1993 VOLKSWAGEN GOLF wiper fluid

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Windscreen wiper and washer system
Vipers and washe rs o nly work w hen igni­
t io n is switched on.ff : r The heated windscreen washer jets* are swit c hed o n when the ign ition is 9 swi tc hed on and the amoun t of heat is regu­at ed automa tically acco rding to the ambi ­ent tem peratu re
Wh
en it is fr eez ing, ch eck that th e wipe r blades are not fro zen to t he g lass before switching the wipers on for the first time .
Windscreen
• Flick wipe _Ih lever to pressure point befo re deten te 1 .
• Wiper slow Le ve r at pos it io n 1.
• Wiper fast
Lever at posit ion 2
• Intermittent wipe Lever at posit io n 3 The w ipers "vork about every 6 seco nds.

W ith
an infinitely variable intermit­
tent wipe* the wipe dela y can be pro­

gram med betw een abou t 1.5 and 22 sec ­

o nds:

- Sw it c h
on intermitte nt wipe and wipe
once.
- Swi tc h off intermitte nt wi
pe an d then swi tch on again afte r the desired delay
The selec ted delay can be ch anged as oft e n as required. A fter switching off ignition the
se lec ted pause r ever ts back to a six seco nd
I n terv al.
• Automatic washJwipe facility Pull leve r tow ards steer ing whee l -wipe rs
and wash e r work.

R elease
lever-
The was he r st ops an d th e wi pers ca rry on
for abo ut 4 seconds.

Headlight w asher system*
Whe n the head lights are on, the lenses are
washed ev ery tim e the windsc reen is w ashed.
At r egular intervals such a s when filli ng t he tank, cake d-o n dir t a nd Insec ts should be re­
m oved.
Rear window
Press lever aw ay fr om steenng whee l and release -th e wipe r works about every 6
seco nds (inte rm ittent wip e) Pressing and releasi ng lever agai n switches the w iper off.
Automatic wash/wipe
P ress lever away from stee ring wh eel, an d
ho ld in t his positi on ­The wip er an d was her wor k as long as th e
l ever is he ld in thi s posi tio n
Release leve r ­
T he was her stops and th e wiper carr ies on for abo ut 4 seco nd s,
Notes
• T opp ing-up was her fluid
- se e page 103. • Changing winds creen w ipe r blades
- see page 1 04
55

Downloaded from www.Manualslib.com manuals search engine GENERAL MAINTENANCE

Cleaning seat belts
Keep belts clean because they ma y not

retract properly if very dirty .

Dirt y be
lts can be cleaned by was hing w ith

a mild soap solutio n without taking the belts

out of the vehicle.

Note
Inert ia reel belts should be completel y dry
before they are allowed to roll up.
Attention Do not have the belts cleaned chemically because the cleaning compounds damage the webbing material. Ensure that the belts do not come into contact with cor­rosive fluids.
Steel wheels
The wheels and the whee l tr ims should be
cle aned thoroughly at regular inter vals w hen the vehicle is being washed. This w ill
prevent brake dust , dirt and road salt from
accu mulating on the wheel. Persistent
ingr ained brake dust can be removed With an industrial grim e remov er. P aint damage
should be repaired before rust can form.
Alloy wheels
In order to maintain th e smart appearan ce
of all oy wheels for a long period, regular
car e is necessary . In particular, salt and brake pad dust must be washed off th or­ ough
ly
at leas t every tw o w eeks otherwise
the surface of the alloy Will be damaged
After being w ashed, the w heels shou ld be treated with an acid-free cleaner for al loy wheels. About every three months it is necessary to give wheels a good rubbing
w ith hard wax. Paint polish or other abrasiv e
solutions must not
be used. If the protecti ve
paint coat has been damaged , eg. by stone
impact, the damaged spots should be dealt with as soon as possible.
Cleaning and anti-corrosion
treatment of engine compart­
ment
Attention Before doing any work in the en­gine compartment it is essential to read the notes on page 91!
The leaves, blossoms etc . w hich drop into
the water box (underneath the engine
bonnet
in f ront of the windscreen) should
be cleaned out occasional ly This w ill pre­
v ent the water drain holes becoming
blocked
and -on veh ic les w ithout a fresh air
filter -foreign bodies entering the vehicle
interior v
ia the heating and ventilat ion sys­
tem.
Attention For safety reasons pull out igni­tion key before reaching into the water box. Otherwise if the wind­screen wipers are switched on unintentionally the movement of the wiper linkage could cause in­jury.
The engine compartment an d th e outsi de
surface of the power unit are given anti-cor ­
rosion treatment at the factor y.
In th e winter w hen the vehicle is being
driven frequ entl y on salted roads, good anti­
corrosion treatment is very important. For
th is reason the entire engin e comp
artment and the plen um chamber should be thor­
ough ly cleaned before and after the salting
period
and then preserved so that the salt cannot have a damag ing effect
The ignition must be switched off before washing the engine.
If the engine compartment is cle aned at any
time with greas e removing solution s 1) or if
one has the engine washed, the anti-cor­
rosion compound is nearly alwa ys removed as wel l. It is the refore essential to ask for
durable preserv ation of all surfaces, seams,
joints and components in the engine com­partment to be carried out. This applies also
1) Only the corre e clean ing solutions may be use d -on no aecoun petrol or Diesel.
88

Downloaded from www.Manualslib.com manuals search engine Washer system
The fluid container is on the left of the en­
gine compartment. The container holds
about 4 litres, on ve hicles with headlight
washer system * about 7 litres. The con­
t ainer illustrated is for veh icle s with head­
l ight washer system.
T he rear
window washer is supplied w ith
flu i d from the container in the engine com­
partment.
Filling the container
It is advisable to add a window cleaning sol­ution with a wa x remo ver (with anti-freeze
additive in winter) to the water because
plai n water is not usually sufficient to clean
the glass and headlight lenses quickl y and
th oroughly The mixing ratios on the win­dow cleaner packaging must be adhered to.
E v
en w hen heated windscreen washer jets* ar e fitted, a w indow clean­
ing solution containing anti-freeze should be
added to the water in th e w inter.
Note I' If at any time no window cleaning solution
w ith anti-freeze additive is available, methylated spirits can be used. Do not,
under any circumstances, add engine cool­
ing system fluid or other additives.
GENERAL MAINTENANCE

Adjusting washer jets
When the vehicle is stationary, the water should hit the windscreen approximately as sh own .
The
Jet for the rear w indow washer is in the wiper shaft. The water jet shou ld hit the
g lass in the cen tre of the wiped area.
The jets
can be adjusted with a need le .
The jets fo r the
headlight washer sys­tem* can only be adjusted with a special
tool. When adju stmen t is necessary, con­
tact your Volkswagen dealer.
103