2023 TOYOTA RAIZE suspension

421-1. For safe use
RAIZE_OM_General_BZ358E
WARNING
⬛Modification and disposal of SRS airbag system components
Do not dispose of your vehicle or pe rform any of the following modifications
without consulting your Toyota dealer.
The SRS airbags may malfunction or deploy (inflate) accidentally, causing death
or serious injury.
⚫Installation, removal, disassembly and repair of the SRS airbags
⚫Vehicles without SRS side and curtain shield airbags: Repairs, modifications,
removal or replacement of the steerin g wheel, instrument panel, dashboard
⚫Vehicles with SRS side and curtain sh ield airbags: Repairs, modifications,
removal or replacement of the steering wheel, instrument panel, dashboard,
seats or seat upholstery, front, side and rear pillars or roof side rails
⚫Repairs or modifications of the front fender, front bumper or side of the
occupant compartment
⚫Installation of a grille guard (bull bars, kangaroo bar, etc.), snow plows or
winches
⚫Modifications to the vehi cle’s suspension system
⚫Installation of electronic devices such as mobile two-way radios (RF trans-
mitter) and CD players
⚫Modification to your vehicle for a person with a physical disability
⬛If the SRS airbags deploy (inflate)
⚫A loud noise and white gas will be emitted.
⚫Vehicles without SRS curtain shield airbag : In addition to the front seat, parts
of the airbag module (steering whee l hub, airbag cover and inflator) may
become hot for several minutes. Th e airbag itself may also be hot.
⚫Vehicles with SRS side and curtain shie ld airbags: Parts of the airbag module
(steering wheel hub, airbag cover and infl ator), as well as parts of the front
seat, front pillar, center pillar, rear pillar, and roof side rails, may also become
hot for several minutes. The airbag itself may also be hot.
⚫The windshield may be damaged.
RAIZE_OM_General_BZ358E.book 42 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2374-5. Using the driving support systems
RAIZE_OM_General_BZ358E
WARNING
Driving
4
⬛When the TRC/VSC systems are turned off
Be especially careful and drive at a speed appropriate to the road conditions.
As these are the systems to help ensure vehicle stability and driving force, do
not turn the TRC/VSC systems off unless necessary.
⬛Replacing tires
Make sure that all tires are of the spec ified size, brand, tread pattern and total
load capacity. In addition, make sure th at the tires are inflated to the recom-
mended tire inflation pressure level.
The ABS, TRC and VSC systems will not func tion correctly if different tires are
installed on the vehicle.
Contact your Toyota dealer for further information when replacing tires or
wheels.
⬛Handling of tires and the suspension
Using tires with any kind of problem or modifying the suspension will affect the
driving assist systems, and may cause a system to malfunction.
RAIZE_OM_General_BZ358E.book 237 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2886-1. Maintenance and care
RAIZE_OM_General_BZ358E
NOTICE
✽: If equipped
⬛When using a high pressure car wash
⚫Do not splash water directly to the cameras✽ or their surrounding area using
a high-pressure washer during a car wash. The high water pressure adds
stress and may prevent the equipment from working properly.
⚫Do not bring the nozzle tip close to the coupling parts, boots (rubber or resin
covers) and connectors of the following parts.
The parts may be damaged if they come into contact with high pressure
water.
⦁ Drive system parts
⦁ Steering parts
⦁ Suspension parts
⦁ Brake parts
⚫Resin parts, such as moldings and bumpers, may be deformed and dam-
aged, so keep the cleaning nozzle at le ast 30 cm (11.9 in.) away from the
vehicle body. Also, do not continuous ly spray water in the same place.
⚫Do not spray the lower part of the windshield continuously. If water enters
the air conditioning system intake loca ted there, the air conditioning system
may not operate correctly.
RAIZE_OM_General_BZ358E.book 288 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2936-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Do-it-yourself maintenance
⚫What about do-it-yourself maintenance?
Many of the maintenance items are easy to do yourself if you have a little mechanical
ability and a few basic automotive tools. Simple instructions for how to perform them
are presented in this section.
Note, however, that some maintenance task s require special tools and skills. These
are best performed by qualified technician s. Even if you are an experienced do-it-
yourself mechanic, we recommend that repairs and maintenance be conducted by
your Toyota dealer who will keep a record of maintenance on your vehicle. This
record could be helpful should you ever require Warranty Service.
⬛Does your vehicle need repairs?
Be on the alert for changes in performance and sounds, and visual tip-offs that
indicate service is needed. Some important clues are:
⚫Engine misses, stumbling or pinging
⚫Appreciable loss of power
⚫Strange engine noises
⚫A fluid leak under the vehicle (However , water dripping from the air condi-
tioning system after use is normal.)
⚫Change in exhaust sound (This may indica te a dangerous carbon monoxide leak.
Drive with the windows open and have th e exhaust system checked immediately.)
⚫Flat-looking tires, excessive tire squeal when cornering, uneven tire wear
⚫Vehicle pulls to one side when driven straight on a level road
⚫Strange noises related to suspension movement
⚫Loss of brake effectiveness, spongy feeling brake pedal or clutch pedal (vehi-
cles with a manual transmission), pe dal almost touches the floor, vehicle
pulls to one side when braking
⚫Engine coolant temperature continually higher than normal
If you notice any of these clues, take yo ur vehicle to your Toyota dealer as soon
as possible. Your vehicle may need adjustment or repair.
WARNING
⬛If your vehicle is not properly maintained
Improper maintenance could result in serious damage to the vehicle and pos-
sible death or serious injury.
⬛Handling of the battery
Battery posts, terminals and related accessories contain lead and lead com-
pounds which are known to cause brain damage. Wash your hands after han-
dling. ( ➞P. 321)
RAIZE_OM_General_BZ358E.book 293 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2976-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
*1Replace both the engine oil and oil filter, even when the maintenance
reminder does not appear, after 6 mont hs have passed, since the last oil
change.
*2After 80000 km (48000 miles) or 48 months inspection, inspect every 20000
km (12000 miles) or 12 months.
*3Including the filter in fuel tank.
25Drive shaft bootsIIIIIIII6
26Front wheel align-
ment (toe-in)II48
27Suspension ball joint
and dust coverIIII12
28
Manual transmis-
sion oil (including
front differential)
IRI: 48
R: 96
29
Continuously varia-
ble transmission
fluid (including front
differential)
Inspect every 12 months, Replace every
100000 km (60000 miles)―
30Front and rear sus-
pensionIIII12
31Tires and inflation
pressureIIIIIIII6
32Lights, horns, wipers
and washersIIIIIIII6
33Air conditioning filterRRRR24
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
RAIZE_OM_General_BZ358E.book 297 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2986-2. Maintenance
RAIZE_OM_General_BZ358E
Additional maintenance schedule (except for Mexico)
Refer to the following table for normal maintenance schedule items
requiring more frequent service specific to the type of severe conditions.
(For outline, see “Maintenan ce schedule requirements”.)
A-1: Operating on rough or muddy roads, or roads with melted snow
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 of brake pipes and hosesEvery 10000 km (6000 miles) or 6
months
Inspection*1 of steering wheel, linkage
and steering gear boxEvery 5000 km (3000 miles) or 3
months
Inspection*1 of suspension ball joint and
dust coverEvery 10000 km (6000 miles) or 6
months
Inspection*1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection*1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body*
2
Every 10000 km (6000 miles) or 6
months
A-2: Operating on dusty ro ads (Roads in areas where their pavement rate is
low, or a cloud of dust ofte n arises and the air is dry.)
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 or replacement of air cleaner
filter
I: Every 2500 km (1500 miles) or 3 months
R: Every 20000 km (12000 miles) or 48 months
RAIZE_OM_General_BZ358E.book 298 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2996-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Replacement of air conditioning filter Every 20000 km (12000 miles) or 24
months
B-1: Heavily loaded vehicle (Example: Using a car top carrier, etc.)
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Replacement of manual transmission oil
(including front differential)Every 40000 km (24000 miles) or 48
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection*1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body*
2
Every 10000 km (6000 miles) or 6
months
B-2: Repeated short trips less than 8 km (5 miles) and outside temperatures remain below freezing (Engine temperature will not reach to normal temperature)
Replacement of engine oil (WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
RAIZE_OM_General_BZ358E.book 299 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3006-2. Maintenance
RAIZE_OM_General_BZ358E
*1Perform correction or replacement as necessary.
*2For seat mounting bolts, front and rear suspension member retaining bolts.
*3Replace both engine oil and oil filter every 3 months, in which the vehicle is
mainly driven in dirt or dusty roads, when the maintenance reminder does not
appear.
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
B-3: Extensive idling and/or low speed driving for a long distance such as police, taxi or door-to-door delivery use
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
B-4: Continuous high speed driving (80% or more of maximum vehicle speed) for over 2 hours
Replacement of manual transmission oil
(including front differential)Every 40000 km (24000 miles) or 48
months
Inspection*1 or replacement of continu-
ously variable transmission fluid
(including front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
RAIZE_OM_General_BZ358E.book 300 ページ ２０２２年５月１７日　火曜日　午後１時５９分