1994 CHEVROLET SUBURBAN maintenance schedule

Explanation Of Scheduled Maintenance Services
Below are explanations of the services listed in the maintenance charts.
The proper fluids and lubricants to
use are listed in this section. Make sure
whoever services your vehicle uses these.
All parts should be replaced and
all necessary repairs done before you or anyone else drives the vehicle.
1. ENGINE OIL AND OIL FILTER CHANGE* -ALWAYS USE SH
ENERGY CONSERVIJTG TI (GASOLINE ENGINE) OR CF-4/SH
(DIESEL ENGINE) QUALITY OILS OF THE PROPER VISCOSITY.
To determine the preferred viscosity oil for your vehicle’s engine
(e.g.
SAE 5W-30 or low-30), see “Engine Oil” in the Index.
2. CHASSIS LUBRICATION - Lubricate the front suspension, king
pin bushings, steering linkage, transmission, and transfer case shift
linkage, parking brake cable guides, rear driveline center splines and
front axle propshaft splines, brake pedal springs, and clutch pedal
springs at the intervals specified.
Ball joints and king pin bushings should not be lubricated unless their
temperature is
10°F (-12”C), or higher. When the weather is cold, let
them warm up before lubrication or they could be damaged.
Also, be sure to check all the vehicle fluid levels at this time.
3. CLUTCH FORK BALL STUD LUBRICATION (5-SPEED
MANUAL TRANSMISSION
WITH DEEP LOW ) - Not
applicable to utility or wagon models.
4. COOLING SYSTEM SERVICE*? - Drain, flush and refill system
with new coolant. See “Engine Coolant’’
in the Index for the proper
coolant and mixture to use
in your vehicle.
Also inspect the hoses and replace them
if they are cracked, swollen, or
deteriorated. Tighten all
hose clamps (except constant tension clamps).
Remove debris and clean
the outside of the radiator and air
conditioning condenser. Wash the radiator
neck. To ensure proper
operation, pressure test the radiator and cap.
5. AIR CLEANER FILTER REPLACEMENT* - Replace at every
30,000 miles (50 000 km) or more often under dusty conditions. Ask
your dealer for the proper replacement intervals
for your driving
conditions.
6. FRONT WHEEL BEARING REPACK (2-WHEEL DRIVE
ONLY)
- Clean and repack the front wheel bearings at each brake
relining, or at the specified interval, whichever comes first.
4’ An Emission Control Service
*A fluid loss in these systems may indicate a problem. Have them
inspected and repaired at once.
7- 18
ProCarManuals.com

Maintenance Record
After each of the preceding Scheduled Maintenance Services is performed,
record the date, odometer reading, services performed (list
item numbers)
and who performed the services in
the appropriate column. In addition,
retain copies of your receipts. It
is suggested that receipts be kept with your
Owner's Manual.
7-28 ProCarManuals.com

L
Lights ..................................................... 2-47
Brake System Warning ......................................... 2-67
Bulb Replacement
............................................. 6-86
Charging System Light
......................................... 2-70
Front Parking/Turn Signal
....................................... 6-52
CheckGagesLight
............................................ 2-71
Dome
....................................................... 2-49
Headlights (See “Headlights”)
Indicator
.................................................... 2-66
Operation
................................................... 2-37
Reading ..................................................... 2-49
Service Engine
Soon ...................................... 2-7 1. 6-59
Rear
........................................................ 6-55
Replacement Chart
............................................ 6-86
SideMarker .................................................. 6-53
Loading Your Vehicle ....................................... 4-12, 6-59
Add-on Equipment
........................................... 6-61
Accelerator Control System
..................................... 6-48
Constant Velocity Joints
........................................ 6-48
Front Shock Absorbers
......................................... 6-46
Front Suspension and Steering Linkage
............................ 6-46
Front Wheel Bearings .......................................... 6-46
TailgateHandle
............................................... 6-49
HoodLatchesandHinge ........................................ 6-48
Lockcylinders ............................................... 6-49
Propeller Shaft Slip Splines
..................................... 6-48
RearAxle ................................................... 6-33
Recommended Lubricants ...................................... 7-25
Transfercase ................................................ 6-34
Luggagecarrier ................................................. 2-79
Lubrication
..................................................... 6-48
Body
....................................................... 6-48
FrontAxle
................................................... 6-35
Maintenance Otherltems
.................................................. 6-46
Record .................................................. 7.2. 7.27
Scheduled Maintenance .................................... 747-1 8
When Towing
a Trailer ......................................... 4-36
Master Cylinder (See “Brakes”)
Mirrors
........................................................ 2-51
Electric Outside ............................................... 2-52
Inside ....................................................... 2-51
Multifunction Lever .............................................. 2-38
Turn SignalLane Change Indicator
............................... 2-73
Underbody
.................................................. 6-76
... ModelReference .................................................. 111
6
ProCarManuals.com

Safety Belts (continued)
Extender
.................................................... 1-42
Lapshoulder ................................................. 1-29
Larger Children
............................................... 1-40
Properwear ................................................. 1-18
Questions
& Answers .......................................... 1-17
RearSeat
.................................................... 1-28
ReminderLight
............................................... 1-18
Replacing After a Crash
........................................ 1-43
RightFrontPassenger
.......................................... 1-26
Small Children and Babies
...................................... 1-31
Use During Pregnancy ......................................... 1-26
Safety Chains
................................................... 4-39
Safety Warnings and Symbols
........................................ vi
Scheduled Maintenance Services
................................ 747-1 8
Seats
........................................................... 1-2
Controls
...................................................... 1-2
Easy Entry Seat
................................................ 1-6
ManualFront
.................................................. 1-2
PowerDriver’s
................................................ 1-3
RearFolding .................................................. 1-8
Reclining
..................................................... 1-5
Removable
.................................................. 1-10
SeatbackLatches ............................................... 1-5
Secondary Air Injection (AIR System) ............................... 6-59
Service Do-It-Yourself
................................................ 6-3
Parts Identification Label
....................................... 6-80
Publications
................................................... 8-7
Replacement Parts and Filter Recommendations
..................... 6-83
Service Engine Soon Light
................................... 2-7 1, 6-59
Service Station Checks
............................................ 7-29
Shift Indicator Light ......................................... 2-25, 2-72
Shifting Into Park
................................................ 2-28
Single Belt Accessory Drive
....................................... 6-47
SpareTire
...................................................... 5-26
Removal
.................................................... 5-26
Storage
..................................................... 5-37
Specification Charts
.............................................. 6-81
Speedometer
.................................................... 2-65
Starting your Engine
........................................ 2-13, 2-16
Steering ........................................................ 4-7
ColumnShiftLever
............................................ 2-28
In Emergencies
................................................ 4-8
Tips
......................................................... 4-7
Storage Compartments
............................................ 2-56
Other ....................................................... 2-63
Sunvisors
..................................................... 2-53
WhyTheyWork
.............................................. 1-14
b
ProCarManuals.com