2020 FORD EXPLORER check engine

experienced extended periods of
extreme/severe duty cycle driving.
Changing or checking the transfer case,
front and/or rear axle lubricant is not
necessary unless the unit has been
submerged in water, shows signs of
leakage, a message indicating required
service displays. Contact your authorized
dealer for service.
California fuel filter replacement: If you
register your vehicle in California, the
California Air Resources Board has
determined that the failure to perform this
maintenance item does not nullify the
emission warranty or limit recall liability
before the completion of your vehicle's
useful life. Ford Motor Company, however,
urges you to have all recommended
maintenance services performed at the
specified intervals and to record all vehicle
service.
Hot climate oil change intervals:
Vehicles operating in the Middle East,
North Africa, Sub-Saharan Africa or
locations with similar climates using an
American Petroleum Institute (API)
Certified for Gasoline Engines (Certification
mark) oil of SM or SN quality, the normal
oil change interval is 5,000 mi (8,000 km)
.
If the available API SM or SN oils are not
available, then the oil change interval is
3,000 mi (4,800 km)
.
Engine air filter and cabin air filter
replacement
: The life of the engine air
filter and cabin air filter is dependent on
exposure to dusty and dirty conditions.
Vehicles operated in these conditions
require frequent inspection and
replacement of the engine air filter and
cabin air filter.
SCHEDULED MAINTENANCE
RECORD
After the scheduled maintenance services
are performed, record the Repair Order #,
Distance and Engine Hours in the boxes
provided. 495
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Scheduled MaintenanceE146852
Repair Order #:Distance:
Engine hours (optional): Multi-point inspection (recommended): Signature:
Dealer stamp

3
360 Degree Camera....................................241
Front Camera...................................................... 242
Side Camera........................................................ 243
Using the System............................................... 242
4
4WD See: Four-Wheel Drive.................................... 208
9
911 Assist...........................................................55
A
A/C See: Climate Control.......................................... 137
About This Manual...........................................9
ABS See: Brakes............................................................ 214
ABS driving hints See: Hints on Driving With Anti-Lock
Brakes................................................................. 215
Accessories...................................................484
Accessories See: Replacement Parts
Recommendation............................................ 16
Active Park Assist........................................235 Using Active Park Assist.................................. 236
Adaptive Cruise Control
............................246
Adaptive Cruise Control –
Troubleshooting............................................ 256
Adaptive Cruise Control Indicators - Vehicles With: Adaptive Cruise Control
With Lane Centering
................................253
Adaptive Cruise Control Indicators - Vehicles With: Adaptive Cruise Control
With Stop and Go
.....................................253
Adaptive Cruise Control Indicators - Vehicles With: Intelligent Adaptive
Cruise Control
.............................................253
System Warnings............................................... 253
Adaptive Cruise Control Limitations - Vehicles With: Adaptive Cruise Control
With Lane Centering................................247 Adaptive Cruise Control Limitations -
Vehicles With: Adaptive Cruise Control
With Stop and Go
.....................................248
Sensor Limitations............................................ 248
Adaptive Cruise Control Precautions - Vehicles With: Adaptive Cruise Control
With Lane Centering
...............................246
Adaptive Cruise Control Precautions - Vehicles With: Adaptive Cruise Control
With Stop and Go.....................................246
Hilly Condition Usage....................................... 247
When Following a Vehicle............................... 247
Adaptive Cruise Control – Troubleshooting........................................256
Adaptive Cruise Control – Information Messages......................................................... 256
Adaptive Headlamps
.....................................91
System Check......................................................... 91
Adjusting the Headlamps
........................340
Vertical Aim Adjustment................................ 340
Adjusting the Set Speed Tolerance.....................................................255
Adjusting the Steering Wheel - Vehicles With: Manual Adjustable Steering
Column...........................................................80
Adjusting the Steering Wheel - Vehicles With: Power Adjustable Steering
Column...........................................................80
End of Travel Position.......................................... 81
Memory Feature.................................................... 81
AFS See: Adaptive Headlamps................................. 91
Airbag Disposal
...............................................53
Air Conditioning See: Climate Control.......................................... 137
Air Filter See: Changing the Engine Air Filter - 2.3L
EcoBoost™..................................................... 329
See: Changing the Engine Air Filter - 3.0L.................................................................... 330
See: Changing the Engine Air Filter - 3.3L...................................................................... 331
Alarm See: Anti-Theft Alarm........................................ 78
Ambient Lighting - Vehicles With: 10.1 Inch Information and Entertainment
Display Screen
..............................................93
Adjusting the Brightness................................... 94
537
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Blind Spot Information System.............264
Blind Spot Information System with Trailer
Tow.................................................................... 266
Switching the System On and Off..............268
System Errors...................................................... 268
Using the Blind Spot Information System.............................................................. 265
BLIS See: Blind Spot Information System.........264
Bonnet Lock See: Opening and Closing the Hood..........323
Booster Seats..................................................33 Types of Booster Seats...................................... 33
Brake Fluid Check.........................................337 Brake Fluid Service Interval............................ 337
Brakes...............................................................214 General Information.......................................... 214
Breaking-In.....................................................297
Bulb Specification Chart...........................424
C
Canceling the Set Speed..........................245
Capacities and Specifications - 2.3L EcoBoost™.................................................395
Air Conditioning System................................. 395
Alternative Engine Oil for Extremely Cold Climates........................................................... 398
Automatic Transmission................................. 395
Engine Coolant................................................... 396
Engine Oil.............................................................. 397
Front Axle............................................................ 400
Fuel Tank.............................................................. 398
Grease.................................................................... 398
Hydraulic Brake System.................................. 399
Locks...................................................................... 399
Rear Axle............................................................... 401
Transfer Case..................................................... 400
Washer Reservoir............................................... 401
Capacities and Specifications - 3.0L................................................................402
Air Conditioning System................................. 402
Alternative Engine Oil for Extremely Cold Climates........................................................... 405
Automatic Transmission................................ 403
Engine Coolant.................................................. 404
Engine Oil............................................................. 404
Front Axle............................................................. 408Fuel Tank..............................................................
406
Grease................................................................... 406
Hydraulic Brake System................................. 406
Locks...................................................................... 407
Rear Axle.............................................................. 408
Transfer Case...................................................... 407
Washer Reservoir.............................................. 409
Capacities and Specifications - 3.3L, Gasoline
.......................................................409
Air Conditioning System.................................. 410
Alternative Engine Oil for Extremely Cold Climates............................................................ 412
Automatic Transmission................................. 410
Engine Coolant..................................................... 411
Engine Oil................................................................ 411
Front Axle.............................................................. 415
Fuel Tank................................................................ 413
Grease..................................................................... 413
Hydraulic Brake System................................... 413
Locks....................................................................... 414
Rear Axle................................................................ 415
Transfer Case....................................................... 414
Washer Reservoir................................................ 416
Capacities and Specifications - 3.3L, Hybrid Electric Vehicle (HEV)
...............416
Air Conditioning System................................... 417
Alternative Engine Oil for Extremely Cold Climates........................................................... 420
Automatic Transmission.................................. 417
Engine Coolant.................................................... 418
Engine Oil.............................................................. 419
Front Axle.............................................................. 422
Fuel Tank.............................................................. 420
Grease.................................................................... 420
Hydraulic Brake System................................... 421
Locks........................................................................\
421
Rear Axle............................................................... 423
Transfer Case....................................................... 422
Washer Reservoir............................................... 423
Capacities and Specifications...............384
Cargo Nets......................................................281
Car Wash See: Cleaning the Exterior.............................. 346
Catalytic Converter
......................................198
On-Board Diagnostics (OBD-II)................... 199
Readiness for Inspection and Maintenance (I/M) Testing................................................... 199
Center Console
................................................171
539
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Changing a Bulb...........................................343
LED Lamps........................................................... 343
License Plate Lamp.......................................... 344
Rear Direction Indicator and Reversing Lamp................................................................. 343
Changing a Fuse............................................321
Fuses........................................................................\
321
Changing a Road Wheel
............................376
Dissimilar Spare Wheel and Tire Assembly
Information...................................................... 376
Tire Change Procedure..................................... 377
Changing the 12V Battery.........................338 Battery Management System....................... 339
Remove and Reinstall the Battery..............339
Changing the Engine Air Filter - 2.3L EcoBoost™.................................................329
Changing the Engine Air Filter - 3.0L................................................................330
Changing the Engine Air Filter - 3.3L..................................................................331
Changing the Front Wiper Blades.........342
Changing the Rear Wiper Blades...........342
Changing the Vehicle Wi-Fi Hotspot Name or Password
..................................429
Checking MyKey System Status..............66 MyKey Distance.................................................... 66
Number of Admin Keys...................................... 67
Number of MyKeys............................................... 67
Checking the Wiper Blades......................342
Child Restraint and Seatbelt Maintenance.................................................43
Child Restraint Positioning.........................35
Child Safety......................................................23 General Information............................................ 23
Child Safety Locks.........................................36 Left-Hand Side...................................................... 37
Right-Hand Side................................................... 37
Cleaning Leather Seats
.............................349
Cleaning Products.......................................345 Materials............................................................... 345
Cleaning the Engine
....................................347
Cleaning the Exterior..................................346 Cleaning the Headlamps................................ 346
Exterior Chrome Parts..................................... 346
Exterior Plastic Parts........................................ 346
Stripes or Graphics........................................... 346
Underbody............................................................ 347
Under Hood.......................................................... 347Cleaning the Instrument Panel and
Instrument Cluster Lens........................348
Cleaning the Interior...................................348 Mirrors.................................................................... 348
Cleaning the Wheels..................................350
Cleaning the Windows and Wiper Blades............................................................347
Clearing All MyKeys.......................................66
Climate............................................................456 Accessing Rear Climate Controls................458
Accessing the Climate Control Menu........456
Directing the Airflow........................................ 456
Rear Climate Control Lock Indicator..........458
Setting the Blower Motor Speed.................456
Setting the Temperature................................ 456
Switching Auto Mode On and Off...............456
Switching Dual Zone Mode On and Off....................................................................... 457
Switching Maximum Air Conditioning On and Off.............................................................. 457
Switching Maximum Defrost On and Off....................................................................... 457
Switching Rear Auto Mode On and Off...................................................................... 458
Switching Recirculated Air On and Off...................................................................... 458
Switching the Air Conditioning On and Off...................................................................... 456
Switching the Climate Controlled Seats On and Off.............................................................. 457
Switching the Climate Control On and Off....................................................................... 457
Switching the Heated Exterior Mirrors On and Off.............................................................. 457
Switching the Heated Rear Window On and Off....................................................................... 457
Switching the Heated Seats On and Off....................................................................... 457
Switching the Heated Steering Wheel On and Off.............................................................. 457
Switching the Heated Windshield On and Off....................................................................... 457
Switching the Rear Climate Controlled Seats On and Off.......................................... 458
Switching the Rear Heated Seats On and Off...................................................................... 458
Switching the Rear Ventilated Seats On and Off............................................................. 458
540
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Switching the Ventilated Seats On and
Off...................................................................... 458
Climate Control..............................................137
Climate Controlled Seats..........................158
Automatic Climate Controlled Seats..........158
Heated Seats....................................................... 158
Ventilated Seats................................................. 158
Cold Weather Precautions.......................297
Collision, Damage or Fire Event.............303 Guidance for Ford Motor Company Electric
and Hybrid-Electric Vehicles Equipped
With High Voltage Batteries..................... 303
Connecting the Vehicle to a Mobile Network........................................................426
Enabling the Modem Using FordPass.......................................................... 426
Enabling the Modem Using the Touchscreen................................................... 426
What Is the Modem.......................................... 426
Coolant Check See: Engine Coolant Check............................ 332
Crash Sensors and Airbag Indicator
........52
Creating a MyKey...........................................65
Programming and Changing Configurable
Settings.............................................................. 66
Creating a Vehicle Wi-Fi Hotspot..........429 Connecting a Device to the Wi-Fi
Hotspot............................................................ 429
Finding the Wi-Fi Hotspot Name and Password......................................................... 429
Cross Traffic Alert........................................268 Cross Traffic Alert Behavior When Trailer
is Attached........................................................ 271
Cross Traffic Alert Indicator............................. 271
Cross Traffic Alert Information Messages........................................................... 271
Cross Traffic Alert System Limitations ....................................................... 270
Cross Traffic Alert System Sensors.............270
Switching the System On and Off................271
Using Cross Traffic Alert................................. 269
Cruise Control
...............................................244
Cruise Control Indicators..........................245
Cruise Control - Vehicles With: Adaptive Cruise Control With Lane
Centering........................................................82
Cruise Control - Vehicles With: Adaptive Cruise Control With Stop and Go.........83 Cruise Control - Vehicles With: Cruise
Control
............................................................83
Cup Holders......................................................171
Customer Assistance................................306
D
Data Recording
..................................................11
Comfort, Convenience and Entertainment
Data....................................................................... 13
Event Data................................................................ 13
Service Data............................................................ 12
Services That Third Parties Provide...............14
Services That We Provide.................................. 14
Vehicles With a Modem...................................... 14
Vehicles With an Emergency Call System.................................................................. 15
Vehicles With SYNC............................................. 14
Daytime Running Lamps - Vehicles With: Configurable Daytime Running
Lamps.............................................................90
Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL)............90
Declaration of Conformity
.......................534
Declaration of Conformity - Vehicles With: SYNC 3..............................................534
Radio Frequency Statement......................... 534
Digital Radio...................................................431 HD Radio Reception and Station
Troubleshooting............................................ 432
Direction Indicators
........................................91
Direction Indicator................................................ 92
Switching the Direction Indicators On and Off........................................................................\
.. 91
Doors and Locks.............................................69
Drive Mode Control.....................................279 Drive Modes......................................................... 279
Drive Modes
...................................................279
Deep Snow/Sand.............................................. 279
Eco........................................................................\
.. 280
Normal.................................................................. 280
Slippery................................................................. 280
Sport...................................................................... 280
Tow/Haul.............................................................. 280
Trail........................................................................\
. 280
Driver Alert.....................................................259 PRINCIPLE OF OPERATION.......................... 259
USING DRIVER ALERT.................................... 259
541
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Driver and Passenger Airbags....................47
Children and Airbags.......................................... 48
Proper Driver and Front Passenger Seating Adjustment........................................................ 47
Driver and Passenger Knee Airbags.........51
Driving Aids....................................................259
Driving Hints..................................................296
Driving Through Water...............................297
DRL See: Daytime Running Lamps - Vehicles With:
Configurable Daytime Running
Lamps................................................................. 90
See: Daytime Running Lamps - Vehicles With: Daytime Running Lamps (DRL)................90
E
Economical Driving.....................................296
Electric Parking Brake
.................................215
Applying the Electric Parking Brake.............215
Automatically Releasing the Electric
Parking Brake.................................................. 216
Manually Releasing the Electric Parking Brake................................................................... 216
Releasing the Electric Parking Brake if the Vehicle Battery is Running Out of
Charge................................................................ 217
Electric Vehicle Information....................465 Engine On Due To............................................. 466
Power Flow.......................................................... 465
Vehicle Operational States............................ 465
Electromagnetic Compatibility.............506
Emergency Call Limitations
.......................56
Emergency Call Requirements.................55
Emission Law.................................................197 Noise Emissions Warranty, Prohibited
Tampering Acts and Maintenance.........198
Tampering With a Noise Control System............................................................... 197
End User License Agreement.................509 VEHICLE SOFTWARE END USER LICENSE
AGREEMENT (EULA) ................................ 509
Engine Block Heater
.....................................178
Using the Engine Block Heater...................... 179
Engine Coolant Check................................332 Adding Coolant................................................... 333
Coolant Change................................................. 334Engine Coolant Temperature
Management.................................................. 336
Fail-Safe Cooling............................................... 334
Recycled Coolant............................................... 334
Severe Climates................................................. 334
Engine Emission Control............................197
Engine Immobilizer See: Passive Anti-Theft System..................... 78
Engine Oil Check...........................................327 Adding Engine Oil.............................................. 328
Engine Oil Dipstick - 2.3L EcoBoost™..................................................327
Engine Oil Dipstick - 3.0L..........................327
Engine Oil Dipstick - 3.3L...........................327
Engine Specifications - 2.3L EcoBoost™.................................................384
Drivebelt Routing............................................... 384
Engine Specifications - 3.0L, ST............385 Drivebelt Routing............................................... 386
Engine Specifications - 3.0L...................385 Drivebelt Routing............................................... 385
Engine Specifications - 3.3L, Gasoline........................................................387
Drivebelt Routing............................................... 387
Engine Specifications - 3.3L, Hybrid Electric Vehicle (HEV)............................388
Drivebelt Routing............................................... 388
Entertainment..............................................446 AM/FM Radio...................................................... 447
Apps....................................................................... 455
Bluetooth Stereo or USB................................ 454
CD (If equipped)................................................ 453
HD Radio ™ Information (If
Available)........................................................ 450
SiriusXM® Satellite Radio (If Activated)....................................................... 448
Sources.................................................................. 447
Supported Media Players, Formats and Metadata Information................................ 455
USB Ports............................................................. 455
Environment.....................................................19
EPB See: Electric Parking Brake.............................. 215
Essential Towing Checks..........................293 Before Towing a Trailer.................................... 294
Hitches................................................................... 293
Launching or Retrieving a Boat or Personal Watercraft (PWC)........................................ 294
542
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Safety Chains......................................................
293
Trailer Brakes....................................................... 293
Trailer Lamps....................................................... 293
When Towing a Trailer..................................... 294
Event Data Recording See: Data Recording.............................................. 11
Export Unique Options.................................18
Exterior Mirrors - Excluding: ST................98 360-Degree Camera.......................................... 99
Auto-dimming Feature...................................... 99
Auto-Folding Mirrors .......................................... 98
Blind Spot Information System...................... 99
Direction Indicator Mirrors ............................... 99
Fold-Away Exterior Mirrors............................... 98
Heated Exterior Mirrors ..................................... 99
Memory Mirrors .................................................... 99
Power Exterior Mirrors........................................ 98
Puddle Lamps....................................................... 99
Exterior Mirrors - ST......................................99 Auto-dimming Feature...................................... 101
Auto-Folding Mirrors......................................... 100
Blind Spot Information System..................... 101
Direction Indicator Mirrors................................ 101
Fold-Away Exterior Mirrors............................. 100
Heated Exterior Mirrors..................................... 101
Memory Mirrors.................................................... 101
Power Exterior Mirrors........................................ 99
Puddle Lamps...................................................... 101
F
Fastening the Seatbelts
..............................39
Seatbelt Locking Modes................................... 40
Using Seatbelts During Pregnancy................39
Flat Tire See: Changing a Road Wheel........................ 376
Floor Mats
......................................................298
Fog Lamps - Front See: Front Fog Lamps........................................ 90
Ford Credit
.........................................................15
US Only..................................................................... 15
Ford Protect..................................................485 Ford Protect Extended Service Plan
(CANADA ONLY).......................................... 486
Ford Protect Extended Service Plans (U.S. Only)................................................................. 485
Four-Wheel Drive
........................................208
Principle of Operation..................................... 208Front Fog Lamps............................................90
Front Fog Lamp Indicator.................................. 91
Switching the Front Fog Lamps On or Off........................................................................\
. 90
Front Parking Aid
..........................................232
Object Distance Indicator............................... 233
Front Passenger Sensing System
............48
Front Wiper Blades See: Changing the Front Wiper Blades......342
Fuel and Refueling.......................................186
Fuel Consumption.......................................195 Advertised Capacity.......................................... 195
Calculating Fuel Economy.............................. 196
Filling the Fuel Tank.......................................... 196
Fuel Filler Funnel Location
.......................188
Fuel Filter.........................................................341
Fuel Quality - E85........................................186 Choosing the Right Fuel - Flex Fuel
Vehicles............................................................. 186
Switching Between E85 and Gasoline............................................................. 187
Fuel Quality - Gasoline..............................188 Choosing the Right Fuel.................................. 188
Fuel Shutoff..................................................300
Fuses.................................................................313
Fuse Specification Chart
............................313
Engine Compartment Fuse Box.................... 313
Passenger Compartment Fuse Panel........318
G
Garage Door Opener...................................162
Garage Door Opener See: Universal Garage Door Opener............162
Gauges
.............................................................104
12 Inch Display..................................................... 106
4 Inch Display...................................................... 104
6 Inch Display...................................................... 105
Engine Coolant Temperature Gauge..........106
Fuel Gauge............................................................ 107
Gearbox See: Transmission............................................. 202
General Information on Radio Frequencies...................................................57
Intelligent Access.................................................. 57
General Maintenance Information........487 Multi-Point Inspection.................................... 489
Owner Checks and Services......................... 488
543
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index

Memory Function.........................................150
Easy Entry and Exit Feature............................. 151
Linking a PreSet Position to your Remote Control ............................................................... 151
Saving a PreSet Position................................... 151
Message Center See: Information Displays................................. 112
Mirrors See: Windows and Mirrors................................ 97
Mobile Communications Equipment.......17
Moonroof.........................................................102 Bounce-Back....................................................... 103
Opening and Closing the Moonroof............102
Rear SunShade Opening and Closing........103
Motorcraft Parts - 2.3L EcoBoost™................................................390
Motorcraft Parts - 3.0L...............................391
Motorcraft Parts - 3.3L..............................392
MyKey – Troubleshooting...........................67
MyKey ™.............................................................64
Principle of Operation........................................ 64
N
Navigation.....................................................460 Changing the Format of the Map................462
cityseeker............................................................. 464
Michelin Travel Guide...................................... 465
Navigation Map Accuracy and Updates........................................................... 465
Route Guidance................................................. 462
Setting a Destination........................................ 461
SiriusXM Traffic and Travel Link.................. 465
Zoom...................................................................... 462
Network Connectivity
................................426
Connecting the Vehicle to a Mobile
Network............................................................ 426
Network Connectivity – Troubleshooting........................................427
Normal Scheduled Maintenance..........490 Intelligent Oil-Life Monitor™........................ 490
Normal Maintenance Intervals...................... 491
O
Oil Change Indicator Reset......................328
Oil Check See: Engine Oil Check....................................... 327Opening and Closing the Hood..............323
Closing the Hood............................................... 324
Opening the Hood............................................. 323
Ordering Additional Owner's Literature........................................................311
Obtaining a French Owner ’s Manual............311
Overhead Console.........................................171
Overriding Automatic High Beam Control............................................................96
Overriding Reverse Braking Assist..........221
Overriding the Set Speed..........................252
P
Parking Aids
...................................................230
Principle of Operation...................................... 230
Passive Anti-Theft System.........................78 Programming a Spare Intelligent Access
Key........................................................................\
. 78
SecuriLock®........................................................... 78
PATS See: Passive Anti-Theft System..................... 78
Pedestrian Alert System
.............................54
Pedestrian Protection..................................54
Perchlorate........................................................15
Personalized Settings
..................................118
Fuel Economy....................................................... 119
Hybrid Information.............................................. 119
Trip 1 and 2.............................................................. 119
Personal Safety System ™
..........................45
How Does the Personal Safety System
Work?.................................................................. 45
Phone..............................................................458 Android Auto...................................................... 460
Apple CarPlay..................................................... 460
Pairing Your Cell Phone for the First Time.................................................................. 459
Text Messaging.................................................. 459
Using Your Cell Phone..................................... 459
Post-Crash Alert System
..........................304
Power Door Locks See: Locking and Unlocking............................. 69
Power Liftgate
..................................................74
Hands-Free Feature............................................ 76
Obstacle Detection.............................................. 76
Opening and Closing the Liftgate................... 74
Setting the Liftgate Open Height................... 76
Stopping the Liftgate Movement................... 75
546
Explorer (CTW) Canada/United States of America, enUSA, Edition date: 201902, Third-Printing- Index