1994 JEEP CHEROKEE tailgate

To remove and install a front floor front carpet
(Fig. 30), it is necessary to remove and then install
the shift lever boots (Fig. 31).
When replacing a front carpet, position and cut
openings in carpet with a razor knife for shift levers
and boots (Fig. 31).
CARGO FLOOR CARPET
The cargo floor carpet (Fig. 30) is retained in place
by the:
²rear seat,
²shoulder belt buckle anchors, and
²wheelhouse carpets.
To remove and then install a cargo floor carpet
(Fig. 30), it is necessary to remove and then install
the rear seat.
WHEELHOUSE, DOOR SILL AND TAILGATE CARPETS
The wheelhouse, door sill and tailgate carpets (Fig.
32) are retained in place with:
²adhesive,
²velcro strips, and²screws.
A replacement carpet for any of the three possibly
will require some modifications to accommodate the
attached components.
ADD-A-TRUNK
REMOVAL
1. Remove the nylon thumb screws (Fig. 33).
2. Remove the trunk.
INSTALLATION
1. Position the trunk in the cargo space and insert
the nylon thumbscrews with washers through the
predrilled holes and into the well nuts.
2. Tighten the thumb screws.
Fig. 32 Wheelhouse, Door Sill and Tailgate Carpets
Fig. 32 Add-A-Trunk Assembly
JBODY COMPONENTSÐXJ VEHICLES 23 - 199

PAINT APPLICATION
INDEX
page page
Accent Paint........................... 202
Base/Color Coat........................ 201
Basecoat/Clearcoat...................... 202
Body Undercoat......................... 203
Buffing and Polishing..................... 203
Exterior Body Colors..................... 204Paint Repair on Galvanized Metals.......... 202
Plastic Components...................... 203
Primer................................ 201
Stone Chip Protection.................... 201
Surface Preparation...................... 201
SURFACE PREPARATION
Proper surface preparation is the key to top-quality
body panel refinishing. The bare metal must be
cleaned, de-greased, de-waxed and treated with phos-
phate.
Always clean the panel surface with a wax and
grease removal solution, and then wipe the surface
with a tack rag before applying primer or paint.
Cleaning will also remove any residual silicone from
the painted surface.
Body putty that is procured from a major supplier
is highly recommended. If a synthetic body filler is to
be used, it should also be a quality product.
STONE CHIP PROTECTION
When applicable, the stone chip protection coat
(Fig. 1) must be applied before the primer coat. The
coating extends downward from the character line to
the bottom flanges. Then horizontally to the wheel-
house opening flanges.
PRIMER
The type of primer to be used is dependent on the
condition of the panel surface. Bare metal should be
primed with an epoxy-base. A sealant is recom-
mended when applying a second color coat over an
existing color coat. With certain colors, sealants are
also important in preventing color bleed-through.
BASE/COLOR COAT
Base/color coat paint finishes must be applied in an
clean environment. Top-loader guns are recom-
mended for applying the base/color coat paint.
Base/color coat paint (Figs. 2, 3, and 4) should be
reduced/thinned and applied according to the manu-
facturers recommendations. Refer to the suppliers in-
structions.
Fig. 2 Body Base/Color Coat Paint FinishÐYJ
Vehicles
Fig. 3 Hood and Tailgate Base/Color Coat Paint
FinishÐYJ Vehicles
Fig. 1 Stone Chip Protection CoatÐTypical
JBODY COMPONENTSÐXJ VEHICLES 23 - 201

30RH/32RH AUTOMATIC TRANSMISSION . . . 21-66
30RH/32RH GENERAL SPECIFICATIONS . . . 21-322
30RH/32RH IN-VEHICLE SERVICE.........21-96
30RH/32RH PRESSURE TEST
SPECIFICATIONS....................21-323
30RH/32RH SNAP RING/THRUST
WASHER/THRUST PLATE
SPECIFICATIONS....................21-322
30RH/32RH TORQUE SPECIFICATIONS....21-323
30RH/32RH TRANSMISSION DIAGNOSIS . . . 21-69,
21-77,21-78,21-79,21-80,21-81,21-82,21-83,21-84,
21-85
30RH/32RH TRANSMISSION OVERHAUL . . . 21-112
30RH/32RH TRANSMISSION REMOVAL
AND INSTALLATION..................21-108
3-2 DOWNSHIFT, HYDRAULIC FLOW
DURING FULL THROTTLE..............21-92
3-2 DOWNSHIFT, HYDRAULIC FLOW
DURING PART THROTTLE..............21-91
4WD INDICATOR......................8E-22
4WD INDICATOR INOPERATIVE............8E-4
4WD INDICATOR LAMP..................8E-2
60-WAY CONNECTOR, POWERTRAIN
CONTROL MODULE (PCM).............14-38
ABBREVIATIONS, SYMBOLS, FUSES........8W-6
ABS BRAKE DIAGNOSIS...................5-3
ABS BRAKES, BRAKE BLEEDINGÐWITH.....5-14
ABS COMPONENT SERVICE...............5-47
ABS FAULT DIAGNOSIS................5-4,5-6
ABS OPERATION IN ANTILOCK BRAKING
MODE..............................5-43
ABS OPERATION IN NORMAL BRAKING
MODE..............................5-43
ABS SYSTEM OPERATION................5-39
ABS SYSTEM WIRING AND ELECTRICAL
CIRCUITS............................5-4
ABS WARNING LIGHT DISPLAY.............5-3
ABSOLUTE PRESSURE (MAP) SENSOR,
MANIFOLD; FUEL SYSTEM.............14-57
ABSOLUTE PRESSURE (MAP) SENSOR,
MANIFOLD; IGNITION SYSTEMS....8D-5,8D-27
ABSOLUTE PRESSURE (MAP) SENSORÐ
PCM INPUT, MANIFOLD...............14-21
ABSOLUTE PRESSURE (MAP) SENSOR
TEST, MANIFOLD; FUEL SYSTEM........14-44
ABSOLUTE PRESSURE (MAP) SENSOR
TEST, MANIFOLD; IGNITION
SYSTEMS..........................8D-14
ABSORBER, SHOCK; FRONT
SUSPENSION AND AXLE............2-12,2-14
ABSORBER, SHOCK; REAR SUSPENSION
AND AXLES........................3-3,3-5
A/C BLOWER MOTOR...................24-43
A/C CONDENSER......................24-42
A/C CONTROL PANEL...................24-41
A/C CONTROL PANEL REPLACEMENT,
HEATER ............................24-26
A/C OPERATION........................24-1
A/C PERFORMANCE TEST................24-8
A/C RECIRCULATING AIR DOOR
VACUUM MOTOR REPLACEMENT........24-31
ACCELERATION SENSOR INSTALLATION.....5-52
ACCELERATION SENSOR REMOVAL........5-52
ACCELERATION SWITCH.................5-41
ACCELERATION SWITCH OPERATION.......5-45
ACCELERATOR PEDAL..................14-16
ACCELERATOR PEDAL AND THROTTLE
CABLE........................14-16,14-54
ACCENT PAINT.......................23-202
ACCESSORY DRIVE BELT.................0-20
ACCESSORY DRIVE BELTS, ENGINE........7-31
ACCUMULATOR PISTONS AND SPRINGS . . 21-179
ACTUATOR MOTOR STALL TEST...........8P-6
ADAPTER HOUSING AND PARK LOCK
COMPONENT OVERHAUL.............21-120
ADAPTER HOUSING SEAL REPLACEMENT . . 21-182
ADD-A-TRUNK.......................23-199
ADJUSTER PLUG ASSEMBLY
REPLACEMENT......................19-27
ADJUSTMENT, BRAKELIGHT SWITCH.......5-66
ADJUSTMENT, DIFFERENTIAL SHIM
PACK MEASUREMENT..................2-42
ADJUSTMENT, DOOR LATCH
.............23-55
ADJUSTMENT, DRUM BRAKE
..............5-35
ADJUSTMENT, FOG LAMP BEAM
..........8L-12
ADJUSTMENT, FRONT BAND
.............21-99ADJUSTMENT, HEADLAMP BEAM..........8L-3
ADJUSTMENT, HOOD....................23-9
ADJUSTMENT, LIFTGATE................23-70
ADJUSTMENTÐMAJOR, DOOR
ALIGNMENT.........................23-47
ADJUSTMENTÐMINOR, DOOR
ALIGNMENT.........................23-46
ADJUSTMENT, PARK INTERLOCK CABLE . . . 21-186
ADJUSTMENT, PARKING BRAKE...........5-63
ADJUSTMENT, PRELIMINARY
INSPECTION.......................21-167
ADJUSTMENT PROCEDURES,
TRANSMISSION ASSEMBLY...........21-146
ADJUSTMENT, REAR BAND..............21-99
ADJUSTMENT, SHIFT CABLE............21-186
ADJUSTMENT, SHIFT LINKAGE....21-275,21-296
ADJUSTMENT, TAILGATE...............23-160
ADJUSTMENT, TRANSMISSION
ASSEMBLY..............21-15,21-51,21-255
ADJUSTMENT, TRANSMISSION
THROTTLE CABLE..............21-98,21-185
ADJUSTMENT, TRANSMISSION
THROTTLE VALVE CABLE..............21-70
ADJUSTMENT, VALVE BODY ASSEMBLY . . . 21-144
ADJUSTMENT, WHEEL SENSOR AIR GAP....5-49
ADJUSTMENT (XJ), PARK INTERLOCK
CABLE.............................21-97
ADJUSTMENT (XJ), SHIFT CABLE.........21-97
ADJUSTMENT (YJ), GEARSHIFT LINKAGE . . . 21-96
ADJUSTMENTS, ALIGNMENT
MEASUREMENTS......................2-6
ADJUSTMENTS IN VEHICLE, GEAR........19-37
ADJUSTMENTS ON BENCH, GEAR.........19-42
ADJUSTMENTS, SPECIFICATIONS AND
BAND..............................21-66
ADJUSTMENTS, STEERING GEAR.........19-22
AIR CLEANER..........................25-7
AIR CLEANER FILTER ELEMENT, ENGINE....0-16
AIR CLEANER HOUSING; EMISSION
CONTROL SYSTEMS...................25-8
AIR CLEANER HOUSING; FUEL SYSTEM....14-54
AIR CONDITIONER COMPRESSOR/HOSES/
FITTINGS............................0-21
AIR CONDITIONING CLUTCH RELAY.......14-54
AIR CONDITIONING CLUTCH RELAYÐ
PCM OUTPUT.......................14-24
AIR CONDITIONING CONTROLSÐPCM
INPUT.............................14-19
AIR CONDITIONING, DESCRIPTION........24-41
AIR CONDITIONING SCHEMATIC..........24-25
AIR CONDITIONING SYSTEM DIAGNOSIS . . . 24-12
AIR CONDITIONING SYSTEMÐXJ
VEHICLES..........................24-14
AIR CONDITIONING SYSTEMÐYJ
VEHICLES..........................24-15
AIR CONTROL (IAC) MOTOR, IDLE........14-56
AIR CONTROL (IAC) MOTORÐPCM
OUTPUT, IDLE.......................14-25
AIR CONTROL MOTOR TEST, IDLE........14-46
AIR DEFLECTOR, COWL WEATHERSTRIP
SEAL/CROSSMEMBER.................23-10
AIR DOOR VACUUM MOTOR, FRESH.......24-41
AIR DOOR VACUUM MOTOR
REPLACEMENT, A/C RECIRCULATING.....24-31
AIR EXHAUST GRILLEÐXJ VEHICLES......23-30
AIR FILTER; EMISSION CONTROL
SYSTEMS...........................25-9
AIR FILTER; FUEL SYSTEM..............14-54
AIR GAP ADJUSTMENT, WHEEL SENSOR....5-49
AIR GAP, REAR SPEED SENSOR............5-3
AIR INTAKE DUCT, FRESH...............24-41
AIR PRESSURE TEST...................21-73
AIR, PURGING COMPRESSOR OF.........24-17
AIR TEMPERATURE SENSOR, INTAKE......14-54
AIR TEMPERATURE SENSOR, INTAKE
MANIFOLD.....................8D-5,8D-27
AIR TEMPERATURE SENSORÐPCM
INPUT, INTAKE.......................14-20
AIR TEMPERATURE, SENSOR RESISTANCE
(OHMS)ÐCOOLANT TEMPERATURE
SENSOR/MANIF; FUEL SYSTEM
.........14-43
AIR TEMPERATURE SENSOR TEST,
INTAKE
............................14-43
AIR TEMPERATURE SENSOR TEST,
INTAKE MANIFOLD
...................8D-14
AIR VENTILATION, FRESH
...............24-39AIRFLOW DIAGRAM....................24-23
ALIGNMENT ADJUSTMENTÐMAJOR,
DOOR.............................23-47
ALIGNMENT ADJUSTMENTÐMINOR,
DOOR.............................23-46
ALIGNMENT, FRAME...................13-10
ALIGNMENT, FRONT WHEEL...............2-5
ALIGNMENT, HOOD...................23-138
ALIGNMENT MEASUREMENTS AND
ADJUSTMENTS........................2-6
ALIGNMENTÐMINOR, XJ DOOR..........23-46
ALIGNMENT, REAR AXLE..................3-8
ALIGNMENT SPECIFICATIONSÐXJ
VEHICLES............................2-9
ALIGNMENT SPECIFICATIONSÐYJ VEHICLES . . 2-9
ANALYSIS, BACKLASH AND CONTACT
PATTERN; FRONT SUSPENSION AND AXLE . 2-44
ANALYSIS, BACKLASH AND CONTACT
PATTERN; REAR SUSPENSION AND AXLES . 3-25
ANCHOR AND BUMPER, LIFTGATE
LICENSE PLATE SCREW...............23-72
ANGLE MEASUREMENT, UNIVERSAL
JOINT..............................16-4
ANTENNA, RADIO.......................8F-8
ANTENNA TESTS.......................8F-9
ANTILOCK BRAKE SYSTEM (ABS)...........5-1
ANTI-LOCK BRAKE SYSTEM (ABS)
INDICATOR LAMP.....................8E-2
ANTILOCK BRAKE SYSTEM OPERATION.....5-43
ANTILOCK BRAKING MODE, ABS
OPERATION..........................5-43
ANTI-LOCK INDICATOR..................8E-4
ANTILOCK MODE, VEHICLE RESPONSE.......5-3
APPLICATION CHARTS, GEARTRAIN
OPERATION........................21-159
APPLICATION, PAINT..................23-201
APPLICATION, TRANSMISSION...........21-66
APPLIQUE, RADIATOR GRILLE
...........23-134
APPLIQUEÐXJ VEHICLES, QUARTER
WINDOW
...........................23-29
APRONS, FENDER SPLASH
.............23-147
ARM AND PIVOT ASSEMBLY
REPLACEMENT, FRONT WIPER
...........8K-9
ARM, LOWER SUSPENSION
...............2-11
ARM, PITMAN
...................19-15,19-18
ARM REPLACEMENT, FRONT WIPER
........8K-8
ARM REPLACEMENT, REAR WIPER
........8K-12
ARM, UPPER SUSPENSION
...............2-11
ARMS, ROCKER
....................9-19,9-59
ASH RECEIVER TRAY LAMP, I/P
..........23-92
ASSEMBLY AND ADJUSTMENT
PROCEDURES, TRANSMISSION
........21-146
ASSEMBLY AND ADJUSTMENT,
TRANSMISSION
..........21-15,21-51,21-255
ASSEMBLY AND ADJUSTMENT, VALVE
BODY
.............................21-144
ASSEMBLY, CALIPER
....................5-29
ASSEMBLY, DIFFERENTIAL; FRONT
SUSPENSION AND AXLE
................2-36
ASSEMBLY, DIFFERENTIAL; REAR
SUSPENSION AND AXLES
...............3-19
ASSEMBLY, FINAL; FRONT SUSPENSION
AND AXLE
...........................2-44
ASSEMBLY, FINAL; REAR SUSPENSION
AND AXLES
..........................3-26
ASSEMBLY, FUEL RAIL
..................14-56
ASSEMBLY, GEAR
......................19-41
ASSEMBLY, PRESSURE GAUGE AND
MANIFOLD
...........................24-2
ASSEMBLY REPLACEMENT, ADJUSTER
PLUG
..............................19-27
ASSEMBLY REPLACEMENT, CONNECTOR
AND TERMINAL
......................8W-5
ASSEMBLY REPLACEMENT, FRONT WIPER
ARM AND PIVOT
......................8K-9
ASSEMBLY REPLACEMENT, SOLENOID
AND LATCH
..........................8P-6
ASSEMBLY REPLACEMENTÐXJ VEHICLES,
DRIVE AXLE; FRONT SUSPENSION AND
AXLE
...............................2-21
ASSEMBLY REPLACEMENTÐXJ VEHICLES,
DRIVE AXLE; REAR SUSPENSION AND
AXLES
..........................3-11,3-30
JINDEX1
Description Group-Page Description Group-Page Description Group-Page

CRANKSHAFT POSITION SENSORÐPCM
INPUT.............................14-20
CRANKSHAFT POSITION SENSOR TEST;
FUEL SYSTEM.......................14-44
CRANKSHAFT POSITION SENSOR TEST;
IGNITION SYSTEMS...................8D-9
CROSSMEMBER COVER, FRAME..........13-14
CROSSMEMBER, RADIATOR SUPPORT......23-5
CUSHION AND COVER, BUCKET SEAT......23-98
CUSHION COVERÐXJ VEHICLES, REAR
SEAT .............................23-107
CUSHION, ENGINE FRONT SUPPORT.......13-15
CUSHION RECONDITIONINGÐXJ
VEHICLES, REAR SEAT...............23-108
CUSHIONÐXJ VEHICLES, REAR SEAT.....23-107
CYLINDER BLOCK..................9-45,9-85
CYLINDER BORES, HONING................9-2
CYLINDER COMBUSTION PRESSURE
LEAKAGE TEST DIAGNOSIS...........9-5,9-6
CYLINDER DISPOSAL, LIFTGATE
SUPPORT ROD......................23-70
CYLINDER, DOOR KEY LOCK.............23-54
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ2.5L 4...................25-2
CYLINDER ENGINE, VACUUM ROUTING
SCHEMATICÐ4.0L 6...................25-3
CYLINDER, FULL-METAL DOOR KEY
LOCK.............................23-178
CYLINDER HEAD COVER, ENGINE......9-18,9-59
CYLINDER HEAD, ENGINE............9-19,9-60
CYLINDER HEAD GASKET FAILURE
DIAGNOSIS, ENGINE....................9-5
CYLINDER INSTALLATION, MASTER....5-20,5-50
CYLINDER INSTALLATION, WHEEL.........5-37
CYLINDER, LIFTGATE SUPPORT ROD......23-69
CYLINDER, MASTER.....................5-40
CYLINDER OVERHAUL, WHEEL............5-36
CYLINDER OVERHAUL, MASTER...........5-20
CYLINDER REMOVAL, MASTER........5-20,5-50
CYLINDER REMOVAL, WHEEL.............5-36
CYLINDER REPLACEMENT, LIFTGATE
LOCK...............................8P-7
CYLINDER, STANDARD MASTER...........5-20
CYLINDER, TAILGATE LOCK.............23-160
CYLINDER/POWER BOOSTER TEST,
MASTER............................5-11
CYLINDER/STRIKER, LIFTGATE LATCH/
KEY LOCK..........................23-68
CYLINDERS, KEY LOCK............23-2,23-132
D RANGE FIRST GEAR, HYDRAULIC
FLOW IN...........................21-87
D RANGE SECOND GEAR, HYDRAULIC
FLOW IN...........................21-88
D RANGE THIRD GEAR, HYDRAULIC
FLOW IN...........................21-89
DAMAGE TORQUE, COLLISION............13-1
DAMAGED OR WORN THREADS, REPAIR.....9-4
DAMPENER, STEERING............19-15,19-18
DAMPER, ENGINE......................9-13
DAMPER, VIBRATION................9-26,9-67
DASH PANEL INSULATION PANEL.........23-95
DASH PANEL INSULATOR PANEL.........23-11
DATA LINK CONNECTORÐPCM INPUT.....14-20
DATA LINK CONNECTORÐPCM OUTPUT....14-24
DATA, VEHICLE DIMENSION . . . INTRO.-3,INTRO.-4
DATA, VEHICLE LOAD................INTRO.-3
DATA, XJ VEHICLE LOAD.............INTRO.-5
DATA, YJ-VEHICLE LOAD.............INTRO.-6
DAYTIME RUNNING LIGHTS (CANADA
ONLY) .............................8L-16
DECODING, VEHICLE CODE...........INTRO.-3
DECODING, VEHICLE IDENTIFICATION
NUMBER (VIN)....................INTRO.-2
DEFLECTOR, COWL WEATHERSTRIP
SEAL/CROSSMEMBER AIR.............23-10
DEFOGGER GRID REPAIR, REAR
WINDOW............................8N-2
DEFOGGER GRID TEST, REAR
WINDOW............................8N-1
DEFOGGER, REAR WINDOW..............8A-1
DEFOGGER RELAY, REAR
................8N-4
DEFOGGER SWITCH REPLACEMENT,
REAR WINDOW
.......................8N-4
DEFOGGER/FOG LAMP/REAR WIPER
SWITCHES, REAR
....................8E-21
DEFROSTER DUCT REPLACEMENT
........24-29DEFROSTER NOZZLE AND DUCT..........24-40
DELAY FUNCTION TROUBLE
DIAGNOSISÐXJ VEHICLES, HEADLAMP . . . 8L-16
DELAY MODULE REPLACEMENTÐXJ
VEHICLES, HEADLAMP................8L-16
DELAY MODULEÐXJ VEHICLES,
SENTINEL HEADLAMP.................8L-15
DELIVERY SYSTEM, FUEL................14-2
DEPTH INFORMATION, PINION GEAR;
FRONT SUSPENSION AND AXLE..........2-37
DEPTH INFORMATION, PINION GEAR;
REAR SUSPENSION AND AXLES..........3-19
DEPTH VARIANCE, PINION GEAR; FRONT
SUSPENSION AND AXLE................2-38
DEPTH VARIANCE, PINION GEAR; REAR
SUSPENSION AND AXLES...........3-20,3-38
DESCRIPTION (AIR CONDITIONING).......24-41
DESCRIPTION; AUDIO SYSTEMS...........8F-1
DESCRIPTION (HEATING)................24-37
DESCRIPTION; HEATING AND AIR
CONDITIONING.................24-17,24-22
DESCRIPTION; OVERHEAD CONSOLE.......8C-1
DESCRIPTION; POWER DOOR LOCKS.......8P-1
DESCRIPTION; POWER WINDOWS.........8S-1
DESCRIPTION; TRANSMISSION AND
TRANSFER CASE....................21-156
DESCRIPTION; TURN SIGNALS AND
HAZARD WARNING FLASHER........8J-1,8J-2
DESCRIPTION/SYSTEM OPERATION,
MULTI-PORT FUEL INJECTION (MFI)Ð
COMPONENT........................14-17
DESIGNATION CODES, VEHICLE........INTRO.-1
DESIGNATIONS, LABELS/PLATES, CODES
AND DIMENSIONS.................INTRO.-1
DESIGNATIONS, VEHICLE.............INTRO.-1
DETECTION AND REPAIR, FIXED GLASS
WATER LEAK..................23-83,23-189
DIAGNOSING INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING NON-INTERMITTENT
WINDSHIELD WASHER................8K-12
DIAGNOSING PARKING BRAKE
PROBLEMS..........................5-10
DIAGNOSING POWER DOOR LOCKS....8P-1,8P-9
DIAGNOSING REAR WIPER...............8K-6
DIAGNOSING REAR WIPER WASHER.......8K-6
DIAGNOSING REAR WIPER/WASHER......8K-14
DIAGNOSING SERVICE BRAKE
PROBLEMS...........................5-8
DIAGNOSING WINDSHIELD WASHER
(INTERMITTENT)......................8K-4
DIAGNOSING WINDSHIELD WASHER
(NON-INTERMITTENT)..................8K-4
DIAGNOSING WINDSHIELD WIPERS . . . 8K-3,8K-11
DIAGNOSINGÐALL LAMPS OUT..........8E-16
DIAGNOSINGÐTURN SIGNAL
INOPERATIVE.........................8J-2
DIAGNOSIS, 2.5L STARTER MOTOR NOISE . . . 8A-13
DIAGNOSIS, 30RH/32RH TRANSMISSION . . 21-69,
21-77,21-78,21-79,21-80,21-81,21-82,21-83,21-84,
21-85
DIAGNOSIS, ABS BRAKE..................5-3
DIAGNOSIS, ABS FAULT................5-4,5-6
DIAGNOSIS, AIR CONDITIONING
SYSTEM............................24-12
DIAGNOSIS AND REPAIR............8G-1,8G-2
DIAGNOSIS; AUDIO SYSTEMS.............8F-1
DIAGNOSIS, AW-4 TRANSMISSION
.......21-167
DIAGNOSIS, AXLE NOISE/VIBRATION;
FRONT SUSPENSION AND AXLE
..........2-16
DIAGNOSIS, AXLE NOISE/VIBRATION;
REAR SUSPENSION AND AXLES
..........3-7
DIAGNOSIS, BELT
.......................7-31
DIAGNOSIS CHARTS, INSPECTION
..........6-4
DIAGNOSIS; CHIME/BUZZER WARNING
SYSTEMS
...........................8U-1
DIAGNOSIS, CLUTCH
.....................6-3
DIAGNOSIS, COMPRESSOR
..............24-13
DIAGNOSIS, CONVERTER HOUSING
LEAK
..............................21-73
DIAGNOSIS; COOLING SYSTEM
.............7-4
DIAGNOSIS, CYLINDER COMBUSTION
PRESSURE LEAKAGE TEST
...............9-6
DIAGNOSIS, DISCONNECT AXLE/SHIFT
MOTOR
.............................2-27DIAGNOSIS, DOME/COURTESY LAMP
TROUBLE...........................8L-19
DIAGNOSIS, ECU........................5-4
DIAGNOSISÐELECTRICAL, SERVICE.......24-14
DIAGNOSIS, ENGINE.....................9-5
DIAGNOSIS, ENGINE CYLINDER HEAD
GASKET FAILURE......................9-5
DIAGNOSIS, EXHAUST SYSTEM............11-2
DIAGNOSIS, FOG LAMP TROUBLE.........8L-12
DIAGNOSIS, GAUGE PACKAGE............8E-22
DIAGNOSIS, GEAR LEAKAGE..............19-8
DIAGNOSIS GUIDES AND CHARTS........21-76
DIAGNOSISÐHAZARD LAMPS
INOPERATIVE.....................8J-1,8J-2
DIAGNOSIS, HCU........................5-4
DIAGNOSIS, HEATING SYSTEM...........24-11
DIAGNOSIS, IGNITION OFF DRAW (IOD).....8A-8
DIAGNOSIS, IGNITION SECONDARY
CIRCUIT...........................8D-12
DIAGNOSIS, ILLUMINATED ENTRY
SYSTEM TROUBLE..............8L-21,8L-22
DIAGNOSIS INFORMATION, GENERAL;
CLUTCH..............................6-3
DIAGNOSIS INFORMATION, GENERAL;
TRANSMISSION AND TRANSFER
CASE.............................21-167
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐXJ.........................8E-3
DIAGNOSIS, INSTRUMENT CLUSTER;
INSTRUMENT PANEL AND
GAUGESÐYJ........................8E-14
DIAGNOSIS, INTAKE MANIFOLD LEAKAGE.....9-5
DIAGNOSIS, LIGHTED VANITY MIRROR
TROUBLE...........................8L-19
DIAGNOSIS, MANUAL STEERING
SYSTEM............................19-36
DIAGNOSISÐMECHANICAL, SERVICE;
ENGINES.............................9-8
DIAGNOSISÐMECHANICAL, SERVICE;
HEATING AND AIR CONDITIONING........24-8
DIAGNOSIS, MULTI-PORT FUEL
INJECTION (MFI)ÐGENERAL...........14-32
DIAGNOSIS, NOISE.....................3-45
DIAGNOSIS, NP231 SERVICE............21-274
DIAGNOSIS, NP242 SERVICE............21-295
DIAGNOSIS, PERFORMANCE.............24-10
DIAGNOSIS; POWER MIRRORS............8T-1
DIAGNOSIS; POWER SEATS..............8R-1
DIAGNOSIS, POWER STEERING SYSTEM....19-3,
19-4,19-5,19-6,19-7
DIAGNOSIS, PRELIMINARY..............21-69
DIAGNOSIS, PRESSURE..................24-9
DIAGNOSIS PROCEDURES; BRAKES......5-3,5-7
DIAGNOSIS, PUMP LEAKAGE..............19-8
DIAGNOSIS, RADIO NOISE................8F-2
DIAGNOSIS; REAR WINDOW DEFOGGER....8N-2
DIAGNOSIS, SERPENTINE DRIVE BELT......7-32
DIAGNOSIS, SERVICE BRAKE..............5-7
DIAGNOSIS, SERVICE; FRONT
SUSPENSION AND AXLE................2-18
DIAGNOSIS, SERVICE; REAR
SUSPENSION AND AXLES................3-9
DIAGNOSIS, SERVICE; TRANSMISSION
AND TRANSFER CASE . 21-2,21-33,21-171,21-172
DIAGNOSIS, SPRING AND SHOCK;
FRONT SUSPENSIONAND AXLE
......2-12,2-14
DIAGNOSIS, SPRING AND SHOCK; REAR
SUSPENSIONAND AXLES
.............3-3,3-5
DIAGNOSIS, STARTING SYSTEM
..........8A-10
DIAGNOSIS; STEERING
.................19-35
DIAGNOSIS, SUSPENSION AND
STEERING SYSTEM
.....................2-7
DIAGNOSIS, SYSTEM
.....................7-7
DIAGNOSISÐTURN SIGNAL
INOPERATIVE
.........................8J-1
DIAGNOSISÐVEHICLE RUNS ROUGH
AND/OR HAS A MISS, INJECTOR
........14-49
DIAGNOSIS, VIBRATION
.............22-9,22-10
DIAGNOSISÐXJ VEHICLES, HEADLAMP
DELAY FUNCTION TROUBLE
............8L-16
DIAGNOSISÐXJ VEHICLES, HEADLAMP
TROUBLE
............................8L-1
DIAGNOSISÐYJ VEHICLES,
HEADLAMP TROUBLE
..................8L-2
6 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

GRILLE OPENING PANEL (GOP), GRILLE.....23-3
GRILLEÐXJ VEHICLES, AIR EXHAUST.....23-30
GROUND, POWER.....................14-22
GROUP INDEX; ELECTRICAL..............8A-1
GUARD, BRUSH........................23-3
GUARD/EDGE PROTECTOR STRIP, DOOR
EDGE..............................23-61
GUIDES AND CHARTS, DIAGNOSIS........21-76
HALF METAL DOOR MIRROR (EXTERNAL) . . 23-158
HALF-METAL DOOR LATCH STRIKER......23-175
HALF-METAL SOFT TOP DOOR..........23-173
HAND DRIVE, BATTERY CLASSIFICATIONS
AND RATINGSÐLEFT.................8B-10
HAND DRIVE, BATTERY CLASSIFICATIONS
AND RATINGSÐRIGHT................8B-10
HAND DRIVE, BATTERY REPLACEMENTÐ
LEFT...............................8B-1
HAND DRIVE, BATTERY REPLACEMENTÐ
RIGHT..............................8B-2
HAND DRIVE, BELT SERVICEÐEXCEPT
RIGHT..............................7-34
HAND DRIVE, BELT SERVICEÐWITH
RIGHT..............................7-35
HAND DRIVE, DRIVERS DOOR POWER
LOCK SWITCHÐ2-DOOR LEFT...........8P-2
HAND DRIVE, DRIVERS DOOR POWER
LOCK SWITCHÐ2-DOOR RIGHT..........8P-3
HAND DRIVE, DRIVERS DOOR POWER
WINDOW SWITCHÐ2-DOOR LEFT........8S-6
HAND DRIVE, DRIVERS DOOR POWER
WINDOW SWITCHÐ2-DOOR RIGHT......8S-7
HAND DRIVE, GENERATOR
REPLACEMENTÐLEFT.................8B-7
HAND DRIVE, GENERATOR
REPLACEMENTÐRIGHT................8B-9
HAND DRIVE (RHD), BELT TENSIONÐ
EXCEPT RIGHT.......................7-33
HAND DRIVE (RHD), BELT TENSIONÐ
RIGHT..............................7-34
HAND DRIVE VEHICLES, RIGHT............23-1
HAND DRIVE, WASHER PUMP
REPLACEMENTÐLEFT.................8K-2
HAND DRIVE, WASHER PUMP
REPLACEMENTÐRIGHT................8K-3
HANDLE, DOOR EXTERNAL..............23-55
HANDLE, FULL-METAL DOOR ASSIST.....23-175
HANDLE, FULL-METAL DOOR LATCH
EXTERNAL RELEASE.................23-178
HANDLE, FULL-METAL DOOR LATCH
INSIDE RELEASE AND LOCK...........23-175
HANDLE, FULL-METAL DOOR WINDOW
GLASS REGULATOR.................23-175
HANDLE, TAILGATE LATCH AND
RELEASE..........................23-160
HANDLEÐXJ VEHICLES, ASSIST.........23-118
HANGER BRACKET, MUFFLER/TAILPIPE.....13-16
HARD TOP DOME/CARGO LAMP BULB
REPLACEMENTÐYJ VEHICLES..........8L-20
HARD TOP LIFTGATE GLASS............23-162
HARD TOP QUARTER WINDOW GLASS....23-188
HARD TOP REPAIR....................23-165
HARD TOP ROOF VENT................23-165
HARD TOP SERVICE...................23-164
HARD TOP SERVICE INFORMATION.......23-164
HAZARD LAMPSÐXJ....................8J-1
HAZARD LAMPSÐYJ....................8J-2
HCU DIAGNOSIS........................5-4
HCU INSTALLATIONÐXJ.................5-54
HCU INSTALLATIONÐYJ.................5-54
HCU PUMP AND PEDAL TRAVEL
SENSOR OPERATION...................5-44
HCU REMOVALÐXJ.....................5-53
HCU REMOVALÐYJ.....................5-54
HCU SOLENOID VALVE OPERATION.........5-43
HEAD COVER, ENGINE CYLINDER......9-18,9-59
HEAD, ENGINE CYLINDER............9-19,9-60
HEAD GASKET FAILURE DIAGNOSIS,
ENGINE CYLINDER.....................9-5
HEADLAMP BEAM ADJUSTMENT...........8L-3
HEADLAMP BULB REPLACEMENT
..........8L-3
HEADLAMP DELAY FUNCTION TROUBLE
DIAGNOSISÐXJ VEHICLES
.............8L-16
HEADLAMP DELAY MODULE
REPLACEMENTÐXJ VEHICLES
..........8L-16
HEADLAMP DELAY MODULEÐXJ
VEHICLES, SENTINEL
.................8L-15HEADLAMP DIMMER SWITCH
REPLACEMENT.......................8L-6
HEADLAMP SWITCH REPLACEMENT........8L-4
HEADLAMP SWITCH/ILLUMINATION
RHEOSTAT..........................8E-21
HEADLAMP TROUBLE DIAGNOSISÐ
XJ VEHICLES.........................8L-1
HEADLAMP TROUBLE DIAGNOSISÐYJ
VEHICLES...........................8L-2
HEADLAMPS...........................0-35
HEADLINER.........................23-121
HEAT SHIELDS........................14-12
HEAT SHIELDS, EXHAUST................11-1
HEAT SHIELDS, MUFFLER AND TAILPIPE . . . 13-17
HEATER AND A/C CONTROL PANEL
REPLACEMENT......................24-26
HEATER CONTROL CABLE REPLACEMENT . . . 24-30
HEATER CONTROL PANEL REPLACEMENT . . . 24-39
HEATER CORE........................24-28
HEATER CORE AND HOUSING............24-40
HEATER CORE HOUSING REPLACEMENT . . . 24-29
HEATER, ENGINE BLOCK.................7-37
HEATER/DEFROSTER OPERATION.........24-37
HEATER/DEFROSTER/INSTRUMENT
PANEL OUTLET DOOR VACUUM MOTOR
REPLACEMENT......................24-30
HEATING ELEMENT TEST, OXYGEN
SENSOR (O2S)......................14-45
HEATING SCHEMATIC...................24-24
HEATING SYSTEM DIAGNOSIS............24-11
HEATING SYSTEMÐYJ VEHICLES.........24-14
HIGH LINE CLUSTER...................8E-12
HIGH MOUNTED STOP LAMP (CHMSL)Ð
XJ, CENTER.........................8L-10
HIGH MOUNTED STOP LAMP (CHMSL)Ð
YJ, CENTER.........................8L-11
HINGE, LIFTGATE......................23-67
HINGE REPLACEMENT, HOOD.............23-9
HINGE, TAILGATE.....................23-159
HINGE/HINGE PIN REPLACEMENT, DOOR . . . 23-58
HINGES, FULL-METAL DOOR............23-179
HITCHES, TRAILER.....................23-88
HOISTING AND TOWING, JUMP
STARTING,............................0-7
HOLDDOWN AND FLOOR BRACKETSÐ
XJ VEHICLES, SPARE TIRE/WHEEL......23-128
HONING CYLINDER BORES................9-2
HOOD..........................23-6,23-137
HOOD ADJUSTMENT....................23-9
HOOD ALIGNMENT....................23-138
HOOD HINGE REPLACEMENT..............23-9
HOOD INSULATOR PANEL..............23-138
HOOD LATCH REPLACEMENT............23-10
HOOD LATCH STRIKER REPLACEMENT.....23-10
HOOD SAFETY LATCH.................23-139
HOOKÐXJ VEHICLES, REAR TOW.........23-87
HOOKS, FRONT TOW....................13-5
HOOKS, TOW.........................13-14
HORN PAD REPLACEMENT, HORN SWITCH . . . 8G-3
HORN SWITCH (HORN PAD)
REPLACEMENT.......................8G-3
HOSE REPLACEMENT, PRESSURE AND
RETURN............................19-9
HOSE ROUTING SCHEMATICS,
VACUUM............................25-1
HOSE SPLASH SHIELDÐXJ VEHICLES,
FUEL FILLER........................23-86
HOSES, BRAKE BLEEDINGÐBRAKE FLUID
AND LEVELÐBRAKELINES..............5-13
HOSES, BRAKELINES....................5-15
HOSES, COOLING SYSTEM...............7-26
HOSES/TUBING, RUBBER AND PLASTIC.....0-28
HOUSING, AIR CLEANER; EMISSION
CONTROL SYSTEMS...................25-8
HOUSING, AIR CLEANER; FUEL SYSTEM....14-54
HOUSING AND PARK LOCK COMPONENT
OVERHAUL, ADAPTER................21-120
HOUSING END PLUG...................19-26
HOUSING, EVAPORATOR................24-42
HOUSING, EVAPORATOR/BLOWER.........24-33
HOUSING, HEATER CORE................24-40
HOUSING LEAK DIAGNOSIS, CONVERTER
. . . 21-73
HOUSING, LIFTGATE LICENSE PLATE
LAMP
..............................23-72
HOUSING REPLACEMENT, CLUTCH
.........6-11
HOUSING REPLACEMENT, HEATER CORE
. . . 24-29HOUSING SEAL REPLACEMENT,
ADAPTER..........................21-182
HOUSINGS, INSTRUMENT CLUSTER
AND GAUGE........................23-190
HUB BEARING AND AXLE SHAFT...........2-24
HYDRAULIC CLUTCH....................0-22
HYDRAULIC COMPONENTS................5-1
HYDRAULIC CONTROL UNIT (HCU).........5-39
HYDRAULIC FLOW DURING FULL
THROTTLE 3-2 DOWNSHIFT............21-92
HYDRAULIC FLOW DURING PART
THROTTLE 3-2 DOWNSHIFT............21-91
HYDRAULIC FLOW IN D RANGE FIRST
GEAR..............................21-87
HYDRAULIC FLOW IN D RANGE SECOND
GEAR..............................21-88
HYDRAULIC FLOW IN D RANGE THIRD
GEAR..............................21-89
HYDRAULIC FLOW IN MANUAL FIRST
GEAR (1) POSITION..................21-94
HYDRAULIC FLOW IN MANUAL SECOND
(2) RANGE..........................21-93
HYDRAULIC FLOW IN PARK AND NEUTRAL . . . 21-86
HYDRAULIC FLOW IN REVERSE..........21-95
HYDRAULIC FLOW IN THIRD GEAR
(CONVERTER CLUTCH ENGAGED)........21-90
HYDRAULIC LINKAGE INSTALLATION,
CLUTCH.............................6-12
HYDRAULIC LINKAGE REMOVAL,
CLUTCH.............................6-11
HYDRAULIC PRESSURE TEST......21-71,21-168
HYDRAULIC SYSTEM..................21-160
HYDRAULIC TAPPETS...............9-24,9-65
HYDROMETER TEST....................8A-3
IDENTIFICATION, AW-4 VALVE AND
SPRING...........................21-330
IDENTIFICATION, CIRCUIT................8W-2
IDENTIFICATION, COMPONENT............8W-2
IDENTIFICATION, ENGINE AND
TRANSMISSION/TRANSFER CASE.....INTRO.-3
IDENTIFICATION, MAJOR COMPONENT . . INTRO.-3
IDENTIFICATION NUMBER (VIN)
DECODING, VEHICLE...............INTRO.-2
IDENTIFICATION NUMBER (VIN) PLATE,
VEHICLE.........................INTRO.-1
IDENTIFICATION, TRANSFER CASE
. 21-273,21-293
IDENTIFICATION, TRANSMISSION
.....21-1,21-32,
21-66,21-157
IDENTIFICATION, WIRE CODE
.............8W-2
IDENTIFICATION, WIRING AND
COMPONENT
.......................8W-13
IDLE AIR CONTROL (IAC) MOTOR
.........14-56
IDLE AIR CONTROL (IAC) MOTORÐPCM
OUTPUT
............................14-25
IDLE AIR CONTROL MOTOR TEST
.........14-46
IDLE SWITCHÐPCM INPUT, EXTENDED
....14-21
IDLE SWITCH TEST, EXTENDED
...........14-45
IGNITION CABLES, DISTRIBUTOR CAP
AND ROTOR
.........................0-18
IGNITION CIRCUIT SENSEÐPCM INPUT
....14-21
IGNITION COIL; FUEL SYSTEM
...........14-57
IGNITION COIL; IGNITION SYSTEMS
. . 8D-4,8D-11,
8D-26
IGNITION COILÐPCM OUTPUT
...........14-26
IGNITION COIL RESISTANCE
.............8D-11
IGNITION KEY WARNING SWITCH
REPLACEMENT
.......................8U-4
IGNITION OFF DRAW (IOD) DIAGNOSIS
.....8A-8
IGNITION SECONDARY CIRCUIT
DIAGNOSIS
.........................8D-12
IGNITION SWITCH; BRAKES
...............5-42
IGNITION SWITCH CONTINUITY TESTS
.....8D-31
IGNITION SWITCH; IGNITION SYSTEMS
....8D-30
IGNITION SWITCH INSTALLATION/
ADJUSTMENT
.......................8D-31
IGNITION SWITCH REMOVAL
............8D-30
IGNITION SWITCH TESTING
.............8D-30
IGNITION TIMING
......................8D-14
IGNITION WIRING, SECONDARY
...........8W-1
ILLUMINATED ENTRY SYSTEM SERVICE
INFORMATION
.......................8L-20
ILLUMINATED ENTRY SYSTEM TROUBLE
DIAGNOSIS
....................8L-21,8L-22
JINDEX11
Description Group-Page Description Group-Page Description Group-Page

INSTRUMENT PANEL ILLUMINATION
LAMPS............................8E-16
INSTRUMENT PANEL LAMPS..............8E-4
INSTRUMENT PANEL REPLACEMENT.......8E-8
INSTRUMENT PANEL SERVICE..........23-192
INSULATION PANEL, DASH PANEL........23-95
INSULATOR PANEL, DASH PANEL.........23-11
INSULATOR PANEL, HOOD..............23-138
INTAKE AIR TEMPERATURE SENSOR......14-54
INTAKE AIR TEMPERATURE SENSORÐ
PCM INPUT.........................14-20
INTAKE AIR TEMPERATURE SENSOR TEST . . . 14-43
INTAKE DUCT, FRESH AIR...............24-41
INTAKE MANIFOLD.....................14-57
INTAKE MANIFOLDÐ2.5L ENGINE..........11-8
INTAKE MANIFOLDÐ4.0L ENGINE..........11-9
INTAKE MANIFOLD AIR TEMPERATURE
SENSOR.......................8D-5,8D-27
INTAKE MANIFOLD AIR TEMPERATURE
SENSOR TEST.......................8D-14
INTAKE MANIFOLD LEAKAGE DIAGNOSIS.....9-5
INTERCHANGEABILITY, PARTS............21-66
INTERIOR COMPONENTS..........23-91,23-190
INTERIOR LAMPS......................8L-19
INTERIOR LAMPS, XJ..................8L-23
INTERIOR LAMPS, YJ..................8L-23
INTERIOR PAINT CODES, XJ............23-205
INTERIOR PAINT CODES, YJ............23-206
INTERIOR REARVIEW MIRROR...........23-74
INTERIOR REARVIEW MIRROR
SUPPORT BRACKET REPLACEMENT......23-75
INTERIOR TRIM PANELS AND SCUFF
PLATESÐXJ VEHICLES...............23-112
INTERLOCK CABLE ADJUSTMENT (XJ),
PARK........................21-97,21-186
INTERMEDIATE (COUPLING) SHAFT . . 19-21,19-43
INTERMITTENT WINDSHIELD WASHER,
DIAGNOSING........................8K-12
INTERMITTENT WIPER MODULE...........8K-5
INTERMITTENT WIPER WASHER..........8K-20
INTERNATIONAL VEHICLE CONTROL
AND DISPLAY SYMBOLS............INTRO.-3
IN-VEHICLE SERVICE, 30RH/32RH.........21-96
IN-VEHICLE SERVICE, AW-4.............21-173
ISOLATION, COMPRESSOR..............24-17
JACK STORAGEÐXJ VEHICLES..........23-127
JOINT ANGLE MEASUREMENT,
UNIVERSAL..........................16-4
JOINT REPLACEMENT, UNIVERSAL.........16-9
JOINTS, UNIVERSAL....................16-2
JOUNCE BUMPER, REAR................13-18
JUMP STARTING........................0-7
JUMP STARTING, HOISTING AND TOWING.....0-7
KEY LOCK CYLINDER, DOOR.............23-54
KEY LOCK CYLINDER, FULL-METAL
DOOR............................23-178
KEY LOCK CYLINDERS.............23-2,23-132
KEY WARNING SWITCH REPLACEMENT,
IGNITION............................8U-4
KEYLESS ENTRY.......................8P-8
KNOCK, LOW SPEED; FRONT
SUSPENSION AND AXLE................2-17
KNOCK, LOW SPEED; REAR SUSPENSION
AND AXLES...........................3-8
KNUCKLE AND BALL STUDS, STEERING.....2-30
LABEL, TIRE INFLATION PRESSURE.....INTRO.-3
LABEL, VEHICLE EMISSION CONTROL
INFORMATION (VECI)
..................25-1
LABEL, VEHICLE SAFETY CERTIFICATION
. INTRO.-1
LABELS/DECALS/PLATES
...........23-1,23-132
LABELS/PLATES, CODES AND
DIMENSIONS, DESIGNATIONS,
.......INTRO.-1
LAG TEST, TIME
......................21-169
LAMP, 4WD INDICATOR
..................8E-2
LAMP, ANTI-LOCK BRAKE SYSTEM (ABS)
INDICATOR
..........................8E-2
LAMP BEAM ADJUSTMENT, FOG
..........8L-12
LAMP, BRAKE INDICATOR; INSTRUMENT
PANEL AND GAUGESÐXJ
...............8E-2
LAMP, BRAKE INDICATOR; INSTRUMENT
PANEL AND GAUGESÐYJ
..............8E-16
LAMP BULB REPLACEMENT, BACK-UP/
REAR TURN SIGNAL/TAIL
...............8L-9
LAMP BULB REPLACEMENT, FRONT PARK/
TURN SIGNAL
........................8L-8LAMP BULB REPLACEMENT, SIDE
MARKER............................8L-7
LAMP BULB REPLACEMENT,
UNDERHOOD........................8L-18
LAMP BULB REPLACEMENTÐYJ
VEHICLES, HARDTOP DOME/CARGO.....8L-20
LAMP BULB/ELEMENT REPLACEMENT,
FOG ...............................8L-13
LAMP (CHECK ENGINE), MALFUNCTION
INDICATOR; INSTRUMENT PANEL
AND GAUGESÐXJ................8E-2,8E-4
LAMP (CHECK ENGINE), MALFUNCTION
INDICATOR; INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-16
LAMP (CHMSL)ÐXJ, CENTER HIGH
MOUNTED STOP.....................8L-10
LAMP (CHMSL)ÐYJ, CENTER HIGH
MOUNTED STOP.....................8L-11
LAMP, COOLANT TEMPERATURE
INDICATOR..........................8E-1
LAMP FOR DIAGNOSTIC TROUBLE CODES,
INDICATOR (CHECK ENGINE)...........8A-19
LAMP HOUSING, LIFTGATE LICENSE
PLATE .............................23-72
LAMP, I/P ASH RECEIVER TRAY..........23-92
LAMP, LICENSE PLATE..................8L-10
LAMP, LOW FUEL WARNING..............8E-2
LAMPÐPCM OUTPUT, EMR..............14-24
LAMPÐPCM OUTPUT, GENERATOR.......14-25
LAMPÐPCM OUTPUT, MALFUNCTION
INDICATOR.........................14-26
LAMP REPLACEMENT, DOME.............8L-20
LAMP REPLACEMENT, FOG..............8L-15
LAMP REPLACEMENT, UNDERHOOD.......8L-18
LAMP, SEAT BELT REMINDER............8E-16
LAMP SERVICE INFORMATION, DOME/
COURTESY.........................8L-19
LAMP SERVICE INFORMATION, FOG.......8L-12
LAMP SERVICE INFORMATION,
UNDERHOOD........................8L-17
LAMP, SERVICE REMINDER INDICATOR
(SRI)...............................25-1
LAMP SPEED CONTROL SWITCH TEST,
STOP...............................8H-7
LAMP SUPPORT BRACKET, I/P TWEETER
SPEAKER/COURTESY.................23-95
LAMP SWITCH REPLACEMENT, FOG.......8L-14
LAMP TROUBLE DIAGNOSIS, DOME/
COURTESY.........................8L-19
LAMP TROUBLE DIAGNOSIS, FOG.........8L-12
LAMP, UPSHIFT INDICATOR;
INSTRUMENT PANELAND GAUGESÐXJ....8E-2
LAMP, UPSHIFT INDICATOR;
INSTRUMENT PANELAND GAUGESÐYJ . . . 8E-16
LAMPÐYJ RENEGADE VEHICLES, FOG....23-150
LAMP/REAR WIPER SWITCHES, REAR
DEFOGGER/FOG......................8E-21
LAMPS, EXTERIOR......................8L-1
LAMPS, INDICATOR....................8E-14
LAMPS INOPERATIVE, DIAGNOSISÐ
HAZARD.........................8J-1,8J-2
LAMPS, INSTRUMENT PANEL.............8E-4
LAMPS, INSTRUMENT PANEL
ILLUMINATION......................8E-16
LAMPS, INTERIOR.....................8L-19
LAMPS OUT, DIAGNOSINGÐALL..........8E-16
LAMPS, XJ EXTERIOR..................8L-23
LAMPSÐXJ, HAZARD...................8J-1
LAMPS, XJ INTERIOR..................8L-23
LAMPS, YJ EXTERIOR..................8L-23
LAMPSÐYJ, HAZARD...................8J-2
LAMPS, YJ INTERIOR..................8L-23
LATCH ADJUSTMENT, DOOR.............23-55
LATCH AND RELEASE HANDLE,
TAILGATE..........................23-160
LATCH ASSEMBLY REPLACEMENT,
SOLENOID...........................8P-6
LATCH, DOOR.........................23-56
LATCH EXTERNAL RELEASE HANDLE,
FULL-METAL DOOR..................23-178
LATCH, FULL-METAL DOOR
.............23-179
LATCH, HOOD SAFETY
.................23-139
LATCH INSIDE RELEASE AND LOCK
HANDLE, FULL-METAL DOOR
..........23-175
LATCH RELEASE AND LOCK RODS,
DOOR INSIDE
.......................23-57LATCH RELEASE CABLE REPLACEMENT....23-10
LATCH REPLACEMENT, HOOD............23-10
LATCH STRIKER AND BUMPERÐXJ
VEHICLES, REAR SEATBACK...........23-111
LATCH STRIKER, HALF-METAL DOOR.....23-175
LATCH STRIKER REPLACEMENT, HOOD....23-10
LATCH STRIKER REPLACEMENT, SAFETY . . . 23-10
LATCH STRIKER, TAILGATE.............23-161
LATCH/KEY LOCK CYLINDER/STRIKER,
LIFTGATE...........................23-68
LEAD CORRECTION CHART...............22-5
LEAF SPRING; FRONT SUSPENSION AND
AXLE...............................2-14
LEAF SPRING; REAR SUSPENSION AND
AXLES............................3-3,3-6
LEAF SPRING EYE BUSHING
REPLACEMENT; FRONT SUSPENSION
AND AXLE...........................2-15
LEAF SPRING EYE BUSHING
REPLACEMENT; REAR SUSPENSION
AND AXLES........................3-4,3-6
LEAK DETECTION AND REPAIR, FIXED
GLASS WATER................23-83,23-189
LEAK DIAGNOSIS, CONVERTER HOUSING . . . 21-73
LEAK DOWN TEST, FUEL PRESSURE........14-7
LEAK TEST, REFRIGERANT................24-8
LEAKAGE DIAGNOSIS, GEAR
..............19-8
LEAKAGE DIAGNOSIS, INTAKE
MANIFOLD
............................9-5
LEAKAGE DIAGNOSIS, PUMP
..............19-8
LEAKAGE TEST, CYLINDER COMBUSTION
PRESSURE
...........................9-6
LEAKAGE TEST DIAGNOSIS, CYLINDER
COMBUSTION PRESSURE
................9-6
LEAKS, REPAIRING
.....................22-3
LEAKS, TESTING COOLING SYSTEM FOR
....7-18
LEFT HAND DRIVE, DRIVERS DOOR
POWER LOCK SWITCHÐ2-DOOR
.........8P-2
LEFT HAND DRIVE, DRIVERS DOOR
POWER WINDOW SWITCHÐ2-DOOR
......8S-6
LETTERS, JEEP BODY CODE
...............5-2
LEVEL AND CONDITION, CHECKING
FLUID
.......................21-96,21-173
LEVEL AND CONDITION, FLUID
...........21-69
LEVEL, BRAKE FLUID
....................5-13
LEVELÐBRAKELINES AND HOSES,
BRAKE BLEEDINGÐBRAKE FLUID
........5-13
LEVEL, CLUTCH FLUID
...................6-14
LEVEL, COMPRESSOR OIL
................24-6
LEVEL, CORRECT FLUID
.................5-48
LEVEL, TRANSFER CASE FILL
...........21-294
LEVELS, OPERATING SOUND
...............5-3
LEVER INSTALLATION (XJ WITH FULL
CONSOLE), PARKING BRAKE
............5-60
LEVER INSTALLATION (XJ WITH MINI
CONSOLE), PARKING BRAKE
............5-58
LEVER INSTALLATION (XJ WITHOUT
CONSOLE), PARKING BRAKE
............5-60
LEVER POSITIONS, TRANSMISSION
RANGES AND SHIFT
.................21-157
LEVER REMOVAL (XJ WITH FULL
CONSOLE), PARKING BRAKE
............5-59
LEVER REMOVAL (XJ WITH MINI
CONSOLE), PARKING BRAKE
............5-58
LEVER REMOVAL (XJ WITHOUT
CONSOLE), PARKING BRAKE
............5-60
LICENSE PLATE LAMP
..................8L-10
LICENSE PLATE LAMP HOUSING,
LIFTGATE
...........................23-72
LICENSE PLATE SCREW ANCHOR
AND BUMPER, LIFTGATE
..............23-72
LIFTGATE ADJUSTMENT
.................23-70
LIFTGATE GLASS, HARD TOP
............23-162
LIFTGATE GLASS WEATHERSTRIP SEAL
REPLACEMENT
.....................23-163
LIFTGATE HINGE
.......................23-67
LIFTGATE LATCH/KEY LOCK CYLINDER/
STRIKER
...........................23-68
LIFTGATE LICENSE PLATE LAMP
HOUSING
...........................23-72
LIFTGATE LICENSE PLATE SCREW
ANCHOR AND BUMPER
...............23-72
JINDEX13
Description Group-Page Description Group-Page Description Group-Page

LIFTGATE LOCK CYLINDER
REPLACEMENT.......................8P-7
LIFTGATE OPENING WEATHERSTRIP SEAL . . . 23-70
LIFTGATE PILLAR TRIM COVERSÐXJ
VEHICLES.........................23-116
LIFTGATE REMOVAL/INSTALLATION........23-65
LIFTGATE SERVICE INFORMATIONÐXJ
VEHICLES..........................23-65
LIFTGATE SUPPORT ROD BALL
STUD REPLACEMENT.................23-70
LIFTGATE SUPPORT ROD CYLINDER.......23-69
LIFTGATE SUPPORT ROD CYLINDER
DISPOSAL..........................23-70
LIFTGATE TRIM PANEL.................23-66
LIFTGATE WINDOW GLASSÐXJ
VEHICLES..........................23-81
LIFTGATE WIPER.......................8K-5
LIFTGATE WIPER SWITCH REPLACEMENT....8K-6
LIGHT DISPLAY, ABS WARNING............5-3
LIGHT DISPLAY, BRAKE WARNING..........5-4
LIGHTED VANITY MIRROR...............8L-19
LIGHTED VANITY MIRROR TROUBLE
DIAGNOSIS.........................8L-19
LIGHTS, BRAKE WARNING.................5-1
LIGHTS (CANADA ONLY), DAYTIME
RUNNING...........................8L-16
LIGHTS, SYSTEM WARNING..............5-42
LIMITED SLIP DIFFERENTIAL...............3-8
LIMITS, AW-4 OIL PUMP WEAR.........21-325
LINE CLUSTER, HIGH...................8E-12
LINE CLUSTER, LOW...................8E-11
LINE FITTINGS, TRANSMISSION COOLER . . 21-187
LINERS, REAR WHEELHOUSE FLARES.....23-18
LINERS, WHEELHOUSE SPLASH.........23-146
LINES AND FITTINGS, SERVICING
TRANSMISSION COOLER.............21-106
LINK CONNECTORÐPCM INPUT, DATA.....14-20
LINK CONNECTORÐPCM OUTPUT, DATA . . . 14-24
LINK, DRAG.....................19-14,19-17
LINK REPLACEMENT, FUSIBLE............8W-4
LINKAGE ADJUSTMENT, SHIFT....21-275,21-296
LINKAGE ADJUSTMENT (YJ), GEARSHIFT . . . 21-96
LINKAGE AND BALL STUDS, STEERING.....0-30
LINKAGE FLUID, CLUTCH..................6-1
LINKAGE, GEARSHIFT..................21-70
LINKAGE INSTALLATION, CLUTCH
HYDRAULIC..........................6-12
LINKAGE REMOVAL, CLUTCH HYDRAULIC....6-11
LINKAGEÐXJ, STEERING..........19-14,19-73
LINKAGEÐYJ, STEERING..........19-17,19-73
LINKS, FUSIBLE.......................8W-3
LOAD DATA, VEHICLE................INTRO.-3
LOAD DATA, XJ VEHICLE.............INTRO.-5
LOAD DATA, YJ-VEHICLE.............INTRO.-6
LOAD TEST, BATTERY...................8A-4
LOCATING A SYSTEM...................8W-2
LOCATIONS, SPLICE..............8W-2,8W-53
LOCATIONS, TRANSMISSION SWITCH
AND PLUG..........................21-33
LOCATIONS, XJ RHD SPLICE............8W-67
LOCATIONS, XJ SPLICE................8W-59
LOCATIONS, YJ SPLICE................8W-53
LOCK COMPONENT OVERHAUL,
ADAPTER HOUSING AND PARK........21-120
LOCK COMPONENT REPLACEMENT,
PARK .............................21-102
LOCK CYLINDER, DOOR KEY.............23-54
LOCK CYLINDER, FULL-METAL DOOR
KEY ..............................23-178
LOCK CYLINDER REPLACEMENT,
LIFTGATE............................8P-7
LOCK CYLINDER, TAILGATE.............23-160
LOCK CYLINDER/STRIKER, LIFTGATE
LATCH/KEY.........................23-68
LOCK CYLINDERS, KEY............23-2,23-132
LOCK HANDLE, FULL-METAL DOOR.......23-175
LOCK, HYDROSTATIC.....................9-4
LOCK RODS, DOOR INSIDE LATCH
RELEASE...........................23-57
LOCK SWITCH, PASSENGER DOOR
.........8P-5
LOCK SWITCHÐ2-DOOR LEFT HAND
DRIVE, DRIVERS DOOR POWER
..........8P-2
LOCK SWITCHÐ2-DOOR RIGHT HAND
DRIVE,DRIVERS DOOR POWER
..........8P-3
LOCK SWITCHÐ4-DOOR, DRIVERS
DOOR POWER
........................8P-4LOCKS, DIAGNOSING POWER DOOR . . . 8P-1,8P-9
LOCKS, POWER; ELECTRICAL.............8A-1
LOCKS, POWER; POWER DOOR LOCKS.....8P-1
LOCKS, POWER DOOR..................8P-10
LOCK/UNLOCK RELAY REPLACEMENT,
DOOR.............................8P-12
LOOP MODES OF OPERATION, OPEN
LOOP/CLOSED.......................14-27
LOOP/CLOSED LOOP MODES OF
OPERATION, OPEN...................14-27
LOSS OF SENSOR INPUT..................5-3
LOW FUEL WARNING INOPERATIVE........8E-4
LOW FUEL WARNING LAMP..............8E-2
LOW LINE CLUSTER...................8E-11
LOW SPEED KNOCK; FRONT SUSPENSION
AND AXLE...........................2-17
LOW SPEED KNOCK; REAR SUSPENSION
AND AXLES...........................3-8
LOW WASHER INDICATOR INOPERATIVE....8E-4
LOWER SUSPENSION ARM...............2-11
LUBRICANT AND REPLACEMENT PARTS,
RECOMMENDED.......................0-3
LUBRICANT CHANGE; FRONT
SUSPENSION AND AXLE................2-22
LUBRICANT CHANGE; REAR SUSPENSION
AND AXLES......................3-13,3-30
LUBRICANT, RECOMMENDED.............21-2
LUBRICANT SPECIFICATIONS, BODY........0-35
LUBRICANT SPECIFICATIONS; FRONT
SUSPENSION AND AXLE................2-20
LUBRICANT SPECIFICATIONS; REAR
SUSPENSION AND AXLES...........3-11,3-30
LUBRICANT, TRANSFER CASE.....21-273,21-294
LUBRICANT, TRANSMISSION.............21-33
LUBRICANTS, CHASSIS COMPONENT
AND WHEEL BEARING.................0-30
LUBRICANTS, CLASSIFICATION OF..........0-2
LUBRICATION, CLUTCH COMPONENT........6-1
LUBRICATION, COMPONENTS
REQUIRING NO........................0-3
LUG NUT, WHEEL......................22-11
LUGGAGE RACKÐXJ VEHICLES..........23-32
MAGNETIC CLUTCH....................24-18
MAIN BEARING FITTING CHART.......9-43,9-83
MAIN BEARINGS, CRANKSHAFT.......9-40,9-80
MAIN OIL SEALS, REAR..............9-44,9-84
MAINTENANCE, BATTERY................8B-1
MAINTENANCE, ENGINE..................0-13
MAINTENANCE SCHEDULES...............0-5
MAINTENANCE, SEVERE SERVICE...........0-5
MAJOR COMPONENT IDENTIFICATION . . . INTRO.-3
MALFUNCTION INDICATOR LAMP
(CHECK ENGINE); INSTRUMENT PANEL
AND GAUGESÐXJ................8E-2,8E-4
MALFUNCTION INDICATOR LAMP
(CHECK ENGINE); INSTRUMENT PANEL
AND GAUGESÐYJ...................8E-16
MALFUNCTION INDICATOR LAMPÐPCM
OUTPUT............................14-26
MANIFOLDÐ2.5L ENGINE, ENGINE
EXHAUST............................11-7
MANIFOLDÐ2.5L ENGINE, INTAKE.........11-8
MANIFOLDÐ4.0L ENGINE, ENGINE
EXHAUST............................11-7
MANIFOLDÐ4.0L ENGINE, INTAKE
.........11-9
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR; FUEL SYSTEM
...............14-57
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR; IGNITION SYSTEMS
......8D-5,8D-27
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSORÐPCM INPUT
................14-21
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR TEST; FUEL SYSTEM
..........14-44
MANIFOLD ABSOLUTE PRESSURE (MAP)
SENSOR TEST; IGNITION SYSTEMS
......8D-14
MANIFOLD AIR TEMPERATURE SENSOR,
INTAKE
........................8D-5,8D-27
MANIFOLD AIR TEMPERATURE
SENSOR TEST, INTAKE
................8D-14
MANIFOLD ASSEMBLY, PRESSURE
GAUGE
..............................24-2
MANIFOLD, INTAKE
....................14-57
MANIFOLD LEAKAGE DIAGNOSIS, INTAKE
.....9-5
MANUAL FIRST GEAR (1) POSITION,
HYDRAULIC FLOW IN
.................21-94MANUAL SECOND (2) RANGE,
HYDRAULIC FLOW IN.................21-93
MANUAL SHIFTING TEST...............21-168
MANUAL STEERING GEAR..........19-35,19-73
MANUAL STEERING GEAR
SPECIFICATIONS.....................19-44
MANUAL STEERING GEARÐYJ VEHICLES....0-32
MANUAL STEERING SYSTEM DIAGNOSIS . . . 19-36
MANUAL TRANSMISSION................0-22
MANUAL TRANSMISSION, AX 15.........21-32
MANUAL TRANSMISSION, AX 4/5..........21-1
MANUAL TRANSMISSION, SELECTIVE
SNAP RING CHARTÐAX 15...........21-321
MANUAL TRANSMISSION, TORQUE
SPECIFICATIONSÐ AX 15.............21-320
MANUAL VALVE SHAFT OVERHAUL.......21-205
MANUAL VALVE SHAFT SEAL
REPLACEMENT.....................21-178
MARKER LAMP BULB REPLACEMENT,
SIDE...............................8L-7
MASTER CYLINDER.....................5-40
MASTER CYLINDER INSTALLATION.....5-20,5-50
MASTER CYLINDER OVERHAUL...........5-20
MASTER CYLINDER REMOVAL........5-20,5-50
MASTER CYLINDER, STANDARD...........5-20
MASTER CYLINDER/POWER BOOSTER
TEST...............................5-11
MATCH MOUNTING TIRES................22-7
MATERIAL, BRAKELINING.................5-1
MATS, CARPET/FLOOR.................23-198
MATS, CARPETS AND FLOOR...........23-129
MEASUREMENT AND ADJUSTMENT,
DIFFERENTIAL SHIM PACK..............2-42
MEASUREMENT, DIFFERENTIAL AND
PINION; FRONT SUSPENSION AND AXLE....2-38
MEASUREMENT, DIFFERENTIAL AND
PINION; REAR SUSPENSION AND AXLES....3-20
MEASUREMENT, UNIVERSAL JOINT
ANGLE..............................16-4
MEASUREMENTS AND ADJUSTMENTS,
ALIGNMENT...........................2-6
MEASURING WITH PLASTIGAGE............9-3
METALS, PAINT REPAIR ON GALVANIZED . . 23-202
METRIC SYSTEM NOTATION...........INTRO.-8
METRIC, THREAD NOTATIONÐSAE.....INTRO.-9
(MFI)ÐCOMPONENT DESCRIPTION/
SYSTEM OPERATION, MULTI-
PORT FUEL INJECTION................14-17
(MFI)ÐCOMPONENT REMOVAL/
INSTALLATION, MULTI-PORT FUEL
INJECTION..........................14-54
(MFI)ÐGENERAL DIAGNOSIS,
MULTI-PORT FUEL INJECTION..........14-32
MINI-FLOOR CONSOLEÐXJ VEHICLES....23-124
MIRROR (EXTERNAL), HALF METAL
DOOR
............................23-158
MIRROR, INTERIOR REARVIEW
...........23-74
MIRROR, LIGHTED VANITY
..............8L-19
MIRROR, REARVIEW
..................23-183
MIRROR REPLACEMENT, POWER
..........8T-4
MIRROR RETAINING BRACKET,
REARVIEW
.........................23-183
MIRROR SUPPORT BRACKET
REPLACEMENT, INTERIOR REARVIEW
....23-75
MIRROR SWITCH, POWER
................8T-2
MIRROR SWITCH REPLACEMENT,
POWER
.............................8T-4
MIRROR SWITCH TESTING, POWER
........8T-2
MIRROR TROUBLE DIAGNOSIS, LIGHTED
VANITY
............................8L-19
MIRRORS, EXTERNAL
..................23-31
MIRRORS, POWER
.....................8A-1
MISS, INJECTOR DIAGNOSISÐVEHICLE
RUNS ROUGH AND/OR HAS A
..........14-49
MODE, ABS OPERATION IN ANTILOCK
BRAKING
............................5-43
MODE, ABS OPERATION IN NORMAL
BRAKING
............................5-43
MODE, VEHICLE RESPONSE IN
ANTILOCK
............................5-3
MODEL 30 AXLE AND TUBE AXLE
(2WD)
..............................2-20
MODEL 30 FRONT AXLE
.............2-46,2-47
MODEL 35, REAR AXLE
..........3-11,3-28,3-50
14 INDEXJ
Description Group-Page Description Group-Page Description Group-Page

PUMP REPLACEMENTÐLEFT HAND
DRIVE, WASHER......................8K-2
PUMP REPLACEMENT, REAR WASHER.....8K-13
PUMP REPLACEMENTÐRIGHT HAND
DRIVE, WASHER......................8K-3
PUMP REPLACEMENT, WASHER......8K-6,8K-11
PUMP SEAL REPLACEMENT, OIL.........21-189
PUMP TESTS, WATER....................7-9
PUMP WEAR LIMITS, AW-4 OIL.........21-325
PUMPSÐGENERAL INFORMATION, WATER . . . 7-9
PUMPSÐREMOVAL/INSTALLATION, WATER . . 7-10
PURGING COMPRESSOR OF AIR..........24-17
QUARTER AND WHEELHOUSE TRIM
PANELSÐXJ VEHICLES..............23-115
QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES, REAR..........23-151
QUARTER PLASTIC INSERT ÐXJ
VEHICLES, QUARTER WINDOW GLASS/
REAR..............................23-80
QUARTER TRIM PANEL EXTENSIONÐXJ
VEHICLES.........................23-115
QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES, REAR..................23-80
QUARTER WINDOW APPLIQUEÐXJ
VEHICLES..........................23-29
QUARTER WINDOW GLASS, HARD TOP . . . 23-188
QUARTER WINDOW GLASS/REAR QUARTER
PLASTIC INSERT ÐXJ VEHICLES, REAR . . 23-80
QUICK-CONNECT FITTINGS..........14-9,14-59
RACK PISTON AND WORM SHAFT
REPLACEMENT......................19-30
RACKÐXJ VEHICLES, LUGGAGE..........23-32
RADIATOR FAN RELAYÐPCM OUTPUT.....14-26
RADIATOR GRILLE APPLIQUE...........23-134
RADIATOR PRESSURE CAP...............7-20
RADIATOR SUPPORT CROSSMEMBER......23-5
RADIATORS...........................7-22
RADIO ANTENNA.......................8F-8
RADIO CONNECTOR PINS................8F-3
RADIO ILLUMINATION RELAY.............8F-3
RADIO NOISE DIAGNOSIS................8F-2
RADIO REPLACEMENT...............8F-4,8F-6
RADIO SPEAKERS..................8F-4,8F-6
RADIO/CLOCK ILLUMINATION.............8E-4
RAIL ASSEMBLY, FUEL..................14-56
RAIL, FUEL...........................14-30
RAIL MOULDINGÐXJ VEHICLES, DRIP.....23-29
RANGE FIRST GEAR, HYDRAULIC FLOW
IN D...............................21-87
RANGE, HYDRAULIC FLOW IN MANUAL
SECOND (2).........................21-93
RANGE SECOND GEAR, HYDRAULIC FLOW
IN D...............................21-88
RANGE THIRD GEAR, HYDRAULIC FLOW
IN D...............................21-89
RANGES AND SHIFT LEVER POSITIONS,
TRANSMISSION.....................21-157
RATE, CHARGE.........................8A-6
RATINGS, BATTERY CLASSIFICATIONS......8A-8
RATINGSÐLEFT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATINGSÐRIGHT HAND DRIVE, BATTERY
CLASSIFICATIONS....................8B-10
RATIOS, GEAR.........................21-2
RATIOS, TRANSMISSION GEAR...........21-33
REAR AXLE 8 1/4 INCH..................3-50
REAR AXLE ALIGNMENT..................3-8
REAR AXLE MODEL 35..................3-50
REAR AXLES, FRONT....................0-26
REAR BAND ADJUSTMENT..............21-99
REAR BUMPER....................13-6,13-18
REAR CABLE REPLACEMENT (XJ),
PARKING BRAKE......................5-62
REAR CABLE REPLACEMENT (YJ),
PARKING BRAKE......................5-63
REAR CARPET/MATÐXJ VEHICLES.......23-130
REAR CLUTCH OVERHAUL..............21-128
REAR DEFOGGER RELAY.................8N-4
REAR DEFOGGER/FOG LAMP/REAR
WIPER SWITCHES....................8E-21
REAR DOOR FIXED WINDOW GLASS
......23-53
REAR DOOR WINDOW GLASS
............23-52
REAR DOOR WINDOW GLASS
REGULATOR
........................23-51
REAR FASCIA AND SKID PLATEÐYJ
RENEGADE VEHICLES
................23-152REAR JOUNCE BUMPER................13-18
REAR MAIN OIL SEALS..............9-44,9-84
REAR QUARTER EXTENSION PANELÐYJ
RENEGADE VEHICLES................23-151
REAR QUARTER VENT WINDOW GLASSÐ
XJ VEHICLES........................23-80
REAR SEAT CUSHION COVERÐ
XJ VEHICLES.......................23-107
REAR SEAT CUSHION
RECONDITIONINGÐXJ VEHICLES.......23-108
REAR SEAT CUSHIONÐXJ VEHICLES.....23-107
REAR SEATBACK COVERÐXJ VEHICLES . . . 23-111
REAR SEATBACK LATCH STRIKER AND
BUMPERÐXJ VEHICLES..............23-111
REAR SEATBACK RECONDITIONINGÐXJ
VEHICLES.........................23-111
REAR SEATBACKÐXJ VEHICLES.........23-109
REAR SERVO AND BAND OVERHAUL.....21-136
REAR SHOULDER BELTS...............23-196
REAR SHOULDER/LAP BELT/BUCKLEÐ
XJ VEHICLES.......................23-120
REAR SPEED SENSOR AIR GAP............5-3
REAR SUSPENSION COMPONENTS, XJ......3-50
REAR SUSPENSION COMPONENTS, YJ......3-50
REAR TOW HOOKÐXJ VEHICLES.........23-87
REAR WASHER PUMP REPLACEMENT.....8K-13
REAR WHEEL SENSOR INSTALLATION......5-50
REAR WHEEL SENSOR REMOVAL..........5-49
REAR WHEELHOUSE FLARES AND
LINERS............................23-18
REAR WINDOW DEFOGGER GRID
REPAIR .............................8N-2
REAR WINDOW DEFOGGER GRID TEST.....8N-1
REAR WINDOW DEFOGGER SWITCH
REPLACEMENT.......................8N-4
REAR WIPER ARM REPLACEMENT........8K-12
REAR WIPER, DIAGNOSING...............8K-6
REAR WIPER MOTOR REPLACEMENT......8K-13
REAR WIPER SWITCH REPLACEMENT.....8K-13
REAR WIPER WASHER, DIAGNOSING.......8K-6
REAR WIPER/WASHER, DIAGNOSING......8K-14
REAR WIPER/WASHER SWITCH TESTING . . . 8K-7,
8K-14
REARVIEW MIRROR...................23-183
REARVIEW MIRROR, INTERIOR...........23-74
REARVIEW MIRROR RETAINING
BRACKET..........................23-183
REARVIEW MIRROR SUPPORT
BRACKET REPLACEMENT, INTERIOR.....23-75
RECEIVER.............................8P-8
RECEIVER DRIERÐ4.0L ENGINES.........24-32
RECEIVER-DRIER REPLACEMENT.........24-42
RECEIVER SERVICE....................8P-11
RECIRCULATING AIR DOOR VACUUM
MOTOR REPLACEMENT, A/C............24-31
RECIRCULATING BALL POWER
STEERING GEAR.....................19-19
RECIRCULATING-BALL POWER STEERING
GEARS.............................19-69
RECOMMENDATIONS, TOWING.............0-8
RECOMMENDED BRAKE FLUID........5-13,5-48
RECOMMENDED FLUID; TRANSMISSION
AND TRANSFER CASE............21-66,21-96
RECOMMENDED LUBRICANT..............21-2
RECOMMENDED LUBRICANT AND
REPLACEMENT PARTS..................0-3
RECONDITIONING, BUCKET SEATBACK....23-102
RECONDITIONINGÐXJ VEHICLES, REAR
SEAT CUSHION.....................23-108
RECONDITIONINGÐXJ VEHICLES, REAR
SEATBACK.........................23-111
REFILLING COOLING SYSTEM.............7-17
REFINISHING, BRAKE DRUM..............5-37
REFINISHING, DISC BRAKE ROTOR.........5-32
REFRIGERANT LEAK TEST................24-8
REFRIGERANT (R-12)....................24-1
REGULATOR, FRONT DOOR WINDOW
GLASS.............................23-48
REGULATOR, FUEL PRESSURE...........14-30
REGULATOR, FULL-METAL DOOR
WINDOW GLASS
....................23-177
REGULATOR HANDLE, FULL-METAL
DOOR WINDOW GLASS
..............23-175
REGULATOR, REAR DOOR WINDOW
GLASS
.............................23-51
REGULATOR REPLACEMENT, WINDOW
......8S-9RELAY, AIR CONDITIONING (A/C)
CLUTCH............................14-54
RELAY, AUTOMATIC SHUT DOWN
(ASD); FUEL SYSTEM.................14-54
RELAY, AUTOMATIC SHUT DOWN (ASD);
IGNITION SYSTEMS..........8D-1,8D-8,8D-20
RELAY BANKS, FUSE CHARTS............8W-8
RELAY CONNECTIONS, STARTER..........8A-12
RELAY, FUEL PUMP....................14-56
RELAYÐPCM OUTPUT, AIR
CONDITIONING CLUTCH...............14-24
RELAYÐPCM OUTPUT, AUTO SHUT
DOWN (ASD)........................14-24
RELAYÐPCM OUTPUT, FUEL PUMP.......14-25
RELAYÐPCM OUTPUT, RADIATOR FAN.....14-26
RELAYÐPCM OUTPUT, TORQUE
CONVERTER CLUTCH.................14-27
RELAY, RADIO ILLUMINATION.............8F-3
RELAY, REAR DEFOGGER................8N-4
RELAY REPLACEMENT, DOOR LOCK/
UNLOCK...........................8P-12
RELAY REPLACEMENT, STARTER..........8B-4
RELAY TEST, STARTER MOTOR...........14-48
RELAY TEST, TORQUE CONVERTER
CLUTCH............................14-45
RELAY TESTING, AUTOMATIC
SHUTDOWN (ASD)...................14-43
RELAY TESTING, FUEL PUMP............14-44
RELAY, TORQUE CONVERTER CLUTCH.....14-60
RELEASE AND LOCK HANDLE, FULL-
METAL DOOR LATCH INSIDE..........23-175
RELEASE AND LOCK RODS, DOOR
INSIDE LATCH.......................23-57
RELEASE BEARING REPLACEMENT.........6-11
RELEASE CABLE REPLACEMENT, LATCH....23-10
RELEASE HANDLE, FULL-METAL DOOR
LATCH EXTERNAL...................23-178
RELEASE HANDLE, TAILGATE LATCH......23-160
RELEASE PROCEDURE, FUEL PRESSURE....14-5
RELEASE PROCEDURE, FUEL SYSTEM
PRESSURE.........................14-56
RELIEF/ROLLOVER VALVE, FUEL TANK
PRESSURE....................14-15,14-56
RELIEF/ROLLOVER VALVE, PRESSURE . . 25-5,25-9
REMINDER INDICATOR (SRI) LAMP,
SERVICE............................25-1
REMINDER LAMP, SEAT BELT............8E-16
REMOVAL, ACCELERATION SENSOR........5-52
REMOVAL AND INSTALLATION, 30RH/
32RH TRANSMISSION................21-108
REMOVAL AND INSTALLATION, AW-4
TRANSMISSION.....................21-189
REMOVALÐAX 15, TRANSMISSION.......21-34
REMOVAL, BRAKE PEDAL................5-65
REMOVAL, BRAKELIGHT SWITCH..........5-66
REMOVAL, CALIPER.....................5-27
REMOVAL, CLUTCH COVER AND DISC......6-10
REMOVAL, CLUTCH HYDRAULIC
LINKAGE............................6-11
REMOVAL, CLUTCH PEDAL...............6-15
REMOVAL, DIFFERENTIAL; FRONT
SUSPENSION AND AXLE................2-32
REMOVAL, DIFFERENTIAL; REAR
SUSPENSION AND AXLES...............3-16
REMOVAL, DISC BRAKESHOE.............5-25
REMOVAL, DRUM BRAKESHOE............5-34
REMOVAL, FRONT WHEEL SENSOR........5-49
REMOVAL, IGNITION SWITCH............8D-30
REMOVAL, MASTER CYLINDER........5-20,5-50
REMOVAL, POWER BRAKE BOOSTER . . . 5-22,5-51
REMOVAL, PRINTED CIRCUIT
............8E-24
REMOVAL, REAR WHEEL SENSOR
.........5-49
REMOVAL, ROTOR
......................5-30
REMOVAL, TRANSFER CASE
......21-276,21-296
REMOVAL, TRANSMISSION
...............21-3
REMOVAL, TRANSMISSION AND
CONVERTER
.......................21-108
REMOVAL, TRANSMISSION AND TORQUE
CONVERTER
.......................21-189
REMOVAL, TRANSMISSION VALVE BODY
. . 21-176
REMOVAL, VALVE BODY
...............21-100
REMOVAL, WHEEL CYLINDER
.............5-36
REMOVALÐXJ, HCU
....................5-53
REMOVAL (XJ WITH FULL CONSOLE),
PARKING BRAKE LEVER
................5-59
18 INDEXJ
Description Group-Page Description Group-Page Description Group-Page