSÐACCESSORIES . 23-208
TORQUE SPECIFICATIONS, AW-4
.........21-331
TORQUE SPECIFICATIONS, BATTERY
.......8B-10
TORQUE SPECIFICATIONS; BATTERY/
STARTER/GENERATOR SERVICE
.........8B-12
TORQUE SPECIFICATIONS, BRAKE
..........5-67
TORQUE SPECIFICATIONS; CLUTCH
........6-17
TORQUE SPECIFICATIONS; ELECTRICAL
.....8A-8
TORQUE SPECIFICATIONS; ENGINES
....9-49,9-89
TORQUE SPECIFICATIONS; EXHAUST
SYSTEM AND INTAKE MANIFOLD
........11-10
TORQUE SPECIFICATIONS; FRONT
SUSPENSION AND AXLE
................2-47
TORQUE SPECIFICATIONS; HEATING AND
AIR CONDITIONING
...................24-45
TORQUE SPECIFICATIONS; HORNS
.........8G-3
TORQUE SPECIFICATIONS;
INTRODUCTION
...................INTRO.-8
TORQUE SPECIFICATIONS, NP231/NP242
. . 21-331
TORQUE SPECIFICATIONS; PROPELLER
SHAFTS
............................16-14
TORQUE SPECIFICATIONS; REAR
SUSPENSION AND AXLES
...............3-50
TORQUE SPECIFICATIONS, STARTER
MOTOR
............................8B-11
TORQUE SPECIFICATIONS; STEERING
......19-73
TORQUE SPECIFICATIONS XJ
.............8K-7
TORQUE SPECIFICATIONSÐXJ VEHICLES
. . 23-207
TORQUE VALUES, STANDARD
.........INTRO.-9
TOW HOOKÐXJ VEHICLES, REAR
.........23-87
TOW HOOKS
..........................13-14
TOW HOOKS, FRONT
....................13-5
TOWING, JUMP STARTING, HOISTING
.......0-7
TOWING RECOMMENDATIONS
..............0-8
TRACK BAR
....................2-10,2-13,3-6
TRACKS, BUCKET SEAT PLATFORM
.......23-105
TRAC-LOK DIFFERENTIAL
................3-44
JINDEX23
Description Group-Page Description Group-Page Description Group-Page

VARIATION, DISC BRAKE ROTOR
THICKNESS..........................5-31
VEHICLE CODE DECODING............INTRO.-3
VEHICLE CODE PLATE................INTRO.-2
VEHICLE CONTROL AND DISPLAY
SYMBOLS........................INTRO.-7
VEHICLE CONTROL AND DISPLAY
SYMBOLS, INTERNATIONAL.........INTRO.-3
VEHICLE DESIGNATION CODES........INTRO.-1
VEHICLE DESIGNATIONS.............INTRO.-1
VEHICLE DIMENSION DATA....INTRO.-3,INTRO.-4
VEHICLE EMISSION CONTROL
INFORMATION (VECI) LABEL............25-1
VEHICLE, ENGINE STARTER MOTOR
TEST PROCEDURES ON................8A-9
VEHICLE, GEAR ADJUSTMENTS IN........19-37
VEHICLE, GENERATOR TEST
PROCEDURES ON....................8A-14
VEHICLE IDENTIFICATION NUMBER (VIN)
DECODING.......................INTRO.-2
VEHICLE IDENTIFICATION NUMBER (VIN)
PLATE...........................INTRO.-1
VEHICLE LOAD DATA................INTRO.-3
VEHICLE LOAD DATA, XJ.............INTRO.-5
VEHICLE RESPONSE IN ANTILOCK MODE.....5-3
VEHICLE SAFETY CERTIFICATION LABEL . INTRO.-1
VEHICLE SPEED CONTROL SYSTEM
ELECTRICAL TESTS...................8H-5
VEHICLE SPEED SENSOR................14-60
VEHICLE SPEED SENSOR TEST; FUEL
SYSTEM............................14-45
VEHICLE SPEED SENSOR TEST;
VEHICLE SPEEDCONTROL SYSTEM.......8H-5
VEHICLE SPEED SENSORÐPCM INPUT....14-23
VEHICLE VIBRATION....................22-9
VENT DOOR CONTROL CABLES...........24-39
VENT, HARD TOP ROOF................23-165
VENT WINDOW, FRONT DOOR............23-50
VENT WINDOW GLASS, FULL-METAL
DOOR............................23-177
VENT WINDOW GLASSÐXJ VEHICLES,
REAR QUARTER.....................23-80
VENTILATION, FRESH AIR...............24-39
VENTILATION SYSTEM, CRANKCASE;
EMISSIONCONTROL SYSTEMS...........25-5
VENTILATION SYSTEM, CRANKCASE;
LUBRICATIONAND MAINTENANCE........0-17
VIBRATION; FRONT SUSPENSION AND AXLE . 2-17
VIBRATION; PROPELLER SHAFTS..........16-3
VIBRATION; REAR SUSPENSION AND AXLES . . 3-8
VIBRATION DAMPER; ENGINES........9-26,9-67
VIBRATION DIAGNOSIS; WHEELS AND
TIRES.........................22-9,22-10
VIBRATION, DRIVELINE..................16-3
VIBRATION, TIRE NOISE OR..............22-4
VIBRATION TYPES......................22-9
VIBRATION, VEHICLE....................22-9
VISUAL INSPECTION...................14-32
VOLTAGE, BATTERY OPEN CIRCUIT.........8A-4
VOLTAGE DROP METHOD, STARTER
FEED CIRCUITTESTS -.................8A-9
VOLTAGE SPECIFICATIONS, OUTPUT.......8B-12
VOLTAGE TEST, BATTERY OPEN CIRCUIT....8A-3
VOLTAGEÐPCM INPUT, BATTERY.........14-19
VOLTMETER...........................8E-1
VOLTMETER INOPERATIVE................8E-3
VOLTMETER, OPERATIONAL CHECK.......8A-15
WARNING INOPERATIVE, LOW FUEL........8E-4
WARNING LAMP, LOW FUEL..............8E-2
WARNING LIGHT DISPLAY, ABS............5-3
WARNING LIGHT DISPLAY, BRAKE..........5-4
WARNING LIGHTS, BRAKE.................5-1
WARNING SWITCH REPLACEMENT,
IGNITION KEY........................8U-4
WASHER, DIAGNOSING INTERMITTENT
WINDSHIELD........................8K-12
WASHER, DIAGNOSING NON-
INTERMITTENTWINDSHIELD............8K-12
WASHER, DIAGNOSING REAR WIPER.......8K-6
WASHER INDICATOR INOPERATIVE, LOW....8E-4
WASHER (INTERMITTENT), DIAGNOSING
WINDSHIELD
.........................8K-4
WASHER, INTERMITTENT WIPER
.........8K-20
WASHER (NON-INTERMITTENT),
DIAGNOSINGWINDSHIELD
..............8K-4
WASHER NOZZLE REPLACEMENT
.........8K-13WASHER PUMP REPLACEMENT . . 8K-2 8K-6,8K-11
WASHER PUMP REPLACEMENT, REAR.....8K-13
WASHER PUMP REPLACEMENTÐRIGHT
HAND DRIVE.........................8K-3
WASHER, STANDARD WIPER............8K-19
WASHERS, WINDSHIELD WIPERS..........8A-1
WASHER/THRUST PLATE SPECIFICATIONS,
30RH/32RH SNAP RING/THRUST.......21-322
WATER LEAK DETECTION AND REPAIR,
FIXEDGLASS..................23-83,23-189
WATER PUMPS.....................7-9,7-10
WATER PUMP TESTS.....................7-9
WATERDAM, FULL-METAL DOOR.........23-176
WEAR COMPENSATION, CALIPER
OPERATION..........................5-24
WEAR INDICATORS, TREAD...............22-3
WEAR PATTERNS, TIRE..................22-4
WEATHERSTRIP SEAL, COWL...........23-139
WEATHERSTRIP SEAL, LIFTGATE
OPENING...........................23-70
WEATHERSTRIP SEAL REPLACEMENT,
LIFTGATEGLASS....................23-163
WEATHERSTRIP SEAL, TAILGATE........23-161
WEATHERSTRIP SEAL, WINDSHIELD
FRAME............................23-185
WEATHERSTRIP SEAL/CROSSMEMBER
AIRDEFLECTOR, COWL................23-10
WEATHERSTRIP SEALS, DOOR WINDOW
GLASSAND DOOR OPENING............23-62
WEATHERSTRIP SEALS, FULL-METAL
DOOR............................23-180
WHEEL ALIGNMENT, FRONT...............2-5
WHEEL BALANCE, TIRE..................22-6
WHEEL BEARING LUBRICANTS, CHASSIS
COMPONENT.........................0-30
WHEEL BEARINGS, FRONT...............0-31
WHEEL BRAKE COMPONENTS..............5-1
WHEEL CYLINDER INSTALLATION..........5-37
WHEEL CYLINDER OVERHAUL.............5-36
WHEEL CYLINDER REMOVAL.............5-36
WHEEL INSTALLATION...................22-6
WHEEL LUG NUT......................22-11
WHEEL NUT TIGHTENING............5-32,5-37
WHEEL ORNAMENTATION................22-6
WHEEL REPLACEMENT..................22-6
WHEEL RUNOUT, TIRE...................22-8
WHEEL SENSOR AIR GAP ADJUSTMENT....5-49
WHEEL SENSOR INSTALLATION, FRONT.....5-49
WHEEL SENSOR INSTALLATION, REAR......5-50
WHEEL SENSOR REMOVAL, FRONT........5-49
WHEEL SENSOR REMOVAL, REAR.........5-49
WHEEL SPEED SENSOR OPERATION........5-45
WHEEL SPEED SENSORS.................5-41
WHEEL, STEERING.....................19-45
WHEEL/TIRE SIZE AND INPUT SIGNALS......5-3
WHEELHOUSE FLARES AND LINERS, REAR . 23-18
WHEELHOUSE SPLASH LINERS..........23-146
WHEELHOUSE TRIM PANELSÐXJ
VEHICLES,QUARTER.................23-115
WHEELS..............................22-6
WINDOW APPLIQUEÐXJ VEHICLES,
QUARTER..........................23-29
WINDOW DEFOGGER GRID REPAIR, REAR . . . 8N-2
WINDOW DEFOGGER GRID TEST, REAR.....8N-1
WINDOW DEFOGGER, REAR..............8A-1
WINDOW DEFOGGER SWITCH
REPLACEMENT, REAR..................8N-4
WINDOW EXTERIOR MOULDINGS, DOOR . . . 23-61
WINDOW, FRONT DOOR VENT
............23-50
WINDOW GLASS AND DOOR OPENING
WEATHERSTRIP SEALS, DOOR
..........23-62
WINDOW GLASS, FIXED
..........23-73,23-183
WINDOW GLASS, FRONT DOOR
..........23-49
WINDOW GLASS, FULL-METAL DOOR
.....23-178
WINDOW GLASS, FULL-METAL DOOR
VENT
.............................23-177
WINDOW GLASS, HARD TOP QUARTER
. . . 23-188
WINDOW GLASS, REAR DOOR
...........23-52
WINDOW GLASS, REAR DOOR FIXED
......23-53
WINDOW GLASS REGULATOR, FRONT
DOOR
.............................23-48
WINDOW GLASS REGULATOR, FULL-
METAL DOOR
......................23-177
WINDOW GLASS REGULATOR HANDLE,
FULL-METALDOOR
..................23-175WINDOW GLASS REGULATOR, REAR
DOOR
.............................23-51
WINDOW GLASSÐXJ VEHICLES,
LIFTGATE
...........................23-81
WINDOW GLASSÐXJ VEHICLES,
REAR QUARTERVENT
.................23-80
WINDOW GLASS/REAR QUARTER
PLASTIC INSERTÐXJ VEHICLES,
QUARTER
..........................23-80
WINDOW REGULATOR REPLACEMENT
.......8S-9
WINDOW SWITCH, PASSENGER DOOR
......8S-8
WINDOW SWITCH
..............8S-5,8S-6,8S-7
WINDSHIELD FRAME
..................23-184
WINDSHIELD FRAME WEATHERSTRIP
SEAL
.............................23-185
WINDSHIELD GLASS
..................23-185
WINDSHIELD GLASS REPLACEMENT
......23-75
WINDSHIELD REVEAL MOULDING
. . . 23-73,23-183
WINDSHIELD SERVICE INFORMATION
......23-75
WINDSHIELD SIDE MOULDINGÐXJ
VEHICLES
.........................23-114
WINDSHIELD WASHER, DIAGNOSING
INTERMITTENT
......................8K-12
WINDSHIELD WASHER,
DIAGNOSINGNON-INTERMITTENT
.......8K-12
WINDSHIELD WASHER (INTERMITTENT),
DIAGNOSING
.........................8K-4
WINDSHIELD WASHER (NON-
INTERMITTENT),DIAGNOSING
............8K-4
WINDSHIELD WIPER MOTOR
.............8K-2
WINDSHIELD WIPERS, DIAGNOSING
. . 8K-3,8K-11
WIPER ARM AND PIVOT ASSEMBLY
REPLACEMENT,FRONT
.................8K-9
WIPER ARM REPLACEMENT, FRONT
........8K-8
WIPER ARM REPLACEMENT, REAR
........8K-12
WIPER BLADE REPLACEMENT, FRONT
......8K-8
WIPER CONTROL SWITCH REPLACEMENT
. . . 8K-15
WIPER, DIAGNOSING REAR
...............8K-6
WIPER, LIFTGATE
.......................8K-5
WIPER MODULE, INTERMITTENT
..........8K-5
WIPER MOTOR, FRONT
.................8K-10
WIPER MOTOR REPLACEMENT, REAR
.....8K-13
WIPER MOTOR, WINDSHIELD
.............8K-2
WIPER SWITCH REPLACEMENT,
LIFTGATE
............................8K-6
WIPER SWITCH REPLACEMENT,
REAR
..............................8K-13
WIPER SWITCH TESTING
...............8K-19
WIPER SWITCHES, REAR DEFOGGER/
FOGLAMP/REAR
.....................8E-21
WIPER WASHER, DIAGNOSING REAR
.......8K-6
WIPER WASHER, INTERMITTENT
.........8K-20
WIPER WASHER, STANDARD
............8K-19
WIPERS, DIAGNOSING WINDSHIELD
. . 8K-3,8K-11
WIPERS/WASHERS, FRONT
...............8K-1
WIPERS/WASHERS GENERAL INFORMATION,
FRONT
..............................8K-8
WIPER/WASHER, DIAGNOSING REAR
......8K-14
WIPER/WASHER SWITCH TESTING,
REAR
..........................8K-7,8K-14
WIRE CODE IDENTIFICATION
.............8W-2
WIRING AND COMPONENT IDENTIFICATION
. 8W-13
WIRING AND ELECTRICAL CIRCUITS,
ABS SYSTEM
..........................5-4
WIRING DIAGRAM SHEETS AND INDEXES
. . . 8W-1
WIRING DIAGRAMS YJ
.................8W-73
WIRING PROBLEMS, TROUBLESHOOTING
. . . 8W-3
WIRING REPAIR
.......................8W-4
WIRING, SECONDARY IGNITION
...........8W-1
WOODGRAIN MOULDING
................23-19
WOODGRAIN OVERLAY
.................23-22
WORM SHAFT REPLACEMENT, RACK
PISTON
............................19-30
WORN THREADS, REPAIR DAMAGED OR
.....9-4
JINDEX25
Description Group-Page Description Group-Page Description Group-Page