1994 CHEVROLET CAMARO check engine light

Downloaded from www.Manualslib.com manuals search engine Service and Appearance Care
2. The aiming ring will swing open like
gate. Remove the aiming ring from
thl
assembly. Place it face down, with the
aim indicator up. Be careful not to
damage
the aiming bubble.
. . .208
I
-
a3
e
4,
Pull the headlight out of the assembly.
Remove the wiring connector from
thl
headlight socket by lifting the plastic
locking tabs on the connector and
pulling
it from the socket.
Check the new headlight again. The
number
of the light must match the
number on the headlight being
replaced. The letter
“U” or “L” must
also match.
5.
6.
7.
0.
Plug the wiring connector into the
headlight socket. Snap the locking
tabs onto the socket.
Place the new headlight in the
headlight assembly. The socket must
be pointing
in the same direction the
socket on
the burned out bulb was.
Insert the tabs on the aiming ring into
the tabs
in the headlight assembly.
Hold the aiming ring closed, insert the
screws at the end of the ring. Tighten
the screws until the aiming ring
touches the plastic nuts on
both the
top and bottom.
Do not overtighten.
Do not damage the vertical aiming
bubble.

Downloaded from www.Manualslib.com manuals search engine 9. Check the headlight aim indicators.
The horizontal indicator (A) should be
on
0 (zero). If the vehicle is level, the
vertical indicator (B) should also be
on 0 (zero). If the vehicle isn’t level,
check the vertical aim on a
level
surface as soon as you can. If either
indicator doesn’t read
0 (zero), adjust
the headlight aim. See “Adjusting Headlight Aim” in the Index.
If your vehicle is damaged in an accident
and the headlight aim seems to be
affected, see your Chevrolet dealer.
Headlights
on damaged vehicles may
require recalibration
of the horizontal aim
by your Chevrolet dealer.
s ....... I,
... I......, 1..1...... . . . , . . . . . .
Center High-Mounted Stoplight
To replace the bulb:
1. Remove the two screws in the
stoplight
lens.
2. Gently pull the assembly out and remove the bulb from
the back of the
assembly.
3. Reverse the steps with a new bulb.
209. ,

Downloaded from www.Manualslib.com manuals search engine Service and Appearance Care
Fuses and Circuit
Breakers
The wiring circuits in your vehicle are
protected from short circuits by a
combination of fuses, circuit breakers,
and fusible thermal links in the wiring
itself. This greatly reduces the chance of
fires caused by electrical problems.
There are two fuse centers on your
vehicle. One is in the left side of your
instrument panel. The other
is in the engine compartment.
Open the cover on either of the boxes to
expose
the fuses.
Look at the silver-colored band inside
the fuse.
If the band is broken or melted,
replace the fuse. Be sure you replace a
bad fuse
with a new one of the correct
size.
If you ever have a problem on the road
and don’t have a spare fuse, you can
borrow one of the correct value. Just pick
some feature of your vehicle that you car
get along without
- like the radio or
cigarette lighter
- and use its fuse, if it i
the size you need. Replace it as soon as
you can.
Headlights
The headlight wiring is protected by a
circuit breaker. An electrical overload
will cause the lights to go on and off,
or
in some cases to remain off. If this
happens, have your headlight wiring
checked right away.
Windshield Wipers
The windshield wiper motor is protected
by a circuit breaker and a fuse. If the
motor overheats due to heavy snow, etc.,
the wiper will stop until the motor
cools. If the overload is caused by
some electrical problem and not
snow, etc., be sure to get it fixed.
Power Windows and Other Power
Options
Circuit breakers protect the power
windows and other power accessories.
When the current load is too heavy,
the circuit breaker opens and closes,
protecting the circuit until the problem
is fixed or goes away.
. . .228

Downloaded from www.Manualslib.com manuals search engine Maintenance Schedule
Section C: Periodic Maintenance Inspections (Cont.)
INSPECTION
OR SERVICE
Rear Axle Service
Brake System
Inspection
-
WHAT SHOULD BE DONE
Check the transmission fluid level; add if needed. See “Manual Transmission” in the Index.
A fluid loss may indicate a problem. Check the system and repair if needed.
Check the gear lubricant level in the rear axle and add if needed. See “Rear Axle” in the Index.
A fluid loss may indicate a problem. Check the axle and repair it
if needed. If your vehicle
is used to pull a trailer, have the rear axle gear lubricant changed every
7,500 miles
(12 500 km).
Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks,
cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also
inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums,
wheel cylinders, calipers, parking brake, etc. The parking brake is self-adjusting and
no manual
adjustment is required. You may need to have your brakes inspected more often if your driving
habits or conditions result in frequent braking.
NOTE: A low brake fluid level can indicate worn disc brake pads which may need to be serv-
iced. Also, if the brake system warning light stays on or comes on, something may be wrong
with the brake system. See “Brake System Warning Light” in the Index.
If your anti-lock brake
system warning light stays on, comes on or flashes, something may be wrong with the anti-lock
brake system. See “Anti-Lock Brake System Warning Light” in the Index.
. . .250

Downloaded from www.Manualslib.com manuals search engine Customer Assistance Information
Service Publications
Information on how to obtain Product
Service Publications (PSP’s) and Indexes
as described below is applicable only
in
the fifty U.S. states (and the District of
Columbia) and only for cars and light
trucks with
GVWR less than 10,000
pounds
(4 536 kg).
In Canada, information pertaining to
Product Service Bulletins and Indexes can
be obtained by writing to:
General Motors of Canada Limited
Service Publications Department
1908 Colonel Sam Dr.
Oshawa, Ontario
L 1 H 8P7
Chevrolet regularly sends its dealers
useful service bulletins about Chevrolet
products. Chevrolet monitors product
performance in the field. We then prepare
bulletins for servicing our products better.
Now, you can get these bulletins too.
Bulletins cover various subjects. Some
pertain to the proper use and care
of your
vehicle. Some describe costly repairs.
Others describe inexpensive repairs
which, if done on time with the latest
parts, may avoid future costly repairs.
Some bulletins tell a technician how to repair
a new or unexpected condition.
Others describe a quicker way to fix your
vehicle. They can help a technician
service your vehicle better.
Most bulletins apply to conditions
affecting a small number
of cars or trucks.
Your Chevrolet dealer or
a qualified
technician may have to determine
if a
specific bulletin applies to your vehicle.
Individual PSP’s
If you don’t want to buy all the PSP’s
issued by Chevrolet for all car or truck
models
in the model year, you can buy
individual PSP’s, such as those which
may pertain to a particular model. To do
this, you will first need to see our index of
PSP’s. It provides a variety of
information. Here’s what you’ll find
in
the index and how you can get one:
What You’ll Find in the Index:
0 A list of all PSP’s published by
Chevrolet
in a model year (I 990 or
later). PSP’s covering all models of
Chevrolet cars or light trucks (less
than
10,000 pounds (4 536 kg)
GVWR) are listed in the same index.
0 Ordering information so you can buy
the specific PSP’s you may want.
0 Price information for the PSP’s you
may want to buy.
How You Can Get an Index:
Indexes are published periodically. Most
of the PSP’s which could potentially
apply to the most recent Chevrolet models
will be listed in the most recent
publication for that model year. This
means you may want to wait until the
end
of the model year before ordering an
index, if you are interested in buying
PSP’s pertaining to a current model year
car or truck.
Some PSP’s pertaining to a particular
model year vehicle may be published
in
later years, and these would be listed in
the later year’s index. When you order an
index for
a model year that is not over
yet, we’ll send you the most recently
published issue. Check the ordering form
for indexes for earlier model years.
Cut out the ordering
form, fill it out, and
mail
it in. We will then see to it that an
index is mailed to you. There is no charge
. . .262

Downloaded from www.Manualslib.com manuals search engine Index
Care Compact Discs
............... 121
Safety Belts
................. 223
Cassette And Compact Disc
Storage
..................... 87
Cassette Tape Player. AMFM
Stereo
with .................. 1 13
Cassette Tape Player.
Care of Your
................. 120
Chains. Tire
................... 220
Changing a Flat Tire ............. 167
Check Gages Light
.............. 100
Checking Things under
the Hood . . 184
Checking Your Restraint Systems
. . 43
Chemical Paint Spotting
.......... 225
Chevrolet/Geo Roadside Assistance
.................. 260
Child Restraints
................ 35
Rear Seat
................... 37
Right Front Seat
.............. 39
Top Strap
................... 36
Where to Put the
.............. 35
Children (Safety Belts) ........... 34
Children. Larger (Safety Belts)
.... 42
Cigarette Lighter
................ 89
Circuit Breakers. Fuses and ....... 228
City Driving
................... 136
Cleaner. Air ................... 191
Cleaning
Aluminum Wheels
............ 224
Convertible Top
.............. 224 Cleaning
Fabric
...................... 221
Glass
....................... 223
Inside
of Your Chevrolet ....... 221
Instrument Panel. Top
of ....... 222
Leather
..................... 222
Outside of Your Chevrolet
...... 223
Problems. Special
............. 222
Tires
....................... 224
Twin Lift-off Roof Panels
...... 223
Vinyl ...................... 222
Windshield and Wiper Blades
... 223
Clock. Setting the
............... 112
Close-Out Panel
................ 88
Clutch. Hydraulic ............... 197
Comfort Controls
............... 108
Comfort Controls and Audio
Systems
.................... 107
Compact Disc. To Play a
......... 1 17
Compact
Disc Player. AMFM
Stereo
with .................. 116
Compact Disc Storage.
Cassette and
................. 87
Compact Discs. Care
of Your ...... 121
Compact Spare Tire
............. 176
Compartments. Storage and
....... 86
Console. Front
................. 87
Control of a Vehicle
............. 126
Control.
Loss of ................ 132 Controls
Air Conditioner
.............. 110
Brightness .................. 80
Comfort .................... 108
Features and
................. 45
Heater
...................... 108
Main Light
.................. 80
Remote Lock ................ 49
Seat
........................ 12
Convertible Top
................ 101
Installing the Boot Cover ....... 102
To Lower
................... 101
To Raise .................... 103
Convex Outside Mirror
.......... 82
Coolant Adding
..................... 199
Engine
..................... 198
Heater. Engine ............... 59
How to Add to the Coolant
Recovery Tank
............. 160
How to Add to the Radiator
. . 161. 163
Temperature Gage. Engine
...... 97
Cooling
....................... 110
Cooling System ................ 158
Courtesy Lights
................ 81
Courtesy Transportation .......... 261
Covered Visor Vanity Mirror
...... 89
Cruise Control
................. 76
ASR and
.................... 79
Passing Another Vehicle
While Using
............... 78
... 268

Downloaded from www.Manualslib.com manuals search engine Four-Way Manual Seat .......... 12
Freeway Driving
............... 137
Front
Ashtray
..................... 89
Console
.................... 87
Map Lights
.................. 7 1
Seat. Manual ................ 12
Seatback Latches
............. 14
Seatbacks. Reclining
.......... 13
Towing Hook-ups ............. 154
Fuel
......................... 181
Fuel Gage
...................... 94
Fuels
in Foreign Countries ........ 182
Fuse
Block. Main ............... 229
Fuse Block. Underhood
.......... 230
Fuses and Circuit Breakers ....... 228
Gages Engine Coolant Temperature
.... 97
Engine Oil Pressure ........... 99
Fuel
....................... 94
Warning Lights and Indicators
... 93
Gasolines for Cleaner
Air ........ 182
Glass (Cleaning) ................ 223
GloveBox
.................... 86
GM Participation in BBB Auto Line -
Alternative Dispute Resolution
Program
.................. 259
Halogen Bulbs ............... 205
Hatch Release
.................. 5 I
Hatch Release. Remote .......... 52
Hazard Warning Flashers
......... 148
Headlight Aiming
............... 205
Headlight High/Low Beam ....... 74
Heater Controls ................ 108
Heater. Engine Coolant (Block)
.... 59
Heating
....................... 108
Highway Hypnosis
.............. 138
Hill and Mountain Roads ......... 138
Hitches
....................... 144
Hood Release
.................. 184
Hood. Checking Things underthe
. . I84
Hook.Ups. Front Towing ......... 154
Hook.Ups. Rear Towing
......... 156
Horn ......................... 72
How to Add Coolant to the
Coolant Recovery Tank
........ 160
How
to Add Coolant to the
Radiator
................. 16 1. 163
Hydraulic Clutch
............... 197
Hydroplaning .................. 135
Hypnosis. Highway
............. 138
Identification Number. Vehicle
.... 227
If a Tire Goes Flat .............. 166
If You’re Stuck: In Sand. Mud. Ice
or Snow
.................... 177
Ignition Switch
................. 55
Inflatable Restraint System.
Supplemental
................ 26
Identification. Engine
............ 227 Inflation
. Tire Pressure .......... 2 15
Inside
Daymight Rearview
Mirror
...................... 82
Instrument Cluster
.............. 92
Instrument Panel
............... 91
Instrument Panel. Cleaning the
Topof
..................... 222
Interior Lights
................. 81
Jump Starting ................. 149
Key Release Button ............ 56
Keys ......................... 46
Label, Service Parts
Identification
................ 227
Lane Change Indicator,
Turn Signal and
.............. 73
Lap-Shoulder Belt (Safety Belts)
... 21
Larger Children (Safety Belts)
..... 42
Latches, Front Seatback .......... 14
Leaving Your Vehicle
............ 48
Leaving Your Vehicle with the
Engine Running
.............. 68
Lighter. Ashtray and
............. 89
Lighter, Cigarette
............... 89
Lights
Air Bag Readiness ............ 27
Anti-Lock Brake System Warning
.................. 95
ASR
....................... 96
... 270

Downloaded from www.Manualslib.com manuals search engine Lights Brake System Warning
......... 94
Bulb Replacement
............ 23 I
Check Gages ................ I00
Courtesy .................... 8 1
Daytime Running ............. 80
Fog ........................ 81
Front Map
................... 81
Gages and Indicators. Warning . . 93
Interior
..................... 81
Low Coolant ................. 101
Low Oil .................... 100
Low Traction ................ 97
Main Control
................ 80
Malfunction Indicator Lamp .... 98
Operation
of ................. 79
Safety Belt Reminder
.......... 20
Service Engine Soon
.......... 98
Skip Shift
................... 64
Lights On Reminder
............. 80
Limited-Slip Rear Axle
.......... 66
Loading Your Vehicle ........... 2 12
Lock Control. Remote
........... 49
Locks. Door
................... 47
Locks. Power Door
............. 48
Loss of Control ................ 132
Low Coolant Light
.............. 101
Low Oil Light ................. 100
Low Traction Light ............. 97
Lubricant. Rear Axle
............ 197
Lubricants. Recommended
....... 25 1
Main Fuse Block ............. 229
Main Light Control .............. 80
Maintenance
Inspections. Periodic
.......... 249
Record
..................... 253
Schedule
.................... 237
Services
. Scheduled ........... 240
Underbody
.................. 225
When Trailer Towing
.......... 146
Malfunction Indicator Lamp ...... 98
Manual Adjust Mirror
................ 82
Front Seat
................... 12
Remote Control Mirror ........ 82
Seat. Four-Way
............... 1 2
Transmission (Five-Speed)
..... 62
Transmission (Six-Speed) ...... 63
Transmission Fluid
............ 196
Windows
................... 71
Map Lights. Front .............. 81
MapPocket ................... 86
Master Cylinder. Brake .......... 202
Mirrors
Control. Electric
.............. 82
Convex Outside
.............. 82
Inside Day/Night Rearview
..... 82
Manual Adjust
............... 82
Manual Remote Control ........ 82
Visor Vanity. Covered
......... 89
Mountain Roads. Hill and ........ 138
New Vehicle “Break-In” ...... 55
Night Driving .................. 133
Night Vision
................... i34
Nuts . Wheel ................... 233
Odometer
. Speedometer and .... 92
Odometer. Trip
................. 93
Off-Road Recovery
............. 131
Oil. Engine .................... 187
Operation of Lights ............. 79
Overheating. Engine
............ 157
Owner Checks and Services
....... 246
P (Park) Shifting into ......... 67
P (Park). Shifting out of .......... 69
Paint Chemical Spotting
............ 225
Finish Care
.................. 224
Finish Damage
............... 225
Foreign Material
.............. 225
Brake
...................... 66
On Hills (Trailer Towing) ...... 146
Over Things That Burn ........ 70
Your Vehicle
................. 69
Parts. Replacement
.............. 233
Passenger Positions (Safety Belts)
. . 31
Rear Seat
................... 31
Right Front
.................. 31
Parking
PASS-Key
I1 ................... 53
271 . .