1990 VOLKSWAGEN TRANSPORTER page 54

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

INSTRUMENTCLUSTER
page

1 -
Speedometer/Odometer
.... 40

2
-
Digital clock*
40

3
-
Tachometer* or normal clock
. . 41

4
-
Coolant temperature gauge
. . 41
5
-
Fuel gauge
42

6
-
Warning/indicator lights
|B25-624J

1 -
Speedometer/Odometer

The
speedometer
indicates road
speed.

The
odometer
indicates
the
distance
driven.
USA
models: Miles

Canada
models: Kilometers
To record
a
distance, reset
the
trip

odometer to
zero by pressing the button.
The last
digit
in red indicates
1
/10 of a mile
or kilometer. 2
-
Digital
clock*
To
set the
digital clock, use
a
ball
point

pen.

•
Push
left
button
below display window
briefly
to
advance one hour
at a
time
and

right
button
to
advance
one
minute
at a

time.

•
Hold buttons depressed
to
advance
hours or minutes rapidly.

•
For second accuracy, synchronize
with

the
aid of a
digital
wrist
watch
or a
time
signal
from
your radio. Set the clock one minute slow, then briefly push
right
button

the moment the seconds of the
wrist
watch have completed a
full
minute or the signal
in the radio sounds.
40 *where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

WARNING continned •
The
engine compartment
of any

motor vehicle
is a
potentially hazard­
ous
area.
Before you check anything in the engine compartment, stop
the

engine and
let it
cool down. Always
exercise extreme caution when work­
ing
one the
engine. Heed
all of the

WARNINGS on page
97.

Reduce the risk
of
scalding from
hot

coolant by following these steps.
• If the coolant reservoir cap must be
removed, wait until
the
engine
has

cooled down.
• Protect face, hands
and
arms
by

covering
the cap
with
a
large, thick
rag
to
protect against escaping fluid
and
steam.

• Carefully and slowly
turn
cap
one

turn
to
allow excess pressure
to es­
cape before completely removing

cap.

•
To
help avoid being burned,
do not

spill
antifreeze
or
coolant
on the ex­

haust system
or hot
engine parts.
Under
some conditions, the ethylene
glycol
in
engine coolant
is
combusti­
ble.
If a
visual check shows that coolant level
and V-belt
are
normal,
but the
warning light continues to
flash,
contact
your
near­
est dealer
to
have
the
cause located
and

corrected.
For more details see "Cooling system"
on

page 104.

If the
coolant gauge needle nears
the

upper end
of
the scale and the engine ap­
pears
to be
overheating,
turn
off the air

conditioner.
Do
not
install accessories
(fog
lights
or
in­
sect screens,
for
example)
on top of the

front
bumper.
They
may
restrict engine
cooling.
5
-
Fuel gauge
The needle
in
the fuel gauge will indicate the fuel level
in the
tank shortly after
the
ignition is switched on.
The fuel tank capacity is
16
gal/60
(syncro
18.5/70)
liters.
When
the
needle reaches the
red
area
at
the bottom there
is a
reserve
of
about 2.6 U.S. gal.
or
10 liters
of
fuel left in the tank.
Time to refuel.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS
AND
EQUIPMENT

WARNING
/ INDICATOR
LIGHTS

1 2 3 4 5 6 7 8
your vehicle is equipped
with
several
•nportant indicator and warning devices to
~ionitor the continued reliable operation of .our vehicle. Familiarize yourself
with

:hese
devices so if one should come on .ou know what to do.
-allure to heed applicable warnings and "nportant vehicle information may result in

serious
personal injury or vehicle damage.

WARNING
•
Whenever
stalled
or stopped for
epair,
move
the
vehicle
a
safe
distance
off the road, stop the
engine
and
turn

on the
emergency
flasher
(see
page

46).
• The
engine
compartment
of any

-lotor
vehicle
is a
potentially
hazard­
ous
area.
Before
you check
anything
in

?ie
engine
compartment,
stop the
engine
and let it cool down.
Always

exercise
extreme
caution
when
work­
ing
under
the
engine
hood.
Heed
all of
re
WARNINGS
on
page
97.
page

1 - Brake 43

2
- Safety belt 18

3
- Turn signals 44
4 - Alternator 44
5
- For additional light
6 - For additional light 7 - Oil pressure 43
8 - High beam 45
9 - Coolant temperature/level . . . 45
10 - For additional switch 9 10
B25-5t?

1-Brake
« ->

The
light comes on while the engine is
cranking.
It goes out after the engine is started and the parking brake is
fully
released.
This is your assurance
that
the
brake warning light is functioning properly.
If the brake warning light does not light JC
while cranking the engine or setting :ne parking brake, there may be a malfunction in the electrical system. In this
case
c;~-
tact your Volkswagen dealer.
'where applicable
Always
heed
WARNINGS
on next page


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
I CONTROLSAND EQUIPMENT
WARNING If the brake warning
light
does not go
out
with
the engine running and the parking brake released or lights up
while driving, the fluid level
in
the brake
fluid reservoir may
be
too low.
This might be
due
to
a
leak in one of the two independently functioning brake circuits.
If the brake pedal travel has increased,
one of the brake circuits may have

failed.
Avoid driving the vehicle and have it towed to the nearest Volkswa­
gen dealer or qualified workshop for re­ pair.
If brake pedal travel has not increased

and
braking performance remains un­
impaired,
proceed carefully to
your

nearest Volkswagen dealer or qualified
workshop to have the braking system inspected and corrected.

For detailed information see
"Brakes" on

page 29. 2-
Safety belt
|
A
FASTEN
BELTS

Refer
to
"Safety belts"
on
page
14 for

details.

3
-
Turn
signals E^

Refer
to
"Turn
signal/headlight dimmer
switch lever" on page 49 for details.
4
- Alternator

This
light comes
on
when
the
ignition
is
turned on and goes out after the engine
is
started.
If the
light does
not go out
after

starting
and
revving-up
the
engine
momentarily
or
lights
up
while driving,
there may be a malfunction
in
the electrical system
or
the V-belt
to
the alternator may be loose
or
broken.

In
this
case,
turn
the engine off and

contact
your
Volkswagen dealer.

5
- For additional
light

6
- For additional
light
7
- Engine Oil pressure

When
the
ignition
is
turned
on, the oil
pressure warning light comes on for a bulb

check.
It
should
go out
after
the
engine
has
started.

If the
warning light does
not go out or

flashes
while driving
(above
2000
engine rpm a buzzer
will
sound simultaneously),
it

indicates,
that the oil pressure is too low.

Stop the engine immediately, check the
engine
oil
level
and add
oil, if necessary.
If engine oil level is normal, but the
light

continues to flash, do not continue to
operate the vehicle. This could damage
the engine.

Turn
the engine off and contact the nearest Volkswagen dealer for assistance.

The oil pressure warning
light
is not an indicator for low engine oil level. To

check
the oil level, always use dipstick
(see page 99).

Make
it a habit to have the engine oil
level checked
with
every
fuel filling.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND EQUIPMENT

SWITCHES
3 4 5

page
1 - Lights

1
-
Lights
46

2
-
Instrument illumination
46

3
-
Emergency flasher
46

4
-
Rear window defogger
47
5
- For
additional switch Depress
the
rocker switch
to the
first stop
to turn
on the
parking, side marker, license
plate,
tail
and
instrument panel lights. Depress
the
switch
to the
second stop
to

turn
on the
headlights (ignition
on).

To conserve battery power,
the
headlights will
go out
automatically when
the
ignition is turned
off or
when
the
engine
is
started.

Headlight dimmer and
headlight flasher see
page
48. 2 - InstrumeriL illumination

Turn
the
thumb wheel below rocker switch
to adjust
the
brightness
of
instrument

lights.

3 - Emergency
flasher

The emergency flasher works indepen­ dently
of the
ignition switch position.
If your vehicle
is
disabled
or
parked under
emergency conditions, depress the switch
to make
all
four turn signals flash simul­
taneously.
The
warning light
in the
rocker
switch flashes,
too.

WARNING
Move the vehicle a safe distance off the
road when stalled or stopped for
repairs. Do not park or operate the
vehicle in areas where the hot exhaust system may come in contact with dry
grass, brush, fuel spill or other material
which can cause a fire.

46


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

-Rear
window Trm defogger* I I1*

__e
rear window defogger works only
with

re ignition on.

_-e
rear window defogger - together :i the flow through ventilation - will
••= o to keep the inside of the rear window
: ear of condensation and frost.

~~e
rear window defogger is not designed

Of
melting snow. Therefore, always re-
_:ve heavy snow and ice accumulations
refore driving off.

Zepress
the switch to
turn
on the rear * ndow defogger.
~ie control
light
in the switch will
light
• to remind you
that
the defogger is
switched on. After the rear window has

ceen
cleared, switch off the rear window :efogger to avoid unnecessary drain
:i the battery.
By saving electricity, you save fuel. See

aso
page 72.
Vhen
the rear window defogger is
i.vitched on, the outside mirrors
with

;!ectric remote control* are electrically
bated at the same time (see page 13).
Electrically
heated seat*
With ignition on, the backrest and seat
cushion
of the driver's seat can be heated
electrically.
The heating element can be regulated and turned on and off
with
the thumbwheel switch behind the steering wheel.
where applicable


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
EMULATION/HEATING

CONTROLS
AND EQUIPMENT
I
perating
Controls

_evers
A and C - Air
distribution

.ever A at
right
- windshield (1) and side
A'ndow
(2)
outlets
open,
•ver C at
left
-
footwell
outlets
under
:ashboard (4) and
footwell
outlets
in
:=ssenger compartment* open.

_ever
B -
Temperature
control

•
increase heat - slide lever to
right.
~3
decrease heat - slide lever to
left.
Lever
D -
Roof
outlets
in
passenger

compartment*

To increase outside air
flow
- slide lever to
left.

To decrease outside air
flow
- slide lever to
right.

Fan
control
switch
E
The air column can be regulated
with
three
fan speed settings. Air
outlets/vents

Heater or outside air
flow
from
outlets
1, 2, 3, 4 and
footwell
outlets
in passenger
compartment*, according to control lever positions.
Outside air
flow
from
roof
outlets
in
pas­

senger compartment*.
The side dashboard
outlets
3 are indi­ vidually adjustable -
side lever down -
vent
open side lever up
-vent
closed.

Adjust air
flow
direction sideways or up and down
with
center lever.

WARNINGS
see
next
page.

'where
applicable
51


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans

Downloaded from www.Manualslib.com manuals search engine
CONTROLS AND
EQUIPMENT

Malfunctions

if the
unit
does not
operate

• Outside temperatures may be below
41° For + 5°C.
• The air conditioner fuse may have blown. Turn the
unit
off and check fuse.

See
page 129 for use panel location.
General
hints

If
water
drips
under
the
vehicle

When outside temperature is high and the
air very humid, condensed water can drip
off the evaporator under the vehicle. This
is
normal and does not indicate a leak.

Payload
reduction

The weight of the air conditioner installed in your vehicle reduces the vehicle's load
carrying capacity. For weight information,

see
sticker on
left
doorjamb.

Maintenance
The condenser should be checked peri­
odically for cleanliness. If clogged
with

dirt
or insects, the condenser should be
washed down
with
water.
After the winter months and before ex­
tended summer
usage,
the air conditioner should be checked and, if necessary, ser­
viced by your Volkswagen dealer.


www.westfaliaT3.info - a useful website for owners and enthusiasts of VW Westfalia T25 / T3 Campervans