1993 VOLKSWAGEN GOLF coolant level

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

Warning lamps
Attention • Be careful when opening the coolant expansion tank! When the engine is hot the cooling sys­tem is under pressure -Danger of scalding! Let engine cool down therefore before unscrewing the cap_
• Do not touch the fan. The fan can switch on suddenly -even when ignition is switched off.
For furthe r details see pages 98 and 98.
1 -Coolant temperaturel _~_ If the coolant le vel is in orde r the trouble Coolant level') may be due to failure of the radiato r fan.
Check radiator fan fuse and renew is
T he wa rni ng lamp lights up for a few sec­
necessary -see page 119.onds as a functional check when ign ition IS coo lant level .
. 46 switched on.
2 - Engine oil pressure ... .. 47 If the warning lamp does not go out al­
If the lamp does not go out afterwards or 3 -Alternator . 47 though coolant level and fan fuse are inflashes when driving, either the coolant 4 -Glow plugs ... 47 orde r, do not drive on -call in expe rt as­tempe ratur e is too high or the coolant 5 -Brake system .. 48 sistance
.
level1 l too low: 6 -Brake pad wear indicator .48 If the trouble is only caused by the fan andStop, switch engine off and check7 -Turn signals 48
assuming coolant level is in order and tem­level . Add coolant if necessary . 8 -Main beam .
48
perature warning lamp is out -one can drive on to the nearest Volkswagen dealer. In 11 Only 011 vehicl es wi h a t omatic coolant order to make good use of the air stream for level lllonit or (see page 97 l. cooling , do not let engine idle or drive very
slowly .
he
layout
of the warning lamps depends on the model and the engine fitted. The sym­
bols shown here are also on the actual
warn ing lamps.
1 -Coolant temperature /

Downloaded from www.Manualslib.com manuals search engine CONTROLS AND EQUIPMENT

2 -Engine oil pressure ~
e wa rning lamp flashes when ignition is :ched on. the lamp must go out when ,=~g ne has started.
, 'Il e warning lamp does not go out or
ash es when driving -a buzzer also sounds
-' e!,gine spe,eds above 2000 rpm -stop, switch engine off, check oil level and if ecessary, add oil -see page 94.
- - he lamp comes
on although the oil level 5 n order, do not drive on. Do not even "'., t he engine at idling speed -call in expert ~slstance.
-du ring the Journe y the engine is operated
a : a speed less than idling speed, it ca n ~ appen that the oil warning lamp lights up. "crease engine speed by accelerating or :'langing down .
Note Th e oil pressure warning lamp is not an oil level indicator. The oil level shou.'d therefore be checked at reg, ular Intervals, preferably every time the fuel tank is filled.J
3 -Alternator
The warning lamp comes on w hen the igni­

tion IS sWitched on and must go out when

the engine is started .

The alternator
is driven by a long-life ribbed

belt.

If the warning lamp lights during the

Journey ,
stop, switch off engine and
check ribbed belt.

If
t~e ribbed belt is loose or broken, do not
drive on -the coolant pump is no longer

being driven. The ribbed belt must be
checked/renewed by the next Volkswagen

dealer.

If the ribbed belt
is not loose or broken, one
can normally drive on to the next Vo lks­

wag en dea ler. However as the battery is
then discharging co ntinuously , all electrical

consumers which are not absolutely essen­

tial should be switched off.

4 -Glow plugs
(Diesel engines only)

When the engine
is cold the w arning lamp

come s on when key IS turned to Drive posi­

tion (ignition on)

If the warning lamp does not come on, there IS a defectln the glow plug system -call in expert assistance.
When the lamp goes out, start the engine
Immediately -see page 37.
As the 55 kWDiesel engine glow period be­
gins automatically after closing the drivers'
door,
It can happen that after switching to
the driving position (Ignition on) with a cold
engine, that the glow plug warning lamp
does not light up . The engine
can be started
straight away
When the engine
is warm the glow plug
lamp does not come on -the engine ca n be started straight away
Note
If while driving a fault occurs in the engine
management system of the 66 kW Diesel
engine, this
is indicated by a flashing warn­Ing lamp The engine must be checked by a
Volkswagen dealer as soon as possible.
47

Downloaded from www.Manualslib.com manuals search engine GENERAL MAINTENANCE
Cooling system
The cooling system is filled at the factory with a perman ent coolant whic h is not
changed . The coo lant consists of w ater and a 40 % concent ration of our coolant additive
G 11 V8B (anti-f reeze on glycol basi s with
anti-corrosion additives). Thi s mi xture not
only gives the necessary frost prot ection
down to -25°C but also pro te cts the allo y
parts in the cooling system against cor­
rosion. In add it ion it pr event s scal ing and ra­ises the boiling point of the coo lant
The concentr atio n of the co olant therefore
must not be reduce d in the summer or in
wa rm countries, by tOPPing up with plain
w ater. The coolant additive propor­tion must be at least 40 %.
If greater protection against frost is re­
qu ired, th e propor tion of G 11 V8B additive
c a n be increased, but onl y up to 60 % (Irost
prot ection to appr ox. -40 Cl. oth erwise the
a n ti-freeze prot ection is red uced and fur­
t h ermore the cool ing effec t is im paired .
Vehicles for expor t to cold cou ntries usually
h ave frost protection down to -35°C.
Only our G 11 V8B or an addi tive with the specification TL-VW 774 B (ma rked on container ) should be added to the coolant.
The ad dit ive s can be obtained from Volks­
w ag
en dealer s.
Other additives c a n b e very detri­mental to the anti·corrosion effect in particular.
The subsequent corro sion damage can lead to coolant loss resulting in major engine damage.
Checking coolant level
The expansion tank is in the engine com­
p artm ent on the bulkhead -see Fig
The level can o nly be checked properly
w he n engin e is not running .
The coo lant level must be bet ween the MIN
and Mt>,X marks on e xpansion tank when
engine is cold and can be slightly above the
MAX mark when it is warm .
07

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX

A Acceleration figu res . . .... . . .

Accessories

Adjusting washer jets

A ir conditioner
.. ....... .

Airbag

Alloy w heels

Analog clock
..
Anti-freeze.

Anti-dazzle inside mirror

Anti-knock properties of the fuel

Anti-locking brake system
(ABS)
Anti-theft warning system

Aq uaplaning .... ..... .

Ashtray .......... . .
ATF.
Automatic gearbox.

Automatic tra ns mission fluid

Automati c was h plants .... . . . .

Axle weights. . ....... .

B Battery . . . ....... . . . . .

Belt height adjustment ... .. . . .

Blower ...
Bonnet.
B rake fluid.
Brake pad wear indicat or

Brake servo .

Brake system

Brake warni
ng I'amp .

B rakes

B ulb changing.

Burglar alarm .
1
36

111
103
59
18
88
41
97

12

82
76
8
106
68

96
32

96

85

143

100
15

56, 59
90

99

48
75
99
48
75

121
8

C Capacities .. . . .... . 146
Care 85
Care of body . . . . . . . . . . . . . 85
Care of vehicle 85

Cavity preservation 89

Central locking system 7

Cetane Number . . . . . . . . . . 84

Changing bulb s . . . . . . . . . . 1
21
Changing wheels 116
Chassis number 147
Child safety . 21
Child seats ........ . . . . . . . 21
Chi ld-proo f catch ......... 9

Cigarette lig hter 68

Cigarette lig h ter socket. 68
Cleaning and anti -corrosion treatment of

engine compartment . . . . . . . . 88

Clean ing veh ic le . . . . . . . . . . 85

C limat ronic 62
Clock .. 41
Cockpit . . . . . . . . . . 4

Cold starting aid 37
Compression rat io 134

Cons umption figures. . 137

Coolant additive 97
Coolant level 46, 97
Coolant tempera ture gauge 45

Cool ing system . . . . . . . . . . 97
Cruise control system 54

Cubic capacity 134

D Dash panel 4
Defrosting windows 57,60,62
Diesel fuel 84
Dimensions. 145

Dip lever 53

Direction indicators 48, 53
Do-it-yourself ......... .
112

Door locks . ..... . . 9
Doors . .. 9
Driver's seat
25

Driving abroad .... . 110
Driving economically 72
Driving tips ...... . ... ..... ..... . 71
Driving with four-wheel drive 79
Dust and pollen filter ...... . .. . . 104

1 48

Downloaded from www.Manualslib.com manuals search engine ALPHABETICAL INDEX

E F H Electri
c windows 10.52 Fan . . .. 98 Hand brake 31 Emergency li ght s 51 Filling the tank ...... . . 81 Head restraints .. ............... 24
E me rgency startin g 128
Filter preheating .......... . . 84 Headlight flasher ........ .. . 53 Engine First
aid kit ........... . . . 112 Headlight range control ........... 51 -Code letters 147
Folding/sliding cover 30 Headlig ht washer system
55
- Data 134 Foot mats ............ . 31 Heated rear window 52 -Number 147 Four wheel drive 79 Heating
56 -Oil .. 92 Fresh air filte r ........ . 104 Height adjustable seat. 26
- Oil capacity. 146 Fresh air venti lation
58, 61 Height adjustable steering wheel
35
- Oil change intervals 2.95 Front fogligh ts ........... . .
50 High beams. ........... 48
- Oil consumption
94 Front
seats
25 Horn
4
- Oil level
..... . . .. . . 94 Fuel ........... . . . 82
- Oil pressure 47 -Additives. 83, 84
- Starting/stopping 36 -
Consumption ........ . 72,137 Engine compartment. 91 -Filter preh eating . 84 Identification
data
147
E ngine number. 147 -Gauge
45 Idling speed boost ......... 37 ~Environment -Saving
72 Ignition lock. . . . . . . . . 35
-Battery. . . . . . . . . . . . .
. . . . . . . .. 102 Fuel gauge Fuses. 45
119 Increasing
luggage space
I nertia reel belts ......... 27 14 -Brake fluid. . . . . . . . . . . . . . . . . . .. 99 InSide mirror . . . . . . . . . . . . 12 -Care ofcar. . . . . . . . . . . . . . . . . . .. -Coolant ...................... 85 98 G Inspection intervals
Instruments 95
39
-Driving with low emissions and n
oise......... ............... 72 Gear change marks
Gear stick ....... . . 39, 71 31 Interior
lights 67
-Engine oil .................... -En vironmentally conscious drivin g . . . . . . . . . . . . . . . . . . . . . .. - Exhaust gas system .... . .. . ...
95
72
74
Glove box light .......... .
Glow plugs
Gross vehicle
weight
67,126 37
143
- Filling th e tank ................ 81 -~~.......................... ~ -Maintenance. . . . . . . . . . . . . . . . . .. 2 - Old oil . ....................... 95 - Old tyres .................... 107 - Tyre pressure ................ 105 - Tvres .... . .. . . ............... 107 - Unfeade d fuel. . . . . . . . . . . . . . . .. 83 - Washing th e vehicle ........... 86 Exha..JS. gas system 74
149