2022 TOYOTA PRIUS PLUG-IN HYBRID check engine

6347-3. Do-it-yourself maintenance
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
Checking and replacing fuses
Turn the power switch off.
Confirm that the charging connector is not connected. Also, do not use the
Remote Air Conditioning System during the procedure.
Open the fuse box cover.
Engine compartment type A fuse box
While pushing the 2 claws, lift
up the cover.
When closing the cover, make
sure to attach the 2 claws.
Engine compartment type B fuse box
While pushing the 3 claws, lift
up the cover.
When closing the cover, make
sure to attach the 3 claws.
If any of the electrical components do not operate, a fuse may
have blown. If this happens, check and replace the fuses as nec -
essary.
1
2

6688-2. Steps to take in an emergency
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
O If a message or image about an open/close state of a part or replenishment
of a consumable is shown
Confirm the part indicated by the multi-information display or a warning light,
and then perform the coping method such as closing the open doo r or
replenishing a consumable.
Q If “See Owner’s Manual” is shown
O If “Braking Power Low Stop in a Safe Place See Owner’s Manual” is shown,
this may be a malfunction. Immediately stop the vehicle in a sa fe place and
contact any authorized Toyota retailer or Toyota authorized rep airer, or any
reliable repairer. Continuing to drive the vehicle may be dange rous.
O If “Engine Oil Pressure Low” is shown, this may be a malfunction. Immedi-
ately stop the vehicle in a safe place and contact any authoriz ed Toyota
retailer or Toyota authorized repairer, or any reliable repaire r.
O If the following messages are shown, there may be a malfunction. Immedi-
ately have the vehicle inspected by any authorized Toyota retai ler or Toyota
authorized repairer, or any reliable repairer.
• “Plug-in charging system malfunction.”
• “Hybrid System Malfunction”
• “Check Engine”
• “Hybrid Battery System Malfunction”
• “Accelerator System Malfunction”
• “Smart Entry & Start System Malfunction See Owner’s Manual”
O If “Exhaust Filter Full See Owner’s Manual” is shown on the multi-informa-
tion display is shown, follow the instruction. ( P. 5 0 8 )
Q If “Shift System Not Active Apply Parking Brake Securely While Parking
See Owner’s Manual” is shown
Indicates a temporary operation failure or malfunction in the s hift control sys-
tem. Immediately have the vehicle inspected by any authorized T oyota
retailer or Toyota authorized repairer, or any reliable repaire r.
When the message is shown, the hybrid system may not be started or the
shift position may not be changed normally. (Coping method: P. 672)
Q If “Shift System Malfunction Apply Parking Brake Securely While Park-
ing See Owner’s Manual” is shown
Indicates a malfunction in the shift control system. Immediatel y have the vehi-
cle inspected by any authorized Toyota retailer or Toyota autho rized repairer,
or any reliable repairer.
When the message is shown, the hybrid system may not be started or the
shift position may not be changed normally. (Coping method: P. 672)

6718-2. Steps to take in an emergency
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
8
When trouble arises
QIf “Auto Power OFF to Conserve Battery” is shown
The power switch has been turned off by the automatic power off function.
When starting the hybrid system next time, operate the hybrid s ystem for
approximately 5 minutes to recharge the 12-volt battery.
Q If “Engine Oil Level Low Add or Replace” is displayed
The engine oil level may be low. Check the level of the engine oil, and add
engine oil if necessary. This message may be displayed if the v ehicle is
stopped on a slope. Move the vehicle to a level surface and che ck if the mes-
sage disappears.
Q If “Accelerator and Brake Pedals Pressed Simultaneously” is shown
The accelerator and brake pedals are being depressed simultaneo usly.
( P. 310)
Release the accelerator pedal and depress the brake pedal.
Q If a message that indicates the malfunction of front camera is displayed
The following systems may be suspended until the problem shown in the
message is resolved. ( P. 366, 657)
O PCS (Pre-Collision System)
O LTA (Lane Tracing Assist)
O AHS (Adaptive High-beam System)
O RSA (Road Sign Assist)
O Dynamic radar cruise control with full-speed range
Q If a message that indicates the malfunction of radar sensor is displayed
The following systems may be suspended until the problem shown in the
message is resolved. ( P. 366, 657)
O PCS (Pre-Collision System)
O LTA (Lane Tracing Assist)
O Dynamic radar cruise control with full-speed range
Q If “Radar Cruise Control Unavailable See Owner’s Manual” is shown
The dynamic radar cruise control with full-speed range system i s suspended
temporarily or until the problem shown in the message is resolv ed. (causes
and coping methods: P. 366)
Q If “Radar Cruise Control Unavailable” is shown
The dynamic radar cruise control with full-speed range system c annot be
used temporarily. Use the system when it becomes available agai n.

6998-2. Steps to take in an emergency
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
8
When trouble arises
Once the hybrid system has started, remove the jumper cables in
the exact reverse order from which they were connected.
To install the engine cover, conduct the removal procedure in
reverse. After installing, check that the fixed pins are insert ed
securely.
Once the hybrid system starts, have the vehicle inspected at an y
authorized Toyota retailer or Toyota authorized repairer, or an y reliable
repairer as soon as possible.
Q When opening the cover of the positive (+) battery terminal
 P. 595
Q Starting the hybrid system when the 12-volt battery is discharged
The hybrid system cannot be started by push-starting.
Q To prevent 12-volt battery discharge
O Turn off the headlights and the audio system while the hybrid system is off.
O Turn off any unnecessary electrical components when the vehicle is running
at a low speed for an extended period, such as in heavy traffic .
Q When the 12-volt battery is removed or discharged
O Information stored in the ECU is cleared. When the 12-volt battery is
depleted, have the vehicle inspected at any authorized Toyota r etailer or
Toyota authorized repairer, or any reliable repairer.
O Some systems may require initialization. (P. 734)
Q When removing the 12-volt battery terminals
When the 12-volt battery terminals are removed, the information stored in the
ECU is cleared. Before removing the 12-volt battery terminals, contact any
authorized Toyota retailer or Toyota authorized repairer, or an y reliable
repairer.
Q Charging the 12-volt battery
The electricity stored in the 12- volt battery will discharge gradually even when
the vehicle is not in use, due to natural discharge and the dra ining effects of
certain electrical appliances. If the vehicle is left for a lon g time, the 12-volt
battery may discharge, and the hybrid system may be unable to s tart. (The
12-volt battery recharges automat ically while the hybrid system is operating.)
8
9

7068-2. Steps to take in an emergency
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
After stopping the hybrid system and waiting for 5 minutes or
more, start the hybrid system again and check if “Hybrid System
Overheated” is shown on the multi-information display.
If the message does not disappear:
Stop the hybrid system and contact any authorized Toyota
retailer or Toyota authorized repairer, or any reliable repaire r.
If the message is not displayed:
The hybrid system temperature has dropped and the vehicle may
be driven normally.
However, if the message appears again frequently, contact any a utho-
rized Toyota retailer or Toyota authorized repairer, or any rel iable
repairer.
WARNING
Q To prevent an accident or injury when inspecting under the hood of
your vehicle
Observe the following precautions.
Failure to do so may result in serious injury such as burns.
O If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot.
O After the hybrid system has been turned off, check that the “Accessory”,
“Ignition ON” or mileage display ( P. 213) on the main display and the
“READY” indicator are off.
When the hybrid system is operating, the gasoline engine may au tomati-
cally start, or the cooling fans may suddenly operate even if t he gasoline
engine stops. Do not touch or approach rotating parts such as t he fan,
which may lead to fingers or clothing (especially a tie, a scar f or a muffler)
getting caught, resulting in serious injury.
O Do not loosen the coolant reservoir caps while the hybrid system and radi-
ator are hot.
High temperature steam or coolant could spray out.
6

7159-1. Specifications
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
9
Vehicle specifications
Generation/traction motor
Traction motor
QOil capacity (Drain and refill [Reference*])
*: The engine oil capacity is a reference quantity to be used when changing
the engine oil. Park the vehicle on level ground. After warming up the
engine and turning off the hybrid system, wait more than 5 minutes, and
check the oil level on the dipstick.
Electric motor (generation motor/traction motor)
Ty p ePermanent magnet synchronous motor
Maximum output22.5 kW
Maximum torque40 N•m (4.1 kgf•m, 29.5 ft•lbf)
Ty p ePermanent magnet synchronous motor
Maximum output53 kW
Maximum torque163 N•m (16.6 kgf•m, 120.2 ft•lbf)
Hybrid battery (traction battery)
Ty p eLithium-ion battery
Voltage3.7 V/cell
Capacity25 Ah
Quantity95 cells
Nominal voltage351.5 V
Lubrication system
With filter4.2 L (4.4 qt., 3.7 Imp.qt.)
Without filter3.9 L (4.1 qt., 3.4 Imp.qt.)

743Alphabetical index
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
Child-protectors ....................... 276
Cleaning............................ 566, 572
Aluminum wheels .................. 567
Exterior.................................. 566
Front camera......................... 358
Hybrid battery (traction
battery) air intake vent ........ 573
Interior ................................... 572
Radar sensor ........................ 357
Seat belts .............................. 575
Water-repellent coating ......... 567
Clock ......................................... 194
Adjustment ............................ 200
Coat hooks ............................... 563
Combination meter .................. 194
Clock adjustment .................. 200
Main display .......................... 212
Multi-information display ....... 220
Warning lights and
indicators ............................ 204
Condenser ................................ 593
Console box ............................. 545
Consumption screen ............... 264
Coolant ..................................... 591
Capacity ................................ 718
Checking ............................... 591
Preparing and checking
before winter....................... 516
Cooling system ........................ 591
Engine overheating ............... 703
Hybrid system overheating ... 705
Cruise control
Dynamic radar cruise control
with full-speed range .......... 401
Cup holders .............................. 546
Curtain shield airbags ............... 39
Customizable features ............ 724Daytime running light
system .................................... 338
Deck board ............................... 550
Defogger
Outside rear view mirrors...... 527
Rear window ......................... 527
Windshield ............................ 527
Dimension ................................ 712
Display
Drive information................... 222
Dynamic radar cruise control
with full-speed range .......... 401
Energy monitor ............. 223, 261
Head-up display .................... 254
LTA (Lane Tracing Assist) .... 388
Main display .......................... 212
Multi-information display ....... 220
Parking Support Brake
function ............................... 468
Pre-collision warning............. 369
RCTA detection screen......... 423
RSA (Road Sign Assist)........ 396
S-IPA (Simple Intelligent
Parking Assist System) ...... 477
Toyota parking assist
sensor................................. 451
Warning messages ............... 665
Do-it-yourself maintenance .... 581
Door courtesy lights................ 541
Location ................................ 541
Wattage ................................ 721D

745Alphabetical index
Prius Plug-in Hybrid_OM_OM47E75E_(EE)
Emergency brake signal ......... 510
Emergency flashers................. 646
Emergency brake signal ....... 510
Emergency tire puncture
repair kit ................................. 673
Energy monitor ................ 223, 261
Engine
Accessory mode ................... 325
Compartment ........................ 587
Engine switch ........................ 323
Exhaust gas precautions......... 50
Hood ..................................... 584
How to start the hybrid
system ................................ 323
Identification number............. 714
If the hybrid system will not
start..................................... 691
If your vehicle has to be
stopped in an emergency ... 647
Ignition switch (power
switch) ................................ 323
Overheating .......................... 703
Power switch ......................... 323
Engine coolant ......................... 591
Capacity ................................ 718
Checking ............................... 591
Preparing and checking
before winter....................... 516Engine oil ................................. 588
Capacity ................................ 715
Checking ............................... 588
Oil pressure warning light ..... 658
Preparing and checking
before winter....................... 516
Engine switch (power
switch) .................................... 323
Auto power off function ......... 325
Changing the power switch
modes................................. 325
If your vehicle has to be
stopped in an emergency ... 647
Starting the hybrid system .... 323
EPS (Electric Power
Steering)................................. 510
Function ................................ 510
Warning light ......................... 658
EV City mode switch ................. 88
EV driving range ...................... 109
EV mode ..................................... 85
EV/HV mode selection
switch ....................................... 88
Exhaust gas precautions .......... 50
Extended Headlight
Lighting system..................... 338