2022 TOYOTA GR86 brake fluid

299
6
6-3. Do-it-yourself maintenance
Maintenance and care
“UPPER LEVEL” line
“LOWER LEVEL” line
If the fluid level is at or below the
“LOWER LEVEL” line, add distilled
water.
■Adding distilled water
1 Remove the vent plug.
2 Add distilled water.
If the “UPPER LEVEL” line cannot be seen, check the fluid level by looking
directly at the cell.
3 Put the vent plug back on and
close it securely.
■Before recharging
When recharging, the battery produces
hydrogen gas which is flammable and
explosive. Therefore, observe the fol- lowing before recharging:
●If recharging with the battery installed on the vehicle, be sure to disconnect
the ground cable.
●Make sure the power switch on the
charger is off when connecting and disconnecting the charger cables to
the battery.
■After recharging/reconnecting the
battery
The engine may not start. Follow the
procedure below to initialize the system.
1 Shift the shift lever to P (automatic
transmission) or depress the brake pedal with the shift lever in N (man-
ual transmission).
2 Open and close either door.
3 Restart the engine.
●Unlocking the doors using the smart
entry & start system may not be possi-
ble immediately after reconnecting the battery. If this happens, use the wire-
less remote control or the mechanical
key to lock/unlock the doors.
●Start the engine with the engine
switch in ACC. The engine may not start with the engine switch turned off.
However, the engine will operate nor-
mally from the second attempt.
●The engine switch mode is recorded
by the vehicle. If the battery is discon- nected and reconnected, the vehicle
will return the engine switch mode to
the status it was in before the battery was disconnected. Make sure to turn
off the engine before disconnecting
the battery. Take extra care when con- necting the battery if the engine switch
mode prior to the battery being dis-
connected is unknown.
If the engine will not start even after mul-
tiple attempts, contact any authorized Toyota dealer or repairer, or another
duly qualified and equipped profes-
sional.
A

3347-2. Steps to take in an emergency
Fluid leaks under the vehicle.
(Water dripping from the air con-
ditioning after use is normal.)
 Flat-looking tires or uneven tire
wear
 Engine coolant temperature
gauge continually points higher
than normal.
 Changes in exhaust sound
 Excessive tire squeal when cor-
nering
 Strange noises related to the
suspension system
 Pinging or other noises related to
the engine
 Engine missing, stumbling or
running roughly
 Appreciable loss of power
 Vehicle pulls heavily to one side
when braking
 Vehicle pulls heavily to one side
when driving on a level road
 Loss of brake effectiveness,
spongy feeling, pedal almost
touches the floor
If you think something is
wrong
If you notice any of the follow-
ing symptoms, your vehicle
probably needs adjustment or
repair. Contact any authorized
Toyota retailer or Toyota
authorized repairer, or any reli-
able repairer as soon as possi-
ble.
Visible symptoms
Audible symptoms
Operational symptoms

3367-2. Steps to take in an emergency
■Brake system warning light (warning buzzer)
■Vacuum pressure system warning light
■High coolant temperature warning light (warning buzzer)
If a warning light turns on or a war ning buzzer sounds
Calmly perform the following actions if any of the warning lights
comes on or flashes. If a light comes on or flashes, but then goes
off, this does not necessarily indicate a malfunction in the system.
However, if this continues to occur, have the vehicle inspected by
any authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
Actions to the warning lights or warning buzzers
Warning lightDetails/Actions
(red)
Indicates that:
 The brake fluid level is low; or
 The brake system is malfunctioning
This light also comes on when the parking brake is not released. If
the light turns off after the parki ng brake is fully released the sys-
tem is operating normally.
 Immediately stop the vehicle in a safe place and contact
any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer. Continuing to drive the
vehicle may be dangerous.
Warning lightDetails/Actions
(yellow)
Indicates a malfunction in the vacuum pressure system.
 Have the vehicle inspected by any authorized Toyota
retailer or Toyota authorized repairer, or any reliable
repairer immediately.
Warning lightDetails/Actions
Indicates that the engine coolant temperature is too high
 Immediately stop the vehicle in a safe place.
Handling method ( P.362)

3748-1. Specifications
*: The recommended oil grade is API GL-4. However, API GL-3 can also be used.
*1: Minimum pedal clearance when depressed with a force of 300 N (30 kgf, 67 lbf)
while the engine is running.
Carpet
Brake pedal
Pedal clearance
NOTICE
■Transmission fluid type
If oil other than “MT GEAR OIL LV 75W” is used, the following may be experi- enced:
●The overall performance and function of the transmission may be adversely affected.
●Rattling noises may occur during idling and fuel consumption may increase.
Never use different brands together.
Clutch
Pedal free play
Left-hand drive vehicles
4.3 16.4 mm (0.170.65 in.)
Right-hand drive vehicles
4.1 15.7 mm (0.160.62 in.)
Fluid typeSAE J1703 or FMVSS No.116 DOT 3
Brakes
Pedal clearance*174 mm (2.91 in.) Min.
Pedal free play0.51.5 mm (0.0200.059 in.)
Parking brake lever travel*27 - 8 clicks
Fluid typeSAE J1703 or FMVSS No.116 DOT 3 or SAE
J1704 or FMVSS No.116 DOT 4
A
C

389Alphabetical Index
Alphabetical Index
A
A/C
Air conditioning filter................... 314
Automatic air conditioning system
................................................. 264
ABS (Anti-lock Brake System) .... 256
Warning light .............................. 338
Active Sound Control (ASC) ........ 152
Adaptive Cruise Control .............. 185
Warning message ...................... 344
Air conditioning filter ................... 314
Air conditioning system
Air conditioning filter................... 314
Automatic air conditioning system
................................................. 264
Airbags
Correct driving posture................. 27
Locations of airbags ..................... 32
SRS airbags ................................. 32
SRS warning light ...................... 337
Alarm ............................................... 81
Warning buzzer .......................... 336
Antennas (smart entry & start sys-
tem).............................................. 109
Anti-lock Brake System (ABS) .... 256
Warning light .............................. 338
ASC (Active Sound Control) ........ 152
Audio system-linked display ......... 97
Automatic air conditioning system
..................................................... 264
Automatic headlight leveling system
..................................................... 154
Automatic light control system ... 153
Automatic transmission............... 143
Manual mode ............................. 146
Paddle shift switches ......... 145, 146
Auxiliary box ................................. 276
Auxiliary boxes ............................. 275
Average fuel consumption ............ 94
Average vehicle speed ................... 94
B
Back-up light
Replacing light bulbs ..................321
Wattage ......................................375
Battery
Battery checking......................... 298
If the battery is discharged ......... 359
Preparing and checking before win-
ter ............................................. 260
Warning light ..............................337
Blind Spot Detection (BSD) .........226
Bottle holders................................274
Brake
Fluid ...........................................374
Parking brake .............................151
Warning light ..............................336
Brake assist...................................256
Break-in tips .................................. 131
Brightness control
Instrument panel light control ....... 91
BSD (Blind Spot Detection) .........226
C
Camera
High Beam Assist system........... 156
Care
Exterior ....................................... 282
Interior ................................285, 287
Seat belts ...................................285
Ultrasuede®................................287
Wheels and wheel ornaments .... 282
Chains ............................................262
Child restraint system
Child seats definition .................... 56
Child seats installation ................. 65
Fixed with an ISOFIX lower anchor-
age ............................................. 67
Riding with children ...................... 56
Using a top tether anchorage ....... 68
Child safety
Battery precautions ............ 300, 361
Child restraint system................... 56

391Alphabetical Index
If the electronic key does not operate properly .................................... 357
If the engine will not start ........... 355
If the fuel filler door cannot be opened..................................... 357
If the vehicle is submerged or water on the road is rising ................. 327
If you have a flat tire................... 345
If you lose your keys .................. 356
If you think something is wrong.. 334
If your vehicle becomes stuck .... 364
If your vehicle has to be stopped in an emergency .......................... 326
If your vehicle needs to be towed
................................................. 329
If your vehicle overheats ............ 362
Engine
ACCESSORY mode .................. 141
Compartment ............................. 295
Engine switch ............................. 139
Fuel pump shut of f system ......... 335
Hood .......................................... 293
How to start the engine .............. 139
Identification number.................. 369
If the engine will not start ........... 355
If your vehicle has to be stopped in
an emergency .......................... 326
Ignition switch (engine switch) ... 139
Overheating ............................... 362
Tachometer .................................. 88
Engine coolant Capacity ..................................... 372
Checking .................................... 297
Preparing and checking before win-ter ............................................ 260
Engine coolant temperature gauge ....................................................... 88
Engine immobilizer system ........... 79
Engine oil Capacity ..................................... 370
Checking .................................... 295
Preparing and checking before win-ter ............................................ 260
Warning light .............................. 337
Engine oil temperature gauge ....... 94 Engine switch................................139
Auto power off function .............. 142
Changing the engine switch modes.................................................141
If your vehicle has to be stopped in
an emergency ..........................326
EPS (Electric Power Steering) ..... 256 Warning light ..............................338
Event data recorder (EDR) ............... 6
Extended headlight lighting system ..................................................... 155
EyeSight ........................................165 Adaptive Cruise Control .............185
Conventional Cruise Control ...... 201
Lane Departure Warning ............214
Lane Sway Warning ................... 216
Lead Vehicle Start Alert .............. 218
Malfunction ................................. 222
Pre-Collision Braking System..... 175
Pre-Collision Throttle Management
.................................................209
Temporary stop ..........................222
F
Flat tire
Tire pressure warning system .... 303
Vehicles without a spare tire ...... 345
Floor mats ....................................... 26
Fluid Automatic transmission .............. 373
Brake .......................................... 374
Manual transmission ..................373
Washer ....................................... 300
Fog lights....................................... 159
Switch.........................................159
Front position lights Wattage ......................................375
Front seats Adjustment ................................. 117
Cleaning .............................285, 287
Correct driving posture ................. 27
Head restraints ...........................120
Seat heaters ............................... 269

397Alphabetical Index
Open door .................................. 104
Seat belt ............................. 339, 340
Warning lights............................... 336 ABS ............................................ 338
Automatic he adlight leveling system
warning light ............................ 341
Automatic transmission fluid temper- ature ........................................ 339
Brake system .......... ................... 336
BSD/RCTA warning light ............ 340
Charging system ........................ 337
Conventional cruise control indicator ................................................. 340
Electric power steering............... 338
EyeSight warning light ............... 341
GPF system warning light .......... 342
High coolant temperature........... 336
LED headlight warning light ....... 341
Low engine oil pressure ............. 337
Low fuel level ............................. 339
Malfunction indicator lamp ......... 337
Master warning light ................... 341
Open door warning .................... 339
RAB warning light ...................... 341
Seat belt reminder light ...... 339, 340
Slip indicator .............................. 338
SRH warning light ...................... 340
SRS............................................ 337
Tire pressure .............................. 342
Warning messages ....................... 344
Warning reflector storage box .... 276
Washer Checking .................................... 300
Preparing and checking before win-ter ............................................ 260
Switch ........................................ 160
Washing and waxing .................... 282
Weight
Weight ........................................ 368
Wheels Replacing wheels ....................... 308
Size ............................................ 375
Window lock switch ..................... 127
Windows
Power windows .......................... 126 Rear window defogger ............... 266
Washer ....................................... 160
Windshield wipers ........................160
Winter driving tips ........................260
Wireless remote control Battery-Saving Function ............. 110
Locking/Unlocking ...................... 101
Replacing the battery ................. 316