2020 VOLVO S60 Warranty and Maintenance Records Information

7
SERVICE AND MAINTENANCE
Demanding driving
In demanding driving conditions, such as
operating the vehicle in hot weather, towing a
trailer, or driving for extended periods at higher
altitudes than normal, it may be advisable to
switch to higher octane fuel (91 or higher) or
to change gasoline brands to fully utilize your
engine’s capacity, and for the smoothest possible
operation.
NOTE
When switching to higher octane fuel or
changing gasoline brands, it may be necessary
to fill the tank more than once before a
difference in engine operation is noticeable.Fuel FormulationsDo not use gasoline that contains lead as a knock
inhibitor, and do not use lead additives. Besides
damaging the exhaust emission control systems
on your vehicle, lead has been strongly linked to
certain forms of cancer.
Many fuels contain benzene as a solvent.
Unburned benzene has been strongly linked to
certain forms of cancer. If you live in an area where
you must fill your own gas tank, take precautions.
These may include:•
standing upwind away from the filler nozzle
while refueling
•
refueling only at gas stations with vapor
recovery systems that fully seal the mouth of
the filler neck during refueling
•
wearing neoprene gloves while handling a fuel
filler nozzle.
WARNING
California Proposition 65
Operating, servicing and maintaining a
passenger vehicle can expose you to chemicals
including engine exhaust, carbon monoxide,
phthalates, and lead, which are known to
the State of California to cause cancer and
birth defects or other reproductive harm. To
minimize exposure, avoid breathing exhaust, do
not idle the engine except as necessary, service
your vehicle in a well ventilated area and wear
gloves or wash your hands frequently when
servicing your vehicle. For more information
go to www.P 65Warnings.ca.gov/passenger-
vehicle.Use of AdditivesWith the exception of gas line antifreeze during
winter months, do not add solvents, thickeners,
or other store-bought additives to your vehicle’s
fuel, cooling, or lubricating systems. Overuse may
damage your engine, and some of these additives
contain organically volatile chemicals. Do not
needlessly expose yourself to these chemicals.
WARNING
Never carry a cell phone that is switched
on while refueling your vehicle. If the phone
rings, this may cause a spark that could ignite
gasoline fumes, resulting in fire and injury.
WARNING
Carbon monoxide is a poisonous, colorless, and
odorless gas. It is present in all exhaust gases.
If you ever smell exhaust fumes inside the
vehicle, make sure the passenger compartment
is ventilated, and immediately return the
vehicle to a trained and qualified Volvo service
technician for correction.Deposit control gasoline (detergent
additives)Volvo recommends the use of detergent gasoline
to control engine deposits. Detergent gasoline
is effective in keeping injectors and intake valves
clean. Consistent use of deposit control gasolines
will help ensure good drivability and fuel economy.
If you are not sure whether the gasoline contains
deposit control additives, check with the service
station operator.
NOTE
Volvo does not recommend the use of external
fuel injector cleaning systems.Unleaded fuelEach Volvo has a three-way catalytic converter
and must use only unleaded gasoline. U.S. and
Canadian regulations require that pumps delivering
unleaded gasoline be labeled “UNLEADED”. Only
these pumps have nozzles which fit your vehicle’s
filler inlet. It is unlawful to dispense leaded fuel into
a vehicle labeled “unleaded gasoline only”. Leaded
gasoline damages the threeway catalytic converter
and the heated oxygen sensor system. Repeated
use of leaded gasoline will lessen the effectiveness


8
SERVICE AND MAINTENANCEof the emission control system and could result
in loss of emission warranty coverage. State
and local vehicle inspection programs will make
detection of misfueling easier, possibly resulting in
emission test failure for misfueled vehicles.
NOTE
Some U.S. and Canadian gasolines contain
an octane enhancing additive called
methylcyclopentadienyl manganese tricarbonyl
(MMT). If such fuels are used, your Emission
Control System performance may be affected,
and the Check Engine Light (malfunction
indicator lamp) located on your instrument
panel may light. If this occurs, please return
your vehicle to an authorized Volvo retailer for
service.Gasoline containing alcohol and ethers
(oxygenated fuels)Some fuel suppliers sell gasoline containing
“oxygenates” which are usually alcohols or ethers.
In some areas, state or local laws require that the
service pump be marked indicating use of alcohols
or ethers. However, there are areas in which the
pumps are unmarked. If you are not sure whether
there is alcohol or ethers in the gasoline you buy,
check with the service station operator. To meet
seasonal air quality standards, some areas require
the use of “oxygenated” fuel.
Methanol
Do not use gasolines containing methanol (methyl
alcohol, wood alcohol). This practice can result in
vehicle performance deterioration and can damage critical parts in the fuel system. Such damage may
not be covered under the New Vehicle Limited
Warranty.
Volvo allows the use of the following “oxygenated”
fuels; however, the octane ratings listed in your
owner’s manual must still be met.
Alcohol – Ethanol
Fuels containing up to 10% ethanol by volume
may be used. Ethanol may also be referred to as
Ethyl alcohol, or “Gasohol.”
Ethers – MTBE
Fuels containing up to 15% MTBE may be used.
Engine oilThis vehicle comes from the factory with
synthetic oil.Oil specificationsFull synthetic engine oil meeting the minimum
RBS0-2AE/SAE 0W20 must be used. Lower
quality oils may not offer the same fuel economy,
engine performance, or engine protection.
Volvo recommends:Oil additives must not be used.


9
SERVICE AND MAINTENANCE
Oil viscosity
Incorrect viscosity oil can shorten engine life under
normal use. SAE 0W-20 will provide good fuel
economy and engine protection.
Turbocharger Operating TipsIn order to maximize the efficiency and operation
of your vehicle, the following points should be
observed:
1. Oil change and filter replacement every
10,000 miles/16,000 km, or at a time interval
based on the type of driving and conditions as
detailed in your Owner’s Manual. You should
maintain a record of these services (repair
order receipts).
2. Do not use engine oil additives as they may
adversely affect the engine.
CAUTION
Never race the engine immediately after
starting. Oil flow may not reach some
lubricating points fast enough to prevent
turbocharger damage.
Before switching off the engine, let it operate
at idle for a short time to allow the spinning of
the turbocharger compressor’s turbine vanes to
slow. After hard driving, this idle time should last
a couple of minutes, during which the vanes will
slow and the compressor will cool down while
still receiving oil lubrication. If the turbine vanes
are spinning at high speeds when the engine is
switched off, there is a great risk of heat damage
and/or turbine seizure due to lack of lubrication.Do not race the engine just prior to switching
off!

10
SERVICE AND MAINTENANCEMaintenance Service OperationsNon-hybrid models onlyService operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Engine
Engine oil and filter, replaceXXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
A
XXXXXXX
Service Reminder Indicator (SRI), resetXXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damageXXX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B. XXX
Spark plugs, replaceXX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agentXXXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
C
X
Timing belt tensioner & idler pulley, replace
C
X
Steering, Front and Rear Suspension
Power steering fluid level, check/adjustXXXXXXXXXXXXXXX

11
SERVICE AND MAINTENANCE
Service operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Steering/front suspension, check for wear
according to: Wheel angles checkXXX
Rear suspension, check for wear according
to: Wheel angles checkXXX
Transmission, Driveshaft and Differential
Automatic transmission fluid level, check/
adjust
D
XXX
Final drive/bevel gear, visual inspection
(AWD models only)
E
XXX
Driveshaft joints, check for wear/playXXX
Driveshafts, check rubber bootsXXX
Propeller shaft, pilot bearing and universal
joints, check wear (AWD models only)XXX
Controls and Lighting
Washer fluid level, check/adjustXXXXXXXXXXXXXXX
Check all wiper blades and washers for
headlights and windshields for function and
signs of wearXXXXXXXXXXXXXXX
External lighting, checkXXXXXXXXXXXXXXX
Headlights, fog lights, check and alignXXXXXXX


12
SERVICE AND MAINTENANCEService operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Horn, check functionXXXXXXXXXXXXXXX
Body
Cabin air filter, replace
F
XXXXXXX
Clean inside of windshield in front of camera
(vehicles with camera for collision warning)XXXXXXXXXXXXXXX
Seatbelts
Seatbelts, check functionXXXXXXXXXXXXXXX
Brake System
Brake fluid level, check & adjustXXXXXXXXXXXXXXX
Brake fluid, replace
G
XXX
Parking brake, check/adjustXXXXXXXXXXXXXXX
Brake pads/discs, checkXXXXXXXXXXXXXXX
Brake hoses and lines, check for damage/
leaksXXX
Wheels and Tires
Wheels and tires, check wear and conditionXXXXXXXXXXXXXXX
Wheels and tires check inflation pressureXXXXXXX
Tire inflator kit
H


13
SERVICE AND MAINTENANCE
Service operation Schedule of services
All Non-hybrid
Modelsmiles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Spare tire check for damage, wear, and tire
pressure
I
XXXXXXXXXXXXXXX
Check and replace parts or software, as required by Volvo Car USA, LLC, that are covered under the terms of the Volvo New Car Warranty.
A In the event of a leak from the transmission, check the oil level.
B May be necessary to change more frequently when driving in dusty/dirty areas.
C Replace at 150,000 miles/240,000 kilometers or 10 years, whichever comes first.
D Check automatic transmission fluid level only if an external leak is identified. Volvo recommends changing transmission fluid every 50,000 miles/80,000 kilometers, only on vehicles used for towing,
or when a message appears in the instrument panel text window.
E Only check the level if there is leakage.
F Recommended to replace at least once a year or more often in heavy traffic or dirty/dusty areas.
G Recommended to replace every 3 years or 40,000 miles (if driven in mountainous areas or humid climates – every one year) at owner’s request.
H Check expiration date label every four years for replacement date on vehicles with this equipment.
I Check spare tire pressure (where applicable) every two years or every 40,000 miles/64,000 kilometers.


14
SERVICE AND MAINTENANCEHybrid models onlyService operation Schedule of services
Hybrid Models miles x 1000 10 20 30 40 50 60 70 80 90 100 110 120 130 140 150
km x 1000 16 32 48 64 80 96 112 128 144 160 176 192 208 224 240
Engine
Engine oil and filter, replaceXXXXXXXXXXXXXXX
Engine/Transmission/Timing gear check for
leaks
A
XXXXXXX
Service Reminder Indicator (SRI), resetXXXXXXXXXXXXXXX
Fuel lines and fuel filter, check for leakage
and damageXXX
Engine Air cleaner (ACL), clean the air
cleaner housing/replace filter
B.XXX
Spark plugs, replaceXX
Engine coolant check & adjust antifreeze
rating & anti-corrosion agentXXXXXXXXXXXXXXX
Accessory drive belt, belt tensioner & idler
pulley, replace
C
X
Timing belt tensioner & idler pulley, replace
C
X
Steering, Front and Rear Suspension
Power steering fluid level, check/adjustXXXXXXXXXXXXXXX