1981 CHEVROLET MONTE CARLO Owners Manual

Downloaded from www.Manualslib.com manuals search engine 2, Never leta child stand ,or kneel on any seat Children who can sit up by
themselves should
be placed on a sealand restrained with the seat belts
provided, When children ride in a rear seat, .they should be restrained with
a lap
belt, When child(en ride in the front seat, they should wear both lap
and shoulder belt If the .shoulder beH irritates the neck or face due to .the child's size, this may be r.educed by placing the child closer to the center
of the
vehicle , If irritalior Is not reduced, place the child in the rear seat
3, General Motors ~iseS that childr"", be restrained properly when riding ,
However. unusual cond~ions may prevent use of restraints. and require
that a small child
stand, If that ~s.lhe'Child should stand on the floor , behind the'driver's seat This will help reduce the chance and/or \he
severity of injury in case of a frontal collision, --'-'-'''"''''''''i''':>' ~7','" ,,.' ;.,,~"".'. _ .. .. ,
TRAILER TOWING
This car is designed and intended to be used mainly to carry people, Towing a
trailer will affect handling , durability and economy , Your safety and satisfaction
depend :,upoQ proper use of correct llqUipmenl. Also , you should avoiq
overloads
and other abusive use,
' The '
!1'lIiximum 1000000trailet: weight youe;mpull with your vehicle depends ,on what special equipffienrfi'as been installed on il,. We do not recommend towing
any
trailer more than 450 kilograms (1.000 pounds) gross trailer weight unless your vehicle has the required 'equipment
.. .... ~ ' °' -"""''1111'''.''-'' .. J~._ .. _ '."'-:,_, :" .,', .... ,,', , ,'" :', : ' . .. ....... :.' .... " ..... : .. , :"',' "'." ,: ",' ,i,.:." .... __ .. -:,:· .. ,,' .. _." . .'~:.,:;.,~')ff';:.' CAUTION: Do not .. try to tow .. • nv:,,. tr-I.-'r ,mqrtt:,_lt)arr ' 2 '2., Idfogranl( (5,000 Pounds) WPU trliler,we~t IlC) 'In.tter what trailer toWing -'equiprrient is instelled. Trai" over iMM maximum-~_iir:nlt.,-c:OuId teriously affect ~ __ vehk:"'. pertormence ; -_durability and
handling, ~_~kf l'esuh. in personal i~~;_-_, ;""_~ ':~.,,:.:.
Information ,on trailer towing ability, speciateq(Jipn1ent required, and optional
equipment available should.be obtained from your dealer . Ask for the trailering
~rocliure, Or, write: Consum~r Helations Department Chevrolet Motor Divfsion,
Warren , Michigan 48090. (In Canada, write to General Motors of Canada
limited , Customer Services Department, Oshilwa , Ontario L IJ 5Z6),
Tires
When towing trailers be sure your tires areprope,ly inflated'to 'the inflation
,
pressure shown 'on the .. Tire Placard on \he driver's door , The allowable
passenger . and cargo load for this vehicle, also.shown on the Tire Placard , is
reduced by the traiter tongue weight whenever . the trailer is attached to the
'v~hicle, See "Service arid Maintenance," Section 5, for more tire informatlon ,
Maintenance
More' frequent service is required when using your vehicle to pull a traileL See
Section A of the Maintenance Schedule folder for Automatic Transmission Fluid , Engine Oil, and Hear Axle Ltibricantchange requirements for. trailering ,
Now and \hen, check that all trailer hitch bolts and nuts are tight Also see the
Maintenance Schedule
foider, and the Index in this manual, for important facts
on belts, cooling system care and brake adjustment.
1-12

Downloaded from www.Manualslib.com manuals search engine Break·ln Schedule
See the new vehicle break-in instructions in this manual. Also, we
recommended you drive your new vehicle for 500 miles (600 kilometers) before
trailer towing . AI the end of this 500 mile (600 kilometer) break-in period, avoid
speeds over 50 mph (80 km/h) and full throttle starts during the first 500 miles (800 kilometers) of trailer towing.
CAUTIONS:
BRAKES-To help avoid personal injury due 10 poor braking action:
• Trailer brakes of adequate size are required on Irailers more Ihan 450 kilograms (1,000 pounds) loaded weight.
• If you use trailer brakes with this vehicle , follow the installation and balance
instructions of the trailer brake maker.
• Do not tap into the vehicle's brake system tl the trailer brake system uses
more than 0.3 cubic centimeter (0.02 cubic inch) of fluid from the vehitle's
master cylinder. In this case, the vehicle brake fluid capacity will not be enough to operate both the vehicle and trailer brakes under all kinds of
use.
• All brake fluid parts must be able to stand 20 650 kPa (3,000 psi) .. The
brake fluid tap must be made to the master cylinder port supplying fluid to
the rear brakes. Copper tubing is subject to fatigue failure and must not be
used.
• Before going down a steep or long grade, reduce speed. and shiftlhe transmission into a lower gear 10 help control too' long or too often . This
could cause
Ihe brakes 10 overheal and reduce brake ef\ectiveness. .
HITCHES2T6 HeIP'avoid pe,sona/ ,jQiYry.Que 10 sway caused by such things as
crosswinds , big trucks passing or roact roughness, or due to separalion of the
trailer :
• A properly installed and adjusted (1) frame mounted, weight-distributing
hitch and (2) sway control with enough capacity are required for trailers
more than 900 kilograms
(2,000 pounds) loaded weight.
• If your vehicle has air shocks, keep them at a minimum pressure of 70 to 105 kPa (10 to 15 psi) when installing, adjusting or towing with a weight­
distributing hitch.
• Keep the trailer tongue load at 10"10 of the loaded trailer \'feight for dead­
weight hitches, and 12"10 for weight-distribuling hitches. Tongue loads can be adjusted by proper distribution of the load in the trailer. This can be
checked by
weighjng separately the loaded trailer and then the tongue .
• Do not use axle-mounted hitches. They can damage the axle hOuSing, wheel bearings, wheels or lires.
•
When you remove a trailer hitch, be sure to seal any mounting holes in the
bocjy. This will help prevent entry of exhaust fumes, dirt or water. (See
"Engine Exhaust Gas Caution (Carbon Monoxide)" at the beginning of "Starting and Operating," Section 2 of this manual.)
1-13

Downloaded from www.Manualslib.com manuals search engine NOT1C~: Uoeonty ~ ...... hhches ....... pomiIt ' nonnoI ..,o,otlon' ..... Energy Ab8Orb4ng Bumper system, if to equipped~-For ex..".,.., • rigid fore 8nd 1ft conMction between the bumper and any other pwt Of-the c. mIIy Inc,. ... dMnege Nl the event gf I colli.lon.
TRAILER TOWING TIPS
, Getti"9
Started
Before entering traffic w~h a traile, that has electric brakes, start the vehicle
and trailer moving and apply the traile' brakes by hand to be sure the trailer brakes ' are working and the trailer eleCtrical syStem is connected ,
".d~,~!!.~!.~~,CooUng If your engine overheats "foliowthe steps under, "Engine Cooling System" in
"InCase of Emergency," Section 3 01 this manual.
Long Uphill Grades
When goingup,long grades ; you can reduce the chance of engine overheating
by dOwnshifting the transinission to a
Jower'gear range and reducing speeds to
'" '4S mph (70 km /h) or below . '. " " ,-,-."." .. ,. '
Transmission
See the method for checking the transmission fluid level in "Service and
"'~!!illl£<;': Section S of thismanuaJ.
Parking
You should not park vehicles with trailers on a grade (hill); However, If
you must park on a 'grade, these ste,PS }l1ust be fallowed:
1. Apply theregular .brakes . ,'\' y .
2, . Have someone place wheel chocks under the trailer wheels .
3. When the wheel cho cks are in place, release the regular brakes until, the
c hocks absorb the load. .
4 . Apply
the parking brake.
S . Shift the transmission to
"P"(l'ark) .
If the veh icle is parked on a .gr ad e, don 't Shift the transmission to "P "(Park )
until
the trailer wheels are chocked and tOO parking brake is set If you dO, the weight of the vehicle and trailer may put'somuch force on the parking pawl in
the transmission that it·may be hard to Shift out of "P "(Park) .
When' s tarting, after being parked On a grade :
L Apply the regular brakes and hold.
2. Start ,the engine in , "P"( Park) .
.
3 . '. Shift into gear and releas .e the parking brake ..
4. Release the regular brakes and drive until the chocks are free .
S .
Apply the regular brakes and haveanoti1er person remOve the chocks.
1-14

Downloaded from www.Manualslib.com manuals search engine SECTION 2
STARTING AND OPERATING
ENGINE EXHAUST GAS CAUTION
(CARBON MONOXIDE)
Do not breathe exhaust gas because it contains carbon monoxide, which by
itself has no color or odor. Carbon monoxide is a dangerous gas. It can cause
unconsciousness and can be lethal.
If
at any time you think exhaust fumes are entering the vehicle, have the cause
determined and corrected
assdon.as possible. If you must drive under. lhese conditions , drive only wilh All windows fully OPEN .
To allow proper operation of your vehicle's ventilation system, keep the.air inlet grille in front of the windShield clear of snow, leaves or other obstructions at all
times.
Protect against carbon monoxide entry into the vehicle body . The best way is to keep the engine exhaust system, vehicle body and body ventilation system
properly maintained. We recommend that the exhaust system and body be inspected by a competent lechniclan :
•
each time the vehicle is raised for an oil change;
• whenever a change is noticed in the sound of the exhaust system;
• whenever the exhaust system, underbody or rear of the vehicle is damaged or. becomes corroded .
See your Miiintenance Schedule folder for parts recuiring inspection.
To allow proper operation of your vehicle's ventilation system, keep the air inlet
grille
in front of the windshi~1d clear of snow, leaves or other obstructions at all
times.
Do not perk or idle this vehicle for more than 10 minutes with the ventilation
system control switch in the "off" position while the engine is running . Even
with
the ventilation system on, running the engine while parked is not recommended . Entry of carbon monoxide into the vehicle body is possible with
a
poorly repaired , damaged, or corroded exhaust system or body.
Do
not run the. engine in CONFINED areas (such as garages or next to a
building) any more than needed to move the vehicle . When Ih.e vehicle has to be stopped in an UNCONFINED area with the engine running for any more
than a few minutes, take the following stepa :
A. Adjust the heating
or cooling ' system to force outside air into the vehicle as
follows:
1. On vehicles not ecuipped wijh air condijioning, set the fan to medium or high speed and the upper control lever to any position except
"Off."
2. On vehicles ecuipped with air conditioning , set the fan to medium or
high speed and the upper control lever to any position except "Off" or
"Max., "
B . Keep the exhaust tailpipe area clear 01 snow and other material to help
reduce the
buildup 01 exhaust gases under the vehicle.

Downloaded from www.Manualslib.com manuals search engine The trunk lid should be closed while driving to help prevent drawing exhaust gas into the vehicle. If the trunk must remain open for some reason while
moving . or ff electricai wiring or other cable conneclionS to a trailer must pass through the sealbelweeri the trunk lid and the body, follow these precautionS :
• Close all windows.
• Adjust the heating or cooling system to force outside air into the vehicle as
described above. but set the fan to high speed .
• On vehicles with outside ' air vents in or under the instrument panel ; open
the vents
fully.
NEW VEHICLE "BREAK-IN" PERIOD
You can drive your new vehicle from its very first mile/kilometer without
following a formal "break-in" schedule. However. there are things you can do during the first few hundred miles/kilometers of driving . that will add to the
future performance and economy of your
vehicle. We recommend you limit
your speed during the first 500 miles (800 kilometers) to a maximum of 55 mph (90 km /h) ; but do not drive for long periods at anyone constant speed. either
fast or
slow. During this time. avoid full throttle starts and. if possible. avoid
hard stops especially during the first 200 miles (320 kilometers) of driving .
Always drive at moderate speed until the engine has COfl'4lletely warmed up.
If you plan to use your new vehicle for trailer towing . see additional information
under " Trailer Towing" in Section 1 of this manual.
GUARD AGAINST THEFT
y~~; '~ew Monte carlo has many features to help prevent theft of the vehicle
itself.
its equipment. and its contents. But these anti-theft features depend
upon you to work.
THE
TIME TO BE MOST ON GUARD ISWHEN LEAVING THE VEHICLE ...
• PARK IN A LIGHTED SPOT WHEN YOU CAN AND FULLY ClOSE BOTH WINDOWS AND ANY ROOF PANaS
• LOCK THE STEERING COLUMN AND TAKE THE KEYS:
•
Turn the key to "Lock " and remove the key. This locks the ignition
and both steering and shift controls.
• If you must leave a kilY with the vehicle . leave the square-head key only. Take the oval· head key with you. This will help prevent unwanted
entry into your
vehicle at a later date . or into your glove box (if locked) or trun k
• LOCK ALL DOORS .
•
KEEP ITEMS OUT OF SIGHT AND LOCKED UP WHEN POSSIBLE.
• Never leave things of va lue in plain sight on seats or floor.
• The glove box otTers a place to hide small item s and if locked, protects even better.
• Lock larger item s in the trunk.

Downloaded from www.Manualslib.com manuals search engine FUEL REQUIREMENTS
Your engine is designed to use only unleaded gasoline . Unleaded gasoline must be uSed for the emission control system to operate properly . Its use will
also reduce spark
plug fouling, exhaust .system corrosion and engine oil deterioration.
Using
leaded gaso~ne can damage the emission control system and could
result
in loss of warranty coverage. The effectiveness of the catalyst in the
catalytic converter decreases after use of as little as one tank of leaded
gasoline.
Also, your vehicle may have the "Computer Command Control" system, which includes an oxygen sensor. Leaded gasoline will damage the
sensor,
and attect emissioncont(ols. (For more information, see "Computer
Command Control
System" in "Service and Maintenance,"Section 5 of this manual. Federal regulations require that pumps delivering unleaded-gasoline
be labeled with the word UNLEADED. Only these pumps have nozzles whichftl the filler neck of your vehicle's gasoline tank.
In the United States, Federal law also requires that gasoline octane ratings be
posted on the pumps. The octane rating shown is an average of Research
octane (R) and Moto< octane (M). In most parts of the United States , you
should use unleaded gasoline with an octane rating of at least 87. However,
you may use unleaded gasoline with an Q!;tane rating as low as 85 in these
. high -altitude areas: Coloraclo , Montana, New Mexico , Utah , Wyoming,
northeastern Nevada, southern Idaho, western South Dakota, and that part of
Texas which is directly south of New Mexico .
Using unleaded gasoline with
an octane rating lower than stated above can
cause persistent, heavy
"spark knock." (" Spark knock" is a metallic rapping
noise.) " severe, this can
lead to engine darnage. " you detect heavy spark knock even ",hery using gasoline of the stated octane rating, 0<. if you hear steady spark knoo~ 'wfiil.)' Holding a' steady speed on level roads, have your
dealer correct the
problem . Failure to take steps to stop such knocking is
misuse
of the vehicle, for which Chevrolet is not responsible . However, now and then you may notice light spark knock for a short time while accelerating
or driving
up hills : This is no cause fo< concern, because you get the greatest
fuel economy
benem from the gasoline's octane rating when there is
occasional light spark knock. Using .gasoline with a higher .octane rating than
that which
allows occasional spark knock is an unnecessary expense.
Gasohol
Gasohol, a mixture of unleaded gasoline and ethanol (grain alcohol), is
available in some areas , You may use gasohol in yourvehicle ,provided it is no
more than 10% ethanoL Be sure the gasohol has octane ratings no lower than
those stated above for unleaded
gasoline . Some vehicles using gasohol could run leaner . Most drivers will not notice a difference, but some may. In such
cases your authorized dealer can make c.ertain adjustments, provided they are
not in violation of the Federal
Clean Air Act. " you. are still not satisfied with gaSOhol performance , you may prefer to uSe unleaded gasoline. •
NOTICE: ,Take care to not spiH gasohol on painted surfaces. Gasohol can cause paint damage, which may not be covered und~r the new vehicle warranty.
2·3

Downloaded from www.Manualslib.com manuals search engine OPERATION IN FOREIGN COUNTRIES
All models which have the Computer Command Control system, (see "Service
and Maintenance," Section 5), are designed
to use unleaded gasoline as
specified under
"Fuel Requirements" in this section of the manual. Therefore,
these cars are not intended for use in areas where unleaded gasoline is
not readily available,
There also is a chance the gasolines available in some countries will not meet the needs of your gasoline engine even if it is not equipped with the Computer
Command Control system; Low~octane-ratedgasolines may cause engine pre­
ignition and serious engine damage, for which Chevrolet is not responsible.
In either case (with or without the Computer Command Control system), the
use of leaded gasoline will cause the emission control system to lose its
effectiveness.
It could also affect coverage· under the emission warranty. In
case of emergency, leaded gasoline may be used in your vehicle if unleaded gasoline is not available, but it should not be used exclusively. If you must use
leaded gasoline exclusively
in a vehicle designed for unleaded gasoline,
different maintenance intervals will be required. For additional information and
a copy of the maintenance schedule write to: Chevrolet Motor Division, Consumer Relations Department, Warren, Michigan 48090, (in Canada, write
to General Motors of Canada Limited, Customer Service Department, Oshawa,
Ontario
L 1J 5Z6).
When writing, please
include:
•
the Vehicle Identification Number and
• the countries in which you plan to travel.
Tires
If you plan to use your vehicle in countries where speeds over 75 mph (120
km/h) are allowed, see lIem3 on page 5-12.
IMPORTANT FACTS YOU SHOULD KNOW ABOUT FUEL
ECONOMY AND HOW
TO IMPROVE IT
How you drive, where you drive and when you drive all affect how many miles/
kilometers you can get from a galion/liter of fuel. The careful attention you give
your vehicle as far as maintenance and repairs are concerned
will also help
fuel economy.
Fuel Selection
Use only unleaded gasoline meeting the octane ratings given under "Fuel Requirements" in "Starting and Operating," Section 2 of this manual.
Unleaded gasoline must be used. for the. emission control ,system to operate
properly. Leaded gasoline will damage the Computer Command Control system
oxygen sensor and affect emission control. Using leaded gasoline can also
damage other parts of the emission control system and
CQuld result in 19s8 of
emission warranty coverage.
"Jackrabbit" Starts
You can save fuel (and prolong engine and tire life) by avoiding fast starts
away from lights and stop signs.
2-4

Downloaded from www.Manualslib.com manuals search engine Steady Cruising Speeds
Once you reach cruising sPeed, keep as steady a speed as road and traffic will allow . Speeding up and slowing down lessens your vehicle's efficiency and uses more fuel.
Stop-And-Start Driving
Frequent stops and starts while driving cut down on your miles per gallon
(kilometers per liter) . Plan even your short shopping trips to take advantage of
through streets to avoid traffic lights. Pace your driving
like the expert drivers
to avoid unneeded stops and braking .
Sudden Stops
Sudden stops can also waste fuel; instead of moving the vehicle, the energy of fuel is wasted as heat in braking. Energy in the fOrm of fuel is also needed to
accelerate
baCk to driving speed.
Excessive Idling
An idling engine uses fuel, too .. If you're faced with more than a minute wait,
and you're not in traffic , it may be better to turn off the engine and start again
later.
Lubricants
A well-lubricated vehicle means less friction between moving parts. See the Maintenance Schedule folder for the proper lubrication intervals.
Air Cleaner
Your vehicle receives its power from a mixture of fuel and air. The air enters
the engine through the air cleaner. A dirty air cleaner element lessens engine
perfOrrnance and can waste/Uel. ,So, it's important to replace the air cleaner
element (filter) at the intervals in Section C of the Maintenance Schedule folder .
Wind Drag
Open windows at high speeds cause "wind drag" which can lessen fuel
economy. Also, fuel economy is less when driving in crosswinds or headwinds .
To
help offset some of this loss, slow down when driving in these conditions.
Air Conditioner
" your vehicle has an optional air conditioner , use the "Economy, " ("Vent" or
"Heater") positions whenever possible. The air conditioner compressor, is not on in these positions and the reduced ,'engine-load can improve fuel economy.
Engine Maintenance
An engine that i. properly maintained ."iill provide better fuel economy than one
that is no\.
One misfiring spark plug will cut .fuel economy quite a bit, and will make a difference in the amount of pollution emitted from yOur vehicle.
Exces~ Weight
Fuel economy is related to the work. the engine must do. The heavier the load,
the more fuel it takes to run your vehicle. Keep weight to a minimum by taking
out any luggage or cargo when it is not needed.
2-5
._ - ---_._---'----