1994 CHEVROLET CAMARO fuel filter

Downloaded from www.Manualslib.com manuals search engine Replacement Parts
AirCleanerFilter .............................................. A1163C
Battery
........................................................ 75-60
Engine Oil Filter
VINEngineCodeS
............................................. PF47
VIN Engine Code
P ............................................. PF25
FuelFilter
...................................................... GF578
PCV Valve VIN Engine Code
S .......................................... CV789C
VIN Engine Code
P .......................................... CV895C
VIN Engine Code S .............................. oR43TSK (0.045" Gap)
VIN Engine Code P
............................. oR45LTSP (0.050" Gap)
Thermostat Temperature Specification
......................... 180" F (82" C)
Wheel
Nut Torque ................................... 100 Ib. ft. (140 Nom)
Radiatorcap ................................................... RC24
Spark Plug
Wheel Nuts
233. ..

Downloaded from www.Manualslib.com manuals search engine Crankcase
VIN Engine Code S .................................... 4.0 qt. (3.8 L)**
Without Filter Change
................................ 4.0 qt. (3.8 L)**
With Filter Change
................................... 5.0 qt. (4.7 L)**
Fuel Tank ........................................... 15.5 gal. (58.7 L)
Five-Speed
........................................... 5.9 pt. (2.8 L)*
Six-Speed
........................................... 8.0 pt. (3.8 L)*
Rear Axle Lubricant
........................................ 3.5 pt. (1.7L)
VIN Engine Code P
Manual Transmission
Vehicle Dimensions
Tread Wheelbase
........................................... 101.1 ‘I (2 566 mm)
Front
.............................................. .60.7 ‘I (1 542 mm)
Length
.............................................. 193.2” (4 908 mm)
Coupe
............................................. 5 1.3“ (1 303 mm)
Convertible
......................................... .52.0” (1 3 12 mm)
Rear ............................................... .60.6“ (1 540 mm)
Width
............................................... 74.1 ‘I (1 883.mm)
Height
*Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual Transmission Fluid” in the Index.
**Recheck the oil level after filling. See “Engine Oil” in the Index.
235. ..

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services
Schedule 1
MAINLY driven under one or more of
the following conditions:
When most trips are less than 4 miles
(6 km).
When most trips are less than 10 miles
(16 km) and outside temperatures
remain below freezing.
When most trips include extended
idling and/or frequent low-speed
operation, as
in stop-and-go traffic.
When towing a trailer.
0 When operating in dusty areas.
Schedule
I should also be followed if the
vehicle is used for deliverv service, police,
taxi or other commercial applications.
* An Emission Control Service.
=t The U.S. En\sironmental Protection Agency
or the California Air Resources Board has
determined that the failure to pellform this
maintemnce item will not
nullifi. the emission
warranty
or limit recall liability prior to the
cvmpletion
cf vehicle usejul life. General
Motors, however, urges rhat all rec.*ornmended
maintenance services
he performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
ITEM NO.
-
1
2
3
4
5
6
7
8 -
9
10
11
WHAT TO SERVICE
See “E,rplanation of Scheduled
Maintenunce Servicae.s”
jullowing
Schedules I and 11.
Engine Oil & Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection*
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code
S) Engine)*
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark Plug Wire Inspection*+
Air Cleaner Filter Replacement*
Fuel Tank, Cap & Lines Inspection*?
Rear Axle Fluid Change
(For Vehicles
Towing Trailers
or for Vehicles with
Limited-Slip Differentials)
WHEN TO PERFORM
Miles (kilometers) or Months
(whichever occursfirst).
Every 3.000 miles (5 000 km) or 3 months.
Every other oil chenge.
At 6,000 miles (10 000 km) and every
15,000 miles (25 000 km) or as necessary.
Every 30,000 miles (50
000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30,000 miles (50 000 km).
Every 100,000 miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and II.
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
. . .240

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section A: Scheduled Maintenance Services (cont.)
Schedule 11
Follow Schedule I1 ONLY if none of
Jhe driving: conditions specified in
Schedule I appl~
* An Emission Contsol Ses\:icc.
il- The US. Envisonmental Psotection Agency
os the Calijosrtia Ais Resousces Bousd has
detesmined that
the failuse to pesfosm this
maintenance item will not nullib the emissiott
warsanty
or limit secall liability psios to the
completion of whicle useful life. Genesal
Motoss, howews, urges that all sccommended
maintenance semices
be pesformed at the
indicated inten*als and
rhe maintenance he
secorded in “Section E: Maintenance Record.”
ITEM NO.
1
-
2
3
-
4
5
6
-
-
-
7
-
8
9
-
10
11
WHAT TO SERVICE
“E.vplanutiol? c?fSd~eduleci
Mairztetzuncx~ Ses\.ic*es‘’ fhllolz*itlg
Schedules I Ulld !I.
Engine Oil Change”
Oil Filter Change*
Chassis Lubrication
Tire and Wheel Rotation
& Inspection
Engine Accessory Drive Belt(s) Inspection”
Cooling System Service”
Transmission Service Spark Plug Replacement
(3.4L L32 (Code S) Engine)”
Spark Plug Replacement
(5.7L LTI (Code P) Engine)*
Spark
Plug Wire Inspection”?
Air Cleaner Filter Replacement”
Fuel Tank, Cap & Lines Inspection’k+
Rear Axle Fluid Change (For Vehicles
with Limited-Slip Differentials) Every
7,500 miles (1 2 500
km) or 12 months.
At first and then every other oil chqnge.
Every 7,500 miles
( 12 SO0 km) or 12 months.
At 7.500 miles (1 2 SO0 km) and then every
15.000 miles
(25 000 km) or as necessary.
Every 30.000 miles
(50 000 km) or 24 months.
See “Explanation of Scheduled Maintenance
Services“ following Schedules
I and 11.
Every 30,000 miles (SO 000 km).
Every IOO.OOO miles ( 166 000 km).
Every 30,000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” following Schedules
I and 11.
Every 30.000 miles (50 000 km).
See “Explanation of Scheduled Maintenance
Services” lollowing Schedules
I and 11.
. . .242

Downloaded from www.Manualslib.com manuals search engine ITEM
NO. SERVICE
6 Transmission Service - For
manual transmissions, fluid
doesn’t require changing. See “Periodic Maintenance
Inspections.”
For automatic transmissions, change both
the fluid and filter
every 15,000 miles (25
000 km)
if the vehicle is mainly driven
under one or more of these
conditions:
In heavy city traffic where the
outside temperature regularly
reaches
90°F (32°C) or
higher.
In hilly or mountainous
terrain.
When doing frequent trailer
towing.
Uses such as found in taxi,
police car or delivery service.
If
you do not use your vehicle
under any
of these conditions,
change both
the fluid and
filter every
100,000 miles
(166 000 km).
ITEM
NO.
7
8
9
10
SERVICE
Spark Plug Replacement* -
Replace spark plugs with the
proper type. See “Replacement
Parts” in the Index.
Spark Plug Wire Inspection*?
-
Inspect for burns, cracks or other
damage. Check the boot
fit at the
distributor and at the spark plugs.
Replace wires as needed.
Air Cleaner Filter Replacement*
- Replace every 30,000 miles
(50 000 km) or more often under
dusty conditions. Ask your
dealer for the proper replacement
intervals for your driving
conditions.
Fuel Tank. Cap and Lines
Inspection”?
- Inspect fuel tank,
cap and lines (including fuel rails
and injection assembly) for
damage or leaks. Inspect fuel cap
gasket for an even filler neck
imprint or any damage. Replace
parts as needed. Periodic
replacement of the fuel filter is
not required.
ITEM
NO. SERVICE
11 Rear Axle Fluid Change - If your
vehicle is used to pull
a trailer,
have the rear axle gear lubricant
changed every
7,500 miles
(12
500 km).
If your vehicle is not used
to pull
a trailer, but has a limited-slip
differential, have the rear axle
gear lubricant changed once after
the first
7,500 miles (12 500 km).
* An Emission Control Service.
t The US. Environmental Protection Agency
or the California Air Resources Board has
determined that the failure to pegorm this
maintenance item will not nullify the emission
warranty or limit recall liability prior to the
completion of vehicle useful life. General
Motors, however, urges that all recommended
maintenance services be performed at the
indicated intervals and the maintenance be
recorded in “Section
E: Maintenance Record.”
245.. .

Downloaded from www.Manualslib.com manuals search engine USAGE FLUID/LUBRICANT
Floor
Shift Linkage
Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Chassis Lubrication Engine oil.
NLGI Grade 2, Category LB or GC-LB.
Rear Axle
(Standard Differential)
I
Axle Lubricant (GM Part No. 1052271) or SAE SOW-90 GL-5 Gear Lubricant.
I
Rear Axle (Limited- I Axle Lubricant (GM Part No. 12345977) or SAE 80W-90 GL-5 Gear Lubricant, and Limited-
Slip Differential) Slip Differential.Lubricant
Additive (GM Part
No. 1052358 or equivalent) where required. See
“Rear Axle”
in the Index. I
Maintenance Schedule
Section D: Recommended Fluids & Lubricants (Cont.)
Windshield Washer GM Optikleen’ Washer Solvent
(GM Part No. 1051515 or equivalent).
Solvent
I
Hood Latch Assembly
a. Pivots and Spring
b. Release Pawl
Anchor
1
~~
a.
Engine oil.
b. Chassis lubricant (GM Part
No. 1052497 or equivalent) or lubricant meeting requirements of
Hood and Door
Hinges, Rear Folding
Seat, Fuel Door Hinge,
Rear Compartment
Lid Hinges NLGI
Grade
2, Category LB or GC-LB.
Engine oil
or Lubriplate Lubricant (GM Part No. 1050109).
~
Weatherstrips I Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).
See “Replacement Parts”
in the Index for recomme’nded replacement filters, valves and spark plugs.
. . .252

Downloaded from www.Manualslib.com manuals search engine Cruise Control To Erase Speed Memory
....... 79
To Get Out of
................ 79
To Increase Speed While Using
. . 77
To Reduce Speed While Using
. . 78
To Resume a Set Speed ........ 77
ToSet
...................... 76
Using on Hills
............... 78
Curves. Driving on
.............. 130
Customer Assistance for the Hearing
or Speech Impaired (TDD)
..... 258
Customer Assistance Information
. . 257
Customer Satisfaction Procedure
... 258
Daytime Running Lights
....... 80
Deep Standing Water
Driving through
.............. 58
Defects. Safety
Reporting to General Motors
.... 260
Reporting to the Canadian
Government
............... 260
Reporting to the United States
Government
............... 259
Defensive Driving
.............. 124
Defogger. Rear Window
......... 1 I1
Defogging and Defrosting
Windows
................... 109
Dimensions. Vehicle
............ 235
Doing Your Own Service Work
.... 180
Door Locks
.................... 47
Door Locks. Power
............. 48 Driver Position (Safety
Belts)
..... 21
Driving
AtNight
.................... 133
City
........................ 136
Defensive
................... 124
Drunken
.................... 124
Freeway
.................... 137
In the Rain .................. 134
On Curves
.................. 130
On Snow or Ice
.............. 140
Through Deep Standing Water
... 58
Winter
...................... 139
With a Trailer
................ 145
Drunken Driving
............... 124
Electrical Center. Underhood
.... 230
Electrical Equipment. Add-on
..... 227
Electric Mirror Control
.......... 82
Emergencies. Braking in
......... 129
Emergencies. Steering in
......... 130
Engine
Coolant
..................... 198
Coolant (Block) Heater
........ 59
Coolant Temperature Gage
..... 97
Exhaust
..................... 70
Identification
................ 227
Oil
........................ 187
Oil Pressure Gage
............. 99
Overheating
................. 157
Specifications
................ 232
Starting Your
................ 57 Environment.
Your Vehicle
andthe
..................... 238
Exhaust. Engine
................ 70
Explanation of Scheduled
Maintenance Services
......... 244
Extender. Safety Belt
............ 43
Fabric Protection
.............. 222
Fan Control Knob
.............. 108
Features and Controls
........... 45
Filling Your Tank
............... 183
Filter.
Air. Replacement .......... 192
Finish Care (Paint)
.............. 224
Finish Damage (Paint)
........... 225
Fixed Mast Antenna
............. 124
Flashers. Hazard Warning
........ 148
Flat Tire. Changing a ............ 167
Flat. If a Tire Goes
.............. 166
Floormats
..................... 89
Flow-Through Ventilation System . . I1 1
Fluid
Automatic Transmission
....... 194
Brake
...................... 203
Manual Transmission
.......... 196
Power Steering
............... 200
Recommended
............... 251
Windshield Washer
........... 201
FogLights
.................... 81
Folding Rear Seatback
........... 15
Foreign Countries. Fuels in ....... 182
Foreign Material Paint Damage
.... 225
269 . .